FaultScore

FaultScore report

2002 Ford F-150 problems

Owners have filed 965 complaints about the 2002 Ford F-150 with NHTSA between 2002 and 2026. The largest single group is the engine & cooling. Across this model's run it ranks 16 of 33 worst.

C

FaultScore 52/100

Higher is worse. Measured against the other years of the Ford F-150.

How this is worked out

The numbers

965

Complaints

63

Crashes reported

115

Fires reported

53

Injuries reported

90,500 mi

Median mileage at failure

Half of reported failures happened before this

14%

Failed under 36,000 miles

Inside a typical bumper-to-bumper warranty

What kind of bad

The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.

Complaint volume 34 vs 50 Severity 100 vs 50 Early failure 24 vs 50
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 34
Against the median year of the Ford F-150. 50 means typical for this model; 100 means roughly double.
Severity — 100
23.9% of these complaints involved a crash, fire, injury or death, against a national rate of 9.7%.
Early failure — 24
14% of failures with a mileage on record happened under 36,000 miles, against a national rate of 29%.

How 2002 compares with every other Ford F-150

Click any bar to open that year's report.

Complaints filed with NHTSA, by model year. Bar colour is the FaultScore grade: A B C D F ungraded

What breaks on a 2002 Ford F-150

Every complaint is filed against a part. Follow any row for the complaints about that part alone.

Engine & Cooling 263 27.3%

4 crashes, 16 fires · median 96,475 mi

Electrical System 110 11.4%

2 crashes, 28 fires · median 86,500 mi

0 crashes, 6 fires · median 127,500 mi

4 crashes, 46 fires · median 120,000 mi

3 crashes, 0 fires · median 54,260 mi

Seat Belts 50 5.2%

2 crashes, 1 fires · median 94,500 mi

2 crashes, 2 fires · median 85,000 mi

Brakes 45 4.7%

2 crashes, 5 fires · median 67,500 mi

Airbags 37 3.8%

30 crashes, 2 fires · median 76,500 mi

Median failure at 68,000 miles

2 crashes, 5 fires · median 120,000 mi

Steering 25 2.6%

3 crashes, 0 fires · median 82,759 mi

Tires 24 2.5%

2 crashes, 0 fires · median 44,022 mi

Suspension 22 2.3%

1 crashes, 0 fires · median 63,546 mi

Lights 14 1.5%

1 crashes, 1 fires · median 39,000 mi

Wheels 13 1.3%

4 crashes, 0 fires · median 100,000 mi

0 crashes, 1 fires · median 40,000 mi

Doors, Latches & Locks 8 0.8%

Median failure at 60,000 miles

Seats 7 0.7%

1 crashes, 1 fires · median 108,475 mi

Child Seats 3 0.3%

Median failure at 21,000 miles

Stability & Traction Control 2 0.2%

0 crashes, 1 fires · median 155,000 mi

Driver Assist & Collision Avoidance 1 0.1%

Exactly what failed

NHTSA files every complaint against a named sub-assembly, not just a system. This is the difference between knowing it was "the engine" and knowing which part of it — the list to hand a mechanic.

Engine 78 43.3%
Cruise Control 19 10.6%
Automatic Transmission 16 8.9%
Body 15 8.3%
Frontal 14 7.8%
Gasoline 13 7.2%
Windshield 13 7.2%
Ignition 12 6.7%

When it fails

Odometer readings owners gave when they filed. About half of all complaints include one.

Under 1,000 miles 24 3.2%
1,000 – 9,999 miles 6 0.8%
10,000 – 24,999 miles 37 4.9%
25,000 – 49,999 miles 102 13.5%
50,000 – 74,999 miles 110 14.6%
75,000 – 99,999 miles 143 18.9%
100,000 – 149,999 miles 198 26.2%
150,000+ miles 136 18.0%

When owners complained

A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.

Jan 2002 peak 24 Jul 2026

NHTSA investigations into the 2002 Ford F-150

An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.

