Owners have filed 533 complaints
about the 1996 Ford Ranger with NHTSA between 1996 and 2023.
The largest single group is the brakes.
Across this model's run it ranks 7 of 26 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 72
Against the median year of the Ford Ranger. 50 means typical for this
model; 100 means roughly double.
Severity — 100
21.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 5
3% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
10,000 – 24,999 miles
33.2%
25,000 – 49,999 miles
22.2%
50,000 – 74,999 miles
77.5%
75,000 – 99,999 miles
2526.9%
100,000 – 149,999 miles
3234.4%
150,000+ miles
2425.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 1996peak 25Feb 2023
Recalls on the 1996 Ford Ranger
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
09V399000
VEHICLE SPEED CONTROL
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Risk: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
09E025000
EXTERIOR LIGHTING:HEADLIGHTS
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
09E012000
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
08E050000
EXTERIOR LIGHTING:HEADLIGHTS
K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.
06E026000
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
01X001000
TIRES:TREAD/BELT
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
Risk: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
00T005000
TIRES:TREAD/BELT
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
Risk: IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
96V161000
EQUIPMENT:OTHER:LABELS
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Risk: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2009292492,877 units in Canada
Other
On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: Dealers will install a new switch or fused wiring harness. Note: This is an expansion of recall 2005028 (05S28) for vehicles not previously included in the campaign.
Reports where the owner recorded a crash, a fire, an injury or a death.
Louisville, KYFire
UNKNOWN OR OTHER
heading back from picking up meal at pizza hut when "POP" sound from front of truck and then cabin filled with smoke. within 20-30 seconds of exiting the car it was in flames (See attached photos) recall notification was never sent to current owner and current owner didnt own in 2009 when it was first recalled. Ford customer service informed that auto insurnace would be required to handle loss of vehicle, but current owner doesnt have comprehensive coverage so insurance company is unable to payout for loss due to fire. This recall should have been communicated to titled owner after purchase.
NHTSA complaint #11496290 — an unverified report by a vehicle owner.
at 80,000 milesMobile, AL1 injured
FUEL SYSTEM, GASOLINE
NANO AND MICRO PARTICULATES/CONTAMINANTS HAVE BEEN SPRAYED FROM AN AIRLINER AND CAUSED SEVERE DAMAGE TO MY BODY AND MY VEHICLE; IT INCLUDES FLAKES, TUBULES AND HIGHLY REFLECTIVE PARTICLES AND METALS. THE VEHICLE HAS STALLED AND LOST TWO GEARS AS A RESULT. IT HAS A GAS LEAKING ISSUE CAUSED BY THE TECHNOLOGY. I HAVE HAD TO GO TO THE EMERGENCY ROOM. MY VEHICLE HAS BEEN CONTAMINATED, DAMAGED AND SABATAGED AS WELL AS MY FAMILY MEMBERS VEHICLES, PERSONS AND PROPERTY. IT'S OCCURING ON AND OFF HIGHWAY. IT'S HAPPENING TO OTHER VEHICLES AS WELL. OIL AND BATTERY INTERIOR AND EXTERIORS AS WELL AS BODILY HARM, RISK AND INJURY. THE TECH AND PARTICULATES ARE HIGHLY DANGEROUS AND DESTRUCTIVE. [XXX] IS THE OFFENDING PARTY THAT CAUSED IT TO HAPPEN WITH THE FEDERAL AGENCIES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11300548 — an unverified report by a vehicle owner.
at 80,000 milesMobile, AL1 injured
ENGINE
NANO AND MICRO PARTICULATES/CONTAMINANTS HAVE BEEN SPRAYED FROM AN AIRLINER AND CAUSED SEVERE DAMAGE TO MY BODY AND MY VEHICLE; IT INCLUDES FLAKES, TUBULES AND HIGHLY REFLECTIVE PARTICLES AND METALS. THE VEHICLE HAS STALLED AND LOST TWO GEARS AS A RESULT. IT HAS A GAS LEAKING ISSUE CAUSED BY THE TECHNOLOGY. I HAVE HAD TO GO TO THE EMERGENCY ROOM. MY VEHICLE HAS BEEN CONTAMINATED, DAMAGED AND SABATAGED AS WELL AS MY FAMILY MEMBERS VEHICLES, PERSONS AND PROPERTY. IT'S OCCURING ON AND OFF HIGHWAY. IT'S HAPPENING TO OTHER VEHICLES AS WELL. OIL AND BATTERY INTERIOR AND EXTERIORS AS WELL AS BODILY HARM, RISK AND INJURY. THE TECH AND PARTICULATES ARE HIGHLY DANGEROUS AND DESTRUCTIVE. [XXX] IS THE OFFENDING PARTY THAT CAUSED IT TO HAPPEN WITH THE FEDERAL AGENCIES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11300548 — an unverified report by a vehicle owner.
