2024 Hyundai Tucson problems

TRAILER HITCHES

The contact owns a 2024 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 25V893000 (Trailer Hitches); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the remedy to be available. The vehicle was taken to the dealer, and the trailer wiring harness was removed, and a dust cap was installed over the wiring receptacle. The dealer had not replaced the tow hitch electrical harness. The contact stated that because the tow hitch electrical harness was not replaced, the vehicle was no longer able to be used for towing. The manufacturer was made aware of the issue, and a case had been opened. The manufacturer confirmed that the tow hitch electrical harness would be replaced but could not provide a time frame for when the part would be available. The failure mileage was approximately 68,000.

NHTSA complaint #11762097 — an unverified report by a vehicle owner.

POWER TRAIN

On 6 occasions over the last 2 months when coming to a stop the engine will increase rpm to 1600 forcing much extra brake pressure to stop, forcing me to shutoff the engine. No codes or indicators and the dealer can't duplicate. I mentioned to the dealer that the car will accelerate while holding down the brake thinking that as a clue as to what's wrong and the service tech told me that is normal but as far as I know it isn't normal. I don't know what to do.

NHTSA complaint #11761051 — an unverified report by a vehicle owner.

SERVICE BRAKES

All four rotors warped with 7,209 miles it still had 8mm of metal and the dealership is saying it for hard braking which just about impossible!!

NHTSA complaint #11761069 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

On 6 occasions over the last 2 months when coming to a stop the engine will increase rpm to 1600 forcing much extra brake pressure to stop, forcing me to shutoff the engine. No codes or indicators and the dealer can't duplicate. I mentioned to the dealer that the car will accelerate while holding down the brake thinking that as a clue as to what's wrong and the service tech told me that is normal but as far as I know it isn't normal. I don't know what to do.

NHTSA complaint #11761051 — an unverified report by a vehicle owner.

ENGINE

I purchased this vehicle brand new in December of 2023 - It has an oil consumption issue which started on May 13, 2024 - I have had the vehicle to the dealership for repairs to resolve the issue 13 times so far - Vehicle is currently at the dealership and has been for 7 days and they have not done anything to rectify the issue - Dealership says they are waiting on Hyundai to give them the approval to proceed - They have not provided me with a loaner vehicle - I have had to rent a car so I can get to work - The vehicle only has 28,388 miles on it - The issue started in May of 2024 with only 5,412 miles on it - I filed a complaint with Hyundai Case # 40508090 but they have failed to repair the vehicle or buy the vehicle back from me - I need help with this issue and I don't know what else to do

NHTSA complaint #11760213 — an unverified report by a vehicle owner.

SEAT BELTS

Rear, middle seat belt will not latch. Upon the first need, June 2026, of having to have five people in the 2024 Tucson we discovered that the rear, middle seat belt would not latch. This created an unsafe situation of driving in downtown Houston with an occupant being unable to be safely restrained in the rear, middle seat. Dealer has confirmed a defective rear, middle seat belt, but will not repair under warranty. Dealer claims the seat belt was damaged by the folding down rear seat.

NHTSA complaint #11759709 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

I have a 2024 Hyundai Tuscon SLE that I purchased new and several months ago there was a recall on the trailer hitch wiring. I took the car to Hyundai and they removed the wiring harness hitch due to a fire danager. Todate I have not received a replacement hiring harness, so my vehicle is now useless for pulling a trailer for several months. (The spring and summer months are when I use this the most and have not been able to.) All I hear from Hyundai is that they do not have a cure for this. I notice that the 2025 and 2026 models have a wiring harness on them that do not need replacing. I need something done ASAP regarding this matter. Why has NOTHING been done regarding this replacement? It has been MUCH TOO LONG! Is there ANYONE at your organization that can help me with this matter ASAP!!!! Thank you.

NHTSA complaint #11756451 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

I have a 2024 Hyundai Tuscon SLE that I purchased new and several months ago there was a recall on the trailer hitch wiring. I took the car to Hyundai and they removed the wiring harness hitch due to a fire danager. Todate I have not received a replacement hiring harness, so my vehicle is now useless for pulling a trailer for several months. (The spring and summer months are when I use this the most and have not been able to.) All I hear from Hyundai is that they do not have a cure for this. I notice that the 2025 and 2026 models have a wiring harness on them that do not need replacing. I need something done ASAP regarding this matter. Why has NOTHING been done regarding this replacement? It has been MUCH TOO LONG! Is there ANYONE at your organization that can help me with this matter ASAP!!!! Thank you.