EA11006 Opened 4 May 2011 Closed 19 Aug 2011 FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Fuel Tank Strap Failure Due to Corrosion

One or both of the steel straps holding up the fuel tank and attaching it to the truck frame can corrode and fail (break or separate).If one strap fails, the tank may tilt and drop and possibly contact the road surface.If both straps break, the entire tank may drop to the road.If either failure occurs while the vehicle is being driven, contact with the road can abrade the tank and create a hole from which gasoline can spill.When the tank drops, it remains attached to the vehicle only by the fuel filler hose and/or supply lines, or in rare instances, by the skid plate, if present.In some cases...

DP05005 Opened 22 Sep 2005 Closed 4 Jan 2006 ENGINE AND ENGINE COOLING:ENGINE

SPARK PLUG EJECTION FROM CYLINDER HEAD

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN A...

EA05005 Opened 22 Mar 2005 Closed 2 Aug 2006 ELECTRICAL SYSTEM

ENGINE COMPARTMENT FIRES

EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHIC...

Recalls on the 2002 Ford F-150

A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.

United States — NHTSA

11V385000

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING

FORD IS RECALLING CERTAIN 1997 THROUGH 2003 MODEL YEAR FORD F-150, 2004 MODEL YEAR FORD F-150 HERITAGE, 1997 THROUGH 1999 MODEL YEAR F-250 LESS THAN 8,500 LBS. GROSS VEHICLE WEIGHT RATING (GVWR), AND 2002 AND 2003 LINCOLN BLACKWOOD VEHICLES MANUFACTURED FROM JUNE 20, 1995, THROUGH AUGUST 4, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. PROLONGED EXPOSURE TO ROAD DEICING CHEMICALS MAY CAUSE SEVERE CORROSION OF THE FUEL TANK STRAPS WHICH SECURE THE TANK TO THE VEHICLE.

Risk: AS A RESULT OF THE CORROSION, ONE OR BOTH STRAPS MAY FAIL ALLOWING THE FUEL LINES TO SEPARATE FROM THE TANK, OR IN SOME CASES, CAUSING THE TANK TO CONTACT THE GROUND. EITHER SCENARIO MAY RESULT IN A FUEL LEAK PRESENTING A FIRE HAZARD.

09E025000

EXTERIOR LIGHTING:HEADLIGHTS

DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

09E012000

EXTERIOR LIGHTING

SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

08E050000

EXTERIOR LIGHTING:HEADLIGHTS

K2 MOTOR IS RECALLING 1,921 AFTERMARKET HEADLAMPS OF VARIOUS MODELS SOLD FOR USE ON THE ABOVE LISTED VEHICLES. THESE HEADLAMPS ARE MISSING THE AMBER SIDE REFLEX REFLECTOR WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Risk: WITHOUT THE AMBER SIDE REFLEX REFLECTORS, THE LIGHTING VISIBILITY MAY BE AFFECTED, POSSIBLY RESULTING IN A VEHICLE CRASH.

07E066000

EQUIPMENT:ELECTRICAL

CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.

Risk: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.

06E067000

EXTERIOR LIGHTING:HEADLIGHTS

CERTAIN MAXZONE HEADLIGHT ASSEMBLIES, DEPO BRAND, P/NOS. 331-1129L-ASN AND 331-1129R-ASN, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

06E065000

EXTERIOR LIGHTING

CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.

Risk: LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.

06E056000

FUEL SYSTEM, GASOLINE

CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.

Risk: FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

Canada — Transport Canada

Canada runs its own recall programme, and its campaigns do not always mirror the American ones.

Recall 2019420 5,327 units in Canada

Other

Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.

Recall 2011281 166,282 units in Canada

Fuel System

On certain 1997-2003 F-150, 2004 F-150 Heritage, 1997-1999 F-250, and 2002-2003 Lincoln Blackwood vehicles that were originally sold in or are currently operated in areas of heavy road salt usage during winter months (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador), the fuel tank straps could corrode and fail. This could allow the fuel tank to contact the ground, which may compromise the tank's integrity and permit fuel leakage. Fuel leakage, in the presence of an ignition source, could result in a fire causing property damage and/or personal injury. Correction: Dealers will install fuel tank straps with improved corrosion protection.

