Owners have filed 249 complaints
about the 2003 Hyundai Sonata with NHTSA between 2002 and 2026.
The largest single group is the airbags.
Across this model's run it ranks 14 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 18
Against the median year of the Hyundai Sonata. 50 means typical for this
model; 100 means roughly double.
Severity — 100
28.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 40
23% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Door
1321.3%
Body
914.8%
Frontal
813.1%
HUB
711.5%
Engine
711.5%
Automatic Transmission
711.5%
Latch
58.2%
Frame AND Members
58.2%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
84.3%
1,000 – 9,999 miles
137.1%
10,000 – 24,999 miles
126.5%
25,000 – 49,999 miles
3016.3%
50,000 – 74,999 miles
3317.9%
75,000 – 99,999 miles
2212.0%
100,000 – 149,999 miles
4524.5%
150,000+ miles
2111.4%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Side barrier crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2003 Hyundai Sonata 4-DR
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2002peak 10Jun 2026
NHTSA investigations into the 2003 Hyundai Sonata
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
PE08071Opened 15 Dec 2008Closed 29 May 2009LATCHES/LOCKS/LINKAGES:DOORS:LATCH
INTERIOR DOOR HANDLE LACERATION HAZARD
THE MANUFACTURER HAS ISSUED A SAFETY RECALL NOTIFICATION AS A RESULT OF THIS INVESTIGATION.THE RECALL AFFECTS 91,202 MY 2002-2003 SUBJECT VEHICLES PRODUCED FROM JANUARY 28, 2002, THROUGH MARCH 22, 2003.THE VEHICLE RECALL POPULATION WAS DEFINED BY THE MANUFACTURER'S USE OF A NEW SUPPLIER FOR THE CHROME PLATING PROCESS BEGINNING IN JANUARY 2002, AND A PRODUCTION CHANGE IN MARCH 2003 TO IMPROVE ADHESION OF THE PLATING TO THE DOOR HANDLE.VEHICLES BEING RECALLED REPRESENT 59 PERCENT OF THE TOTAL MY 2002-2003 PRODUCTION, BUT ACCOUNT FOR 91 PERCENT OF THE CONSUMER COMPLAINTS RECEIVED.THE PROCESS CHAN...
EA08016Opened 21 Aug 2008Closed 20 Apr 2009STRUCTURE:FRAME AND MEMBERS
FRONT SUB-FRAME CORROSION
IN A LETTER DATED APRIL 14, 2009, HYUNDAI-KIA AMERICA TECHNICAL CENTER, INC (HYUNDAI) NOTIFIED NHTSA THAT HYUNDAIIS CONDUCTING A SAFETY RECALL OF MODEL YEAR (MY) 1999 THROUGH 2004 HYUNDAI SONATA VEHICLES MANUFACTURED PRIOR TO NOVEMBER 20, 2003 THAT ARE REGISTERED AND OPERATED IN THE FOLLOWING SALT BELT STATES AND THE DISTRICT OF COLUMBIA: CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN.HYUNDAI IS RECALLING THE VEHICLES TO RE...
PE05059Opened 7 Nov 2005Closed 11 May 2006TIRES
TIRE VALVE STEM FAILURES
THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE), PE05-059, BASED ON NINE CONSUMER COMPLAINTS OF TIRE VALVE STEM FAILURES.THE ALLEGED VALVE STEM FAILURES OCCURRED ONLY AFTER TIRE REPLACEMENT FROM THE ORIGINAL EQUIPMENT (OE) TIRE (MICHELIN 205/65R15 ENERGY MXV4 PLUS) TO A NON-OE? AFTERMARKET TIRE.NINETY-EIGHT PERCENT OF THE AFTERMARKET TIRES ALLEGED TO BE ASSOCIATED WITH THE TIRE VALVE STEM FAILURES WERE DETERMINED TO BE AFTERMARKET TIRES PRODUCED BY BRANDS OF MICHELIN GROUP (BF GOODRICH AND UNIROYAL).MICHELIN ISSUED A TECHNICAL BULLETIN ON SEPTEMBER 15, 2005 MAKIN...
