Owners have filed 353 complaints
about the 2005 Ford Ranger with NHTSA between 2005 and 2025.
The largest single group is the airbags.
Across this model's run it ranks 12 of 26 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 48
Against the median year of the Ford Ranger. 50 means typical for this
model; 100 means roughly double.
Severity — 83
16.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 44
26% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
2352.3%
Underbody Shields
715.9%
Engine
36.8%
Frame AND Members
36.8%
Pressure Monitoring AND Regulating Systems
24.5%
Accelerator Pedal
24.5%
TIE ROD Assembly
24.5%
Rear
24.5%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
94.3%
1,000 – 9,999 miles
167.7%
10,000 – 24,999 miles
136.3%
25,000 – 49,999 miles
3315.9%
50,000 – 74,999 miles
6631.9%
75,000 – 99,999 miles
2311.1%
100,000 – 149,999 miles
2914.0%
150,000+ miles
188.7%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2005peak 12Feb 2025
NHTSA investigations into the 2005 Ford Ranger
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
1
investigation is
still open.
EA15001Opened 24 Feb 2015Still openAIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE05066Opened 5 Dec 2005Closed 24 Mar 2006EXTERIOR LIGHTING:BRAKE LIGHTS
BRAKE LIGHTS INOPERATIVE
THIS PE WAS OPENED BASED ON TECHNICAL SERVICE BULLETIN (TSB) #05-6-19 ISSUED BY FORD MOTOR COMPANY AND SERVICE BULLETIN #09-008/5 ISSUED BY MAZDA MOTOR CORPORATION TO ADDRESS CONCERNS OF THE CENTER HIGH MOUNTED STOP LIGHT (CHMSL) WIRING HARNESS CHAFFING. THE TSB'S AFFECTED THE FORD SUPER CAB AND MAZDA CAB PLUS VEHICLES ONLY.SERVICE TECHNICIANS CONTACTED THE FORD HOTLINE BECAUSE IT WAS DIFFICULT FOR THE TECHNICIANS TO DIAGNOSE AND LOCATE THE CAUSE OF THE INOPERATIVE BRAKE LIGHTS.FORD AND MAZDA ISSUED THE TSB'S TO AID TECHNICIANS IN THE IDENTIFICATION AND REPAIR OF THE WIRE CHAFE CONDITION.OF AL...
Recalls on the 2005 Ford Ranger
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202410014,109 units in Canada
Airbag
Issue: On certain vehicles, the front passenger airbag may have been installed incorrectly during a previous recall repair. As a result, the airbag may not inflate properly in a crash. Note: This recall affects vehicles repaired by a Ford dealer during recalls 17S42 (Transport Canada recall 2017-633) or 18S02 (Transport Canada recall 2018-024). Safety Risk: An airbag that does not inflate properly can increase the risk of injury in a crash. Corrective Action: Ford will notify owners by mail and advise you to take your vehicle to a dealership to inspect and, if necessary, reinstall the front passenger airbag inflator correctly.
Recall 20210778,811 units in Canada
Airbag
Issue: This recall is for certain vehicles that had the driver-front and/or passenger-front airbag inflator replaced after a collision or theft. An obsolete airbag may have been installed. On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, may eventually degrade the propellant contained in the driver-front airbag. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, fragments could be propelled toward vehicle occupants or cause damage to the airbag assembly, preventing its proper function. Safety Risk: If the vehicle is involved in a crash requiring an airbag deployment, the airbag inflator could rupture and create a risk of injury. Corrective Action: The company will notify owners by mail and instruct you to take your vehicle to a Ford dealer to inspect the driver and/or passenger airbag inflator or module and replace it, if necessary. Note: The Canadian climate results in the propellant degrading slowly. This recall is being conducted as a precaution to address future risk. It is expected that all airbag inflators will be replaced before their function would be affected.
