103 of the
3,406 complaints filed about the KIA Sedona
are about the fuel system —
3% of everything owners reported.
The worst model year for it is 2011.
The contact owns a 2019 Kia Sedona. The contact stated that the heat and A/C control knobs had melted twice, and the contact had purchased and personally replaced the entire control panel. Additionally, the contact stated that there was an abnormal strong fuel odor coming from the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed, and the low-pressure fuel pump and fuel injectors were replaced on separate occasions. However, the failure recurred while leaving the dealer. The vehicle was taken back to the dealer, where it was determined that the high-pressure fuel pump needed to be replaced; however, after the repair, the vehicle started making abnormal sounds. Additionally, the contact stated that the abnormally strong fuel odor had worsened. The vehicle was taken back to the dealer, who informed the contact that no diagnostic trouble code was retrieved, and the contact was advised to pick up the vehicle. The contact expressed safety concerns that the vehicle was unsafe to drive due to the persistent failure. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.
NHTSA complaint #11745095 — an unverified report by a vehicle owner.
While driving car gas tank blew a hole and started on fire. Car then lost power while on fire while I was in traffic, luckily I was able to cut into a parking lot and people that were in traffic with me call 911. Fire department confirmed there was a hole in gas tank which sits right underneath driver side. Fire was only contained to where the gas tank and lines are. I have pictures.
NHTSA complaint #11735273 — an unverified report by a vehicle owner.
The contact owns a 2012 Kia Sedona. The contact stated that the engine was damaged while being repaired under NHTSA Campaign Number: 20V101000 (Fuel System, Gasoline). The contact stated that while the dealer was replacing the fuel rail as per the recall remedy, pressure built up, causing a valve cover leak, which damaged the oil pressure sensor. The dealer replaced the valve cover gasket and the oil pressure sensor, but the head gaskets were damaged. The dealer determined that the engine needed to be replaced but refused to replace the engine free of charge. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 235,000.
NHTSA complaint #11735079 — an unverified report by a vehicle owner.
137,000 Miles, regular oil changes every 4,000 miles,even adding 2 quarts during the 4,000 miles it would still come up short by 1 quart. Started throwing p0018 timing code,high pressure fuel pump on front blew off the valve cover,Im assuming due to jumping out of timing,as the high pressure pump sits ontop of one of the Camshaft rollers. Engine started knocking and is now useless.
NHTSA complaint #11729795 — an unverified report by a vehicle owner.
Kia service dealer diagnosed high oil consumption on my car with heavy sounds. They recommend to replace whole engine but it's out of warranty. It has only 106k miles on it. I am afraid the car is posing safety issue as well and it has less miles on it. I filed complain with kia consumer corporate a case has been generated on their system [XXX] but no one had contacted me yet. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11707644 — an unverified report by a vehicle owner.
Check engine light came on all of a sudden. Smell of exhaust/gas coming from car. Took car to the dealership to get the cause of the check engine light coming on. Dealership said it came back 02 sensor bank 2 and exhaust gasket to header.
NHTSA complaint #11701347 — an unverified report by a vehicle owner.
There is a continuous leakage of oil from my van even after the dealer replaced valve cover gasket . When I complained they said it was the leftover oil. After a month again I complained . Then they re-checked and said it is my car's timing cover reseal leaking . Again after few days I had to complain as there was a leak. I got the same standard reply of leftover uncleaned oil is the cause. Few weeks later I took the van to them and they said they thoroughly cleaned and there won't be any leak. I sent them pictures of oil drops underneth the car like I did on earlier occassions. On August 11th this year they checked the car after my complaint and said there was no active leak. On 30th of this month I sent them the pictures of leaked oil spots which they are going to check on 18th September!. Since I got my first appointment on January 19 2025 I took the vehicle to the dealer 5-6 times. In between I complained to them about failure of door locks and wiper blades. They said they were fine and had no issues. A week ago passenger side door lock stopped working often . I took to a mechanic store run by AAA. Their response after few days was that the electrical system was failing due to bad alternator as the battery got depleted. They recommended me to the dealer again. I was searching google and realised that an oil leak can cause alternator to go bad leading to electric failure and even fire accidents. On [XXX] I noticed red flashing sign of alternator and some other (?) after 2 minutes drive from home. So I immediately turned back and went home and parked the van in the garage and waiting for September 18 for an inspection by the dealer. Last week drove to St Louis from Lexington, after the dealer confirmed there was no oil leak. In all their reports they mentioned vehicle is in good health! Each time when I sent a picture of a leak I requested managers at the receiving desk to park at a clean place and check the leak which they never did. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F
NHTSA complaint #11684328 — an unverified report by a vehicle owner.
Engine failed…driving down the road with five small children and without warning all the lights came on and started smoking, leaking fuel, power doors failed, steering, acceleration and more. We had to have the car towed to a shop. A when looking into what’s happening apparently many others are having to spend thousands to fix this issue and I’m afraid that’s where we are. An investigation needs to be opened as this is clearly an ongoing issue for many families
NHTSA complaint #11679912 — an unverified report by a vehicle owner.
Unknown... So whenever it gets hot in the summertime lately. My car has an issue starting sometimes it doesn't start and I've taken it in have the mechanic look at it. They can't figure out what's going on with that. They say that it's known issue that they've had and they told me to Bang on the relay inside my vehicle. And sometimes that starts up right away and other times it takes a little bit for my car to start. They could not figure out what was causing it and sometimes all of my lights on my dashboard light up my air bag, ABS, check engine. Those will light up and I think it's something to do with the electrical or the fuel system. I don't know, i've replaced parts on it and I'm still having the issue. I don't know what is going on. I've replaced some fuses and they've blown so that's why I'm thinking it's something to do with the electrical. My mechanic couldn't figure out what it was and he says he has had many kias have the same issue.
