2025 Chevrolet Silverado 1500 problems

ENGINE

While driving interstate speed pulling a trailer on 08/13/25 had a complete loss of power and truck died. Had to merge on-to the shoulder of the interstate with no power. Parked along side of interstate until towing arrived approx. 2 hours after loss of power event. Truck was towed to Husker Chevrolet where the truck was diagnosed with engine failure. There was no warning of this catastrophic event. On 09/11/26 dealership called stating that they replaced the engine, however the new engine expired while pulling it out of the shop. This would be this trucks 2nd engine.

NHTSA complaint #11764033 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving 60 MPH, the vehicle was losing power. The contact stated that several unknown warning lights and the engine warning light were flashing, and the message “Reduced Acceleration - Drive with Care” was displayed. The vehicle was operated at reduced power and driven to the dealer. The dealer diagnosed the vehicle as having engine failure; however, the part needed for the repair was not available. The failure mileage was approximately 46,000.

NHTSA complaint #11763147 — an unverified report by a vehicle owner.

ENGINE

cold starts sometime there is an audible tick, there is also occasional low oil pressure and the gauge drops and returns to the normal range

NHTSA complaint #11761909 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

cold starts sometime there is an audible tick, there is also occasional low oil pressure and the gauge drops and returns to the normal range

NHTSA complaint #11761909 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, there was an abnormal odor inside the vehicle. The contact stated that water was coming from underneath the driver’s side dashboard. Additionally, the steering wheel was jerking while the lane assist feature was activated; however, the vehicle was not veering to the left or right side of the lane. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed, and several failure codes were retrieved, and a water test was performed; however, the failure could not be duplicated. The vehicle was repaired; however, while the contact's husband was driving at an undisclosed speed, there was an abnormal sound coming from the vehicle. The driver pulled over to the shoulder of the road, and after selecting the 2WD feature, the 4WD feature was disengaging, even though the 4WD warning light was not illuminated. The vehicle was taken to another local dealer, Chevrolet of Troy (1375 S Market St, Troy, OH 45373) for a second opinion. The contact was informed that DTC: U1611 was retrieved, and several unknown repairs were needed. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,000.

NHTSA complaint #11761507 — an unverified report by a vehicle owner.

SERVICE BRAKES

I was driving on the freeway and got a service trailer brake system and a brake system failure 62mph top speed. I exited the freeway and came to a stop sign and hit my brakes to stop but was unable to stop and blew through the stop sign. Luckily there were no cars at the intersection and I was by myself.

NHTSA complaint #11761733 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: WARNINGS

I was driving on the freeway and got a service trailer brake system and a brake system failure 62mph top speed. I exited the freeway and came to a stop sign and hit my brakes to stop but was unable to stop and blew through the stop sign. Luckily there were no cars at the intersection and I was by myself.

NHTSA complaint #11761733 — an unverified report by a vehicle owner.

ENGINE

The engine has been using atleast 1 quart of oil every 2000 miles. This is put my maintenance cost way above the estimated maintenance cost projected by the manufacturer This oil usage is also causing premature engine wear as it's a quart low every 2000 miles. Dealer responses was this is normal for this engine. I went back and forth with the about estimated maintenance cost and ofcourse there responses was it estimated, well that's a very inaccurate estimate or willful lie. Idk just not happy about it.

NHTSA complaint #11761152 — an unverified report by a vehicle owner.

ENGINE

4//6/26 took truck in for knocking noise on the passenger side of the engine- Service could not reproduce the knocking. 6-26-26 low oil light comes on just 3000 miles after oil change - took truck to the dealer - dealer put 2 quarts of oil in the engine. 7-5-26 truck is running poorly took truck into dealership truck displays code P0307 Cylinder 7 Misfire. scoped cylinder 7 and it was damaged beyond repair from piston ring failure. 8-6-26 New 6.2L L87 engine installation complete.

NHTSA complaint #11760771 — an unverified report by a vehicle owner.

ENGINE

Total engine failure . While driving on the highway car started shaking violently and rattling. Car completely shut down was towed to Chevy dealership and was told it needed a full engine replacement. They said there was a hole in the engine the size of a tennis ball and said it was not user error but a defect . They also indicated we were lucky it didn’t blow up. Car is still being repaired . Being replaced with a gm remanufactured engine

NHTSA complaint #11760366 — an unverified report by a vehicle owner.