Recall 2005028 304,417 units in Canada

Electrical

On certain vehicles, the speed control deactivation switch may overheat, smoke, or burn, potentially resulting in an underhood fire. The condition may occur either when the vehicle is parked or when it is in operation. Correction: Initially as an interim repair, owners will be instructed to return their vehicles to their dealers to have the speed control deactivation switch disconnected. As soon as replacement parts are available, owners will be instructed to return to the dealers for installation of a new switch or fused wiring harness.

Recall 2004164 305,024 units in Canada

Steering

On certain vehicles, Ford has issued a scheduled maintenance guide update which specifies that every 20 000 kms, the steering linkage, which includes tie-rod ends, should be inspected. The vehicle owner is asked to place the tie-rod end inspection procedure supplied with this maintenance guide update in the vehicle's glove box for reference and safekeeping. The vehicle owner is to provide the inspection procedure to their repair facility to help properly identify worn tie-rod ends. Performing the vehicle scheduled maintenance, including maintenance inspections, is the responsibility of the vehicle owner. Failure to replace worn tie-rod ends may eventually result in a tie-rod end separation that could adversely affect steering control. If the inspection reveals that a tie-rod end is worn and must be replaced, the repair will be at the owner's expense unless the vehicle is still covered by the basic vehicle warranty, or has an extended service plan coverage that includes these components.

Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.

Complaints that involved harm

Reports where the owner recorded a crash, a fire, an injury or a death.

at 200,000 miles North Bend, NE Fire

ENGINE

The contact owns a 2002 Ford F-150. The contact stated that she observed smoke emanating from under the vehicle near the engine compartment. The contact stated that she opened the hood and flames erupted from the engine compartment near the battery. The contact threw dirt on the engine to extinguish the fire. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 200,000.

NHTSA complaint #11539907 — an unverified report by a vehicle owner.

at 280,000 miles Pleasant Hope, MO Crash 1 injured

AIR BAGS

The contact owned a 2002 Ford F-150. The contact stated that while his wife was driving at 50 MPH, she crashed into a tree. The air bags failed to deploy upon impact. The contact's wife was taken to the hospital where she was treated for a concussion, multiple hematomas to her right thigh, right abdomen, and head; as well as three fractures on her vertebrae. A police report was filed. The vehicle was towed from the scene to an independent tow yard where it remained in their possession. The dealer nor the manufacturer had been notified of the failure. The contact was informed by his insurance that the vehicle was a total loss. The failure mileage was approximately 280,000.

NHTSA complaint #11519988 — an unverified report by a vehicle owner.

Bridgeville, CA Fire

UNKNOWN OR OTHER

Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.

NHTSA complaint #11482791 — an unverified report by a vehicle owner.

Bridgeville, CA Fire

ELECTRICAL SYSTEM

Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.

NHTSA complaint #11482791 — an unverified report by a vehicle owner.

Bridgeville, CA Fire

FUEL/PROPULSION SYSTEM

Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.

NHTSA complaint #11482791 — an unverified report by a vehicle owner.

at 300,000 miles Arbuckle, CA Crash 2 injured

SEATS

I WAS DRIVING ON FREEWAY WHEN A CAR THAT WAS TRAVELING IN AN EXCESS OF 80+ MILES AND REAR-ENDED MY 2002 FORD F 150. MY TRUCK WAS TOTALED AND MY DRIVERS SEAT BACK FRAME BROKE FROM RIGHT SIDE AND NONE OF MY AIRBAGS DEPLOYED. I ENDED UP IN THE HOSPITAL FOR 3 DAYS. I HAD A CONCUSSION, NECK INJURY, KNEES AND RE-INJURED MY BACK. I WAS LUCKY TO BE ALIVE.

