2022 Ford F-150 problems

PARKING BRAKE

The contact owns a 2022 Ford F-150. The contact stated that while the vehicle was parked in the garage, the parking brake activated independently. The failure was a recurring failure. The contact associated the failure with NHTSA Campaign Number: 23V509000 (Parking Brake); however, the VIN was not included in the recall. The dealer was contacted and stated that the repair was not covered because the VIN was not included in the recall. The manufacturer was contacted by phone and was made aware of the failure. The failure mileage was approximately 40,000.

NHTSA complaint #11763028 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The daytime running lights are out. Vehicle is available for inspection. This puts my safety and the safety of others at risk by not being o by reducing visibility of the vehicle during low light scenarios where the headlights are off. Example I live in an area with lots of fog and drive a gray vehicle that is not clearly visible if headlights are off due to light exposure. Problem is consistent and able to be reproduced for inspection. Vehicle has not been inspected by any agent to this point but it is available and will be noticed upon inspection by direction. There are no warning lamps or messages alerting driver of malfunction which poses another safety risk. Problem has been consistent for past 3 weeks upon every start.

NHTSA complaint #11762636 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds on several occasions, the vehicle experienced a temporary loss of motive power while accelerating and turning. The contact stated that the failure was a recurring failure, and the contact needed to maintain a fuel level above half tank. The vehicle was taken to a dealer, where it passed the State Inspection, and the contact was advised to wait until the recall part was available for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, the contact had not received the recall notification. The failure mileage was approximately 20,000.

NHTSA complaint #11762226 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds on several occasions, the vehicle experienced a temporary loss of motive power while accelerating and turning. The contact stated that the failure was a recurring failure, and the contact needed to maintain a fuel level above half tank. The vehicle was taken to a dealer, where it passed the State Inspection, and the contact was advised to wait until the recall part was available for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, the contact had not received the recall notification. The failure mileage was approximately 20,000.

NHTSA complaint #11762226 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds on several occasions, the vehicle experienced a temporary loss of motive power while accelerating and turning. The contact stated that the failure was a recurring failure, and the contact needed to maintain a fuel level above half tank. The vehicle was taken to a dealer, where it passed the State Inspection, and the contact was advised to wait until the recall part was available for the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Additionally, the contact became aware that the VIN was included in NHTSA Campaign Number: 26V104000 (Electrical System, Exterior Lighting); however, the contact had not received the recall notification. The failure mileage was approximately 20,000.

NHTSA complaint #11762226 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford F-150. The contact stated that while driving 35 MPH, the vehicle unexpectedly loss power and decelerated 15 MPH. The failure was a recurring failure but became more frequent in hot weather. The dealer was contacted and associated the failure with NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was reached by phone and was made aware of the failure. The failure mileage was approximately 106,000.

NHTSA complaint #11761875 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford F-150. While the contact’s daughter was driving 5 MPH and turning left from a four-way stop sign, the vehicle stalled. The accelerator pedal was continuously depressed to drive the vehicle to the residence. The contact notified the dealer of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to the dealer, and the vehicle was diagnosed with transmission failure pending the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted via e-mail and was made aware of the failure. The failure mileage was approximately 78,500.

NHTSA complaint #11761991 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

Daytime running lights (LED) in headlights burn out/quit working. Currently it is only the pasenger side of my vehilce but its a common issue and eventually both passenger and driver side DRL's quit working. there is no repair for this, only option for the owner is to replace the entire headlight assembly and that is extremely costly.

NHTSA complaint #11760881 — an unverified report by a vehicle owner.

SERVICE BRAKES

Emergency parking brake came on and would not turn off even when I tried to do a reset. We had to have the truck towed.

NHTSA complaint #11760339 — an unverified report by a vehicle owner.

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

Emergency parking brake came on and would not turn off even when I tried to do a reset. We had to have the truck towed.

NHTSA complaint #11760339 — an unverified report by a vehicle owner.