Recall 201763326,633 units in Canada
Airbag
On certain vehicles, the driver and/or passenger frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. This recall supersedes recall 2015-231 (Ford recall 15S22) and recall 2016-033 (Ford recall 16S03) for these same vehicles and inflators. The recall remedy parts for those recalls were an interim repair and must be replaced with final repair inflators. Correction: Dealers will replace the driver and passenger airbag inflator with a new design inflator.
Recall 201603329,335 units in Canada
Airbag
On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Correction: Dealers will replace the front driver airbag inflator. Note: This recall is superseded by recall 2017633. Please see recall 2017633 for more information. <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2017633">Click here for more information</a>
Recall 201523129,458 units in Canada
Airbag
On certain vehicles, the passenger frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the passenger airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Correction: Dealers will replace airbag inflators. Note: This recall is superseded by recall 2017633. Please see recall 2017633 for more information. <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2017633">Click here for more information</a>
Reports where the owner recorded a crash, a fire, an injury or a death.
at 130,000 milesKennewick, WACrash1 injured
AIR BAGS
The contact owned a 2005 Ford Ranger. The contact stated while driving at 50 MPH, the vehicle was rear-ended by a driver who ran the stop sign. The impact caused the vehicle to flip over multiple times. The air bags failed to deploy. The contact suffered severe head trauma and PTSD from the accident. It was unknown if the other driver sustained any injuries. The contact was taken to the local hospital where medical attention was received for his injuries. A police report was filed. The vehicle was towed to a local salvage junkyard. The VIN was included in NHTSA Campaign Number 23V306000 (Air Bags). The local dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000. The VIN was not available.
NHTSA complaint #11591400 — an unverified report by a vehicle owner.
at 205,000 milesBaltimore, MDCrash
AIR BAGS
The contact owned a 2005 Ford Ranger. The contact stated while driving approximately 10 MPH, the vehicle struck the rear of another vehicle causing a fender bender. The contact stated that the front air bags deployed, and a powdery substance and metal fragments flew out of the air bag and landed on the contact. No injuries were sustained. No medical attention was required. A police report was filed. The vehicle was towed to an independent mechanic and deemed a total loss. The contact stated that he then received notification of the NHTSA Campaign Number: 17V880000 (Air Bags). An unnamed dealer and the manufacturer were notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 205,000.
NHTSA complaint #11526653 — an unverified report by a vehicle owner.
Salem, NHCrash1 injured
AIR BAGS
I was in an accident and the airbags did not inflate. I was going 30-35 MPH, there was a patch of ice, and I hit a tree. The truck was totaled. I smashed my face on the steering wheel, fracturing a bone. Some weeks later I received a letter in the mail from Ford Motor Company with regards to a passenger side airbag recall. I am afraid that this could perhaps be a bigger problem than just passenger side airbags.
NHTSA complaint #11516807 — an unverified report by a vehicle owner.
Dunlop, TNCrash1 injured
AIR BAGS
The contact owned a 2005 Ford Ranger. The contact stated while driving 40 MPH during rain weather conditions, the contact lost control of the vehicle while going around a curve, causing the vehicle to crash into a ditch. No air bags deployed. The contact suffered a head injury and several other unknown injuries due to the seat belt. The paramedic had to cut the seat belt to release the contact from the vehicle. The contact was taken to the hospital to seek medical attention. A police report was filed. The vehicle was towed and was deemed a total loss by the insurance company. The dealer was not contacted. The manufacturer was not contacted. The failure mileage was unknown.
NHTSA complaint #11516287 — an unverified report by a vehicle owner.
at 118,000 milesWilson, NCCrash
POWER TRAIN
I HAVE LEARNED THE HARD WAY THAT THE SHIFTER ON THE 2005 FORD RANGER EXTENDED CAB WILL JUMP OUT OF PARK TO REVERSE. THIS HAPPEN TO ME (JUST RECENTLY) AND CAUSED ME TO TEAR UP MY DOOR AND FENDER ON THE VEHICLE (WHICH WILL BE COSTLY)...
