2011 Ford Escape problems

STEERING

I have a 2011 Ford Escape AWD 3.0 engine. I took it for NY state inspection and it fails due the right side front subframe is rusted and unsafe. Ford has a recall on models up to 2004 but this vehicle has the same issue of the A/C draining on it causing the rust. I have been an auto tech for over 48 years, retired now, and strongly feel this should be a major concern and covered at least 50% by Ford. This design flaw and the fact that I live in a state that uses salt in the winter on the roads, I feel there is nothing I could have done to prevent this from happening.

NHTSA complaint #11757910 — an unverified report by a vehicle owner.

SUSPENSION

I have a 2011 Ford Escape AWD 3.0 engine. I took it for NY state inspection and it fails due the right side front subframe is rusted and unsafe. Ford has a recall on models up to 2004 but this vehicle has the same issue of the A/C draining on it causing the rust. I have been an auto tech for over 48 years, retired now, and strongly feel this should be a major concern and covered at least 50% by Ford. This design flaw and the fact that I live in a state that uses salt in the winter on the roads, I feel there is nothing I could have done to prevent this from happening.

NHTSA complaint #11757910 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2011 Ford Escape. The contact stated that while operating the vehicle, the vehicle lost power steering functionality, and the steering wheel became difficult to turn in either direction. The vehicle was taken to the local mechanic, who diagnosed that the steering torque sensor had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in NHTSA Campaign Number: 14V284000 (STEERING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 150,000.

NHTSA complaint #11757463 — an unverified report by a vehicle owner.

STRUCTURE:BODY

I went for an oil change and my mechanic found that the subframe/cross member assembly was almost rusted through. Very dangerous. Needs to be replaced. Found out this is very common with the Ford Escape model of these years. Will cost thousands to repair.

NHTSA complaint #11756851 — an unverified report by a vehicle owner.

SEAT BELTS

The rear hatch clicks like it wants to open but doesn't release the latch to open it and I can't get to the place to release an lower the spare tire which is safety concern to me. Also the driver side seat belt casing broke and doesn't release every time you push button to unlatch it which can cause serious problems if in an accident I had a individual garage guy inspect an said he had replaced several latch mechanisms in the hatch for several escape owners i can't afford to have it replaced at this time. If we're to have a flat in extreme heat or extremely cold weather it can cause heat stroke or hypothermia. There were no warning signs one day wouldn't open. An seatbelt wouldn't release one day until pushed so hard the casing broke off an could push clip inside

NHTSA complaint #11753547 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

The rear hatch clicks like it wants to open but doesn't release the latch to open it and I can't get to the place to release an lower the spare tire which is safety concern to me. Also the driver side seat belt casing broke and doesn't release every time you push button to unlatch it which can cause serious problems if in an accident I had a individual garage guy inspect an said he had replaced several latch mechanisms in the hatch for several escape owners i can't afford to have it replaced at this time. If we're to have a flat in extreme heat or extremely cold weather it can cause heat stroke or hypothermia. There were no warning signs one day wouldn't open. An seatbelt wouldn't release one day until pushed so hard the casing broke off an could push clip inside

NHTSA complaint #11753547 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The rear hatch clicks like it wants to open but doesn't release the latch to open it and I can't get to the place to release an lower the spare tire which is safety concern to me. Also the driver side seat belt casing broke and doesn't release every time you push button to unlatch it which can cause serious problems if in an accident I had a individual garage guy inspect an said he had replaced several latch mechanisms in the hatch for several escape owners i can't afford to have it replaced at this time. If we're to have a flat in extreme heat or extremely cold weather it can cause heat stroke or hypothermia. There were no warning signs one day wouldn't open. An seatbelt wouldn't release one day until pushed so hard the casing broke off an could push clip inside

NHTSA complaint #11753547 — an unverified report by a vehicle owner.

STEERING

The steering shaft torque sensor unexpectedly malfunctioned while driving resulting in a loss of steering. There was no indication that this would happen, no check engine light was on, and no symptoms prior to the incident. The vehicle is undrivable due to a lack of steering and was diagnosed by an independent garage. The steering shaft torque sensor is recalled for other 2010 Ford Escapes, but not this one.

NHTSA complaint #11739089 — an unverified report by a vehicle owner.

STEERING

I was traveling at 20 mph and slowed to make a turn when the steering wheel took two hands to turn the wheel ... I knew it was a power steering issue. Happend all of a sudden with no warning and I was stuck in the middle of an intersection trying to turn around to go back home

NHTSA complaint #11734832 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2011 Ford Escape. The contact stated that while the vehicle was parked and occupied, while starting the vehicle the contact became aware that the vehicle had lost power steering functionality. The contact turned off and restarted the vehicle and the vehicle operated as intended. Neither an independent mechanic nor a dealer was contacted. The vehicle was not taken to a dealer nor an independent mechanic to be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 161,420.

NHTSA complaint #11729644 — an unverified report by a vehicle owner.