NHTSA complaint #11361288 — an unverified report by a vehicle owner.

The most recent complaints

In the owners' own words, exactly as filed with NHTSA.

Hesperia, CA

UNKNOWN OR OTHER

I had the recall number 05s28 repaired at high desert ford on July sixth as a part of a California safety inspection to register my vehicle. Per ford they are done however they refuse to update the system which holds my vehicle unable to be registered even after the services were rendered and complete. Multiple attempts to trendy have failed any results thus ford is holding my vehicle hostage from legal use in the state

NHTSA complaint #11750981 — an unverified report by a vehicle owner.

Joplin, MO

FUEL/PROPULSION SYSTEM

Cruise control kicked on and won't go off. Gas fumes come from the AC unit. When driving the truck started speeding up. Now the truck is parked.

NHTSA complaint #11729847 — an unverified report by a vehicle owner.

El Paso, TX

SEAT BELTS

Front seatbelts on 2002 Ford F-150 become unlatched unexpectedly while driving. This has been noticed over the last two or three years occasionally, but has been getting worse. Seat belt has become unlatched about 5-6 times during a 600 mile road trip. Seat belt was confirmed by two passengers that it was indeed latched correctly and nothing pushing the release button. Seatbelt was confirmed to be latched by firmly tugging on seat belt to witness that it was latched. Both passengers confirmed that the seatbelt become unlatched randomly while driving. Passenger and driver safety is at risk. If driver seatbelt comes unlatched while driving or during accident, the driver could loose control of truck and put other drivers at risk. The unlatching does not show any warning signs as to when it will become unlatched. Seatbelt just becomes unlatched and starts to recoil without warning. Ford service just says that the truck is out of warranty and that they dont cover seat belt replacements as there is no open recalls for such. Seatbelt is still currently installed on vehicle but can be available for inspection on vehicle or removed for inspection.

NHTSA complaint #11661168 — an unverified report by a vehicle owner.

Federal way, WA

FUEL/PROPULSION SYSTEM

Just learned of recall.

NHTSA complaint #11647264 — an unverified report by a vehicle owner.

Council Bluffs IA, IA

UNKNOWN OR OTHER

DRIVING DOWN [XXX] THE STRAPS ON MY GAS TANK BROKE BECAUSE THEY RUSTED THRU CAUSING GAS TANK TO DROP AND SPILL FUEL ALL OVER [XXX] IN IOWA CAUSING SO MUCH FUEL SPILLED OUT THEY HAD TO CLOSE ONE LANE OF TRAFFIC....THE FIRE DEPT CHIEF OF WHITING, IOWA, STEVEN SNYDER, Can verify what happened....THERE IS A POLICE REPORT BUT I DIDN'T HAVE IT FILING OUT THIS REPORT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11604628 — an unverified report by a vehicle owner.

Council Bluffs IA, IA

FUEL/PROPULSION SYSTEM

DRIVING DOWN [XXX] THE STRAPS ON MY GAS TANK BROKE BECAUSE THEY RUSTED THRU CAUSING GAS TANK TO DROP AND SPILL FUEL ALL OVER [XXX] IN IOWA CAUSING SO MUCH FUEL SPILLED OUT THEY HAD TO CLOSE ONE LANE OF TRAFFIC....THE FIRE DEPT CHIEF OF WHITING, IOWA, STEVEN SNYDER, Can verify what happened....THERE IS A POLICE REPORT BUT I DIDN'T HAVE IT FILING OUT THIS REPORT INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #11604628 — an unverified report by a vehicle owner.

at 108,000 miles Ripley, WV

ENGINE

The contact owns a 2002 Ford F-150. The contact stated while driving at an undisclosed speed, the vehicle made a loud sound. No warning light was illuminated. The vehicle was towed to an independent mechanic, who diagnosed and determined that cylinder #3 spark plug had blown out, but no repair was recommended at the time. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 108,000.