NHTSA complaint #11323211 — an unverified report by a vehicle owner.
at 200,043 milesPortland, ORCrash2 injured
TRACTION CONTROL SYSTEM
TL* THE CONTACT OWNS A 2005 FORD RANGER. WHILE DRIVING 5 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE. THE VEHICLE DROVE OVER AN ICY PATCH, SLID, AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED A STOMACH INJURY, BUT DID NOT RECEIVE MEDICAL ATTENTION. THE OTHER DRIVER SUSTAINED AN INJURED BACK. THE CONTACT DID NOT KNOW IF THE OTHER DRIVER SOUGHT MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE CONTACT'S VEHICLE WAS NOT DAMAGED AND WAS DRIVEN TO THE CONTACT'S HOME. THE VEHICLE WAS LATER TAKEN TO COURTESY FORD LINCOLN (313 NE 122ND AVE, PORTLAND, OR 97230), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200,043. THE VIN WAS UNKNOWN.
NHTSA complaint #11208054 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 223,000 milesSandy, OR
POWER TRAIN
The contact owns a 2005 Ford Ranger. The contact stated that upon arriving to the residence and applying the parking brake and exiting the vehicle, the vehicle started to roll backwards. The contact stated that the vehicle came to a complete stop after rolling across the street and through the neighbor’s fence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 223,000. The VIN was not available.
NHTSA complaint #11640744 — an unverified report by a vehicle owner.
at 223,000 milesSandy, OR
PARKING BRAKE
The contact owns a 2005 Ford Ranger. The contact stated that upon arriving to the residence and applying the parking brake and exiting the vehicle, the vehicle started to roll backwards. The contact stated that the vehicle came to a complete stop after rolling across the street and through the neighbor’s fence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 223,000. The VIN was not available.
NHTSA complaint #11640744 — an unverified report by a vehicle owner.
at 130,000 milesKennewick, WACrash1 injured
AIR BAGS
The contact owned a 2005 Ford Ranger. The contact stated while driving at 50 MPH, the vehicle was rear-ended by a driver who ran the stop sign. The impact caused the vehicle to flip over multiple times. The air bags failed to deploy. The contact suffered severe head trauma and PTSD from the accident. It was unknown if the other driver sustained any injuries. The contact was taken to the local hospital where medical attention was received for his injuries. A police report was filed. The vehicle was towed to a local salvage junkyard. The VIN was included in NHTSA Campaign Number 23V306000 (Air Bags). The local dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was approximately 130,000. The VIN was not available.
NHTSA complaint #11591400 — an unverified report by a vehicle owner.
Atoka, OK
AIR BAGS
See attached document for complaint
NHTSA complaint #11585848 — an unverified report by a vehicle owner.
at 228,000 milesAtoka, OK
AIR BAGS
The contact owns a 2005 Ford Ranger. The contact had taken the vehicle to be repaired under NHTSA Campaign Number: 23V125000 (Air Bags). The contact stated that while the vehicle was having the air bag replaced, the contact became aware that the passenger’s side air bag had not been seated correctly. The contact asked the Service Manager to return the vehicle to have the mechanic properly seat the air bag and secure the air bag correctly. The contact stated that the Service Manager attempted to adjust and tighten the air bag. The contact stated that the vehicle had been repaired but not in a safe manner. The manufacturer had been informed of the issue. The failure mileage was approximately 228,000.
NHTSA complaint #11551579 — an unverified report by a vehicle owner.
Elk Park, NC
SERVICE BRAKES, HYDRAULIC
The contact owns a 2005 Ford Ranger. The contact received notification of NHTSA Campaign Number: 23V306000 (Air Bags) and requested to be removed from the recall distribution list because the vehicle was totaled. The local dealer was contacted. The manufacturer was not contacted.
