Owners have filed 220 complaints
about the 2023 Hyundai Tucson with NHTSA between 2022 and 2026.
The largest single group is the driver assist & collision avoidance.
Across this model's run it ranks 7 of 22 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 28
Against the median year of the Hyundai Tucson. 50 means typical for this
model; 100 means roughly double.
Severity — 87
16.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
82% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Automatic Emergency Braking
1942.2%
Warnings
1226.7%
Adaptive Cruise Control
36.7%
Blind Spot Detection
36.7%
Sun/Moon Roof Assembly
36.7%
Accelerator Pedal
24.4%
Body
24.4%
Warning
12.2%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
517.9%
1,000 – 9,999 miles
414.3%
10,000 – 24,999 miles
1139.3%
25,000 – 49,999 miles
414.3%
50,000 – 74,999 miles
310.7%
75,000 – 99,999 miles
13.6%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Frontal crash test
Side barrier crash test
Side pole crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2023 Hyundai Tucson SUV FWD
15.9% risk
2023 Hyundai Tucson SUV AWD
17.4% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2022peak 13Aug 2026
Recalls on the 2023 Hyundai Tucson
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V893000
TRAILER HITCHES
Hyundai Motor America (Hyundai) is recalling certain 2022-2024 Tucson vehicles equipped with an optional Mobis tow hitch wiring harness. The wiring harness may have been installed incorrectly, allowing water into the control module. Moisture accumulation may cause the trailer lighting to fail or an electrical short circuit.
Risk: Nonfunctioning trailer lights can increase the risk of a crash. A short circuit can increase the risk of a fire.
23V526000
POWER TRAIN:AUTOMATIC TRANSMISSION:FLUID/LUBRICANT:PUMP
Hyundai Motor America (Hyundai) is recalling certain 2023-2024 Palisade Tucson, 2023 Sonata, Elantra, and Kona vehicles. The electronic controller for the Idle Stop & Go oil pump assembly may contain damaged electrical components that can cause the pump controller to overheat.
Risk: An electric oil pump assembly that overheats increases the risk of a vehicle fire.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 20257029,669 units in Canada
Accessories
Issue: This recall is for certain trailer wiring harnesses that were installed before delivery or sold as a dealer accessory. On certain vehicles, the trailer wiring harness may not have been manufactured properly. As a result, water could leak into the harness and cause it to fail. If this happens, the trailer lights and/or the vehicle's stop lights may not work. This could also cause the wiring harness to short circuit. Note: This recall only affects certain vehicles equipped with a Hyundai Genuine accessory trailer wiring harness part number N7H03-AP100. Safety Risk: Vehicle and/or trailer lights that don't work could make the vehicle and/or trailer less visible and cause others not to recognize that the vehicle is braking or intends to turn or change lanes. These issues could increase the risk of a crash. Additionally, a short circuit can create the risk of a fire. Corrective Actions: Hyundai will notify owners in writing. The corrective actions for this recall are under development.
Recall 2024552824,695 units in Canada
Label
Issue: On certain vehicles, the compliance label may be missing information in French. The words listed on the label for "Tires", "Rims", "Front" and "Rear" appear in English only, when they should be listed as "Tires/Pneus", "Rims/Jantes", "Front/Avant" and "Rear/Arriere". Canadian regulations require this information to be listed on the label in both English and French. Safety Risk: These small errors do not affect vehicle safety. Corrective Actions: This is not a recall. The company has corrected the compliance label for all new vehicles.
Recall 202341411,134 units in Canada
Powertrain
Issue: On certain vehicles, the circuit board for the transmission electric oil pump may be damaged. As a result, the circuit board could short circuit and overheat, and various electrical systems may not work properly. Safety Risk: A short circuit could create the risk of a fire. Corrective Actions: Hyundai will notify owners by mail and advise you to take your vehicle to a dealership to inspect the transmission electric oil pump controller, and replace it as necessary. Hyundai recommends parking your vehicle outside and away from other vehicles or buildings until the recall repairs are completed.