ENGINE

There have been multiple instances of engine ticking upon start up. I have 4 videos with sound. I can provide a link if necessary to dropbox or google drive if necessary since there is no way to upload them to this site. This has been reported by GM 6.2L owners as being a precursor to engine failure. I have not had the sound confirmed by a dealer or service center. The vehicle has not been inspected. There have been no warning lamps.

NHTSA complaint #11759939 — an unverified report by a vehicle owner.

ENGINE

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while starting the vehicle remotely, an abnormal grinding and banging sound was heard emanating from the engine compartment. The vehicle independently shut off. The contact attempted to restart the vehicle remotely, but the vehicle shut off again. The contact then attempted to start the vehicle manually, but the vehicle failed to start. The vehicle was towed to the dealer, where it was diagnosed that the engine had failed and needed replacement. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 5,425.

NHTSA complaint #11759809 — an unverified report by a vehicle owner.

ENGINE

The engine in my truck had a catastrophic failure (6.2 litre), same as the thousands with the same problem / failure. It had to be towed to the dealership where it underwent a complete engine replacement... it had 8,906 miles on it at the time of the engine failure. It died after making horrendous and loud noise, I was able to coast for a short distance but it came to a stop in the middle of a residential street and had to be towed to a safe location until the dealership could pick it up and tow it to their facility for diagnostics and repairs. I have the invoice with detailed information of the repairs and parts used.

NHTSA complaint #11759148 — an unverified report by a vehicle owner.

ENGINE

Engine crank bearings failed at only 16,310 miles. Engine replaced with a new one due severe internal damage.

NHTSA complaint #11758825 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Component Affected: Visibility: Interior Trim / Entertainment Center Bezel Glare Description of Safety Hazard:The interior styling of the 2025 Chevrolet Silverado RST contains a design flaw involving the polished chrome trim strip located directly below the main central entertainment center/infotainment screen. Because of the angle of this specific trim piece relative to the driver's seating position, direct sunlight hits this lower screen border and reflects a concentrated, blinding glare directly into the driver’s eyes.This causes immediate, severe visual impairment and a temporary loss of forward visibility while driving. This distraction and blindness prevent the driver from safely observing the road and traffic, creating an imminent crash hazard. The manufacturer has failed to provide a non-reflective, matte finish for this specific entertainment center trim to prevent this hazard.

NHTSA complaint #11758669 — an unverified report by a vehicle owner.

ENGINE

After having the original '25 6.2L GM L87 engine experience crankshaft bearing failure at approx. 5,700 mi, (previously reported to the NHTSA), the (brand new) replacement engine failed approx. 14,000 mi. later for the exact same reason, crankshaft bearing failure. In both incidents, the failure came 100% without warning, and the transmission LOCKED itself into park, leaving the vehicle and myself dangerously stranded in the middle of the highway; it had to be dragged on and off of the flat-bed tow truck both times.

NHTSA complaint #11758644 — an unverified report by a vehicle owner.

STRUCTURE:BODY

On Thursday, July 9, 2026, at approximately 2:30 p.m., I was driving my 2025 Chevrolet Silverado 1500 Duramax on Highway 40 while towing a properly connected trailer. The Multi-Flex tailgate had been fully closed and latched before I began my trip and had not been opened at any point prior to the incident. While traveling on the highway, a California Highway Patrol officer pulled alongside my vehicle and alerted me that my tailgate was down and bouncing on the trailer I was towing. I immediately pulled over to the shoulder and observed that the entire Multi-Flex tailgate had unexpectedly unlatched and was resting on the trailer. I closed and latched the tailgate, which appeared to operate normally, and continued to my destination. At no time before or during the incident did the vehicle display a "Tailgate Open" warning or any other warning message on the instrument cluster. The unexpected opening of the tailgate caused it to strike the trailer, resulting in damage to the Multi-Flex tailgate, the rear bumper, and the trailer. The vehicle has approximately 11,000 miles, was purchased new, and has not been modified. I have opened a case with General Motors, and the vehicle is scheduled to be inspected by an authorized Chevrolet dealership.

NHTSA complaint #11750324 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

On Thursday, July 9, 2026, at approximately 2:30 p.m., I was driving my 2025 Chevrolet Silverado 1500 Duramax on Highway 40 while towing a properly connected trailer. The Multi-Flex tailgate had been fully closed and latched before I began my trip and had not been opened at any point prior to the incident. While traveling on the highway, a California Highway Patrol officer pulled alongside my vehicle and alerted me that my tailgate was down and bouncing on the trailer I was towing. I immediately pulled over to the shoulder and observed that the entire Multi-Flex tailgate had unexpectedly unlatched and was resting on the trailer. I closed and latched the tailgate, which appeared to operate normally, and continued to my destination. At no time before or during the incident did the vehicle display a "Tailgate Open" warning or any other warning message on the instrument cluster. The unexpected opening of the tailgate caused it to strike the trailer, resulting in damage to the Multi-Flex tailgate, the rear bumper, and the trailer. The vehicle has approximately 11,000 miles, was purchased new, and has not been modified. I have opened a case with General Motors, and the vehicle is scheduled to be inspected by an authorized Chevrolet dealership.