Recalls on the 2003 Hyundai Sonata
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 200914810,070 units in Canada
Other
On certain vehicles, repeated use of an interior door handle may wear the chrome plating on the upper edge of the handle. This may result in a crack or separation between the chrome plating - forming a sharp edge which could injure a user's finger. Correction: Dealers will inspect and, if necessary, replace interior door handles.
Recall 200912334,786 units in Canada
Structure
On certain vehicles operated in areas of heavy road salt usage (Ontario, Quebec, New Brunswick, Nova Scotia, Prince Edward Island, and Newfoundland & Labrador), road salt can collect in the rear portion of the side members of the subframe and may result in internal corrosion leading to thinning or perforation of the subframe steel. The corrosion may ultimately lead to separation of the lower control arm at the forward mounting point to the subframe. When separation occurs, in most cases, the movement of the arm will cause the axle to pull out of the transaxle and the vehicle will no longer have drive power to the wheels. In extreme cases, the wheel can also rotate off its designed axis and make contact with the fender or the wheel well. Both outcomes could result in a loss of vehicle control and a crash causing property damage, personal injury or death. Correction: Dealers will inspect and, if necessary, replace the front subframe assembly. Should the subframe not require replacement, drainage holes will be added, as well as treatment with rust-proofing material to arrest the corrosion process.
Recall 200413037,126 units in Canada
Fuel System
On certain vehicles, the fuel tank assembly valve may not close properly. If a vehicle with a fuel tank assembly valve that is not properly closed were to roll over, fuel spillage could occur. Fuel spillage in the presence of an ignition source may result in a fire. Correction: Dealer will install an additional fuel tank assembly valve.
Recall 2003170271 units in Canada
Brakes
On certain vehicles, if the T125/70D15 compact spare tire is installed on any wheel position, the ABS feature will not operate and the ABS warning light will illuminate. Correction: Dealer will replace the spare tire with a new larger diameter T125/80R15 compact spare tire and install a new tire pressure label to provide information applicable to the T125/80R15 compact spare tire.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 180,000 milesTaft, CAFire
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH, THERE WAS SMOKE EMITTING FROM THE FRONT OF THE VEHICLE. IN ADDITION, THERE WAS AN ABNORMAL ODOR OF FUEL INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE COULD NOT BE DETERMINED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V178000 (FUEL SYSTEM, GASOLINE). A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. *TT
NHTSA complaint #11081499 — an unverified report by a vehicle owner.
Poughkeepsie, NYCrash
SERVICE BRAKES
THE BRAKE PEDAL DROPS DURING BRAKING WITH A CLUNK. THE BRAKES ARE WEAK AT THAT POINT BUT RECOVER. I REPLACED THE BRAKE PADS AND ROTORS AND MASTER CYLINDER, STILL THE SAME PROBLEM. IT HAPPENS A LOT. MY WIFE WON'T DRIVE THE CAR ANYMORE.
NHTSA complaint #11040398 — an unverified report by a vehicle owner.
at 100,000 milesMarlboro, NJ4 injured
UNKNOWN OR OTHER
REPORT RECEIPT DATE: MAY 21, 2009 NHTSA CAMPAIGN NUMBER: 09V171000 COMPONENT(S): LATCHES/LOCKS/LINKAGES SIMILAR ISSUE IS HAPPENING IN MY 2003 HYUNDAI SONATA VEHICLE. A CHILD IN MY BACK SEAT JUST SLICED THEIR HAND WITH A 2" INCH CUT AND WE HAD 3 OTHERS SLICE THEIR HAND ON THE FRONT DOOR HANDLE (WE TAPED THIS) BUT WAS NOT AWARE OF BACK SEAT NOR RECALL TILL TODAY. VERY CONCERNED AS TO SAFETY OF CHILDREN IN BACK SEAT. I ONLY REALIZED THIS HAPPENED TO ALL DOOR HANDLES AND THEIR HAD EVEN BEEN A RECALL AS THE PARENT OF THE INJURED CHILD SAID THEIR CAR HAD BEEN RECALLED FOR THIS ISSUE. I CALLED HYUNDAI 4/13/2016 TO DISCUSS AND WAS TOLD MY VIN NUMBER WAS NOT PART OF THE RECALL ALTHOUGH THE EXACT SAME ISSUE. ALL CHROME IS PEELING FROM TOP OF HANDLE AT THE SEAM ON ALL 4 INTERIOR DOOR HANDLES.