at 300,000 milesCanoga Park, CAFire
ENGINE
TL* THE CONTACT OWNED A 1996 FORD RANGER. WHILE DRIVING 30 MPH, FLAMES APPEARED UNDER THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE CAUSE OF THE FIRE WAS UNKNOWN. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TOWED, BUT WAS DEEMED A TOTAL LOSS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED A CASE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000. *TR *JS *BF CONSUMER STATED BOTH ODI 11173289 AND 11173291 HAD MANUFACTURER DEFECT THAT CAUSED THE FIRE.
NHTSA complaint #11173291 — an unverified report by a vehicle owner.
Pittsford, MICrash1 injured
AIR BAGS
TL* THE CONTACT OWNS A 1996 FORD RANGER. WHILE DRIVING DOWN A HILL AT LESS THAN APPROXIMATELY 20 MPH, THE VEHICLE CRASHED INTO A TREE. NONE OF THE AIR BAGS DEPLOYED. THE DRIVER SUSTAINED MINOR BRUISING, WHICH DID NOT REQUIRE MEDICAL TREATMENT. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE MONTHS LATER. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11064581 — an unverified report by a vehicle owner.
at 127,000 milesPansey, ALFire
VEHICLE SPEED CONTROL
TL* THE CONTACT OWNS A 1996 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, SMOKE WAS EMITTED FROM UNDER THE HOOD. THE VEHICLE WAS MERGED ONTO THE SHOULDER OF THE ROAD AND AS THE HOOD WAS RAISED FLAMES STARTED TO RISE. THE CONTACT EXTINGUISHED THE FLAMES AND NOTICED THAT THE WIRES FROM THE VEHICLE SPEED CONTROL STARTED THE FIRE. AS A RESULT, THE WIRES FOR THE MASTER CYLINDER SWITCH MELTED AND ALL OF THE BRAKE FLUID LEAKED OUT. THE FIRE DEPARTMENT WAS NOT NOTIFIED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED HOME. THE DEALER WAS NOT NOTIFIED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 127,000.
NHTSA complaint #10422848 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Crosby, TX
SEAT BELTS
Drivers side seat belt buckle does not work. The tongue on the long strap does not lock into the buckle at the seat. I think this may be a recall problem with other models and/or years, but not 1996 Ford Rangers.
NHTSA complaint #11509207 — an unverified report by a vehicle owner.
Louisville, KYFire
UNKNOWN OR OTHER
heading back from picking up meal at pizza hut when "POP" sound from front of truck and then cabin filled with smoke. within 20-30 seconds of exiting the car it was in flames (See attached photos) recall notification was never sent to current owner and current owner didnt own in 2009 when it was first recalled. Ford customer service informed that auto insurnace would be required to handle loss of vehicle, but current owner doesnt have comprehensive coverage so insurance company is unable to payout for loss due to fire. This recall should have been communicated to titled owner after purchase.
NHTSA complaint #11496290 — an unverified report by a vehicle owner.
Crosby, TX
SEAT BELTS
Drivers side seat belt buckle does not release. Broken about ten years. Currently using middle seat belt buckle.
NHTSA complaint #11451244 — an unverified report by a vehicle owner.
at 200,000 milesWinchester, KY
SUSPENSION
MY 96 FORD RANGER HAS TREMENDOUS FRAME ROT ON THE DRIVE SIDE AT THE FRONT OF THE SPRING SHACKLES. SOMEONE HAD SPRAYED RHINO LINER LIKE MATERIAL ON THE ROT TO COVER IT UP OR TO TRY TO MAKE IT HOLD. THE REST OF THE FRAME IS IN OUTSTANDING CONDITION EXCEPT FOR IT BEING ALMOST BROKEN INTO AT THE GAS TANK STRAP AND FRONT SHACKLES. I HAVE REPLACED EVERY FRONT END PART ON THIS TRUCK THINKING IT WAS IN THE FRONT SUSPENSION. WHEN DRIVING IT RUNS OUT OF LINE FROM THE REAR AND THE FRAME IS STARTING TO BEND.