Reports where the owner recorded a crash, a fire, an injury or a death.
Winter Park, FLCrash1 injured
AIR BAGS
My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wheels,” this warning was not passed on to my client, even though records are kept of individual customer purchases, and these warnings could have been easily shared. A recent check of Amazon’s Safety Recalls and Alerts webpage did not turn up the 2024 NHTSA notice. I am sure there are other Amazon customers out there, who, like my client, have no idea just how dangerous these things are.
NHTSA complaint #11754571 — an unverified report by a vehicle owner.
Winter Park, FLCrash1 injured
UNKNOWN OR OTHER
My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wheels,” this warning was not passed on to my client, even though records are kept of individual customer purchases, and these warnings could have been easily shared. A recent check of Amazon’s Safety Recalls and Alerts webpage did not turn up the 2024 NHTSA notice. I am sure there are other Amazon customers out there, who, like my client, have no idea just how dangerous these things are.
NHTSA complaint #11754571 — an unverified report by a vehicle owner.
Anchorage, AKCrash
UNKNOWN OR OTHER
At dusk I was driving below the speed limit (40 MPH). I was at least 3 car lengths behind the vehicle in front of me when i saw the driver was braking because his brake lights came on and there was an intersection ahead with a stop light. There were at least two cars ahead of the vehicler I was behind. I braked but the car kept on going and appeared to accelerate. I was unable to stop the car with the brakes and collided with the car ahead. It was a sturdy vehicle with a strong bumper so I did not do much damage, if any, to the vehicle but my car requires $6,645.90 of repairs. No one was hurt and the air bags did not deploy. I was wearing my seat belt. There was no warning from ny vehicle that I was getting too close to the vehicle ahead and my car made no attempt to brake automatically. It was as though all warning indicators were not functioning. I have had two other incidents of the car surging ahead but did not report it because no one else was involved and I was able to correct the speed and I thought it was just my imagination.
NHTSA complaint #11718185 — an unverified report by a vehicle owner.
Anchorage, AKCrash
FORWARD COLLISION AVOIDANCE: WARNINGS
At dusk I was driving below the speed limit (40 MPH). I was at least 3 car lengths behind the vehicle in front of me when i saw the driver was braking because his brake lights came on and there was an intersection ahead with a stop light. There were at least two cars ahead of the vehicler I was behind. I braked but the car kept on going and appeared to accelerate. I was unable to stop the car with the brakes and collided with the car ahead. It was a sturdy vehicle with a strong bumper so I did not do much damage, if any, to the vehicle but my car requires $6,645.90 of repairs. No one was hurt and the air bags did not deploy. I was wearing my seat belt. There was no warning from ny vehicle that I was getting too close to the vehicle ahead and my car made no attempt to brake automatically. It was as though all warning indicators were not functioning. I have had two other incidents of the car surging ahead but did not report it because no one else was involved and I was able to correct the speed and I thought it was just my imagination.
NHTSA complaint #11718185 — an unverified report by a vehicle owner.
Ontario, CACrash
POWER TRAIN
As I was pulling into a parking space in a parking garage, the vehicle's engine revved, tires squealed and then the vehicle propelled forward on its own, without my foot being on the accelerator. The vehicle only stopped when it hit a support column and the wall of the parking structure. There was extensive damage to my vehicle and to the parking structure wall. My safety and the safety of others was put at risk due to the car accelerating on its own. The problem has not been confirmed or reproduced by the dealer, but we did take the vehicle to the dealer for inspection and they said they could not find anything wrong with the vehicle that would have caused the unintended acceleration. The vehicle has been inspected by the manufacturer, the insurance company and an investigator for Hyundai. Hyundai infomed us that they are not taking any responsibility for anything that occurred and that they will not share their investigator's report with us. There were no warming lamps or messages related to the problem prior to the failure. However, there have been other occasions while driving on the open road when the engine has revved on its own and I told Hyundai about that. In doing our own research, we have found that there are other 2023 Hyundai Tucson drivers who have had this exact same problem (unintended acceleration causing a crash) while pulling into parking spaces. Additionally, the air bags did not deploy during the collision and therefore the incident was not recorded by the EDR.
