Owners have filed 736 complaints
about the 2003 Ford Escape with NHTSA between 2003 and 2025.
The largest single group is the body & structure.
Across this model's run it ranks 13 of 25 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 25
Against the median year of the Ford Escape. 50 means typical for this
model; 100 means roughly double.
Severity — 84
16.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 30
18% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
5032.1%
Engine
1912.2%
Frame AND Members
1811.5%
Automatic Transmission
1811.5%
Underbody Shields
159.6%
Frontal
149.0%
Accelerator Pedal
117.1%
Cables
117.1%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
152.5%
1,000 – 9,999 miles
284.7%
10,000 – 24,999 miles
335.6%
25,000 – 49,999 miles
6410.8%
50,000 – 74,999 miles
7913.4%
75,000 – 99,999 miles
9215.6%
100,000 – 149,999 miles
17129.0%
150,000+ miles
10818.3%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2003peak 17Apr 2025
NHTSA investigations into the 2003 Ford Escape
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
On July 8, 2012, The Center for Auto Safety has petitioned NHTSA to open defect investigations on Model Year (MY) 2002 ? 2004 Ford Escape and Mazda Tribute vehicles with certain cruise control cables.The Center for Auto Safety has also petitioned for a hearing to address whether Ford Motor Company (Ford) and Mazda North American Operations (Mazda) met their obligations to notify owners and correct a defect in certain Ford Escape and Mazda Tribute vehicles.The petitions to open investigations are denied as unnecessary and the petitions to conduct hearingsare denied.ODI IDs referenced above are:...
PE12019Opened 17 Jul 2012Closed 21 Feb 2013VEHICLE SPEED CONTROL:CABLES
Stuck Throttle
In a letter dated July 25, 2012 Ford Motor Company (Ford) submitted a Defect Information Report (DIR), NHTSA Recall No. 12V-353 to NHTSA identifying a safety defect involving inadequate clearance between the engine cover and the speed control cable connector, which could result in a stuck throttle condition.The vehicles involved are model year (MY) 2001 through MY 2004 Ford Escape vehicles equipped with 3.0L V6 engines and speed (cruise) control.A redesigned engine cover was implemented in production beginning in MY 2005, which provided additional clearance of the speed control cable to the en...
AQ10001Opened 18 Nov 2010Closed 28 Dec 2015UNKNOWN OR OTHER
Fleet Vehicle Recall Completion Audit
On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this...
EA10002Opened 14 Jan 2010Closed 29 Feb 2012SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Engine Compartment Fire
Ford and Mazda recalled model year (MY) 2001 through 2004 Ford Escape (07V-156) and Mazda Tribute (07V-157) vehicles due to non-crash fires or non-fire thermal events originating in the engine compartment at or near the ABS control module.Approximately 545,700 vehicles were subject to the initial safety recalls and approximately 424,700 vehicles were serviced under those campaigns. The campaigns addressed potentially damaged, missing or misplaced seals in the ABS control module wiring harness electrical connector that could allow brake fluid to enter the connector, possibly resulting in corros...
IN LETTERS DATED MARCH 30, 2007, FORD MOTOR COMPANY (FORD) AND MAZDA NORTH AMERICAN OPERATIONS (MAZDA) NOTIFIED THE AGENCY THAT THEY WILL CONDUCT RECALLS 07V-156 AND 07V-157, RESPECTIVELY, TO REMEDY A SAFETY DEFECT THAT MAY RESULT IN FIRE IN A WIRING CONNECTOR USED IN CERTAIN MODEL YEAR (MY) 2001-2004 FORD ESCAPE AND MAZDA TRIBUTE VEHICLES EQUIPPED WITH ABS.THE RECALL CAMPAIGN PRESCRIBES AN INSPECTION OF THE SUBJECT COMPONENTS, WHICH SHALL BE REPAIRED OR REPLACED ONLY IF NECESSARY.IF THE SUBJECT VEHICLE PASSES THE VISUAL INSPECTION THEN THE RECALL INSTRUCTS THE TECHNICIAN TO APPLY ELECTRICAL G...