NHTSA complaint #10855317 — an unverified report by a vehicle owner.
at 120,000 milesBeavercreek, OH6 injured
STRUCTURE:BODY
REPEATED USE OF THE INTERIOR DOOR HANDLE MAY CAUSE WEAR OF THE CHROME PLATE. IF THE TOP EDGE OF THE HANDLE HAS VERY THIN CHROME PLATING, THAT PORTION OF THE PLATING MAY WEAR AWAY MORE EASILY THAN MORE THICKLY PLATED AREAS AS THE DOOR HANDLE IS USED. THE WORN CHROME PLATING ON THE UPPER EDGE OF THE HANDLE MAY RESULT IN A CRACK OR SEPARATION BETWEEN THE CHROME PLATING ON THE INBOARD AND OUTBOARD SURFACES OF THE HANDLE, WHICH MAY FORM A SHARP EDGE. CONSEQUENCE: THIS MAY INFLICT LACERATION INJURIES TO ANYONE USING THE DOOR HANDLE. BASICALLY WHEN YOU GO TO USE THE INSIDE DOOR HANDLES THE PEELING CHROME IS SHARP AND CUTS YOUR FINGERS. HYUNDAI RECALL #93 ENDED IN MARCH 2003, MY CAR WAS MANUFACTURED IN MAY 2003. THE PROBLEM IS IDENTICAL TO THE MODELS IN RECALL #93.
NHTSA complaint #10854985 — an unverified report by a vehicle owner.
at 95,000 milesJackson, GA1 injured
STRUCTURE:BODY:DOOR
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT THE FOUR INTERIOR DOOR CHROME HANDLES EXHIBITED EXTREMELY SHARP EDGES. THE CONTACT SUFFERED FROM A TWO INCH LACERATION TO BOTH FINGERS ON THE LEFT HAND. THE FRONT DRIVER AND PASSENGER UPPER DOOR HANDLES CAUSED THE INJURIES. THE CONTACT APPLIED TAPE TO THE FOUR DOOR HANDLES TO AVOID ADDITIONAL INJURIES. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V171000 (LATCHES/LOCKS/LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.
NHTSA complaint #10720963 — an unverified report by a vehicle owner.
at 187,000 milesLexington, KYCrash2 injured
AIR BAGS
WE WERE INVOLVED IN AN ACCIDENT AND NONE OF THE AIRBAGS PROPERLY DEPLOYED IT ONLY FELL OUT OF THE SEAT ON THE PASSENGER SIDE OF THE CAR AND IT DEPLOYED FLAT NO AIR IN IT OR NOTHING. MY FIANCEE WAS INJURED AS WELL AS MYSELF AND WE ARE CURRENTLY BEING TREATED FOR INJURIES SUSTAINED BY THE ACCIDENT...
NHTSA complaint #10690695 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
at 170,000 milesWest Harrison, NY
SUSPENSION
The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was at Valvoline for a service appointment, the contact was made aware of NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to the dealer, who informed the contact that the subframe assembly and additional unknown parts were not included in the recall repair. In addition, the contact was informed that the recall could not be performed because other repairs were needed prior to the recall repair. The vehicle was not repaired. The contact stated that the vehicle was unsafe to drive. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the repair was not covered under the recall. The failure mileage was approximately 170,000.
