2003 Ford F-350 SD problems

FUEL/PROPULSION SYSTEM

FUEL TANK DELAMINATION LEADING TO STALLING AND EVENTUAL REPLACEMENT OF THE TANK AT MY COST

NHTSA complaint #11166045 — an unverified report by a vehicle owner.

POWER TRAIN

WHILE PREPARING FOR A CAMPING TRIP THIS PASS SUMMER, I WENT TO CHECK THE OIL LEVEL. WHEN I WENT TO REMOVE THE OIL DIPSTICK, THE DIPSTICK TUBE BROKE, DUE TO CORROSION. THIS IS THE FIRST TIME IN MY 25 YEARS OF OWNING A VEHICLE FOR THAT TO HAPPEN. IT WOULD BE ALRIGHT, BUT IN ORDER TO REPLACE THE TUBE, IT IS REQUIRED TO REMOVE THE EXHAUST MANIFOLD TO PROPERLY REPLACE IT. IN TURN IT COST MORE MONEY TO REPLACE A PRODUCT THAT SHOULD NOT BREAK. I WAS FUELING MY TRUCK AND WANTED TO CHECK ALL MY FLUIDS.

NHTSA complaint #11141798 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

WHILE PREPARING FOR A CAMPING TRIP THIS PASS SUMMER, I WENT TO CHECK THE OIL LEVEL. WHEN I WENT TO REMOVE THE OIL DIPSTICK, THE DIPSTICK TUBE BROKE, DUE TO CORROSION. THIS IS THE FIRST TIME IN MY 25 YEARS OF OWNING A VEHICLE FOR THAT TO HAPPEN. IT WOULD BE ALRIGHT, BUT IN ORDER TO REPLACE THE TUBE, IT IS REQUIRED TO REMOVE THE EXHAUST MANIFOLD TO PROPERLY REPLACE IT. IN TURN IT COST MORE MONEY TO REPLACE A PRODUCT THAT SHOULD NOT BREAK. I WAS FUELING MY TRUCK AND WANTED TO CHECK ALL MY FLUIDS.

NHTSA complaint #11141798 — an unverified report by a vehicle owner.

ENGINE

WHILE PREPARING FOR A CAMPING TRIP THIS PASS SUMMER, I WENT TO CHECK THE OIL LEVEL. WHEN I WENT TO REMOVE THE OIL DIPSTICK, THE DIPSTICK TUBE BROKE, DUE TO CORROSION. THIS IS THE FIRST TIME IN MY 25 YEARS OF OWNING A VEHICLE FOR THAT TO HAPPEN. IT WOULD BE ALRIGHT, BUT IN ORDER TO REPLACE THE TUBE, IT IS REQUIRED TO REMOVE THE EXHAUST MANIFOLD TO PROPERLY REPLACE IT. IN TURN IT COST MORE MONEY TO REPLACE A PRODUCT THAT SHOULD NOT BREAK. I WAS FUELING MY TRUCK AND WANTED TO CHECK ALL MY FLUIDS.

NHTSA complaint #11141798 — an unverified report by a vehicle owner.