ENGINE

While driving, my 2022 Ford F-150 equipped with the 2.7L EcoBoost experienced abnormal engine operation, a check-engine light, and reduced engine power. The unexpected reduction in available engine power created a safety concern because loss of acceleration or propulsion can be dangerous when merging, crossing traffic, passing, or traveling at highway speeds. The vehicle was inspected and diagnosed by an authorized Ford dealership. The PCM stored DTC P0332, Knock/Combustion Vibration Sensor “B” Circuit Low. The dealer performed Ford Pinpoint Test DG. Testing reportedly found no open circuit, short to ground, short to voltage, or intermittent circuit fault. The dealer determined that the knock-sensor assembly required replacement.The repair involves replacement of Ford knock-sensor assembly FT4Z-12A699-E, which contains both knock sensors. Access to the assembly requires extensive disassembly of engine fuel and cooling-system components. Ford’s service procedure includes removal of both direct-injection fuel rails, draining the cooling system, removal of the coolant pump, and removal of the coolant outlet connector.I am concerned about the possibility of coolant leakage or contamination affecting the knock-sensor assembly because of its location in relation to cooling-system components. I do not currently know whether coolant contamination caused this particular failure. I request that NHTSA investigate whether coolant leakage or contamination in this area contributes to premature knock-sensor failures on 2.7L EcoBoost engines. I have also identified another 2022 Ford F-150 with the 2.7L EcoBoost that was diagnosed by a Ford dealership with a similar knock-sensor circuit-low fault, P0327 also quoted replacement of the same FT4Z-12A699-E assembly. I request investigation knock-sensor failures on 2.7L EcoBoost F-150s, including Ford warranty/field data and whether coolant leakage or contamination contributes to failures capable of causing unexpected reduced engine powe

NHTSA complaint #11760176 — an unverified report by a vehicle owner.

SERVICE BRAKES

I was driving and went to press the brakes and the pedal went to the floor. The truck would not stop right away and then the rear tires locked up. Light came on the dash ABS, service traction control and brake system failure, this was a similar issue with the 2021 and 2025 model having issues with the EBB/ECU that was on recall.

NHTSA complaint #11760069 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

While driving, my 2022 Ford F-150 equipped with the 2.7L EcoBoost experienced abnormal engine operation, a check-engine light, and reduced engine power. The unexpected reduction in available engine power created a safety concern because loss of acceleration or propulsion can be dangerous when merging, crossing traffic, passing, or traveling at highway speeds. The vehicle was inspected and diagnosed by an authorized Ford dealership. The PCM stored DTC P0332, Knock/Combustion Vibration Sensor “B” Circuit Low. The dealer performed Ford Pinpoint Test DG. Testing reportedly found no open circuit, short to ground, short to voltage, or intermittent circuit fault. The dealer determined that the knock-sensor assembly required replacement.The repair involves replacement of Ford knock-sensor assembly FT4Z-12A699-E, which contains both knock sensors. Access to the assembly requires extensive disassembly of engine fuel and cooling-system components. Ford’s service procedure includes removal of both direct-injection fuel rails, draining the cooling system, removal of the coolant pump, and removal of the coolant outlet connector.I am concerned about the possibility of coolant leakage or contamination affecting the knock-sensor assembly because of its location in relation to cooling-system components. I do not currently know whether coolant contamination caused this particular failure. I request that NHTSA investigate whether coolant leakage or contamination in this area contributes to premature knock-sensor failures on 2.7L EcoBoost engines. I have also identified another 2022 Ford F-150 with the 2.7L EcoBoost that was diagnosed by a Ford dealership with a similar knock-sensor circuit-low fault, P0327 also quoted replacement of the same FT4Z-12A699-E assembly. I request investigation knock-sensor failures on 2.7L EcoBoost F-150s, including Ford warranty/field data and whether coolant leakage or contamination contributes to failures capable of causing unexpected reduced engine powe

NHTSA complaint #11760176 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Recall first fuel pump issue unresolved. It has been over a year since recall was issued

NHTSA complaint #11758836 — an unverified report by a vehicle owner.

SEAT BELTS

There is an issue with my cowl which has 1 drain hole, on passenger side which if gets clogged with debris, causes water to build up and water to intrude from cowl into interior truck causing water intrusion to the body control module and electrical issues, and carpet is wet and creates mold smell and other safety issues. Cowl is not removable

NHTSA complaint #11757933 — an unverified report by a vehicle owner.