NHTSA complaint #11743571 — an unverified report by a vehicle owner.
at 170,000 milesWest Harrison, NY
STRUCTURE
The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was at Valvoline for a service appointment, the contact was made aware of NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to the dealer, who informed the contact that the subframe assembly and additional unknown parts were not included in the recall repair. In addition, the contact was informed that the recall could not be performed because other repairs were needed prior to the recall repair. The vehicle was not repaired. The contact stated that the vehicle was unsafe to drive. The manufacturer was made aware of the failure, and a case was filed. The contact was informed that the repair was not covered under the recall. The failure mileage was approximately 170,000.
NHTSA complaint #11743571 — an unverified report by a vehicle owner.
at 58,000 milesPacifica, CA
SUSPENSION
The contact owns a 2003 Hyundai Sonata. The contact stated that upon taking the vehicle to an independent mechanic, the mechanic discovered severe corrosion on the suspension. Upon investigation, the contact discovered NHTSA Campaign Number: 09V124000 (Suspension). The vehicle was taken to a dealer, and the contact was informed that due to the severe corrosion, the recall repair could not be performed. The mechanic at the dealer described the vehicle as being unsafe to drive. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 58,000
NHTSA complaint #11685113 — an unverified report by a vehicle owner.
Pacifica, CA
STRUCTURE:BODY
NHTSA Campaign ID Number: 09V124000 NHTSA Action Number: EA08016 Recall calls for repair or replacement of front sub-frame, due to corrosion. Local dealer responded, “ . . . we will not be able to perform recall”. I was told the corrosion was too far gone to repair. They refuse to replace the defective part.
NHTSA complaint #11675456 — an unverified report by a vehicle owner.
Cherry Hill, NJ
SUSPENSION
The contact owns a 2003 Hyundai Sonata. The contact stated that while the vehicle was being serviced by an independent mechanic, the mechanic informed the contact that the front subframe was severely corroded. The mechanic determined that the failure was related to a recall. The vehicle was taken to the dealer, where the contact was informed that the subframe needed to be replaced; however, the repair could not be covered under NHTSA Campaign Number: 09V124000 (Suspension) because the parts had been discontinued. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was unknown. Parts distribution disconnect.
NHTSA complaint #11596969 — an unverified report by a vehicle owner.
at 69,425 milesBel Air, MD
STRUCTURE
The contact owns a 2003 Hyundai Sonata. The contact stated that while self-inspecting the vehicle, he noticed that the subframe was extremely rusted. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,425. The contact stated that no assistance has been offered from the dealership from which the vehicle was purchased from.
NHTSA complaint #11533052 — an unverified report by a vehicle owner.
Eagle Mountain, UT
AIR BAGS
Airbag light came on and stays on. Pulled a code that pointed to the wiring in the passenger seat. Moved wiring around and made sure connectors were properly plugged and the light went away for maybe a week. Light is back on again. Removed seat bolts to gain better access, used tubing and electrical tape to straighten any kinked wiring I could find underneath passenger front seat, disconnected and reconnected connections. Airbag light blinked once and still remains on with the code still pointing to the passenger seat wiring. Apparently this issue has been reported many times in online forums with no meaningful response from the company though this clearly affects proper airbag deployment.
NHTSA complaint #11421937 — an unverified report by a vehicle owner.
Eagle Mountain, UT
ELECTRICAL SYSTEM
Airbag light came on and stays on. Pulled a code that pointed to the wiring in the passenger seat. Moved wiring around and made sure connectors were properly plugged and the light went away for maybe a week. Light is back on again. Removed seat bolts to gain better access, used tubing and electrical tape to straighten any kinked wiring I could find underneath passenger front seat, disconnected and reconnected connections. Airbag light blinked once and still remains on with the code still pointing to the passenger seat wiring. Apparently this issue has been reported many times in online forums with no meaningful response from the company though this clearly affects proper airbag deployment.