WHEELS

I PURCHASED LT265/75/16 BF GOODRICH RUGGED TERRAIN T/A TIRES FOR MY TRUCK EXACTLY 5 YEARS AND JUST OVER 21K MILES LATER I HAD 2 SEPARATE TIRE FAILURES LESS THAN A FEW HUNDRED MILES APART. FIRST TIRE A BELT SLIPPED. HAD A GIANT BULGE IN THE TREAD. I PUT MY SPARE ON AND INSPECTED THE OTHER TIRES. ALL OK. NO CRACKS NO DRY ROT. I HAVE PICS. TIRE PRESSURE SET EQUALLY AT 78 PSI. I WAS AWAY CAMPING AND PULLING A 9000 LB TRAILER. LOCAL TIRE STORE DIDN'T HAVE A REPLACEMENT SO I HEADED HOME FIGURED I WOULD REPLACE IT WITH ANOTHER MATCHING TIRE AT HOME. ABOUT 100 MILES LATER WE HAD A SECOND TIRE FAIL. THIS ONE BLEW OUT AT HIGHWAY SPEED, CAUSING A LOT OF DAMAGE TO THE TRUCK AND LEFT ME STRANDED WITH NO SPARE. AFTER DOING SO RESEARCH AND READING BFG RECALLS FOR TIRES SIMILAR TO THIS ONE BUT DIFFERENT SIZES, I AM LEFT TO WONDER IF ALL OF THESE SIZES SHOULD HAVE BEEN INCLUDED IN THE RECALL. THE RECALL TIRES FAILED IN THE SAME MANNER AS MINE THAT WAS NOT INCLUDED ONLY BECAUSE OF THE SIZE AND I WAS NEVER NOTIFIED. I HAD MY WIFE AND 3 KIDS IN THE TRUCK AND IT WAS A DANGEROUS SITUATION. THE TIRE BLEW OUT ON THE PA TURNPIKE. 65 MPH WHILE TOWING A HEAVY TRAILER. SUNNY. 85* DAY. THE BULGED TIRE HAPPENED A LOW SPEED. 25 MPH ON BACK ROADS. ALL OF THESE TIRES SHOULD HAVE BEEN INCLUDED IN THE RECALL IT IS DANGEROUS TO HAVE THEM ON THE ROAD.

NHTSA complaint #11005857 — an unverified report by a vehicle owner.

TIRES

TIRE FAILURE. DESTROYED MY OUTER FENDER ON 2003 F350 DUALLY DAMAGED INCLUDED, OUTER FENDER, INNER FENDER, DAMAGE TO THE BED OF THE TRUCK, AND DAMAGE TO THE SUPPORT BRACKETS. BOUGHT THIS TRUCK USED ABOUT A MONTH AGO. NOT SURE WHEN THE TIRES WERE PURCHASED. MILEAGE ON TIRES IS AN ASSUMPTION

NHTSA complaint #10874730 — an unverified report by a vehicle owner.

ENGINE

I CALLED FORD MOTOR COMPANY ON MY 2003 FORD F350 SD. SC. 4X4 5.4 ENG. WITH THE PROBLEM WITH BOTH EXHAUST MANIFOLDS ROTTING AWAY & THE STUDS & NUTS ROTTING , THEY TOLD ME WE WON'T FIX THE PROBLEM FOR FREE . I WOULD LIKE FOR YOUR HELP TO MAKE FORD MOTOR COMPANY FIX THIS PROBLEMS FOR FREE BECAUSE I TALKED TO MANY FORD DEALERS THEY ARE REPLACING THIS SAME PROBLEMS ON ALL 5.4 ENG. ON FORD TRUCKS AND HAVE TO CHARGE FOR THESE PROBLEMS . PLEASE INVESTAGATE THIS PROBLEMS BEFORE ALL THESE TRUCKS WILL CATCH ON FIRE AND PEOPLE WILL BE INJURY OR FATALITY WILL HAPPEN . PLEASE HELP ME AND MANY PEOPLE CAN GET THESE PROBLEMS FIX FOR FREE FROM FORD MOTOR COMPANY THANKS.

NHTSA complaint #10598413 — an unverified report by a vehicle owner.

WHEELS

BOUGHT TRUCK IN 2009 . ABS LIGHT IS ON WANTED TO FIND OUT IF THERE WAS A RECALL ON HUBS AND IF SO WOULD LIKE TO FIND OUT IF TRUCK WAS SERVICED , AND IF NOT HOW WOULD I PROCEED TO DO RECALL . THANK YOU

NHTSA complaint #10512230 — an unverified report by a vehicle owner.