NHTSA complaint #11366255 — an unverified report by a vehicle owner.
at 200,000 milesWinchester, KY
STRUCTURE:BODY
MY 96 FORD RANGER HAS TREMENDOUS FRAME ROT ON THE DRIVE SIDE AT THE FRONT OF THE SPRING SHACKLES. SOMEONE HAD SPRAYED RHINO LINER LIKE MATERIAL ON THE ROT TO COVER IT UP OR TO TRY TO MAKE IT HOLD. THE REST OF THE FRAME IS IN OUTSTANDING CONDITION EXCEPT FOR IT BEING ALMOST BROKEN INTO AT THE GAS TANK STRAP AND FRONT SHACKLES. I HAVE REPLACED EVERY FRONT END PART ON THIS TRUCK THINKING IT WAS IN THE FRONT SUSPENSION. WHEN DRIVING IT RUNS OUT OF LINE FROM THE REAR AND THE FRAME IS STARTING TO BEND.
NHTSA complaint #11366255 — an unverified report by a vehicle owner.
at 80,000 milesMobile, AL1 injured
FUEL SYSTEM, GASOLINE
NANO AND MICRO PARTICULATES/CONTAMINANTS HAVE BEEN SPRAYED FROM AN AIRLINER AND CAUSED SEVERE DAMAGE TO MY BODY AND MY VEHICLE; IT INCLUDES FLAKES, TUBULES AND HIGHLY REFLECTIVE PARTICLES AND METALS. THE VEHICLE HAS STALLED AND LOST TWO GEARS AS A RESULT. IT HAS A GAS LEAKING ISSUE CAUSED BY THE TECHNOLOGY. I HAVE HAD TO GO TO THE EMERGENCY ROOM. MY VEHICLE HAS BEEN CONTAMINATED, DAMAGED AND SABATAGED AS WELL AS MY FAMILY MEMBERS VEHICLES, PERSONS AND PROPERTY. IT'S OCCURING ON AND OFF HIGHWAY. IT'S HAPPENING TO OTHER VEHICLES AS WELL. OIL AND BATTERY INTERIOR AND EXTERIORS AS WELL AS BODILY HARM, RISK AND INJURY. THE TECH AND PARTICULATES ARE HIGHLY DANGEROUS AND DESTRUCTIVE. [XXX] IS THE OFFENDING PARTY THAT CAUSED IT TO HAPPEN WITH THE FEDERAL AGENCIES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11300548 — an unverified report by a vehicle owner.
at 80,000 milesMobile, AL1 injured
ENGINE
NANO AND MICRO PARTICULATES/CONTAMINANTS HAVE BEEN SPRAYED FROM AN AIRLINER AND CAUSED SEVERE DAMAGE TO MY BODY AND MY VEHICLE; IT INCLUDES FLAKES, TUBULES AND HIGHLY REFLECTIVE PARTICLES AND METALS. THE VEHICLE HAS STALLED AND LOST TWO GEARS AS A RESULT. IT HAS A GAS LEAKING ISSUE CAUSED BY THE TECHNOLOGY. I HAVE HAD TO GO TO THE EMERGENCY ROOM. MY VEHICLE HAS BEEN CONTAMINATED, DAMAGED AND SABATAGED AS WELL AS MY FAMILY MEMBERS VEHICLES, PERSONS AND PROPERTY. IT'S OCCURING ON AND OFF HIGHWAY. IT'S HAPPENING TO OTHER VEHICLES AS WELL. OIL AND BATTERY INTERIOR AND EXTERIORS AS WELL AS BODILY HARM, RISK AND INJURY. THE TECH AND PARTICULATES ARE HIGHLY DANGEROUS AND DESTRUCTIVE. [XXX] IS THE OFFENDING PARTY THAT CAUSED IT TO HAPPEN WITH THE FEDERAL AGENCIES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11300548 — an unverified report by a vehicle owner.