NHTSA complaint #11756451 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The air conditioning system in my 2024 Hyundai Tucson has never adequately cooled the cabin during high outdoor temperatures, since I purchased the vehicle. The vehicle is parked outdoors in direct sunlight daily, as I have no garage or carport access, and the issue is most severe and consistent during hot weather. This creates a heat exposure risk while driving, particularly on hot days when cabin temperatures remain uncomfortably high despite the AC running and set to the coldest setting. Prolonged exposure to excessive cabin heat can pose a safety risk, including impaired driver alertness and general heat-related discomfort/health risk. I brought the vehicle to CMA's Hyundai of Lynchburg on July 9, 2025 to report this issue; the dealership found no fault and stated the AC was working correctly. I brought the vehicle in again on August 11, 2026 with the same complaint; the dealership again reported the AC was blowing air at the correct temperature, with no fault identified. The vehicle has been inspected and is available for further inspection upon request. There were no dashboard warning lights or messages associated with this issue. The problem has been consistent since I've owned the vehicle, and is worse specifically in hot weather.

NHTSA complaint #11756153 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

On 7/29/2026, the vehicle experienced a critical safety failure involving the electronic transmission shift-by-wire system, resulting in an unintended rollaway after the ignition was turned off. While parked on an incline, the driver depressed the brake pedal and pressed the Engine Start/Stop button while the vehicle was still positioned in Drive (D). The engine shut off completely. According to factory safety design and vehicle specifications, cutting the ignition in this state is engineered to automatically trigger an electronic command to shift the transmission into Park (P). However, the vehicle failed to execute this electronic fail-safe. The electronic parking pawl did not engage, and the vehicle effectively defaulted into an un-geared Neutral state. Upon the driver releasing the brake pedal, the unanchored vehicle immediately rolled down the incline with the engine completely powered off. No audible warning chimes or dashboard fault lights were activated prior to or during the event to alert the driver that the transmission had failed to secure the vehicle.

NHTSA complaint #11753788 — an unverified report by a vehicle owner.

SEAT BELTS

Seatbelt is not fastening in the rear center seat

NHTSA complaint #11751464 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

This has happened twice now. When going at a low speed, once in traffic, once while performing a U-turn, while braking, the car is trying to accelerate. I have to practically stand on the brake pedal to avoid the car lurching forward. I saw no warning lights on the dashboard. I haven't yet brought the vehicle to a dealer or service center, but it will be.

NHTSA complaint #11751431 — an unverified report by a vehicle owner.

SEAT BELTS

Center rear buckle fails to latch. Plastic case separated after normal operation of closing/folding down the rear seat. Buckle case separated from buckle latch. Buckle would latch with plastic cover missing, however would be a considerable risk, as a the retaining bar feature is not captive to the buckle and would separate in use, if used. As well as a pinch hazard. The center buckle was only use a handful of times and is free from contamination/debris. A safety buckle shouldn't fail under normal operation of folding a seat as designed. The seat folding action caused the buckle casing to pop off and separate.

NHTSA complaint #11749777 — an unverified report by a vehicle owner.

ENGINE

Subject: Urgent Drivability Concern – 2024 Hyundai Tucson (6/22 Incident) Vehicle: 2024 Hyundai Tucson Date of Incident: XXX Trip Details: [XXX] to [XXX] (~160+ miles) Summary of Issue: During a long-distance drive on XXX, the vehicle experienced severe and consistent drivability issues that created unsafe driving conditions. Symptoms Observed: •Severe loss of acceleration / stalling behavior throughout the entire trip •No check engine light illuminated at any time •When pressing the accelerator: oTachometer increased (RPMs rising) oVehicle speed decreased or failed to increase appropriately •Significant delay in acceleration, especially when: oMerging onto the interstate oPassing other vehicles •Cruise control behavior: oSeemed to manage acceleration more effectively than manual throttle oHowever, still exhibited slow response when additional acceleration was required •Auto Start/Stop system: oSystem automatically disabled itself oWould not allow reactivation during the trip Safety Concern: This condition made it difficult and unsafe to: •Merge into traffic •Maintain appropriate highway speeds •Execute passing maneuvers Dealer Visit (Near [XXX]): •Vehicle was inspected after sitting for a couple of hours •Dealer reported no issues found •However, the problem was persistent and clearly present during operation under driving conditions Took vehicle to a dealership in Raleigh and asked that they look at the fuel injectors. They determined that all 4 injectors were failing and replaced them under warranty. Concerned that Hyundai America has not issued a recall as driving the vehicle with this issue creates a serious safety concern that would lead to injury or loss of life INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11748709 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Subject: Urgent Drivability Concern – 2024 Hyundai Tucson (6/22 Incident) Vehicle: 2024 Hyundai Tucson Date of Incident: XXX Trip Details: [XXX] to [XXX] (~160+ miles) Summary of Issue: During a long-distance drive on XXX, the vehicle experienced severe and consistent drivability issues that created unsafe driving conditions. Symptoms Observed: •Severe loss of acceleration / stalling behavior throughout the entire trip •No check engine light illuminated at any time •When pressing the accelerator: oTachometer increased (RPMs rising) oVehicle speed decreased or failed to increase appropriately •Significant delay in acceleration, especially when: oMerging onto the interstate oPassing other vehicles •Cruise control behavior: oSeemed to manage acceleration more effectively than manual throttle oHowever, still exhibited slow response when additional acceleration was required •Auto Start/Stop system: oSystem automatically disabled itself oWould not allow reactivation during the trip Safety Concern: This condition made it difficult and unsafe to: •Merge into traffic •Maintain appropriate highway speeds •Execute passing maneuvers Dealer Visit (Near [XXX]): •Vehicle was inspected after sitting for a couple of hours •Dealer reported no issues found •However, the problem was persistent and clearly present during operation under driving conditions Took vehicle to a dealership in Raleigh and asked that they look at the fuel injectors. They determined that all 4 injectors were failing and replaced them under warranty. Concerned that Hyundai America has not issued a recall as driving the vehicle with this issue creates a serious safety concern that would lead to injury or loss of life INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11748709 — an unverified report by a vehicle owner.