NHTSA complaint #11711003 — an unverified report by a vehicle owner.
Ontario, CACrash
AIR BAGS
As I was pulling into a parking space in a parking garage, the vehicle's engine revved, tires squealed and then the vehicle propelled forward on its own, without my foot being on the accelerator. The vehicle only stopped when it hit a support column and the wall of the parking structure. There was extensive damage to my vehicle and to the parking structure wall. My safety and the safety of others was put at risk due to the car accelerating on its own. The problem has not been confirmed or reproduced by the dealer, but we did take the vehicle to the dealer for inspection and they said they could not find anything wrong with the vehicle that would have caused the unintended acceleration. The vehicle has been inspected by the manufacturer, the insurance company and an investigator for Hyundai. Hyundai infomed us that they are not taking any responsibility for anything that occurred and that they will not share their investigator's report with us. There were no warming lamps or messages related to the problem prior to the failure. However, there have been other occasions while driving on the open road when the engine has revved on its own and I told Hyundai about that. In doing our own research, we have found that there are other 2023 Hyundai Tucson drivers who have had this exact same problem (unintended acceleration causing a crash) while pulling into parking spaces. Additionally, the air bags did not deploy during the collision and therefore the incident was not recorded by the EDR.
NHTSA complaint #11711003 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Chicago, IL
ELECTRICAL SYSTEM
Under Hyundai Recall 290, the dealership permanently removed the functional trailer light wiring harness and replaced it with a nonfunctional rubber dust cap. A Hyundai case manager informed me that a replacement harness is "in development," but official NHTSA remedy filings show the cap is the final remedy, resulting in the permanent loss of a factory feature I paid for. The removal of towing functionality without a clear timeline for a safe replacement parts remedy constitutes a failure to properly correct the vehicle defect.
NHTSA complaint #11755583 — an unverified report by a vehicle owner.
While backing out of driveway, with parked vehicle along side and one moving vehicle in the road, I was applying the break and the Emergency Stop feature activated. My speed was 2-3 MPH and slowing.
NHTSA complaint #11755478 — an unverified report by a vehicle owner.
Emergency Brake applied while driving. Had been driving with vehicle in front, on each side and one at rear with issues and all of sudden the emergency brake was applied causing the vehicle in back to get very close to my car. This is has happened multiple times and reported to dealership multiple times. This was the second occurence on this day.
NHTSA complaint #11755482 — an unverified report by a vehicle owner.
Winter Park, FLCrash1 injured
AIR BAGS
My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wheels,” this warning was not passed on to my client, even though records are kept of individual customer purchases, and these warnings could have been easily shared. A recent check of Amazon’s Safety Recalls and Alerts webpage did not turn up the 2024 NHTSA notice. I am sure there are other Amazon customers out there, who, like my client, have no idea just how dangerous these things are.
NHTSA complaint #11754571 — an unverified report by a vehicle owner.
Winter Park, FLCrash1 injured
UNKNOWN OR OTHER
My client lost her right eye and suffered a brain injury when an aftermarket rhinestone emblem decal from her steering wheel shot into her face during a low-impact crash with a deer. The crash left minimal damage to the front end of the vehicle, but caused the airbags to deploy, shooting the decal into my client’s head. She purchased this dangerous decoration on Amazon, and despite NHTSA notices in 2023 and 2024 telling consumers to “avoid purchasing these steering wheel decals for all vehicle makes and models” and to “remove any such decals that they have already applied to their steering wheels,” this warning was not passed on to my client, even though records are kept of individual customer purchases, and these warnings could have been easily shared. A recent check of Amazon’s Safety Recalls and Alerts webpage did not turn up the 2024 NHTSA notice. I am sure there are other Amazon customers out there, who, like my client, have no idea just how dangerous these things are.