THE OFFICE OF DEFECTS INVESTIGATION (ODI) RECEIVED A DEFECT PETITION DATED MARCH 5, 2009 ALLEGING THAT THE PETITIONER NEVER RECEIVED THE RECALL REMEDY FOR 07V-156 AND THAT, AS A RESULT, THE PETITIONER'S MY2003 FORD ESCAPE CAUGHT FIRE AT THE ABS CONTROL MODULE.IN RESPONSE TO ODI FOLLOW-UP, THE MANUFACTURER VERIFIED THAT THE PETITIONER'S VEHICLE HAD IN FACT RECEIVED SERVICE RELATED TO SAFETY RECALL 07V156 - A FACT LATER CORROBORATED BY THE PETITIONER.CIRCUMSTANCES OF THE FIRE EXPERIENCED IN THE PETITIONER'S REMEDIED VEHICLE INDICATE THAT THE REMEDY WAS INEFFECTIVE.ADDITIONAL REVIEW BY ODI IDENTI...
IN LETTERS DATED MARCH 30, 2007, FORD AND MAZDA NOTIFIED NHTSA THAT THEY WILL CONDUCT SAFETY RECALLS TO REMEDY A SAFETY DEFECT THAT MAY RESULT IN FIRE IN A WIRING CONNECTOR USED IN CERTAIN MODEL YEAR (MY) 2001-2004 FORD ESCAPE AND MAZDA TRIBUTE SPORT UTILITY VEHICLES EQUIPPED WITH ABS.RECALL 07V-156 INVOLVES APPROXIMATELY 446,450 MY 2001-2004 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999 THROUGH JANUARY 23, 2004.RECALL 07V-157 INVOLVES APPROXIMATELY 95,300 MY 2001-2004 TRIBUTE VEHICLES MANUFACTURED FROM APRIL 17, 2000 THROUGH DECEMBER 19, 2003. ACCORDING TO THE MANUFACTURERS, THE ELECTRIC...
RP04002Opened 24 Jun 2004Closed 31 Aug 2004ENGINE AND ENGINE COOLING
ENGINE STALLING
SUMMARY:THE PETITIONER ALLEGES THAT AFTER HAVING THE RECALL REMEDY PERFORMED ON HER MODEL YEAR (MY) 2001 FORD ESCAPE, IT CONTINUED TO EXHIBIT AN INTERMITTENT STALL CONDITION.CONSEQUENTLY, SHE PETITIONED THE AGENCY TO EXAMINE THE ADEQUACY OF THE RECALL REMEDY FOR SAFETY RECALL 04V-165.ON APRIL 5, 2004, FORD MOTOR COMPANY (FORD) NOTIFIED THE AGENCY THAT IT WOULD CONDUCT A RECALL OF 321,903 MY 2001 THROUGH 2002 AND CERTAIN 2003 MY ESCAPE VEHICLES EQUIPPED WITH 3.0L ENGINES MANUFACTURED BETWEEN JANUARY 21, 2000 AND SEPTEMBER 11, 2002 AT THE KANSAS CITY ASSEMBLY PLANT.THESE VEHICLES EXHIBITED AN IN...
Recalls on the 2003 Ford Escape
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
15V606000
POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
Risk: If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
15E045000
SUSPENSION:FRONT:WHEEL BEARING
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Risk: Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
14V165000
STRUCTURE:FRAME AND MEMBERS
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
Risk: A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
12V353000
ENGINE AND ENGINE COOLING
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
Risk: A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
07V156000
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
Risk: AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
07E023000
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
Risk: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
04V602000
LATCHES/LOCKS/LINKAGES:DOORS:LATCH
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
Risk: IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
04V574000
VEHICLE SPEED CONTROL:CABLES
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
Risk: AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201543811 units in Canada
Powertrain
A safety defect may exist in vehicles in which remanufactured automatic transmissions were installed as service replacement parts. The shift lever bolt may not have been torqued to the proper torque specification. If the improperly torqued shift level bolt loosens and backs out, the shift lever may disengage from the transmission without warning, and the transmission may not respond to the shifter selection movement by the operator. This could result in the loss of transmission gear selection, and possible unintended vehicle movement, which would increase the risk of a crash causing injury and/or property damage. Correction: Dealers will inspect, and if necessary, replace the shift lever assembly and/or the shift level bolt torqued to the proper specification.