NHTSA complaint #11544124 — an unverified report by a vehicle owner.
at 205,000 milesBaltimore, MDCrash
AIR BAGS
The contact owned a 2005 Ford Ranger. The contact stated while driving approximately 10 MPH, the vehicle struck the rear of another vehicle causing a fender bender. The contact stated that the front air bags deployed, and a powdery substance and metal fragments flew out of the air bag and landed on the contact. No injuries were sustained. No medical attention was required. A police report was filed. The vehicle was towed to an independent mechanic and deemed a total loss. The contact stated that he then received notification of the NHTSA Campaign Number: 17V880000 (Air Bags). An unnamed dealer and the manufacturer were notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage was approximately 205,000.
NHTSA complaint #11526653 — an unverified report by a vehicle owner.
Salem, NHCrash1 injured
AIR BAGS
I was in an accident and the airbags did not inflate. I was going 30-35 MPH, there was a patch of ice, and I hit a tree. The truck was totaled. I smashed my face on the steering wheel, fracturing a bone. Some weeks later I received a letter in the mail from Ford Motor Company with regards to a passenger side airbag recall. I am afraid that this could perhaps be a bigger problem than just passenger side airbags.
NHTSA complaint #11516807 — an unverified report by a vehicle owner.
Dunlop, TNCrash1 injured
AIR BAGS
The contact owned a 2005 Ford Ranger. The contact stated while driving 40 MPH during rain weather conditions, the contact lost control of the vehicle while going around a curve, causing the vehicle to crash into a ditch. No air bags deployed. The contact suffered a head injury and several other unknown injuries due to the seat belt. The paramedic had to cut the seat belt to release the contact from the vehicle. The contact was taken to the hospital to seek medical attention. A police report was filed. The vehicle was towed and was deemed a total loss by the insurance company. The dealer was not contacted. The manufacturer was not contacted. The failure mileage was unknown.
NHTSA complaint #11516287 — an unverified report by a vehicle owner.
Silverdale, WA
AIR BAGS
At 200k miles I got an air bag light on my guage cluster. The blinking code corresponded to a bad connection at the CLOCKSPRING. I also noticed my cruise control and horn were also inoperable, also an indicator of a bad CLOCKSPRING. Ford part number 1l5z-14a664-ab is the replacement part and is currently unavailable, for the last 6 months. This part covers a few different models and has been exhausted by the dealers when correcting the Airbag recall. The dealer can not give me a date on a replacement part.
NHTSA complaint #11506987 — an unverified report by a vehicle owner.
Silverdale, WA
VEHICLE SPEED CONTROL
At 200k miles I got an air bag light on my guage cluster. The blinking code corresponded to a bad connection at the CLOCKSPRING. I also noticed my cruise control and horn were also inoperable, also an indicator of a bad CLOCKSPRING. Ford part number 1l5z-14a664-ab is the replacement part and is currently unavailable, for the last 6 months. This part covers a few different models and has been exhausted by the dealers when correcting the Airbag recall. The dealer can not give me a date on a replacement part.
NHTSA complaint #11506987 — an unverified report by a vehicle owner.
Silverdale, WA
UNKNOWN OR OTHER
At 200k miles I got an air bag light on my guage cluster. The blinking code corresponded to a bad connection at the CLOCKSPRING. I also noticed my cruise control and horn were also inoperable, also an indicator of a bad CLOCKSPRING. Ford part number 1l5z-14a664-ab is the replacement part and is currently unavailable, for the last 6 months. This part covers a few different models and has been exhausted by the dealers when correcting the Airbag recall. The dealer can not give me a date on a replacement part.
NHTSA complaint #11506987 — an unverified report by a vehicle owner.