ENGINE

VEHICLE WAS ACCELERATING ONTO ON-RAMP TO INTERSTATE 90 WEST BOUND AT PINES ROAD IN SPOKANE VALLEY WA. VEHICLE WAS DRIVEN BY MY WIFE. AT APPROXIMATELY 30 MPH THEIR WAS A LOUD BANG AND NOISE THAT SOUNDED LIKE AN EXHAUST LEAK. VEHICLE WAS DRIVEN TO THE SHOULDER AND SHUT OFF. MY WIFE CALLED ME AND I CAME TO INVESTIGATE WHAT HAD HAPPENED. I TURNED THE ENGINE OVER AND DETERMINED IT WAS NOT AN EXHAUST LEAK BUT THAT A SPARK PLUG HAD BEEN BLOWN OUT OF THE RIGHT SIDE OF THE ENGINE. IT WAS THE NUMBER 4 SPARK PLUG FROM THE FRONT ON MY V-10 GAS ENGINE. I LOCATED THE BENT SPARK PLUG AT THE APPROXIMATE LOCATION OF WHERE THE INCIDENT OCCURRED. OTHER THAN BEING BENT THE THREADS ON THE PLUG WERE INTACT AND DID NOT APPEAR TO HAVE BEEN CROSS THREADED. I HAD THE PLUGS REPLACED AT JUST OVER 100,000 MILES AS PER THE OWNERS MANUAL. I CHECKED WITH THE AUTO REPAIR SHOP I USED, (AAFES AUTO HOBBY SHOP ON FAIRCHILD AFB), AND INFORMED THEM OF WHAT HAD OCCURRED. THEY INFORMED ME THAT FORD HAD A TECHNICAL SERVICE BULLETIN ON THIS VERY SUBJECT. THIS APPEARS TO BE A MANUFACTURING DEFECT IN THAT REPLACING SPARK PLUGS SHOULD NOT LEAD TO AN EXPLOSIVE EVENT STRONG ENOUGH TO DENT MY HOOD FROM THE INSIDE. I AM NOW EXPECTING TO HAVE 9 MORE LITTLE TIME BOMBS JUST WAITING TO GO OFF UNDER THE HOOD OF MY TRUCK. I AM JUST THANKFUL THAT MY WIFE HADN'T YET GOTTEN UP TO THE SPEED LIMIT OF 60MPH.

NHTSA complaint #10488604 — an unverified report by a vehicle owner.

FUEL/PROPULSION SYSTEM

VEHICLE WAS ACCELERATING ONTO ON-RAMP TO INTERSTATE 90 WEST BOUND AT PINES ROAD IN SPOKANE VALLEY WA. VEHICLE WAS DRIVEN BY MY WIFE. AT APPROXIMATELY 30 MPH THEIR WAS A LOUD BANG AND NOISE THAT SOUNDED LIKE AN EXHAUST LEAK. VEHICLE WAS DRIVEN TO THE SHOULDER AND SHUT OFF. MY WIFE CALLED ME AND I CAME TO INVESTIGATE WHAT HAD HAPPENED. I TURNED THE ENGINE OVER AND DETERMINED IT WAS NOT AN EXHAUST LEAK BUT THAT A SPARK PLUG HAD BEEN BLOWN OUT OF THE RIGHT SIDE OF THE ENGINE. IT WAS THE NUMBER 4 SPARK PLUG FROM THE FRONT ON MY V-10 GAS ENGINE. I LOCATED THE BENT SPARK PLUG AT THE APPROXIMATE LOCATION OF WHERE THE INCIDENT OCCURRED. OTHER THAN BEING BENT THE THREADS ON THE PLUG WERE INTACT AND DID NOT APPEAR TO HAVE BEEN CROSS THREADED. I HAD THE PLUGS REPLACED AT JUST OVER 100,000 MILES AS PER THE OWNERS MANUAL. I CHECKED WITH THE AUTO REPAIR SHOP I USED, (AAFES AUTO HOBBY SHOP ON FAIRCHILD AFB), AND INFORMED THEM OF WHAT HAD OCCURRED. THEY INFORMED ME THAT FORD HAD A TECHNICAL SERVICE BULLETIN ON THIS VERY SUBJECT. THIS APPEARS TO BE A MANUFACTURING DEFECT IN THAT REPLACING SPARK PLUGS SHOULD NOT LEAD TO AN EXPLOSIVE EVENT STRONG ENOUGH TO DENT MY HOOD FROM THE INSIDE. I AM NOW EXPECTING TO HAVE 9 MORE LITTLE TIME BOMBS JUST WAITING TO GO OFF UNDER THE HOOD OF MY TRUCK. I AM JUST THANKFUL THAT MY WIFE HADN'T YET GOTTEN UP TO THE SPEED LIMIT OF 60MPH.