NHTSA complaint #11754571 — an unverified report by a vehicle owner.
East York, PA
UNKNOWN OR OTHER
The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000 RPM without any throttle input from the driver. The condition occurred with the air conditioning turned off and could be reproduced multiple times. At approximately the same time, the Auto Start/Stop system stopped functioning and displayed a warning indicator. A malfunction indicator lamp (check engine light) also appeared during the incident. The warning light later turned off, but the engine surging continued. This unexpected increase in engine speed raises concerns about unintended vehicle movement or loss of driver control if the condition were to occur while shifting into gear or while driving. The unpredictable nature of the malfunction presents a potential safety risk to the occupants of the vehicle and to others on the road. The vehicle has been taken to an authorized Hyundai dealership for diagnosis and repair and remains under inspection. The problem is available for inspection. During my research, I found numerous reports from other Hyundai owners describing similar engine surging, idle fluctuation, and Auto Start/Stop malfunctions involving comparable vehicles. Because similar complaints appear to have been reported by multiple owners, I am submitting this report so the issue can be evaluated for a possible broader safety defect. I have videos of the incident
NHTSA complaint #11752416 — an unverified report by a vehicle owner.
at 76,000 milesFlorida, NY
FUEL SYSTEM, GASOLINE
The contact owns a 2023 Hyundai Tucson. The contact stated that the fuel filler door failed to open as needed. The vehicle was taken to the dealer but was not yet diagnosed or repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 76,000.
NHTSA complaint #11752477 — an unverified report by a vehicle owner.
East York, PA
ELECTRICAL SYSTEM
The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000 RPM without any throttle input from the driver. The condition occurred with the air conditioning turned off and could be reproduced multiple times. At approximately the same time, the Auto Start/Stop system stopped functioning and displayed a warning indicator. A malfunction indicator lamp (check engine light) also appeared during the incident. The warning light later turned off, but the engine surging continued. This unexpected increase in engine speed raises concerns about unintended vehicle movement or loss of driver control if the condition were to occur while shifting into gear or while driving. The unpredictable nature of the malfunction presents a potential safety risk to the occupants of the vehicle and to others on the road. The vehicle has been taken to an authorized Hyundai dealership for diagnosis and repair and remains under inspection. The problem is available for inspection. During my research, I found numerous reports from other Hyundai owners describing similar engine surging, idle fluctuation, and Auto Start/Stop malfunctions involving comparable vehicles. Because similar complaints appear to have been reported by multiple owners, I am submitting this report so the issue can be evaluated for a possible broader safety defect. I have videos of the incident
NHTSA complaint #11752416 — an unverified report by a vehicle owner.
East York, PA
ENGINE
The vehicle developed an intermittent but potentially dangerous engine control malfunction. After the engine reached normal operating temperature, the engine speed (RPM) would repeatedly surge while the vehicle was stopped in Park and Neutral, fluctuating from approximately 1,000 RPM to over 3,000 RPM without any throttle input from the driver. The condition occurred with the air conditioning turned off and could be reproduced multiple times. At approximately the same time, the Auto Start/Stop system stopped functioning and displayed a warning indicator. A malfunction indicator lamp (check engine light) also appeared during the incident. The warning light later turned off, but the engine surging continued. This unexpected increase in engine speed raises concerns about unintended vehicle movement or loss of driver control if the condition were to occur while shifting into gear or while driving. The unpredictable nature of the malfunction presents a potential safety risk to the occupants of the vehicle and to others on the road. The vehicle has been taken to an authorized Hyundai dealership for diagnosis and repair and remains under inspection. The problem is available for inspection. During my research, I found numerous reports from other Hyundai owners describing similar engine surging, idle fluctuation, and Auto Start/Stop malfunctions involving comparable vehicles. Because similar complaints appear to have been reported by multiple owners, I am submitting this report so the issue can be evaluated for a possible broader safety defect. I have videos of the incident
NHTSA complaint #11752416 — an unverified report by a vehicle owner.