Clarence Center, NY
UNKNOWN OR OTHER
My daughter called me screaming when her 2005 Ford Ranger FX4 Level 2 had unexplained runaway throttle while driving back to college in January 2022. The vehicle had the cruise control on for a couple hours and without warning, began to accelerate to the point that it was at the rev limiter, traveling at 90 miles an hour. She called me hysterical and I advised her to shut off the cruise and hit the brakes but nothing would stop her or turn off the cruise. I advised her to turn off the vehicle to ACC position and coast to the shoulder. When she had calmed down, I asked her to restart the truck, it started wide open throttle, so she immediately shut it off. I told my daughter then to mash the gas pedal a few times and restart the vehicle. It restarted at normal idle speed. 1/28/2022- my daughter came home from school today for a visit, the same thing happened again on her drive home. She was able to coast to the shoulder and restart after mashing the pedal a few times. I am advising her not to use the cruise control and to get it into a Ford shop to inspect. There are no lamps or warnings to indicate there is an issue or code/CEL. This is a deadly situation that apparently has occurred with Ford Explorers that have the 4.0 Liter engine and 5.0L engine. It appears from other forums (https://www.explorerforum.com/forums/threads/full-throttle-runaway-vehicle.442563/) that a throttle control cable may have an issue or defect that is causing the throttle spring to not release, or the cable is hanging up. Please see included Explorer forum link above.
NHTSA complaint #11449361 — an unverified report by a vehicle owner.
Wenatchee, WA
VEHICLE SPEED CONTROL
Incident was reported to me by an employee. Driving in traffic on a highway with normal, dry road conditions the accelerator pedal started moving down on its own. The truck accelerated on its own from 50 mph to 70+ mph. Applying the brakes the truck did NOT slow down. Eventually, the accelerator pedal corrected itself and started working normally. There was no indication on the dashboard of the issue. This could have resulted in a serious accident or death. The truck is waiting to be towed to the Ford garage for repair. Thank you, Wendy McNeill
NHTSA complaint #11443366 — an unverified report by a vehicle owner.
Wenatchee, WA
ENGINE
Incident was reported to me by an employee. Driving in traffic on a highway with normal, dry road conditions the accelerator pedal started moving down on its own. The truck accelerated on its own from 50 mph to 70+ mph. Applying the brakes the truck did NOT slow down. Eventually, the accelerator pedal corrected itself and started working normally. There was no indication on the dashboard of the issue. This could have resulted in a serious accident or death. The truck is waiting to be towed to the Ford garage for repair. Thank you, Wendy McNeill
NHTSA complaint #11443366 — an unverified report by a vehicle owner.
Wenatchee, WA
SERVICE BRAKES
Incident was reported to me by an employee. Driving in traffic on a highway with normal, dry road conditions the accelerator pedal started moving down on its own. The truck accelerated on its own from 50 mph to 70+ mph. Applying the brakes the truck did NOT slow down. Eventually, the accelerator pedal corrected itself and started working normally. There was no indication on the dashboard of the issue. This could have resulted in a serious accident or death. The truck is waiting to be towed to the Ford garage for repair. Thank you, Wendy McNeill
NHTSA complaint #11443366 — an unverified report by a vehicle owner.
at 40,909 milesWilliston, VT
AIR BAGS
THE PASSENGER SIDE MODULE - AIR BAG WAS REPLACED TWICE FIRST 3/17/ 2017 AND 8/23/2018 AND THE 2ND TIME THEY REPLACED IT WITH OUTDATED PARTS. REPORT RECALL PART 573 SAFETY - 21V-081. THE REPLACEMENT HAS NOT STARTED YET BUT I THINK THERE SHOULD BE A LAWSUIT ALSO BECAUSE THEY DID THE REPLACEMENT ANYWAY TO SATISFY THE GOVERMENT AND THEY PUT OUR LIFES AT RISK
NHTSA complaint #11397544 — an unverified report by a vehicle owner.
at 182,284 milesHackensack, MN
AIR BAGS
TAKATA AIRBAG RECALL REPLACEMENT PARTS ARE STILL BACKORDERED FOR MY 2005 FORD RANGER WHEN IT WAS TAKEN TO MY LOCAL FORD DEALER.