STEERING

Power steering went out all of a sudden

NHTSA complaint #11725981 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Power steering went out all of a sudden

NHTSA complaint #11725981 — an unverified report by a vehicle owner.

STEERING

The contact had performed service on the 2011 Ford Escape. The contact stated that the owner had experienced unintended loss of power steering functionality, making the steering wheel difficult to turn in either direction. The failure was intermittent. During the failure, the check engine warning light illuminated. Additionally, while the vehicle was idling, the steering wheel was turning from right to left independently. While servicing the vehicle, the DTC: B2278 was displayed. The contact was informed that the steering torque sensor needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failures. The contact was informed that the VIN was not included in NHTSA Campaign Number: 14V284000 (STEERING). The failure mileage was 199,003.

NHTSA complaint #11724177 — an unverified report by a vehicle owner.

STEERING

Torque sensor. No warning. Has not been looked at by a mechanic. Was working fine when I parked it. Came back out and it was steering funny and making a grinding sound

NHTSA complaint #11721082 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

Component: Driver-side door latch and lock assembly. The driver-side door latch appears to have failed, preventing the door from opening from both the inside and outside and creating an occupant entrapment risk. The failure is fully reproducible and ongoing. The condition first occurred without any prior warning signs, messages, or symptoms and has persisted for more than a day without resolving. Although the vehicle responds to unlock commands from the key fob, keypad, and interior door controls with normal audible confirmation, the driver door frequently remains unable to open. Failure behavior includes: •The driver door cannot be opened from inside the vehicle, preventing occupant exit. •The door also cannot be opened from the outside during these events. •An occupant became trapped inside and had to crawl across the vehicle and exit through the passenger side. •The vertical lock indicator moves between locked and unlocked positions, but the latch does not release. •The electronic systems appear functional, yet the mechanical latch does not respond. •Using the physical key can sometimes force the lock cylinder past a mechanical click point, temporarily allowing the door to open; however, this places the mechanism into abnormal states where the door may remain permanently unlocked or, when turned in the opposite direction, cannot be opened at all regardless of unlock attempts. •All other vehicle doors operate normally. Video evidence documenting the failure is available. This condition presents a serious safety concern because occupants could become trapped inside the vehicle during an emergency or after a crash, delaying rescue. The latch mechanism is a critical safety component that consumers cannot reasonably inspect, predict, or maintain. Given the life-safety implications of a door that cannot be opened from either side, this issue warrants investigation for potential defect trends.

NHTSA complaint #11718569 — an unverified report by a vehicle owner.

STRUCTURE:BODY

Component: Driver-side door latch and lock assembly. The driver-side door latch appears to have failed, preventing the door from opening from both the inside and outside and creating an occupant entrapment risk. The failure is fully reproducible and ongoing. The condition first occurred without any prior warning signs, messages, or symptoms and has persisted for more than a day without resolving. Although the vehicle responds to unlock commands from the key fob, keypad, and interior door controls with normal audible confirmation, the driver door frequently remains unable to open. Failure behavior includes: •The driver door cannot be opened from inside the vehicle, preventing occupant exit. •The door also cannot be opened from the outside during these events. •An occupant became trapped inside and had to crawl across the vehicle and exit through the passenger side. •The vertical lock indicator moves between locked and unlocked positions, but the latch does not release. •The electronic systems appear functional, yet the mechanical latch does not respond. •Using the physical key can sometimes force the lock cylinder past a mechanical click point, temporarily allowing the door to open; however, this places the mechanism into abnormal states where the door may remain permanently unlocked or, when turned in the opposite direction, cannot be opened at all regardless of unlock attempts. •All other vehicle doors operate normally. Video evidence documenting the failure is available. This condition presents a serious safety concern because occupants could become trapped inside the vehicle during an emergency or after a crash, delaying rescue. The latch mechanism is a critical safety component that consumers cannot reasonably inspect, predict, or maintain. Given the life-safety implications of a door that cannot be opened from either side, this issue warrants investigation for potential defect trends.

NHTSA complaint #11718569 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

Component: Driver-side door latch and lock assembly. The driver-side door latch appears to have failed, preventing the door from opening from both the inside and outside and creating an occupant entrapment risk. The failure is fully reproducible and ongoing. The condition first occurred without any prior warning signs, messages, or symptoms and has persisted for more than a day without resolving. Although the vehicle responds to unlock commands from the key fob, keypad, and interior door controls with normal audible confirmation, the driver door frequently remains unable to open. Failure behavior includes: •The driver door cannot be opened from inside the vehicle, preventing occupant exit. •The door also cannot be opened from the outside during these events. •An occupant became trapped inside and had to crawl across the vehicle and exit through the passenger side. •The vertical lock indicator moves between locked and unlocked positions, but the latch does not release. •The electronic systems appear functional, yet the mechanical latch does not respond. •Using the physical key can sometimes force the lock cylinder past a mechanical click point, temporarily allowing the door to open; however, this places the mechanism into abnormal states where the door may remain permanently unlocked or, when turned in the opposite direction, cannot be opened at all regardless of unlock attempts. •All other vehicle doors operate normally. Video evidence documenting the failure is available. This condition presents a serious safety concern because occupants could become trapped inside the vehicle during an emergency or after a crash, delaying rescue. The latch mechanism is a critical safety component that consumers cannot reasonably inspect, predict, or maintain. Given the life-safety implications of a door that cannot be opened from either side, this issue warrants investigation for potential defect trends.