Brooklyn, NY
FORWARD COLLISION AVOIDANCE: WARNINGS
2023 Hyundai Tuscon XRT has a dangerous and alarming issue. The Emergency Braking engages at highway speeds where no risk is present. The car groans and pulls dangerously. In addition, the Forward Collision Warning engages on surface streets every 10-15 seconds and there are no risks present. The emergency braking issue has occurred on several occasions. The Forward Collision Warning issue occurs every time the car is driven.
NHTSA complaint #11751880 — an unverified report by a vehicle owner.
2023 Hyundai Tuscon XRT has a dangerous and alarming issue. The Emergency Braking engages at highway speeds where no risk is present. The car groans and pulls dangerously. In addition, the Forward Collision Warning engages on surface streets every 10-15 seconds and there are no risks present. The emergency braking issue has occurred on several occasions. The Forward Collision Warning issue occurs every time the car is driven.
NHTSA complaint #11751880 — an unverified report by a vehicle owner.
at 21,000 milesNiles, IL
POWER TRAIN
The contact's son owns a 2023 Hyundai Tucson. The contact stated that while driving at various speeds, various warning lights illuminated, and various messages were displayed on the instrument panel; however, the warning lights disappeared upon restarting the engine. The contact stated that her son was forced to restart the vehicle after the vehicle failed to accelerate from a complete stop on one occasion. The vehicle was taken to the dealer for diagnosis; however, the dealer was unable to diagnose or duplicate the failure. The contact was informed that the vehicle could not be diagnosed unless the warning lights were illuminated. The manufacturer was notified of the failure, and a case was filed. The contact later received a letter from the manufacturer confirming the dealer's information. The vehicle had yet to be repaired. The failure mileage was 21,000.
NHTSA complaint #11748996 — an unverified report by a vehicle owner.
Raleigh, NC
VEHICLE SPEED CONTROL
I was on the highway on the way to work when my car started stalling. Every time I pressed the gas to give it some power, it would not go anyway where. after getting it towed to get looked at some of the fuel injectors failed and were misfiring. The warning message about ‘check engine’ popped up 2 minutes before it happened. this is the third time now in less than 6 months.
NHTSA complaint #11749034 — an unverified report by a vehicle owner.
at 21,000 milesNiles, IL
ELECTRICAL SYSTEM
The contact's son owns a 2023 Hyundai Tucson. The contact stated that while driving at various speeds, various warning lights illuminated, and various messages were displayed on the instrument panel; however, the warning lights disappeared upon restarting the engine. The contact stated that her son was forced to restart the vehicle after the vehicle failed to accelerate from a complete stop on one occasion. The vehicle was taken to the dealer for diagnosis; however, the dealer was unable to diagnose or duplicate the failure. The contact was informed that the vehicle could not be diagnosed unless the warning lights were illuminated. The manufacturer was notified of the failure, and a case was filed. The contact later received a letter from the manufacturer confirming the dealer's information. The vehicle had yet to be repaired. The failure mileage was 21,000.
NHTSA complaint #11748996 — an unverified report by a vehicle owner.
Raleigh, NC
ENGINE
I was on the highway on the way to work when my car started stalling. Every time I pressed the gas to give it some power, it would not go anyway where. after getting it towed to get looked at some of the fuel injectors failed and were misfiring. The warning message about ‘check engine’ popped up 2 minutes before it happened. this is the third time now in less than 6 months.
NHTSA complaint #11749034 — an unverified report by a vehicle owner.
Raleigh, NC
FUEL/PROPULSION SYSTEM
I was on the highway on the way to work when my car started stalling. Every time I pressed the gas to give it some power, it would not go anyway where. after getting it towed to get looked at some of the fuel injectors failed and were misfiring. The warning message about ‘check engine’ popped up 2 minutes before it happened. this is the third time now in less than 6 months.