NHTSA complaint #11591276 — an unverified report by a vehicle owner.

at 100,000 miles League City, TX

WHEELS:LUGS/NUTS/BOLTS/STUDS

The contact owns a 2002 Ford F-150. The contact stated while at a tire shop to have the tires rotated, the mechanic was unable to remove the tires due to the lug nuts being swollen. The manufacturer was made aware of the failure and suggested to the contact to call the NHTSA Hotline to report the failure. The approximate failure mileage was 100,000.

NHTSA complaint #11569578 — an unverified report by a vehicle owner.

at 70,000 miles Leesville, LA

LATCHES/LOCKS/LINKAGES

The contact owns a 2002 Ford F-150. The contact stated that the rear driver's side and rear passenger's side doors failed to open from inside or outside the vehicle. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact stated that the vehicle was previously serviced due to the failure. The failure mileage was 70,000.

NHTSA complaint #11557057 — an unverified report by a vehicle owner.

Soochoppy, FL

SEAT BELTS

Systems failed. Recalls incomplete

NHTSA complaint #11556537 — an unverified report by a vehicle owner.

Soochoppy, FL

VEHICLE SPEED CONTROL

Systems failed. Recalls incomplete

NHTSA complaint #11556537 — an unverified report by a vehicle owner.

Soochoppy, FL

SERVICE BRAKES

Systems failed. Recalls incomplete

NHTSA complaint #11556537 — an unverified report by a vehicle owner.

at 94,000 miles Madison, AL

VEHICLE SPEED CONTROL

The contact owns a 2002 Ford F-150. The contact stated that while driving approximately 45 MPH and attempting to pass a slower vehicle, the vehicle experienced unintended acceleration. The contact stated that while depressing the accelerator pedal, the pedal suddenly extended to the floorboard causing the vehicle to immediately accelerate faster than intended. During the failure the speed increased to over 75 MPH before the contact shifted the transmission into neutral and the vehicle decelerated. The contact stated that the vehicle had experienced the failure on two other occasions and the cruise control feature was never activated during the failure. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted. The failure mileage was 94,000.

NHTSA complaint #11539704 — an unverified report by a vehicle owner.

at 200,000 miles North Bend, NE Fire

ENGINE

The contact owns a 2002 Ford F-150. The contact stated that she observed smoke emanating from under the vehicle near the engine compartment. The contact stated that she opened the hood and flames erupted from the engine compartment near the battery. The contact threw dirt on the engine to extinguish the fire. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 200,000.

NHTSA complaint #11539907 — an unverified report by a vehicle owner.

at 280,000 miles Pleasant Hope, MO Crash 1 injured

AIR BAGS

The contact owned a 2002 Ford F-150. The contact stated that while his wife was driving at 50 MPH, she crashed into a tree. The air bags failed to deploy upon impact. The contact's wife was taken to the hospital where she was treated for a concussion, multiple hematomas to her right thigh, right abdomen, and head; as well as three fractures on her vertebrae. A police report was filed. The vehicle was towed from the scene to an independent tow yard where it remained in their possession. The dealer nor the manufacturer had been notified of the failure. The contact was informed by his insurance that the vehicle was a total loss. The failure mileage was approximately 280,000.

NHTSA complaint #11519988 — an unverified report by a vehicle owner.

El Paso, TX

ELECTRICAL SYSTEM

Speed control deactivation switch

NHTSA complaint #11511855 — an unverified report by a vehicle owner.

at 80,000 miles Lovelady, TX

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

The contact owns a 2002 Ford F-150. The contact stated while opening the driver’s side rear door, the door failed to unlatch. The contact also attempted to open the passenger’s side rear door; however, the door would not unlatch. The vehicle was taken to an independent mechanic and the contact was informed that the wiring harness in the doors needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 80,000.

NHTSA complaint #11506395 — an unverified report by a vehicle owner.

Bridgeville, CA Fire

UNKNOWN OR OTHER

Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.

NHTSA complaint #11482791 — an unverified report by a vehicle owner.