Recall 201411036,694 units in Canada
Suspension
On certain vehicles registered and operated in areas where road salt is used on the roadways during winter months for extended time periods (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island and Newfoundland-Labrador), the forward attachment point for the lower control arm may separate from the vehicle's subframe. This could affect vehicle handling and increase the risk of a crash causing injury and/or property damage. Correction: Dealers will install a newly designed reinforcement cross-brace.
Recall 201223544,653 units in Canada
Other
On certain vehicles equipped with a 3.0L V6 engine and speed control, inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. A stuck throttle may result in very high vehicle speeds and make it difficult to slow or stop the vehicle if the transmission is not shifted into neutral. This could result in a crash causing property damage and/or personal injury. Correction: Dealers will replace the rear engine cover fastener, which will raise the cover in the area of the speed control cable to provide adequate clearance between the cover the speed control cable connector.
Recall 200710736,546 units in Canada
Brakes
On certain vehicles, the electrical wiring connector to the ABS module may have been manufactured incorrectly. Over time, contaminants can enter the ABS electrical connector interface and corrode the terminals. This could cause the ABS warning indicator to illuminate, an open fuse, and in some instances, smoking, melting or burning of the electrical connector, with the potential for a fire while the vehicle is unattended. In addition, ABS function may be lost. Correction: Dealers will inspect and, if required, repair the wiring connector.
Recall 200442638,034 units in Canada
Engine
On certain vehicles equipped with 3.0L V6 engines, the accelerator cable's inner liner may, over time, migrate out of the conduit at the dash panel fitting during vehicle operation. The liner may migrate to the point that it contacts the accelerator pedal arm. Under these conditions the liner may prevent the pedal from fully returning, which may not allow the throttle body to fully return to the "idle" position. Typically the condition results in a progressive increase in the "idle" speed if liner migration continues over time, but may cause a more sudden increase if a greater portion of the cable moves at one time. An unexpected increase in "idle" speed may result in longer than expected stopping distances, which could potentially lead to a crash. Correction: Dealers will replace the accelerator cable.
Recall 200412624,130 units in Canada
Engine
On certain vehicles equipped with a 3.0L V6 engine, during deceleration at vehicle speeds below 64 km/h, the engine may stall due to an excessively rich fuel-air mixture. Correction: Dealer will reprogram the Powertrain Control Module.
Reports where the owner recorded a crash, a fire, an injury or a death.
Rockfalls, ILCrash
ELECTRICAL SYSTEM
Never received a recall letter or notice
NHTSA complaint #11612466 — an unverified report by a vehicle owner.
Easley, SCCrash1 injured
AIR BAGS
I had a rear end at fault collision that totaled my 2003 Ford Escape on Dec.19, 2021....not one air bag deflated (yes I was at fault) because I was the one whom ran into the back of a jeep.....I'm having neck pain and spasms from whiplash, just curious whu not 1 airbG in the whole car deflated?
NHTSA complaint #11445539 — an unverified report by a vehicle owner.
Birmingham, ALFire
UNKNOWN OR OTHER
The contact owns a 2003 Ford Escape. The contact's nephew stated while driving approximately 35 mph, there was smoke coming from under the hood. The contact pulled over and fire started coming from under the hood. The fire department was called out however, the fire was extinguished before they arrived. A fire report was filed. The vehicle was towed back to the contact's sister’s residence. The vehicle was diagnosed but was not repaired. The contact stated there was no warning light illuminated. The manufacturer was informed of the failure. The failure mileage was unavailable.