NHTSA complaint #11749034 — an unverified report by a vehicle owner.
at 24,038 milesMahanoy, PA
VISIBILITY:SUN/MOON ROOF ASSEMBLY
The contact owns a 2023 Hyundai Tucson. The contact stated that the panoramic sunroof exploded while driving at approximately 40-50 MPH. The rear section of the sunroof glass had shattered into several pieces without impact. The contact closed the shade, and the glass fell inward. There was glass inside the shade and the roof. There were no injuries. There was an abnormally loud sound like a handgun or several balloons popping. The vehicle was previously inspected, and there were no issues found with the sunroof. The vehicle was taken to the local dealer, and the dealer stated that a rock might have caused the failure. The vehicle was not repaired. The dealer referred the contact to the insurance company for assistance. The manufacturer was contacted, and an appointment was scheduled with the local dealer. Additionally, the manufacturer provided a loaner vehicle. The failure mileage was approximately 24,038.
NHTSA complaint #11746494 — an unverified report by a vehicle owner.
Chardon, OH
ELECTRICAL SYSTEM
I received a letter in March that there is a problem with The Tow Hitch Harness Accessory which could lead to a fire etc. They said they will come out with a repair. I contacted the Victory Hyundai dealership in Jefferson Ohio where I got the car in April and they said they have a repair but the trailer electrical/ lights will not work. I got a second letter saying they have a solution for repair in May I contacted Classic Hyundai twice to make sure the repair now will allow the lights and brakes on the trailer work. Julie and Jesica there said all would be fixed and the lights and break lights will work. I brought the car there June 5th 2026 and asked again if all would work. Lyna there said no. I left. I called U-hall Streetsboro Ohio and talked to Bill who handles the hitch repairs and they said they could fix totally and have for some dealerships. I called Hyundai customer service Kyre and asked if Hyundai in Streetsboro Ohio can be set up to have it repaired. He said no. He would not document his response to me. I bought this car with their factory installed hitch because I needed one to pull my boat and move other stuff. My lawn tractor broke down and I have to pay $135 to have it towed for repair. I am unable to fish in my boat since I can not pull it. There is a repair that will work at U-haul and they are ignoring it.They want to make the hitch unusable. Uhaul will fix for $250-$350. If they disconnect the hitch electrical and the car is sold the new owner can get into an accident since they would have no lights and break lights, turn signal. This is a high risk for an accident. They intend to eliminate the fire risk and create an accident risk for the trailer now not working. What kind of engineers they have?? They should be contacted about this situation. It has been several months with no solution when one exists. I have had multiple Hyundais and will no longer purchase another vehicle from them. You should communicate with them on this issue.
NHTSA complaint #11745677 — an unverified report by a vehicle owner.
West Chester, PA
SERVICE BRAKES
While driving on a highway shortly after taking delivery of this vehicle as a Certified Pre-Owned purchase from an authorized Hyundai dealership, I experienced sudden and total brake failure. The Electronic Parking Brake (EPB) warning light illuminated and an audible warning chime sounded. The brake pedal did not respond normally. I was unable to slow the vehicle with the brakes and was forced to make an emergency maneuver to exit the highway and come to a safe stop. Upon inspecting the vehicle after stopping, I discovered that the rear left brake caliper had completely detached from its mounting bracket. The caliper was on the ground beneath the rear of the vehicle. Brake fluid had leaked onto the road surface. The vehicle had been in my possession for less than one full drive since purchase. As part of the CPO certification, the selling dealer performed a multi-point inspection and documented installation of new brake pads and certified the brake system as in good working order. The detachment of the caliper is consistent with mounting bolts that were either not reinstalled or not properly torqued following the dealer's brake service during CPO preparation. I have photographic evidence of the detached caliper and brake fluid loss. INJURIES: None, but significant risk to myself and other highway drivers. FIRES: No. MEDICAL ATTENTION: Not required. CONTACT WITH DEALER/MANUFACTURER: Yes — Hyundai corporate complaint filed. I am requesting this complaint be investigated as a potential safety defect related to brake service practices during Hyundai CPO vehicle preparation.
NHTSA complaint #11745559 — an unverified report by a vehicle owner.