NHTSA complaint #11421937 — an unverified report by a vehicle owner.
at 45,922 milesMesa, AZ
ENGINE
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, WHEN THE VEHICLE LOSS MOTIVE POWER AND STALLED. THE CONTACT PUSHED THE VEHICLE TO THE SIDE OF THE ROADWAY. THE CONTACT HAD THE VEHICLE TOWED TO A CERTIFIED MECHANIC WHO DIAGNOSED THAT CRANKSHAFT POSITION SENSOR AND THE CRANKSHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,922. THE VIN WAS NOT AVAILABLE.*DT
NHTSA complaint #11396614 — an unverified report by a vehicle owner.
at 150,000 milesWilkes Barre, PA
POWER TRAIN
YOU CAN NOT FILL GAS TANK PASS HALF WITH OUT THE SMELL FILLING THE CAR .THE BACK SUSPENSION WHEN YOU GO OVER 40 TALES FROM SIDE TO SIDE .THE CAR WAS ON THE HIGHWAY .
NHTSA complaint #11362935 — an unverified report by a vehicle owner.
at 150,000 milesWilkes Barre, PA
SUSPENSION
YOU CAN NOT FILL GAS TANK PASS HALF WITH OUT THE SMELL FILLING THE CAR .THE BACK SUSPENSION WHEN YOU GO OVER 40 TALES FROM SIDE TO SIDE .THE CAR WAS ON THE HIGHWAY .
NHTSA complaint #11362935 — an unverified report by a vehicle owner.
at 150,000 milesWilkes Barre, PA
FUEL/PROPULSION SYSTEM
YOU CAN NOT FILL GAS TANK PASS HALF WITH OUT THE SMELL FILLING THE CAR .THE BACK SUSPENSION WHEN YOU GO OVER 40 TALES FROM SIDE TO SIDE .THE CAR WAS ON THE HIGHWAY .
NHTSA complaint #11362935 — an unverified report by a vehicle owner.
at 184,077 milesST Joseph, MO
SUSPENSION
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEING INSPECTED BY AN INDEPENDENT MECHANIC, SHE WAS INFORMED THERE WAS CORROSION TO THE VEHICLE'S SUBFRAME. THE CONTACT WAS ALSO INFORMED THAT THE FRONT PASSENGER'S SIDE SWAY BAR LINKAGE AND BOTH FRONT WHEEL BEARINGS NEEDED TO BE REPLACED. A DEALER WAS NOT NOTIFIED OF FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED AS OF YET. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 09V124000 (SUSPENSION) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 184,077.
NHTSA complaint #11325302 — an unverified report by a vehicle owner.
at 109,500 milesDeltona, FL
AIR BAGS
AIR BAG WARNING LIGHT IS ON. WHEN RESET THE LIGHT COMES ON AGAIN.
NHTSA complaint #11204762 — an unverified report by a vehicle owner.
at 103,500 milesPortsmouth, VA
AIR BAGS
AIRBAG LIGHT IS ON BUT THEY HAVE NOT DEPLOYED & NO APPARENT DAMAGE TO THE AIRBAG SYSTEM, WIRING, ETC. WILL NOT PASS INSPECTION WITH THE ABS LIGHT ON, AS YOU WELL KNOW.
NHTSA complaint #11204193 — an unverified report by a vehicle owner.
at 117,000 milesSpringfield, IL
STRUCTURE:FRAME AND MEMBERS
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. WHILE DRIVING 30 MPH, THE VEHICLE BEGAN TO VEER TO THE RIGHT WITHOUT WARNING AND THE POWER STEERING FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT SUBFRAME WAS CORRODED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 117,000.
NHTSA complaint #11115140 — an unverified report by a vehicle owner.
at 117,000 milesSpringfield, IL
STEERING
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. WHILE DRIVING 30 MPH, THE VEHICLE BEGAN TO VEER TO THE RIGHT WITHOUT WARNING AND THE POWER STEERING FAILED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT SUBFRAME WAS CORRODED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 117,000.