NHTSA complaint #11424099 — an unverified report by a vehicle owner.
at 115,000 milesMoses Lake, WAFire
SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE ENTERING THE DRIVEWAY TO PARK, THERE WAS SMOKE PRESENT. THE CONTACT EXITED THE VEHICLE AND OPENED THE HOOD WHEN A FIRE WAS DISCOVERED. THE CONTACT GRABBED A WATER HOSE AND EXTINGUISHED THE FIRE. THE ABS MODULE CONNECTOR WAS MELTED ALONG WITH WIRES. AT THE TIME OF THE INCIDENT THE CONTACT WAS PREGNANT AND HAD HER 4-YEAR-OLD DAUGHTER IN THE VEHICLE. NO INJURIES WERE SUSTAINED. THE FIRE DEPARTMENT WAS NOT CONTACTED. NO POLICE REPORT WAS FILED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED BUT THERE WAS A RECORDING STATING THAT NO CALLS WERE BEING ACCEPTED AT THE MOMENT. THE LOCAL DEALER (UNKNOWN DEALER INFORMATION) WAS THEN CALLED WHERE THEY MENTIONED THAT NHTSA ACTION NUMBER: PE06048 (SERVICE BRAKES, HYDRAULIC) WAS PREVIOUSLY PERFORMED ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.
NHTSA complaint #11340612 — an unverified report by a vehicle owner.
at 175,000 milesYOE, PAFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE HIS VEHICLE WAS NOT RUNNING AND SITTING IN HIS DRIVEWAY, THE VEHICLE CAUGHT ON FIRE WITHOUT WARNING. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE ON HIS OWN, NO INJURIES OCCURRED AND NO FIRE REPORT WAS TAKEN. UPON INVESTIGATION THE CONTACT ASSOCIATED NHTSA CAMPAIGN NUMBER: 07V156000 (ELECTRICAL SYSTEM) WITH HIS FAILURE. THE CONTACT SPOKE WITH A DEALER (APPLE FORD 3250 CAPE HORN RD, RED LION, PA 17356 717-429-0726) AND WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE/FIRE. THE DEALER INFORMED THE CONTACT THAT THE FIRE WAS RELATED TO THE RECALL ASSOCIATED WITH THE VEHICLE. WHEN THE CONTACT INFORMED THE MANUFACTURER OF THE FAILURE, THEY INFORMED HIM THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 175,000.
NHTSA complaint #11245320 — an unverified report by a vehicle owner.
at 98,500 milesHouston, TXFire
ENGINE
TL* THE CONTACT OWNED A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED ON A RANCH, SOMEONE LOOKED OUT THE WINDOW AND FOUND THE VEHICLE ON FIRE. THE POLICE AND THE FIRE DEPARTMENT WERE CALLED TO THE SCENE AND THE FIRE WAS EXTINGUISHED. A FIRE REPORT AND POLICE REPORT WERE FILED. NO INJURIES WERE REPORTED. THE VEHICLE WAS TOTALED AND WAS NOT TOWED AWAY. THE DEALER WAS NOT CALLED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT INQUIRED ABOUT NHTSA CAMPAIGN NUMBER: 07V156000 (SERVICE BRAKES, HYDRAULIC) HOWEVER THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 98,500.
NHTSA complaint #11233323 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Springfield, OH
AIR BAGS
I was doordashing as it's my job and all of sudden my car starts not idling won't stay off od off switch that switch stayed consistently flickered either the engine or transmission is slipping or misfiring
NHTSA complaint #11655657 — an unverified report by a vehicle owner.
Springfield, OH
ENGINE
I was doordashing as it's my job and all of sudden my car starts not idling won't stay off od off switch that switch stayed consistently flickered either the engine or transmission is slipping or misfiring
NHTSA complaint #11655657 — an unverified report by a vehicle owner.