NHTSA complaint #10488604 — an unverified report by a vehicle owner.

WHEELS

MY WIFE AND I WERE TAKING OUR SON BACK TO COLLEGE. THERE WAS A NOISE COMING FROM THE FRONT RIGHT TIRE THAT SOUNDED LIKE THE WARNING FOR YOUR BRAKE PADS, EXCEPT WHEN I APPLIED THE BRAKES IT DIDN'T STOP. SOUNDED LIKE MY BRAKE ROTOR WAS GRINDING. THE NEXT DAY I TOOK MY VEHICLE TO MY MECHANIC TO HAVE MY BRAKES AND ROTORS CHECKED. THEY WERE FINE, BUT I WAS SURPRISED WHEN MY MECHANIC TOLD ME IT WASN'T MY BRAKES BUT INSTEAD IT WAS MY ALUMINUM ALLOY RIM (FACTORY RIMS) HAD CRACKED ALL THE WAY THROUGH ONE OF THE SPOKES ON THE RIM AND HAD STARTED CRACKING ABOUT AN 1 1/2" THROUGH ANOTHER! I TOLD MY MECHANIC THAT I HAD NEVER HAD THIS HAPPEN BEFORE IN MY LIFE. MY MECHANIC REPLIED THAT HE HAD SEEN THIS SAME THING ON 5 OR 6 OF THE SUPER DUTY'S. SO, I BROWSED THE INTERNET TO SEE IF ANYONE ELSE HAD EXPERIENCED THE SAME PROBLEM. COME TO FIND OUT THAT THERE ARE HUNDREDS OF PEOPLE THAT HAVE HAD THE EXACT PROBLEM NOT ONLY WITH THE ALUMINUM ALLOY RIMS BUT THE STEEL RIMS AS WELL AND NOT SPECIFIC TO ANY YEAR. FROM FLORIDA TO CALIFORNIA ALL OVER THE U.S. INFORMED FORD CUSTOMER RELATIONS OF MY FINDINGS AND THERE RESPONSE WAS TO HOLD ON TO MY RECEIPT IN CASE THERE IS A CUSTOMER SATISFACTION PROGRAM (CSP) OR A RECALL EVER PUT IN PLACE.

NHTSA complaint #10482186 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

TL* THE CONTACT OWNS A 2003 FORD F-350 SD. WHILE PARKED, THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT BOTH REAR BRAKE LIGHTS WERE INOPERABLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V352000 (EXTERIOR LIGHTING:BRAKE LIGHTS) AND CONTACTED THE MANUFACTURER. THE MANUFACTURER INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 165,000.

NHTSA complaint #10476656 — an unverified report by a vehicle owner.

TIRES

TL* THE CONTACT OWNS A 2003 FORD F-350 SD EQUIPPED WITH BF GOODRICH COMMERCIAL T/A A/S TIRES, SIZE: 235/85/16. WHILE DRIVING APPROXIMATELY 65 MPH, THE REAR TIRE EXPLODED AND CAUSED REAR END DAMAGE TO THE VEHICLE. THE CONTACT WAS ABLE TO MANEUVER THE VEHICLE TO THE SIDE OF THE ROAD WHERE THE REAR PASSENGER SIDE TIRE WAS REPLACED WITH A SPARE. THE VEHICLE WAS TAKEN TO A TIRE CENTER WHERE A WHERE A NEW TIRE WAS MOUNTED ONTO THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THERE WAS A RECALL ASSOCIATED WITH THE TIRE UNDER NHTSA CAMPAIGN ID NUMBER 12T019000 (TIRES:TREAD/BELT) HOWEVER, THE CONTACT'S TIRE WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 82,000. THE DOT NUMBER AND VIN WERE UNAVAILABLE.