Bridgeville, CA Fire

ELECTRICAL SYSTEM

Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.

NHTSA complaint #11482791 — an unverified report by a vehicle owner.

Bridgeville, CA Fire

FUEL/PROPULSION SYSTEM

Unknown cause of incident. Vehicle is available for inspection. Vehicle spontaneously burst into flames. No reproduction due to incident happening on 09/02/2022. Vehicle inspected by Fire Department and California Highway Patrol. No warnings or symptoms leading up to incident. On 09/02/2022 I attempted to help my wife that was stranded out State Route Highway 36 in her 2009 BMW 750 LI at the Van Duzen Grange. I had been hooked up to her car for approximately 10 to 15 minutes with my truck idling when she screamed, " Your truck's on FIRE!" I barely got myself out of the cab when a ball of flames shot through the dashboard. 3/4ths of the truck was consumed in fire in less than 5 minutes. Fire Department arrived approximately 10 minutes later and doused the fire. Everything in my truck was destroyed. My wife's BMW suffered severe damage to the front end.

NHTSA complaint #11482791 — an unverified report by a vehicle owner.

Paragould, AR

POWER TRAIN

I have a 2002 Ford F-150 and The problem is with the transmission my vechile acts like it's going in reverse and when it goes to backup it seems as something is locked I been over the brakes and rear end and yet nothing has came up I even replaced the transmission filter to see if that would help but nothing so I been having to drive my truck with no reverse and today the overdrive light on the shifter started blinking what is the problem with these transmission please Ford do a recall to fix the transmission

NHTSA complaint #11480382 — an unverified report by a vehicle owner.

Peachtree City, GA

ENGINE

1. Coils on top of spark plug get moisture in them when there is just the right kind of rain storm. This makes the coil or coils fail until the dry out. This seems to make the coil eventually go bad. Yes, it is available for inspection. 2. Not sure if its a combination of heat and moisture but sometime right away and sometimes a few minutes into driving the coil or coils fail and the engine loses power. Then if seems to be a random, unpredictable occurrence until it dries out, Very Unsafe. If one coil fails it loses just a little power, but if more than one fails it loses a lot of power and stalls at times. This is why I am writing it up. A few time now, I have gone to pull into traffic and then I lose power and either have to run off the road or just upset the car behind me if they are not too close. 3 & 4. I have advise all the Ford dealerships in my area trying to find one that has a fix yet. The only fix Ford has, is a new designed coil, which does not appear to be any better. The dealership just replaces the coil. I have had all my coils replaced, some 2 or 3 times. 5. It depends, sometime the engine light will come on and advise which coil is misfiring and sometimes if does not. Right now my engine light is on and it displays the #6 coil misfire. Then the engine light will go out after it dries out and stops failing or it will stay off if the coil had gone bad again. I am sure its not just the F 150, but the 4.6 liter engine that is in other vehicles. I started keeping track in 2012. I wrote a letter to Ford in 2015 and they replied, there was no recall. I have several repair receipts and the letter from Ford if you need that. Just search on your site and you will see many complaints. One example Manufacturer Communication number: 041601. If you google "ford fix for moisture in coils" you will see many forums trying to figure out a fix and just complaining.

NHTSA complaint #11469750 — an unverified report by a vehicle owner.

Queen Creek, AZ

STRUCTURE:BODY

Left rear passenger door will not open. Door is jammed. This will not allow rear passengers to quickly exit vehicle if pinned in due to crash or fire.

NHTSA complaint #11467942 — an unverified report by a vehicle owner.

Texas City, TX

ELECTRICAL SYSTEM

I went to get a state inspection and a code came up Po174

NHTSA complaint #11425809 — an unverified report by a vehicle owner.

Texas City, TX

FORWARD COLLISION AVOIDANCE: AUTOMATIC EMERGENCY BRAKING

I went to get a state inspection and a code came up Po174

NHTSA complaint #11425809 — an unverified report by a vehicle owner.