NHTSA complaint #11115140 — an unverified report by a vehicle owner.
at 136,000 milesEagle Mountain, UT
AIR BAGS
THE AIR BAG LIGHT IS CONSTANTLY ON, MEANING THAT IN THE EVENT OF AN ACCIDENT, THEY WILL NOT DEPLOY. INCREDIBLY DANGEROUS. THIS IS APPARENTLY DUE TO WIRING UNDERNEATH THE PASSENGER SEAT STRETCHING AND PINCHING FROM MOVING THE SEAT ITSELF AND WHEN THINGS ARE PLACED UNDERNEATH THE SEAT THAT MAY DISTURB THE WIRING. I KNOW IT IS THE WIRING UNDERNEATH THE PASSENGER SEAT DUE TO CHECKING THE TROUBLE CODE AND ALSO BEING ABLE TO TEMPORARILY FIX THE ISSUE FOR A COUPLE WEEKS BY GINGERLY MOVING THE WIRES UNTIL THE LIGHT WENT AWAY. NOW I CAN'T GET THE LIGHT TO GO AWAY NO MATTER WHAT METHODS I TRY. CAN'T FIND A REPLACEMENT SET OF WIRES NOR CAN I LOCATE WHICH WIRE SPECIFICALLY IS BEING AFFECTED TO TRY TO FIX THE ISSUE MYSELF. I HAVE SEEN DOZENS OF PEOPLE MAKING THIS SAME COMPLAINT ABOUT THE AIRBAG LIGHT STAYING ON. THIS NEEDS A RECALL SINCE THIS CAN EASILY LEAD TO DEATH SINCE THE AIRBAG WILL NOT DEPLOY TO ATTEMPT SAVING METHODS TO PASSENGERS. LIGHT WAS ON FOR THE PREVIOUS OWNER FOR I DON'T KNOW HOW LONG AND HAS BEEN ON FOR ME FOR ALMOST A YEAR NOW.
NHTSA complaint #11100227 — an unverified report by a vehicle owner.
at 136,000 milesEagle Mountain, UT
ELECTRICAL SYSTEM
THE AIR BAG LIGHT IS CONSTANTLY ON, MEANING THAT IN THE EVENT OF AN ACCIDENT, THEY WILL NOT DEPLOY. INCREDIBLY DANGEROUS. THIS IS APPARENTLY DUE TO WIRING UNDERNEATH THE PASSENGER SEAT STRETCHING AND PINCHING FROM MOVING THE SEAT ITSELF AND WHEN THINGS ARE PLACED UNDERNEATH THE SEAT THAT MAY DISTURB THE WIRING. I KNOW IT IS THE WIRING UNDERNEATH THE PASSENGER SEAT DUE TO CHECKING THE TROUBLE CODE AND ALSO BEING ABLE TO TEMPORARILY FIX THE ISSUE FOR A COUPLE WEEKS BY GINGERLY MOVING THE WIRES UNTIL THE LIGHT WENT AWAY. NOW I CAN'T GET THE LIGHT TO GO AWAY NO MATTER WHAT METHODS I TRY. CAN'T FIND A REPLACEMENT SET OF WIRES NOR CAN I LOCATE WHICH WIRE SPECIFICALLY IS BEING AFFECTED TO TRY TO FIX THE ISSUE MYSELF. I HAVE SEEN DOZENS OF PEOPLE MAKING THIS SAME COMPLAINT ABOUT THE AIRBAG LIGHT STAYING ON. THIS NEEDS A RECALL SINCE THIS CAN EASILY LEAD TO DEATH SINCE THE AIRBAG WILL NOT DEPLOY TO ATTEMPT SAVING METHODS TO PASSENGERS. LIGHT WAS ON FOR THE PREVIOUS OWNER FOR I DON'T KNOW HOW LONG AND HAS BEEN ON FOR ME FOR ALMOST A YEAR NOW.