NHTSA complaint #11750324 — an unverified report by a vehicle owner.

LATCHES/LOCKS/LINKAGES

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the rear liftgate independently opened while there was cargo loaded inside the bed of the vehicle. There was no warning light illuminated. The contact stated that while the vehicle was parked in the garage, after inspecting the vehicle the rear liftgate had independently opened, causing damages to the garage door. The vehicle was taken to a local dealer, where it was diagnosed; however, the failure could not be duplicated. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 6,000.

NHTSA complaint #11750196 — an unverified report by a vehicle owner.

POWER TRAIN

The contact owns a 2025 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed and attempting to accelerate, the vehicle was stalling. The message "Transmission Service" was displayed on the instrument panel. The dealer was contacted and diagnosed the failure as a shifter assembly failure. The vehicle was not repaired because the part was not available. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,000.

NHTSA complaint #11749951 — an unverified report by a vehicle owner.

POWER TRAIN

My truck (2025 Chevy Silverado Trail Boss LZ0 Duramax 3.0l) started to have problems when driving. At a stop light, I started to accelerate at about 2000-3000 RPM. While doing so, there was a loud ticking/grinding noise coming from the transmission/Bell housing area. On June 2nd, I dropped the truck off with the dealership. I didn’t hear back from them until about a month later (July 3rd) and when I did they said the technician confirmed I needed a new ‘axle actuator’. About a week and a half later, they said it did not fix the issue and started to become more of a problem to where they will need an “engine technician” to see if I need a new engine due to the “crank shaft thrust bearing”. The advisor said he will call me on Wednesday, July 15th to update me on what I will need. I requested a Loaner vehicle since I dropped it off and they said no because the dealer does not provide that and would have to get approval from GM to grant me the loaner vehicle bast off the diagnostic.

NHTSA complaint #11750118 — an unverified report by a vehicle owner.

ENGINE

My truck (2025 Chevy Silverado Trail Boss LZ0 Duramax 3.0l) started to have problems when driving. At a stop light, I started to accelerate at about 2000-3000 RPM. While doing so, there was a loud ticking/grinding noise coming from the transmission/Bell housing area. On June 2nd, I dropped the truck off with the dealership. I didn’t hear back from them until about a month later (July 3rd) and when I did they said the technician confirmed I needed a new ‘axle actuator’. About a week and a half later, they said it did not fix the issue and started to become more of a problem to where they will need an “engine technician” to see if I need a new engine due to the “crank shaft thrust bearing”. The advisor said he will call me on Wednesday, July 15th to update me on what I will need. I requested a Loaner vehicle since I dropped it off and they said no because the dealer does not provide that and would have to get approval from GM to grant me the loaner vehicle bast off the diagnostic.

NHTSA complaint #11750118 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Tailgate unlatched while driving and all my items in the trunk fell out without me, knowing about it.

NHTSA complaint #11748256 — an unverified report by a vehicle owner.

POWER TRAIN

Leased a 2025 Chevy Silverado in late 2025. On June 13th 2026 driving home my vehicle all of a sudden had very little power, check engine light went on and thankfully I was at my driveway. Pulled into my residence, shut truck off and called the dealer I leased the truck from at 1:00 pm Satuarday, June 13th. They set me up with a loaner vehicle. I called for a tow truck Monday the June 15th and had truck delivered to dealership. Ive been told, they are looking into? Beyond that, nothing more.

NHTSA complaint #11747766 — an unverified report by a vehicle owner.

ENGINE

Leased a 2025 Chevy Silverado in late 2025. On June 13th 2026 driving home my vehicle all of a sudden had very little power, check engine light went on and thankfully I was at my driveway. Pulled into my residence, shut truck off and called the dealer I leased the truck from at 1:00 pm Satuarday, June 13th. They set me up with a loaner vehicle. I called for a tow truck Monday the June 15th and had truck delivered to dealership. Ive been told, they are looking into? Beyond that, nothing more.

NHTSA complaint #11747766 — an unverified report by a vehicle owner.