NHTSA complaint #11678626 — an unverified report by a vehicle owner.
There was a sudden loss of power while in the middle of the highway. Further inspection resulted in low oil and metal flakes in the oil filter. At the time of initial loss of power there was absolutely zero warning or indication of any issues at all.
NHTSA complaint #11667762 — an unverified report by a vehicle owner.
Rod failure, was told there was fuel mixing with the oil and caused the oil to break down and cause complete engine failure while driving down the highway with my kids. Kia will not do anything about it. How can this be right. I know a lot of people with the same issues.
NHTSA complaint #11626061 — an unverified report by a vehicle owner.
Complete engine failure, knocking like crazy, fuel smell in the oil, The shop said the fuel in the oil broke it down and allowed the motor to fail. We were driving down the highway when it happened with family and kids which was not safe at all. No warning message at all, no check engine light, the shop has inspected and said it’s failed. The kia dealership has said many of the Kia’s have been recalled for engine failure but not ours? But others with the same motor have been.
NHTSA complaint #11621658 — an unverified report by a vehicle owner.
I was driving my 2018 Kia Sedona on [XXX]. I had all 4 of my kids with me in the van, I heard a click, click, click, then the car went dark, in the middle of the road no warning nothing. There was no light or anything that came on as a warning. It just died. It was scary to go through that with my kiddos. We are devastated as the car is only 6yrs old and it wont work at all. Had it towed to my local auto shop. They said the engine is defective and needs to be replaced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11601005 — an unverified report by a vehicle owner.
On June 6th 2024 My 2016 Kia Sedona experienced sudden power loss accompanied by thick smoke out of the exhaust and a loud ticking while on a busy main intersection. Kia's Gross negligence to recall its known troubled engines is causing needless highway incidents. From stolen cars, engine failures and now fires, this is the second Kia I have had fail.
NHTSA complaint #11594935 — an unverified report by a vehicle owner.
I received a letter from Kia America, Inc. extending the warranty on the high pressure fuel pump on my 2020 Kia Sedona. They claim that the fuel control valve plunger may wear unevenly and over time become stuck in the open position. They state different things can happen including stalling. My research found that it can cause stalling at high speeds or in heavy traffic and it may cause a loss of control over the vehicle. ARE THEY TRYING TO AVOID A RECALL. I am [XXX] and this sounds real dangerous. Does a serious accident have to happen before a recall is ordered? i have attached a copy of the letter below. [XXX] cell [XXX] email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11592280 — an unverified report by a vehicle owner.
The contact owns a 2019 Kia Sedona. The contact stated while driving, he became aware of a strong and unpleasant fuel odor that made him and his granddaughter sick. The contact stated that the check engine warning light flashed on and off several times. The vehicle was taken on several occasions to a local dealer where it was diagnosed with a fuel leak and several parts related to the fuel leak failure were replaced; however, the failure persisted. The contact stated the failure had been for a year and the dealer had not been able to repair the vehicle properly. The vehicle was also inspected by an independent mechanic who confirmed the failure and stated that the exhaust was very hot which could cause a fire. The vehicle remained at the dealer unrepaired. The vehicle was no longer under warranty. The manufacturer was made aware of the failure; however, no assistance was provided. The failure mileage was approximately 30,000.
NHTSA complaint #11590999 — an unverified report by a vehicle owner.
The contact owns a 2019 Kia Sedona. The contact stated that while operating the vehicle, there was a strong fuel odor inside the cabin of the vehicle. The check engine warning light had remained illuminated. The vehicle was taken to the local dealer who diagnosed the vehicle and determined that the high-pressure fuel regulator was faulty and needed to be replaced. The high-pressure fuel regulator was replaced but the failure persisted. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 39,000.
NHTSA complaint #11584547 — an unverified report by a vehicle owner.
First, the fuel pump was acting up was told the relay was going bad replaced the relay, Than we have "ESC" and ABS light come one for a bout a week took it to get the code read and they said all four wheel sensors (abs) were not transmitting signals ans that my steering angle sensor was bad which I dont think it is equipped with one now today as of 1/6/2024 ESC, ABS and BRAKE all light up and solid at the same time and tI lost my brakes. no we had no inspections we had warning lights the ESC ABS & BRAKE with a warning alarm
NHTSA complaint #11563973 — an unverified report by a vehicle owner.
My Sedona keeps catching on fire not sure why but now if I get it up to temperature it automatically catches on fire I'm going into my second fire extinguishe
NHTSA complaint #11496863 — an unverified report by a vehicle owner.
The contact owns a 2017 Kia Sedona. The contact stated that after starting the vehicle, the vehicle began to drive rough. There was white smoke coming from the exhaust and the check engine warning light was illuminated. The vehicle was taken to the local service center to be diagnosed. The contact was informed that cylinder #5 had failed. The vehicle was later taken to the local dealer who diagnosed the vehicle and determined that the fuel injector was faulty and had caused the Oxygen sensor to fail. The fuel injector, fuel rail, Oxygen sensor, and gasket were replaced, and the vehicle was fixed. The manufacturer was notified of the failure. The VIN was not available. The failure mileage was 57,000.
NHTSA complaint #11492700 — an unverified report by a vehicle owner.