NHTSA complaint #11364773 — an unverified report by a vehicle owner.
at 105,000 milesBelleville, IL
STRUCTURE:BODY
THE REAR PORTION OF THE FRAME IS RUSTING AWAY AND THE LEAF SPRING SHACKLE FELL OFF WHILE DRIVING ON A CITY STREET CAUSING THE BED OF THE TRUCK TO FALL ONTO THE BUSTED SHACKLE. THE SPARE TIRE MOUNT IS RUSTED SO BAD THAT WE REMOVED THE SPARE TIRE TO AVOID LOOSING THE SPARE WHILE DRIVING. THE REAR BUMPER SEEMS UNSTABLE AS THE FRAME IS RUSTED AND FALLING APART FROM THE REAR SHACKLE MOUNT ON BACK. THE FRONT PORTION OF THE FRAME SEEMS TO BE HOLDING UP OK.
NHTSA complaint #11343487 — an unverified report by a vehicle owner.
at 55,000 milesKansas City, KS
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED WHILE DOING A ROUTINE CHECK UNDER THE VEHICLE, THE CONTACT NOTICED THAT THE SUBFRAME UNDER THE VEHICLE WAS SEVERELY RUSTED. THE VEHICLE WAS NOT TAKEN TO BE INSPECTED BY AN AUTHORIZED DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.
NHTSA complaint #11340976 — an unverified report by a vehicle owner.
at 57,000 milesDracut, MA
SUSPENSION
THE LEAF SPRING BUSHINGS PUSHED THREW THE ROTTED FRAME AND POKED HOLES IN THE BED OF THE TRUCK .THE SPARE TIRE WAS HANGING ON THE GROUND WHEN I GOT HOME ONE DAY. NOW MY INSPECTION STATION WONT PUT A INSPECTION STICKER ON IT BECAUSE THEY SAY ITS TO DANGEROUS.TOYOTA HAD THIS PROBLEM AND ETHER REPAIRED THE VEHICLE OR REPLACED IT.
NHTSA complaint #11324694 — an unverified report by a vehicle owner.
at 57,000 milesDracut, MA
STRUCTURE:BODY
THE LEAF SPRING BUSHINGS PUSHED THREW THE ROTTED FRAME AND POKED HOLES IN THE BED OF THE TRUCK .THE SPARE TIRE WAS HANGING ON THE GROUND WHEN I GOT HOME ONE DAY. NOW MY INSPECTION STATION WONT PUT A INSPECTION STICKER ON IT BECAUSE THEY SAY ITS TO DANGEROUS.TOYOTA HAD THIS PROBLEM AND ETHER REPAIRED THE VEHICLE OR REPLACED IT.
NHTSA complaint #11324694 — an unverified report by a vehicle owner.
at 123,650 milesS. Hamilton, MA
STRUCTURE:BODY
TRUCK IS IN GOOD SHAPE W/123,600 MILES. FRAME ROTTED THROUGH AT REAR AXLE. SPARE TIRE AND HOLDER DROPPED RIGHT OUT OF IT AND WAS HANGING BY A THREAD. I WAS ABLE TO GET IT TO SHOP AND CUT SPARE TIRE AND HOLDER COMPLETELY OFF.
NHTSA complaint #11324538 — an unverified report by a vehicle owner.
at 116,732 milesWilson, NC
POWER TRAIN
TL* THE CONTACT OWNS A 2005 FORD RANGER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED ON AN INCLINE, THE GEAR SHIFTER SHIFTED OUT OF THE PARK POSITION INDEPENDENTLY AND THE VEHICLE ROLLED DOWNHILL AND ENDED UP IN A DITCH. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. BOTH THE DEALER AND THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 116,732. *BF
NHTSA complaint #11323168 — an unverified report by a vehicle owner.
at 118,000 milesWilson, NCCrash
POWER TRAIN
I HAVE LEARNED THE HARD WAY THAT THE SHIFTER ON THE 2005 FORD RANGER EXTENDED CAB WILL JUMP OUT OF PARK TO REVERSE. THIS HAPPEN TO ME (JUST RECENTLY) AND CAUSED ME TO TEAR UP MY DOOR AND FENDER ON THE VEHICLE (WHICH WILL BE COSTLY)...
NHTSA complaint #11323211 — an unverified report by a vehicle owner.