NHTSA complaint #10476647 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

I WAS HAULING A LOADED HORSE TRAILER AND HAD JUST MERGED ONTO THE HIGHWAY. AS I WAS TRYING TO ACCELERATE, THE ENGINE WAS "CATCHING" AND WOULDN'T LET ME ACCELERATE PAST 35 MPH AND WAS REVVING VERY HIGH AND WOULDN'T SHIFT UP INTO THE NEXT GEAR. IT FINALLY STALLED AND COMPLETELY SHUT OFF IN THE MIDDLE OF TRAFFIC AND I HAD TO COAST TO THE SIDE OF THE ROAD WHERE WHITE SMOKE STARTED POURING OUT FROM UNDER THE HOOD. MY ENTIRE RIG - TRUCK, TRAILER AND HORSES, HAD TO BE TOWED HOME AND THEN THE TRUCK TOWED TO THE MECHANIC. HE FOUND THE ENGINE RUNNING POORLY, AND FOUND LOW COMPRESSION ON CYLINDERS #3 AND #8. HE FOUND LOW OIL PRESSURE AND WHEN HE REMOVED THE OIL PAN FROM THE CHASSIS, HE FOUND PISTON MATERIAL IN THE OIL PUMP. HE REMOVED THE ENGINE AND FOUND THE PISTONS IN CYLINDER 3 AND 8 MELTED DOWN. HE HAD TO BORE OUT AND HONE ALL THE CYLINDERS, REPLACE ALL 4 VALVES IN CYLINDER #3 HEAD, REPLACE ALL PISTONS, REPLACE THE MAIN BEARING AND ROD BEARING, UPDATE THE OIL COOLER AND REPLACE 8 PISTONS AND 6 HEAD GASKETS. WHEN HE PUT IT ALL BACK TOGETHER AND TEST DROVE IT, HE FOUND AN EXHAUST LEAK FROM THE EBP SENSOR AND TUBE. THOSE HAD TO BE REPLACED. BEFORE ALL THIS HAPPENED, I HAD NOTICED THAT THE ENGINE SEEMED TO BE "SKIPPING" WHEN I WAS HAULING MY HORSE TRAILER. IT ONLY HAPPENED WHEN I WAS OVER 55 MPH AND IT ONLY HAPPENED WHEN I WAS HAULING. I HAD TAKEN THE TRUCK TO THE MECHANIC BEFORE THE BIG BREAKDOWN (DESCRIBED ABOVE) AND HE COULDN'T FIND ANYTHING WRONG. I THINK THAT IS BECAUSE HE WAS NOT HAULING A TRAILER AND THAT'S THE ONLY TIME THE PROBLEM OCCURRED. THE TOTAL BILL FOR ALL THESE REPAIRS IS $6400.00 AND I HAVE BEEN TOLD THAT FORD WILL DO NOTHING TO HELP ME.

NHTSA complaint #10461939 — an unverified report by a vehicle owner.