TIRES

On February 25, 2026 the car was brought to the service department where it was determined that a front tire had a separated belt which caused vibrations and failure to accelerate . On June 16, 2026 the car was brought to the service department for the same thing. Again a tire had a separated belt again 235/55R19101H

NHTSA complaint #11745445 — an unverified report by a vehicle owner.

TRAILER HITCHES

The contact stated that the vehicle was taken to the dealer for repairs unrelated to a recall but recall repairs were completed unbeknownst to the contact for NHTSA Campaign Number 25V893000 (Trailer Hitches). The dealer removed the wiring harness which rendered the tow hitch inoperable. The manufacturer was notified of the issue and informed the contact that the removal of the wiring harness was the fix for the recall repair. The contact stated that he purchased the specific XRT model due to the specific feature of the tow hitch and now it is inoperable. The approximate failure mileage was 49200

NHTSA complaint #11739323 — an unverified report by a vehicle owner.

TRAILER HITCHES

The contact owns a 2024 Hyundai Tucson. The contact received notification of NHTSA Campaign Number: 25V893000 (Trailer Hitches); however, the part to do the recall repair was not yet available. The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair. The contact stated that a recall repair appointment was scheduled with the dealer and the vehicle was taken to the dealer for the recall repair; however, the dealer informed the contact that parts were not yet ordered. The contact was concerned about the fire risk warning associated with the recall. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA complaint #11739053 — an unverified report by a vehicle owner.

VISIBILITY/WIPER

On Wednesday, May 13, 2026, I turned off the highway and came to a stoplight. While preparing to accelerate as the stoplight turned green, I heard what sounded like a gunshot and saw that my entire rear window had spontaneously shattered. There was no external impact which caused this to occur. I have photos of the incident. Although my one year old son was not in his rear facing car seat at the time, if he had been, he would have been at risk of injury due to glass fragments. I was at risk as the sound startled me into breaking when I should have been accelerating with the rest of traffic and it left my interior exposed to the elements. I am scheduled with Safelite repairs through my insurance company to repair the window on Monday, May 18th. There were absolutely no messages or any symptoms prior to the spontaneous shattering of my window. After researching, according to Chimicles Schwartz Kriner & Donaldson-Smith LLP, there is currently an investigation for a potential class action lawsuit regarding an alleged defect of my make and model causing spontaneous rear window shattering.

NHTSA complaint #11737966 — an unverified report by a vehicle owner.

TRAILER HITCHES

Hyundai Recall 290 was performed on my vehicle by an authorized dealer. Because Hyundai has not manufactured or supplied the necessary extension cable connecting the new module to the hitch, the remedy is incomplete, and my factory-purchased towing equipment is now entirely inoperable. The Dealer has stated "CAMPAIGN COMPLETE" and has no plans to get the necessary cable.

NHTSA complaint #11737596 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

The Manual Speed Limit Assist, or MSLA, feature unintendedly activated while I was driving, nearly causing a collision. I was initially unable to deactivate this steering-wheel based feature, as: (1) I did not intentionally press any buttons to activate it, and: (2) I had to balance the need to visually monitor other vehicles on the highway to avoid a collision and simultaneously figure out how to cancel this feature, which places a limit on the speed that the vehicle can travel. Instead of claiming that this feature malfunctioned, I am claiming that it is an egregiously, poorly designed and dangerous feature. The button to activate it is located on the steering wheel; consequently, a driver can easily activate it without meaning to do so. This inadvertent activation happened to me twice, each time impeding, however briefly, my ability to safely navigate a busy road. This feature was not identified when I purchased the vehicle; however, earlier this year Hyundai belatedly sent a letter to its customers titled "Understanding Manual Speed Limit Assist (MSLA) Feature," pointing out how to activate and disengage the feature (and providing a link to a website for a tutorial with more information: [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11736842 — an unverified report by a vehicle owner.