Goodland, FL
UNKNOWN OR OTHER
Horn on vehicle consistently goes out. Either goes out entirely or the volume of the horn is below a safe level. This is a known Hyundai issue and Hyundai refuses to acknowledge it on this specific model, but has acknowledged it on different models. I Have had multiple repairs by Hyundai directly, and the horn consistently keeps going out. There are sometimes in dangerous situations where I need to utilize the horn to avoid an accident and warn other drivers of danger, and I am unable to do so, and it causes dangerous driving situations. This is a known defect on multiple Hyundai vehicles in this year, but the Tucson is one of the few vehicles they will not call a voluntary recall on and NHTSA needs to be notified about this and act accordingly as a regulatory body to protect consumers and people on the road.
NHTSA complaint #11745447 — an unverified report by a vehicle owner.
Goodland, FL
ELECTRICAL SYSTEM
Horn on vehicle consistently goes out. Either goes out entirely or the volume of the horn is below a safe level. This is a known Hyundai issue and Hyundai refuses to acknowledge it on this specific model, but has acknowledged it on different models. I Have had multiple repairs by Hyundai directly, and the horn consistently keeps going out. There are sometimes in dangerous situations where I need to utilize the horn to avoid an accident and warn other drivers of danger, and I am unable to do so, and it causes dangerous driving situations. This is a known defect on multiple Hyundai vehicles in this year, but the Tucson is one of the few vehicles they will not call a voluntary recall on and NHTSA needs to be notified about this and act accordingly as a regulatory body to protect consumers and people on the road.
NHTSA complaint #11745447 — an unverified report by a vehicle owner.
Rome, GA
ELECTRICAL SYSTEM
I received a Recall notice around January 2026 for the trailer hitch wiring harness on my 2023 Hyundai Tucson Hybrid. For 6 months the local dealer told me there was no fix available from Hyundai. I finally received a notice informing me that parts were now available and to bring it in to dealer for repairs. I took the vehicle in for recall repairs on May 27, 2026. Instead of repairing/replacing the wiring harness, Hyundai removed the entire wiring harness making the trailer hitch which I use for my business inoperable legally. When I noticed the wiring harness missing several days later, the dealer said that was Hyundai's "fix" for the recall issue. I contacted Hyundai USA Customer Service who also told me that removing the wiring harness and replacing it with an inexpensive dust cover was the fix. They told me that sometime in the future there will be another recall to have the wiring harness replaced. In the meantime, they have taken my vehicle VIN off the open recall list, since it has been "fixed". Hyundai sold me a vehicle with a trailer hitch and now they have without my permission or prior knowledge disabled it.
NHTSA complaint #11743550 — an unverified report by a vehicle owner.
Alexandria, VA
UNKNOWN OR OTHER
I was driving on the freeway no where near an overpass going about 65mph when the front panel on my panaromaic sunroof exploded and glass went everywhere. There is no signs that a rock could have possibly hit it. My safety was at risk because I could have crashed and broken glass rained down on me. There were no warning signs and the vehicle has not been inspected yet, but it will be.
NHTSA complaint #11739695 — an unverified report by a vehicle owner.
Alexandria, VA
STRUCTURE:BODY
I was driving on the freeway no where near an overpass going about 65mph when the front panel on my panaromaic sunroof exploded and glass went everywhere. There is no signs that a rock could have possibly hit it. My safety was at risk because I could have crashed and broken glass rained down on me. There were no warning signs and the vehicle has not been inspected yet, but it will be.
NHTSA complaint #11739695 — an unverified report by a vehicle owner.
Alexandria, VA
VISIBILITY/WIPER
I was driving on the freeway no where near an overpass going about 65mph when the front panel on my panaromaic sunroof exploded and glass went everywhere. There is no signs that a rock could have possibly hit it. My safety was at risk because I could have crashed and broken glass rained down on me. There were no warning signs and the vehicle has not been inspected yet, but it will be.
NHTSA complaint #11739695 — an unverified report by a vehicle owner.