at 200,000 milesANN Arbor, MI
AIR BAGS
TAKATA RECALL. I CRASHED MY 1996 FORD RANGER IN 2010. BOTH AIRBAGS DEPLOYED. MY COLLISION SHOP REPLACED THE AIRBAGS WITH UNKNOWN YEAR FORD RANGER AIRBAGS, BUYING SOME NEW PARTS FROM FORD TO COMPLETE THE INSTALL. THERE IS NO WAY TO KNOW IF THESE ARE RECALLED TAKATA AIRBAGS WITHOUT AN INSPECTION. MY LOCAL FORD DEALERSHIP, VARSITY FORD IN ANN ARBOR MI, IS REFUSING TO DO ANYTHING WITHOUT A RECALL NOTICE. ANY INSPECTION, EVEN IF THESE ARE RECALLED AIRBAGS, WILL BE AT MY COST BECAUSE THIS IS A 1996 TRUCK. I CALLED FORD'S RECALL LINE AND EXPLAINED THE SITUATION, AND THEY REFERRED ME TO MY LOCAL DEALERSHIP. THERE SEEMS TO BE NO PLAN TO TRACK DOWN DANGEROUS TAKATA AIRBAGS INSTALLED AFTER MANUFACTURE, EVEN IF THEY WERE ORIGINALLY INSTALLED IN ANOTHER VEHICLE THAT WOULD HAVE BEEN RECALLED.
NHTSA complaint #11176583 — an unverified report by a vehicle owner.
at 300,000 milesCanoga Park, CAFire
ENGINE
TL* THE CONTACT OWNED A 1996 FORD RANGER. WHILE DRIVING 30 MPH, FLAMES APPEARED UNDER THE HOOD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED. THE CAUSE OF THE FIRE WAS UNKNOWN. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TOWED, BUT WAS DEEMED A TOTAL LOSS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED A CASE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 300,000. *TR *JS *BF CONSUMER STATED BOTH ODI 11173289 AND 11173291 HAD MANUFACTURER DEFECT THAT CAUSED THE FIRE.
NHTSA complaint #11173291 — an unverified report by a vehicle owner.
Pittsford, MICrash1 injured
AIR BAGS
TL* THE CONTACT OWNS A 1996 FORD RANGER. WHILE DRIVING DOWN A HILL AT LESS THAN APPROXIMATELY 20 MPH, THE VEHICLE CRASHED INTO A TREE. NONE OF THE AIR BAGS DEPLOYED. THE DRIVER SUSTAINED MINOR BRUISING, WHICH DID NOT REQUIRE MEDICAL TREATMENT. A POLICE REPORT WAS NOT FILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE MONTHS LATER. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA complaint #11064581 — an unverified report by a vehicle owner.
at 124,000 milesMalta, NY
STRUCTURE:BODY
TL* THE CONTACT OWNS A 1996 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE FAILED INSPECTION DUE TO EXTENSIVE RUST ON THE FRAME OF THE VEHICLE. THE INDEPENDENT MECHANIC STATED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THERE WAS NO RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 124,000.
NHTSA complaint #11012292 — an unverified report by a vehicle owner.
at 63,000 milesMoreno Valley, CA
SEAT BELTS
DRIVERS SIDE SEAT BELT WILL NOT STAY LATCHED INTO LATCHING MECHANISM
NHTSA complaint #10938011 — an unverified report by a vehicle owner.
at 219,200 milesMays Landing, NJ
UNKNOWN OR OTHER
THE WHOLE UNDERBODY AND FRAME IS RUSTED AND ROTTED. THE LEAF SPRING SHACKLES HAVE RUSTED AND ROTTED AWAY.
NHTSA complaint #10908184 — an unverified report by a vehicle owner.
at 219,200 milesMays Landing, NJ
SUSPENSION
THE WHOLE UNDERBODY AND FRAME IS RUSTED AND ROTTED. THE LEAF SPRING SHACKLES HAVE RUSTED AND ROTTED AWAY.
NHTSA complaint #10908184 — an unverified report by a vehicle owner.
at 219,200 milesMays Landing, NJ
STRUCTURE:BODY
THE WHOLE UNDERBODY AND FRAME IS RUSTED AND ROTTED. THE LEAF SPRING SHACKLES HAVE RUSTED AND ROTTED AWAY.