Rockfalls, ILCrash
ELECTRICAL SYSTEM
Never received a recall letter or notice
NHTSA complaint #11612466 — an unverified report by a vehicle owner.
at 122,000 milesGlendale Heights, IL
STRUCTURE
The contact owns a 2003 Ford Escape. The contact stated that the front wheel would extend outward while turning the vehicle, braking, or during acceleration, causing the vehicle to slightly veer to the right. The vehicle was taken to the dealer where it was diagnosed that the front passenger’s side control arm had slightly detached. The dealer informed the contact the failure was a result of NHTSA Campaign Number: 14V165000 (Structure) and the vehicle was included; however, the fix needed exceeded the repair stated in the recall remedy. The dealer diagnosed that the front subframe was extremely rusted and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened. The contact was also referred to NHTSA Hotline to file a complaint. The approximate failure mileage was 122,000.
NHTSA complaint #11564147 — an unverified report by a vehicle owner.
at 130,000 milesSaxonburg, PA
ELECTRICAL SYSTEM
The contact owns a 2003 Ford Escape. The contact stated that upon starting the vehicle, and while driving at unknown speeds, the vehicle was smoking. There were no warning lights illuminated. The owner disconnected the battery. The vehicle was taken to an independent mechanic who informed the owner that the ABS module and wiring harness needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 130,000.
NHTSA complaint #11529512 — an unverified report by a vehicle owner.
at 130,000 milesSaxonburg, PA
SERVICE BRAKES, AIR:ANTILOCK:CONTROL UNIT/MODULE
The contact owns a 2003 Ford Escape. The contact stated that upon starting the vehicle, and while driving at unknown speeds, the vehicle was smoking. There were no warning lights illuminated. The owner disconnected the battery. The vehicle was taken to an independent mechanic who informed the owner that the ABS module and wiring harness needed to be replaced. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 130,000.
NHTSA complaint #11529512 — an unverified report by a vehicle owner.
Chicago, IL
SUSPENSION
Driver had uneasy feeling with stability of vehicle as if it was swaying. He got it looked at and was told he probably needed lower control arm and links to take care of the problem. After ordering parts, the vehicle, while driving to work, a loud popping sound was heard and then the vehicle dropped down and had to be towed home (thank God this didn't happen on the expressway). I then looked up any recalls on this vehicle and low and behold there was a recall on this year, make and model car BUT not on this VIN number (Ford's number for this recall is 14S02. Recall date 2014-04-02 Recall no.14V165000). This vehicle suddenly and dangerously broke down from this same problem, and has the same issue that was recalled by Ford on this make, model and year described in their recall (14S02) but the VIN number seems to say otherwise when I looked it up. This needs to be investgated before this happens to someone while driving in snow or rainy condtions or while driving on the expressway. Please investigate!
NHTSA complaint #11456359 — an unverified report by a vehicle owner.
Easley, SCCrash1 injured
AIR BAGS
I had a rear end at fault collision that totaled my 2003 Ford Escape on Dec.19, 2021....not one air bag deflated (yes I was at fault) because I was the one whom ran into the back of a jeep.....I'm having neck pain and spasms from whiplash, just curious whu not 1 airbG in the whole car deflated?
NHTSA complaint #11445539 — an unverified report by a vehicle owner.
Birmingham, ALFire
UNKNOWN OR OTHER
The contact owns a 2003 Ford Escape. The contact's nephew stated while driving approximately 35 mph, there was smoke coming from under the hood. The contact pulled over and fire started coming from under the hood. The fire department was called out however, the fire was extinguished before they arrived. A fire report was filed. The vehicle was towed back to the contact's sister’s residence. The vehicle was diagnosed but was not repaired. The contact stated there was no warning light illuminated. The manufacturer was informed of the failure. The failure mileage was unavailable.
NHTSA complaint #11424099 — an unverified report by a vehicle owner.
Fayetteville, AR
VEHICLE SPEED CONTROL
I was recently driving on the interstate and the gas pedal got stuck so the car started speeding up very fast and the brakes and emergency brake would not make it slow down. After this i found out there was a recall about this problem and it says the previous owner of the vehicle fixed it but it’s happened while i owned it so i don’t think it was fixed correctly.
NHTSA complaint #11423859 — an unverified report by a vehicle owner.