TIRES

PURCHASED 4 LT CONTINENTAL CONITRAC 275/70R18 TIRES/FORD OEM WHEELS FROM BARNEY'S TIRE AND WHEEL IN TEMECULA, CA FOR MY 2003 F350 FORD TRUCK. THESE TIRE AND WHEELS WERE IN NEW CONDITION. JUNE 2, 2011 I HAD DINSAUR TIRE LOCATED IN CALIMESA CA REPLACE THE LEFT FRONT TIRE DUE TO TIRE SEPARATION. NEITHER I OR DINOSAUR TIRE WERE AWARE OF THE CONTINENTAL TIRE RECALL. MARCH 22, I HAD THE LEFT REAR TIRE SEPARATE AND AGAIN CONTACTED DINOSAUR TIRE TO SCHEDULE A REPLACEMENT. AGAIN, THEY WERE UNAWARE OF THE RECALL. THINKING TWO TIRE SEPARATIONS WERE ODD, I PERFORMED A SEARCH ON THE WEB FOR PROBLEMS RELATED TO THESE TIRES AND DISCOVERED CONTINENTAL HAD RECALLED CERTAIN TIRES. EMAILED CONTINENTAL THE DOT NUMBERS OF THE TIRES AND THEY CONFIRMED WITH A EMAIL THESE WERE TIRES SUBJECT TO THE RECALL AND I WAS DIRECTED TO CONTACT AN AUTHORIZED DEALER. CONTACTED DINOSAUR TIRE (AUTHORIZED DEALER) AND FAXED ALL CORRESPONDENCE TO THEM. THEY WERE STILL UNAWARE OF THE RECALL AND DID NOT KNOW THE PROCESS TO FILE A CLAIM. DINOSAUR TIRE CALLED CONTINENTAL WITH ME IN THEIR COMPANY TO GET AN AUTHORIZATION. UNFORTUNATELY AND WRONGFULLY, CONTINENTAL WILL ONLY PRORATE THE REMAINING THREE TIRES BECAUSE THERE WAS A COMPLIANCE DATE OF OCTOBER 15, 2011 AND STATED ALL PERSONS WHO PURCHASED THE TIRES WERE CONTACTED. HAD THE AUTHORIZED DEALER DINOSAUR TIRE BEEN MADE AWARE OF THE RECALLED TIRES LAST JUNE, I COULD OF REPLACED THE 4 TIRES WITHOUT ANY FEES AND FREE OF CHARGE. HOWEVER, BECAUSE CONTINENTAL FAILED TO COMMUNICATE THIS TO THE PUBLIC AND AUTHORIZED CONTINENTAL DEALERSHIPS, DEMONSTRATES A LACK TO TAKE FULL RESPONSIBILITY TO THE PUBLIC FOR TIRES THE PUBLIC ACCIDENTALLY CAME IN POSSESSION OF, AND SOLD BY UNAWARE TIRE COMPANIES. CONTINENTAL WOULD NOT PROVIDE ANY REIMBURSEMENT FOR THE TIRE REPLACED LAST JUNE, 2011. AGAIN - FAILURE TO COMMUNICATE THE RECALL TO THE PUBLIC DEMONSTRATES A LACK OF RESPONSIBILITY.

NHTSA complaint #10452913 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

TL* THE CONTACT OWNS A 2003 FORD F-350 SD DIESEL. THE CONTACT STATED THE VEHICLE EXPERIENCED A BLOWN HEAD GASKET. THE DEALER REPLACED THE MOTOR BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 25,000 AND THE CURRENT MILEAGE WAS 150,000. ..UPDATED 11/28/12 *BF THE CONSUMER STATED WHEN THE HEADS CRACKED IT PUSHED WATER IN THE FUEL AND DESTROYED THE FUEL PUMP, INJECTORS, AND TURBO. UPDATED 11/29/12

NHTSA complaint #10452402 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING

DURING HIGH SPEED HIGHWAY DRIVING THE TURN SIGNAL BECAME STUCK IN RIGHT HAND TURN POSITION. AFTER CLICKING THE SIGNAL LEVER FROM LEFT, CENTER, AND RIGHT HAND TURN POSITIONS THE RIGHT HAND TURN SIGNAL REMAINED ON IN ALL POSITIONS. I HAVE BEEN DRIVING FOR 6 DAYS NOW WITH THE FOUR WAY HAZARDS ON. I FOUND ONLINE THERE WAS A SAFETY RECALL ON THE MULTI FUNCTION TURN SWITCH, BUT WHEN I TOOK VEHICLE TO THE DEALER THEY TURNED ME AWAY AND SAID THERE WAS NO RECALL. THEN I CALLED FORD CUSTOMER RELATIONSHIP CENTER AND THEY SAID THERE WAS NO RECALL EITHER AND ALSO SAID THAT EVEN THOUGH MY TRUCK WAS WITHIN THE YEARS AND MODELS STATED THAT THE VIN # WAS NOT WITHIN THE RECALL. HOW COULD THAT BE? IS A FORD F-350 SD 2003 DIFFERENT FROM ANOTHER FORD F-350 SD 2003. I STILL HAVE THE PROBLEM DESCRIBED IN THE RECALL. SAFETY HAZARD INDEED.