NHTSA complaint #10908184 — an unverified report by a vehicle owner.
at 147,000 milesFayetteville, OH
SERVICE BRAKES
TRUCK WAS PARKED ON THE GARAGE PAD FOR A WEEK. I OPENED THE HOOD AND CHECKED ALL FLUID LEVELS, AND FOUND THE BRAKE FLUID A LITTLE LOW. TOPPED OFF THE MASTER CYLINDER AND GOT BACK INTO THE TRUCK. STARTED ENGINE, AND PUSHED THE BRAKE PEDAL. IT WENT TO THE FLOOR, GOT OUT OF THE TRUCK AND HEARD FLUID DRIPPING. I LOOKED UNDER THE TRUCK AND SAW A PUDDLE OF BRAKE FLUID NEAR THE LEFT REAR WHEEL. I ASKED MY WIFE TO PUSH THE PEDAL DOWN AND I SAW BRAKE FLUID SPRAYING FROM THE MAIN STEEL BRAKE LINE. COULD HAVE BEEN A SERIOUS ACCIDENT AS THE TRUCK WAS USED ONE WEEK PRIOR TO THE ACCIDENT TO HAUL A FULL LOAD OF FIRE WOOD.
NHTSA complaint #10875143 — an unverified report by a vehicle owner.
at 40,000 milesMckinney, TX
SERVICE BRAKES
TL* THE CONTACT OWNED A 1996 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE ROLLED AWAY FOR A FEW SECONDS. THE FAILURE RECURRED INTERMITTENTLY AND BECAME PERMANENT. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS HOWEVER, THE CONTACT WAS UNCERTAIN OF THE REQUIRED REPLACEMENT PART. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000. THE VIN WAS UNAVAILALBE. THE CONTACT NO LONGER OWNED THE VEHICLE.
NHTSA complaint #10872304 — an unverified report by a vehicle owner.
at 129,000 milesEast Nassau, NY
STRUCTURE:BODY
EXTENSIVE RUST DETERIORATION ON STRUCTURAL FRAME MEMBERS WHICH IS SPREADING RAPIDLY. VARIOUS LOCATIONS. I'M VERY CONCERNED ABOUT THE RIGHT SIDE REAR LEAF SPRING MOUNT BREAKING LOOSE WHILE IN MOTION. THE REMAINDER OF THE TRUCK IS IN GENERALLY GOOD CONDITION. WHEN I BOUGHT IT FROM THE ORIGINAL OWNER 7/11, SOME FRAME BRACKETS HAD BEEN REPLACED, BUT THE FRAME APPEARED SOUND. VEHICLE WAS STATIONARY.
NHTSA complaint #10863143 — an unverified report by a vehicle owner.
at 100,000 milesHudson, NH
UNKNOWN OR OTHER
THE FRAME HAS EXPERIENCED SEVERE CORROSION INCLUDING THE SPARE TIRE MOUNT, CROSS MEMBERS, REAR BUMPER, LEAF SPRING SHACKLES, AND PERFORATIONS/RUST THROUGH OF THE MAIN FRAME RAILS.
NHTSA complaint #10824743 — an unverified report by a vehicle owner.
at 206,000 milesKingfield, ME
UNKNOWN OR OTHER
THE REAR BUMPER FELL OFF WHILE DRIVING DUE TO RUSTED FRAME RAILS THAT IT WAS ATTACHED TO.
NHTSA complaint #10722008 — an unverified report by a vehicle owner.
Holly Springs, MS
FUEL/PROPULSION SYSTEM
I HAVE A 1996 FORD RANGER AND WHEN I WAS FILLING UP THE GAS TANK I STARTED NOTICING A STRONG SMELL OF GAS THEN LATER CAME TO FIND OUT IT WAS LEAKING GAS. I HAVE COME TO FIND OUT THAT THIS IS A COMMON DEFECTED WITH THESE VEHICLES. I THINK THAT IT SHOULD BE ADDRESSED BEFORE SOMEONE GETS KILLED IF SOMEONE HAS NOT GOTTEN KILLED YET.
NHTSA complaint #10703092 — an unverified report by a vehicle owner.