Fayetteville, AR
SERVICE BRAKES
I was recently driving on the interstate and the gas pedal got stuck so the car started speeding up very fast and the brakes and emergency brake would not make it slow down. After this i found out there was a recall about this problem and it says the previous owner of the vehicle fixed it but it’s happened while i owned it so i don’t think it was fixed correctly.
NHTSA complaint #11423859 — an unverified report by a vehicle owner.
at 150,000 milesBrownsville, KY
POWER TRAIN
DRIVING DOWN THE INTERSTATE COMING FROM GEORGIA, IT WOULD DOWNSHIFT SUDDENLY WITHOUT WARNING. I HAVE NOT BEEN ABLE TO DRIVE IT IN ABOUT 4 MONTHS.I THOUGHT I HAD EVERYTHING REPAIRED, THEN MY TRUCK STOPPED PULLING IN DRIVE AT A RED LIGHT. MY SAFETY NEUTRAL SWITCH IS BRAND NEW AND THE POSITION SENSOR. 10/12/2020 WHEN PROBLEM AROSE AFTER REPLACING SENSORS 02/09/2021 ANY IDEAS WHY IT IS DOING THIS?
NHTSA complaint #11398303 — an unverified report by a vehicle owner.
at 150,000 milesBrownsville, KY
VEHICLE SPEED CONTROL
DRIVING DOWN THE INTERSTATE COMING FROM GEORGIA, IT WOULD DOWNSHIFT SUDDENLY WITHOUT WARNING. I HAVE NOT BEEN ABLE TO DRIVE IT IN ABOUT 4 MONTHS.I THOUGHT I HAD EVERYTHING REPAIRED, THEN MY TRUCK STOPPED PULLING IN DRIVE AT A RED LIGHT. MY SAFETY NEUTRAL SWITCH IS BRAND NEW AND THE POSITION SENSOR. 10/12/2020 WHEN PROBLEM AROSE AFTER REPLACING SENSORS 02/09/2021 ANY IDEAS WHY IT IS DOING THIS?
NHTSA complaint #11398303 — an unverified report by a vehicle owner.
at 150,000 milesBrownsville, KY
STEERING
DRIVING DOWN THE INTERSTATE COMING FROM GEORGIA, IT WOULD DOWNSHIFT SUDDENLY WITHOUT WARNING. I HAVE NOT BEEN ABLE TO DRIVE IT IN ABOUT 4 MONTHS.I THOUGHT I HAD EVERYTHING REPAIRED, THEN MY TRUCK STOPPED PULLING IN DRIVE AT A RED LIGHT. MY SAFETY NEUTRAL SWITCH IS BRAND NEW AND THE POSITION SENSOR. 10/12/2020 WHEN PROBLEM AROSE AFTER REPLACING SENSORS 02/09/2021 ANY IDEAS WHY IT IS DOING THIS?
NHTSA complaint #11398303 — an unverified report by a vehicle owner.
at 194,000 milesSAN Antonio, TX
POWER TRAIN
I HAVE A 2003 FORD ESCAPE AND I HAVE HAD TO REPLACE 2 OF THE SHIFTER CABLES. THE CABLES TO ALLOW THE TRUCK TO GO FROM PRND12.ON THE DASHBOARD IF THE BLACK BOLD SQUARE ISN'T AROUND THE P WHEN I TURN OFF THE TRUCK THEN I CANNOT TAKE MY KEY OUT OF THE IGNITION WHEN PARKED.I DO NOT WANT THE VEHICLE TO KEEP MOVING .
NHTSA complaint #11394382 — an unverified report by a vehicle owner.