NHTSA complaint #11718569 — an unverified report by a vehicle owner.

STEERING

I purchased this vehicle on 10/16/25 through Affordable Auto Sales 692 Pleasant St Fall River Ma as it is a buy here pay here. It had 97,626 miles on it day of purchase. I noticed trouble with power steering as it is electric and kept locking up and asked several times to fix it. It didn't get repaired until the week before Christmas. On 1-10-26, took it for first oil change and it had 100,837 miles in total I put 3,211 miles on it. The mechanic called me into the garage and showed me 3 things that were critically wrong with the vehicle. It had severe rot in front and rear, mostly rear, the transmission had a significant leak, and the power steering was still not properly fixed. The mechanic informed me that the dealership had not done their safety inspection and this was deemed an unsafe vehicle and I should not be driving it. I brought it to the attention of Affordable Auto sales and they are accusing me of the damage. The owner Lucy Sousa also changed the mileage on the paperwork saying I put 20,000 on itinerary 2 months time. She changed it to 82,294 which is false. I have my inspection report to show accurate mileage. I no longer have this vehicle. I returned it to them. I bought another vehicle from a different dealer.

NHTSA complaint #11716452 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I purchased this vehicle on 10/16/25 through Affordable Auto Sales 692 Pleasant St Fall River Ma as it is a buy here pay here. It had 97,626 miles on it day of purchase. I noticed trouble with power steering as it is electric and kept locking up and asked several times to fix it. It didn't get repaired until the week before Christmas. On 1-10-26, took it for first oil change and it had 100,837 miles in total I put 3,211 miles on it. The mechanic called me into the garage and showed me 3 things that were critically wrong with the vehicle. It had severe rot in front and rear, mostly rear, the transmission had a significant leak, and the power steering was still not properly fixed. The mechanic informed me that the dealership had not done their safety inspection and this was deemed an unsafe vehicle and I should not be driving it. I brought it to the attention of Affordable Auto sales and they are accusing me of the damage. The owner Lucy Sousa also changed the mileage on the paperwork saying I put 20,000 on itinerary 2 months time. She changed it to 82,294 which is false. I have my inspection report to show accurate mileage. I no longer have this vehicle. I returned it to them. I bought another vehicle from a different dealer.

NHTSA complaint #11716452 — an unverified report by a vehicle owner.

ENGINE

I purchased this vehicle on 10/16/25 through Affordable Auto Sales 692 Pleasant St Fall River Ma as it is a buy here pay here. It had 97,626 miles on it day of purchase. I noticed trouble with power steering as it is electric and kept locking up and asked several times to fix it. It didn't get repaired until the week before Christmas. On 1-10-26, took it for first oil change and it had 100,837 miles in total I put 3,211 miles on it. The mechanic called me into the garage and showed me 3 things that were critically wrong with the vehicle. It had severe rot in front and rear, mostly rear, the transmission had a significant leak, and the power steering was still not properly fixed. The mechanic informed me that the dealership had not done their safety inspection and this was deemed an unsafe vehicle and I should not be driving it. I brought it to the attention of Affordable Auto sales and they are accusing me of the damage. The owner Lucy Sousa also changed the mileage on the paperwork saying I put 20,000 on itinerary 2 months time. She changed it to 82,294 which is false. I have my inspection report to show accurate mileage. I no longer have this vehicle. I returned it to them. I bought another vehicle from a different dealer.

NHTSA complaint #11716452 — an unverified report by a vehicle owner.

STEERING

The contact owns a 2011 Ford Escape. The contact stated that upon starting the vehicle, the steering wheel failed to operate as intended. There was no warning light illuminated. The contact stated that the steering wheel was extremely tight, and excessive force was needed to steer the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with a defective steering column that needed to be replaced. Upon investigation, the contact discovered NHTSA Campaign Number: 14V284000 (Steering) and associated the failure with the recall. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,000.

NHTSA complaint #11714206 — an unverified report by a vehicle owner.

STEERING

My power steering has failed five times in the last year. Yes, my vehicle is available for inspection. The power steering went out on me while I was driving, making it very hard to turn my steering wheel. Took it to a Ford dealer last year. They said they couldn't find anything wrong with it. It is very unpredictable when this will happen. It doesn't happen every time I drive it. Don't feel very safe driving!

NHTSA complaint #11702115 — an unverified report by a vehicle owner.

STEERING

i have a cliking nose in my steering wheel when i am driving

NHTSA complaint #11698963 — an unverified report by a vehicle owner.