at 146,000 milesBuda, TX
VEHICLE SPEED CONTROL
THE CONTROL CLUSTERS ON THE STEERING WHEEL HAVE BEEN AT A SUFFICIENTLY HIGH TEMPERATURE THAT THE PLASTIC COVERING OVER THE MICRO SWITCHES HAS DEFORMED AND ON OCCASION IT WILL STICK TO YOUR FINGERS. THE CENTER BUTTON ON THE LEFT SIDE HAS DISINTEGRATED TO THE POINT THAT THE ACTUAL MICRO BUTTON IS NOW OPERATED DIRECTLY THROUGH THE MISSING PORTION OF THE ORIGINAL COVERING. ONE OF THE MICRO BUTTONS ON THE RIGHT SIDE IS IN THE SAME CONDITION AND BOTH CONTROL CLUSTERS HAVE BROKEN LOOSE FROM THE STEERING WHEEL. WITH THE PROBLEMS FORD HAS HAD WITH FIRES I THOUGHT THEY WOULD OFFER SOME ASSISTANCE IN REPAIRING THIS DEFECT BUT BOTH THE LOCAL DEALERS I HAVE TAKEN IT TO HAVE INDICATED NO ASSISTANCE IS AVAILABLE, I GUESS WE WILL WAIT FOR THE FIRE THAT SPREADS THROUGH THE GARAGE AND TAKES DOWN THE WHOLE HOUSE. DEALERS THAT TURNED ME DOWN ARE BLUE BONNET IN NEW BRAUNFELS, TX AND GRIFFITH IN THE KYLE, TX AREA. THE CONTROL STILL ACTUALLY FUNCTIONS IF YOU CAN HOLD IT ALL TOGETHER LONG ENOUGH TO ACTIVATE THE MICRO SWITCHES AND YOU DON'T MIND GETTING STICKY BLACK GOOP ON YOUR FINGERS.
NHTSA complaint #10680744 — an unverified report by a vehicle owner.
at 146,000 milesBuda, TX
ELECTRICAL SYSTEM
THE CONTROL CLUSTERS ON THE STEERING WHEEL HAVE BEEN AT A SUFFICIENTLY HIGH TEMPERATURE THAT THE PLASTIC COVERING OVER THE MICRO SWITCHES HAS DEFORMED AND ON OCCASION IT WILL STICK TO YOUR FINGERS. THE CENTER BUTTON ON THE LEFT SIDE HAS DISINTEGRATED TO THE POINT THAT THE ACTUAL MICRO BUTTON IS NOW OPERATED DIRECTLY THROUGH THE MISSING PORTION OF THE ORIGINAL COVERING. ONE OF THE MICRO BUTTONS ON THE RIGHT SIDE IS IN THE SAME CONDITION AND BOTH CONTROL CLUSTERS HAVE BROKEN LOOSE FROM THE STEERING WHEEL. WITH THE PROBLEMS FORD HAS HAD WITH FIRES I THOUGHT THEY WOULD OFFER SOME ASSISTANCE IN REPAIRING THIS DEFECT BUT BOTH THE LOCAL DEALERS I HAVE TAKEN IT TO HAVE INDICATED NO ASSISTANCE IS AVAILABLE, I GUESS WE WILL WAIT FOR THE FIRE THAT SPREADS THROUGH THE GARAGE AND TAKES DOWN THE WHOLE HOUSE. DEALERS THAT TURNED ME DOWN ARE BLUE BONNET IN NEW BRAUNFELS, TX AND GRIFFITH IN THE KYLE, TX AREA. THE CONTROL STILL ACTUALLY FUNCTIONS IF YOU CAN HOLD IT ALL TOGETHER LONG ENOUGH TO ACTIVATE THE MICRO SWITCHES AND YOU DON'T MIND GETTING STICKY BLACK GOOP ON YOUR FINGERS.
NHTSA complaint #10680744 — an unverified report by a vehicle owner.
at 135,760 milesKennewick, WA
SEAT BELTS
IT TOOK SEVERAL ATTEMPTS TO GET THE DRIVERS SEAT BELT TO LATCH. SHORTLY AFTER THE SEAT BELT CAME UNLATCHED AS I WAS DRIVING. AFTER THAT THE BELT WON'T STAY LATCHED.
NHTSA complaint #10631361 — an unverified report by a vehicle owner.
at 180,000 milesMiddlesex, NC
TIRES
TL* THE CONTACT OWNS A 1996 FORD RANGER EQUIPPED WITH MICHELIN GOODRICH RADIAL TIRES, SIZE P225/70/R14. THE CONTACT STATED THAT AFTER ROTATING THE TIRES, A CRACK WAS DISCOVERED ON THE SIDE WALL OF THE TIRE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN WAS UNABLE TO SEE THE CRACK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS 15,000 AND THE VEHICLE FAILURE MILEAGE WAS 180,000.
NHTSA complaint #10626693 — an unverified report by a vehicle owner.