Ashland, OH
SUSPENSION
WHILE REPLACING THE CONTROL ARMS ON MY 2003 FORD ESCAPE XLT 4X4 I NOTICED ON THE PASSENGER SIDE THERE WAS ALOT OF CORROSION SO MUCH SO THE CONTROL ARM IS BARELY HANGING ON THERE IS A FLAT BAR RUNNING FROM DRIVERS SIDE TO PASSENGER SIDE WHICH HAS BEEN RENDERED USELESS BECAUSE THE BOLT THAT IS USED TO HOLD IT IN PLACE HAS NOTHING TO BOLT TO THIS WAS SUPPOSED TO FIX THE ISSUE WITH CORROSION WELL IT HASN'T ITS NOW GONNA COST ME GOD KNOWS HOW MUCH TO FIX I WOULD LIKE TO KNOW IF THIS ISSUE IS STILL COVERED UNDER, THE RECALL
NHTSA complaint #11387401 — an unverified report by a vehicle owner.
at 106,500 milesAlexandria, VA
SUSPENSION
RECALL #14S02 (NHTSA CAMPAIGN # 14V165000) COVERED REPLACEMENT OF LOWER CONTROL ARM & BALLPOINT FOR EVERY NEARBY STATE, BUT NOT VIRGINIA. BOTH LOWER CONTROL ARMS ON MY VEHICLE ARE CORRODED AND IN NEED OF REPLACEMENT, BUT THERE IS NO OPEN RECALL FOR MY VIN BECAUSE 14S02 DID NOT INCLUDE VIRGINIA. DRIVING VEHICLE WITH CORRODED CONTROL ARMS IS DEEMED DANGEROUS, BUT COSTS OF REPLACING APPROACH VEHICLE VALUE.
NHTSA complaint #11385460 — an unverified report by a vehicle owner.
at 140,000 milesGettysburg, PA
POWER TRAIN
VEHICLE MOVED FORWARD WHEN IN REVERSE GEAR WHEN I WAS TRYING TO BACK UP AT WORK. I HAD TO HAVE PEOPLE AT WORK COME HELP ME PULL THE VEHICLE BACKWARDS TO AVOID CRASHING INTO THE WALL. IT STILL ONLY GOES FORWARD, EVEN IN REVERSE GEAR. IT IS NOT SAFE TO DRIVE!!!
NHTSA complaint #11353342 — an unverified report by a vehicle owner.
Allen Park, MI
SUSPENSION
FORD ESCAPES FROM THE 2001 THROUGH 2004 MODEL YEARS FOR CORROSION OF THE FRONT SUBFRAME. THE SUBFRAME CARRIES THE ENGINE, TRANSMISSION, STEERING GEAR AND THE FRONT SUSPENSION, BRAKES AND WHEELS FORD SAYS THE CORROSION CAN LEAD TO SEPARATION OF A CONTROL ARM -- PART OF THE SUSPENSION THAT HOLDS THE WHEEL AND TIRE IN THE RIGHT PLACE I WAS TOLD THAT THIS PART NEEDS TO BE REPLACED ON MY CAR. IT'S CORRODED BY A MECHANIC. THAN I READ THE USA TODAY 2014 ARTICLE. I WAS NEVER NOTIFIED. I JUST TOOK VIDEO AND PICTURES OF THE PART. ON MY CELL PHONE I CAN SUBMITT. ACCORDING TO THIS ARTICLE FORD KNEW ABOUT THIS. WHAT R MY OPTION TO GET THE REPAIR.
NHTSA complaint #11349735 — an unverified report by a vehicle owner.
at 229,000 milesLittle Rock, AR
POWER TRAIN
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. MARK MCLARTY FORD LOCATED AT 4400 LANDERS RD, NORTH LITTLE ROCK, AR 72117, (501) 945-1200, WAS CONTACTED AND MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V606000 (POWER TRAIN) AND 04V165000 (POWER TRAIN), HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 229,000.
NHTSA complaint #11343633 — an unverified report by a vehicle owner.