AIR BAGS

There is an issue with my cowl which has 1 drain hole, on passenger side which if gets clogged with debris, causes water to build up and water to intrude from cowl into interior truck causing water intrusion to the body control module and electrical issues, and carpet is wet and creates mold smell and other safety issues. Cowl is not removable

NHTSA complaint #11757933 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

There is an issue with my cowl which has 1 drain hole, on passenger side which if gets clogged with debris, causes water to build up and water to intrude from cowl into interior truck causing water intrusion to the body control module and electrical issues, and carpet is wet and creates mold smell and other safety issues. Cowl is not removable

NHTSA complaint #11757933 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

Failure by Ford to fix a fuel pump issue that has been known since Feb 2025. Should a vehicle stall while being operated due to this issue it could lead to a crash. I would think such a serious safety issue would be addressed and fixed to prevent unnecessary accidents/injuries/death.

NHTSA complaint #11757353 — an unverified report by a vehicle owner.

POWER TRAIN

My 2022 Ford F-150 has experienced intermittent delayed starting, uneven idle, and hesitation during acceleration. At times, the engine sounds and feels as though it may shut off. I began noticing these symptoms several months ago, and the most recent occurrence was approximately August 2026. I do not recall seeing any warning lamps or warning messages when these symptoms occurred. The vehicle has not yet been inspected or diagnosed by a Ford dealer or independent repair facility for these specific symptoms, and the cause has not been confirmed. The vehicle is available for inspection upon request. I am concerned because my vehicle is affected by Ford Recall 25S75 / NHTSA Recall 25V455 involving potential fuel pump failure and loss of fuel pressure, which may result in poor engine performance and engine stalling. I am concerned that the symptoms I am experiencing could create a safety risk if the engine loses power or shuts off while driving.

NHTSA complaint #11757075 — an unverified report by a vehicle owner.

ENGINE

My 2022 Ford F-150 has experienced intermittent delayed starting, uneven idle, and hesitation during acceleration. At times, the engine sounds and feels as though it may shut off. I began noticing these symptoms several months ago, and the most recent occurrence was approximately August 2026. I do not recall seeing any warning lamps or warning messages when these symptoms occurred. The vehicle has not yet been inspected or diagnosed by a Ford dealer or independent repair facility for these specific symptoms, and the cause has not been confirmed. The vehicle is available for inspection upon request. I am concerned because my vehicle is affected by Ford Recall 25S75 / NHTSA Recall 25V455 involving potential fuel pump failure and loss of fuel pressure, which may result in poor engine performance and engine stalling. I am concerned that the symptoms I am experiencing could create a safety risk if the engine loses power or shuts off while driving.

NHTSA complaint #11757075 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

My 2022 Ford F-150 has experienced intermittent delayed starting, uneven idle, and hesitation during acceleration. At times, the engine sounds and feels as though it may shut off. I began noticing these symptoms several months ago, and the most recent occurrence was approximately August 2026. I do not recall seeing any warning lamps or warning messages when these symptoms occurred. The vehicle has not yet been inspected or diagnosed by a Ford dealer or independent repair facility for these specific symptoms, and the cause has not been confirmed. The vehicle is available for inspection upon request. I am concerned because my vehicle is affected by Ford Recall 25S75 / NHTSA Recall 25V455 involving potential fuel pump failure and loss of fuel pressure, which may result in poor engine performance and engine stalling. I am concerned that the symptoms I am experiencing could create a safety risk if the engine loses power or shuts off while driving.

NHTSA complaint #11757075 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE

The contact owns a 2022 Ford F-150. The contact stated that while driving approximately 55-65 MPH, the vehicle stalled. The check engine and battery warning lights were illuminated. The contact associated the failure with NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, and the failure was associated with the recall and a diagnostic trouble code related to the ECM reprogramming for the fuel system. The vehicle was towed to the local Ford dealer, who diagnosed the vehicle with a fuel system failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 29,043.

NHTSA complaint #11755908 — an unverified report by a vehicle owner.