NHTSA complaint #11100227 — an unverified report by a vehicle owner.
at 180,000 milesTaft, CAFire
FUEL SYSTEM, GASOLINE
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH, THERE WAS SMOKE EMITTING FROM THE FRONT OF THE VEHICLE. IN ADDITION, THERE WAS AN ABNORMAL ODOR OF FUEL INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE COULD NOT BE DETERMINED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V178000 (FUEL SYSTEM, GASOLINE). A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 180,000. *TT
NHTSA complaint #11081499 — an unverified report by a vehicle owner.
at 139,000 milesMiami, FL
ENGINE
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE FAILED TO START WHEN ATTEMPTED TO DRIVE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TAKEN TO POTAMKIN HYUNDAI (6200 NW 167TH ST, MIAMI LAKES, FL 33014, PHONE: (305) 728-5030), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,000.
NHTSA complaint #11052497 — an unverified report by a vehicle owner.
Poughkeepsie, NYCrash
SERVICE BRAKES
THE BRAKE PEDAL DROPS DURING BRAKING WITH A CLUNK. THE BRAKES ARE WEAK AT THAT POINT BUT RECOVER. I REPLACED THE BRAKE PADS AND ROTORS AND MASTER CYLINDER, STILL THE SAME PROBLEM. IT HAPPENS A LOT. MY WIFE WON'T DRIVE THE CAR ANYMORE.
NHTSA complaint #11040398 — an unverified report by a vehicle owner.
at 232,751 milesLexington, KY
SUSPENSION
6-22-17 MY DAUGHTER WAS RETURN TO WORK IN HER 2003 HYUNDAI SONATA, AS SHE WAS LEAVING AN ADJACENT PARKING LOT TO WHERE SHE PARKED, THE RIGHT FRONT WHEEL POPPED LOUDLY, THE CAR LOST POWER SHE STOPPED THE VEHICLE GOING STRAIGHT AT A RELATIVE LOW SPEED. THE CAR WAS INOPERABLE SO I HAD IT TOWED TO MY HOUSE. 6-24-17 I BEGIN TO INSPECT WHAT HAPPENED, I JACKED THE RT FRT END OFF THE GROUND AND BLOCKED IT UP. I FOUND THE LOWER CONTROL ARM WAS SOMEWHAT LOOSE. IT WAS BROKEN LOOSE FROM THE RT SIDE SUBFRAME. I CAME IN THE HOUSE AND RESEARCHED THE INTERNET AND FOUND THIS WAS A PROBLEM WITH SONATA'S FROM 1999-2004 CAMPAIGN NUMBER 09V12400, I CONTACTED HYUNDAI CUSTOMER SERVICE 6-24-17 AROUND 12:30PM. I GAVE THE CAR INFO TO THE LADY AND SHE SAID ONLY AN A-C RECALL WAS AVAILABLE FOR THE CAR. I ASKED ABOUT THE RECALL AND GAVE THE NUMBER, SHE SAID NOT FOR MY CAR AND THAT WAS ALL THEY COULD OFFER. WHEN THE CONTROL ARM BROKE LOOSE FROM SUBFRAME IT CAUSED THE AXLE TO PULL OUT OF THE DIFFERENTIAL AND THAT WAS WHY IT LOST POWER. I ALSO FOUND THAT THE SUBFRAME IS ALMOST RUSTED THROUGH AND WEAK.
NHTSA complaint #11000983 — an unverified report by a vehicle owner.
Springfield, MA
AIR BAGS
THE PROBLEM IS THAT THE AIR BAG IS ON AND DOESN'T GO AWAY. I HAD IT CHECK AND THERE IS NO CODE FOR IT SO THEY DON'T KNOW WHAT IS CAUSE THAT. I NEED A ANSWER BECAUSE I NEED TO HAVE INSPECT AND IS NOT GOING TO PASS.
NHTSA complaint #10966683 — an unverified report by a vehicle owner.
at 139,000 milesLouisville, KY
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2003 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH AND MAKING A RIGHT TURN, THERE WAS A LOUD NOISE COMING FROM THE VEHICLE. IN ADDITION, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. UPON INSPECTION, IT WAS DISCOVERED THAT THE SUB FRAME HAD FRACTURED DUE TO RUST AND CORROSION. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 139,000.
NHTSA complaint #10928450 — an unverified report by a vehicle owner.