at 229,000 milesLittle Rock, AR
POWER TRAIN
WHILE MY 2003 ESCAPE WAS IN MOTION, THE VEHICLE JERKED AND KICKED AD I PRESSED ACCELERATING ON A HEAVY CITY HIGHWAY. THE VEHICLE COULDN'T DRIVE OR MOVE FORWARD. I BELIEVE IT IS THE TRANSMISSION WENT OUT. THE GEARS WERE SLIPPING OR NOT GOING IN POSITION. I WAS USING MORE GAS, HAVING A RECALL ON TRANSMISSION WAS ANNOUNCED ON 2003 FORD ESCAPE. RECALL ID 234608 ON POWERTRAIN AUTOMATIC TRANSMISSION. AND RECALL ID 234607 AUTOMATIC TRANSMISSION: GEAR POSITION INDICATION. RECALL ID 234607 I CALLED THE FORD SERVICE CENTER. I WAS TOLD NO RECALLS UNDER MY VIN NUMBER. I ASKED FOR ASSISTANCE TO FIX MY TRANSMISSION. NO WAS ANSWER. I TOOK MY CAR BACK TO PLACE I PURCHASED IT CARTER'S RADIATOR, PURCHASED 5-8-2020. CARTER RADIATOR DID DIAGNOSE, FOUND IT WAS THE TRANSMISSION. I WAS TOLD CAR WILL NOT GO INTO GEARS. 4TH GEAR IS IN-OPERATIVE. ONY 1ST & 2ND GEARS OPERATING. TO REPAIR FAULTY TRANSMISSION WILL COST $3900, BUT BECAUSE I PURCHASED VEHICLE FROM THEM, REPAIR COST IS $2400.
NHTSA complaint #11343132 — an unverified report by a vehicle owner.
at 115,000 milesMoses Lake, WAFire
SERVICE BRAKES
TL* THE CONTACT OWNS A 2003 FORD ESCAPE. THE CONTACT STATED THAT WHILE ENTERING THE DRIVEWAY TO PARK, THERE WAS SMOKE PRESENT. THE CONTACT EXITED THE VEHICLE AND OPENED THE HOOD WHEN A FIRE WAS DISCOVERED. THE CONTACT GRABBED A WATER HOSE AND EXTINGUISHED THE FIRE. THE ABS MODULE CONNECTOR WAS MELTED ALONG WITH WIRES. AT THE TIME OF THE INCIDENT THE CONTACT WAS PREGNANT AND HAD HER 4-YEAR-OLD DAUGHTER IN THE VEHICLE. NO INJURIES WERE SUSTAINED. THE FIRE DEPARTMENT WAS NOT CONTACTED. NO POLICE REPORT WAS FILED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED BUT THERE WAS A RECORDING STATING THAT NO CALLS WERE BEING ACCEPTED AT THE MOMENT. THE LOCAL DEALER (UNKNOWN DEALER INFORMATION) WAS THEN CALLED WHERE THEY MENTIONED THAT NHTSA ACTION NUMBER: PE06048 (SERVICE BRAKES, HYDRAULIC) WAS PREVIOUSLY PERFORMED ON THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 115,000.
NHTSA complaint #11340612 — an unverified report by a vehicle owner.
South Hutchinson, KS
POWER TRAIN
SENSE WE BOUGHT THIS 2003 FORD ESCAPE WE HAVE REPLACED 5 ALTENATORS TRANSMISSION PROBLEMS .3 NEUTRAL SAFETY SWITCHES. AND STILL HAVING PROBLEMS THE TRANSMISSION PROBLEMS ARE THE SAME REASON FOR THE RECALL BUT MY CAR IS JUST A MONTH NEWER GO FIGURE
NHTSA complaint #11339318 — an unverified report by a vehicle owner.
South Hutchinson, KS
ELECTRICAL SYSTEM
SENSE WE BOUGHT THIS 2003 FORD ESCAPE WE HAVE REPLACED 5 ALTENATORS TRANSMISSION PROBLEMS .3 NEUTRAL SAFETY SWITCHES. AND STILL HAVING PROBLEMS THE TRANSMISSION PROBLEMS ARE THE SAME REASON FOR THE RECALL BUT MY CAR IS JUST A MONTH NEWER GO FIGURE
NHTSA complaint #11339318 — an unverified report by a vehicle owner.
Philadelphia, PA
WHEELS
I BROUGHT BRACES DRUMS FOR BACK WHEELS STILL IDONOT HAVE BRACES THEY DONOT WORK TOOK TO AUTO PLACE WAS TOLD TO CONTACT DEALER
NHTSA complaint #11338743 — an unverified report by a vehicle owner.