NHTSA complaint #10425609 — an unverified report by a vehicle owner.

EXTERIOR LIGHTING:TURN SIGNAL:SWITCH

DURING HIGH SPEED HIGHWAY DRIVING THE TURN SIGNAL BECAME STUCK IN RIGHT HAND TURN POSITION. AFTER CLICKING THE SIGNAL LEVER FROM LEFT, CENTER, AND RIGHT HAND TURN POSITIONS THE RIGHT HAND TURN SIGNAL REMAINED ON IN ALL POSITIONS. I HAVE BEEN DRIVING FOR 6 DAYS NOW WITH THE FOUR WAY HAZARDS ON. I FOUND ONLINE THERE WAS A SAFETY RECALL ON THE MULTI FUNCTION TURN SWITCH, BUT WHEN I TOOK VEHICLE TO THE DEALER THEY TURNED ME AWAY AND SAID THERE WAS NO RECALL. THEN I CALLED FORD CUSTOMER RELATIONSHIP CENTER AND THEY SAID THERE WAS NO RECALL EITHER AND ALSO SAID THAT EVEN THOUGH MY TRUCK WAS WITHIN THE YEARS AND MODELS STATED THAT THE VIN # WAS NOT WITHIN THE RECALL. HOW COULD THAT BE? IS A FORD F-350 SD 2003 DIFFERENT FROM ANOTHER FORD F-350 SD 2003. I STILL HAVE THE PROBLEM DESCRIBED IN THE RECALL. SAFETY HAZARD INDEED.

NHTSA complaint #10425609 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

TL* THE CONTACT OWNS A 2003 FORD F-350 SD. THE CONTACT STATED THAT THE VEHICLE WOULD STALL SPORADICALLY WITHOUT WARNING. IN ADDITION, THE VEHICLE WOULD HESITATE WHEN ATTEMPTING TO START. THE DEALER DIAGNOSED THAT THE INJECTION CONTROL PRESSURE MODULE WOULD NEED REPLACING. THE MANUFACTURER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM:WIRING) RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 60,200.

NHTSA complaint #10418180 — an unverified report by a vehicle owner.

FUEL SYSTEM, DIESEL

I HAD SEVERAL BREAKDOWNS WITH MY TRUCK AND HAD TO HAVE IT TOWED TWICE. THE FIRST PLACE IT WAS TOWED TO COULD NOT FIND THE PROBLEM THEN AFTER SEVERAL MORE INSTANCES I HAD IT TOWED TO THE DEALERSHIP WHERE I PURCHASED THE VEHICLE AND THEY NEW THE PROBLEM RIGHT AWAY. THE FUEL TANK DELAMINATED AND I WAITED TWO MONTHS FOR ONE BECAUSE THEY WERE IN PRODUCTION AT A COST OF $2000.00 TO BE REPAIRED. THIS SEEMS TO BE A WIDE SPREAD PROBLEM WITH THESE TRUCKS AND IT SHOULD BE WARRANTIED.

NHTSA complaint #10415201 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION:GEAR POSITION INDICATION (PRNDL)

TL* THE CONTACT OWNS A 2003 FORD F-350 SD. THE CONTACT WOULD SHIFT THE VEHICLE INTO PARK, BUT INSTEAD THE VEHICLE WOULD SHIFT INTO REVERSE. THE CONTACT STATED THAT THE GEAR SHIFT WOULD READ PROPERLY, BUT PERFORM IN INACCURATELY. THE MANUFACTURER NOR DEALER WERE NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000.

NHTSA complaint #10408561 — an unverified report by a vehicle owner.

STRUCTURE:FRAME AND MEMBERS

TL* THE CONTACT OWNS A 2003 FORD F250. THE CONTACT NOTICED THAT THE FRAME UNDERNEATH THE VEHICLE WAS COVERED WITH RUST. HE ALSO NOTICED THAT THE RUST WAS AFFECTING THE DRIVERS SIDE DOOR PANEL. THE DEALER DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE MANUFACTURER ALSO OFFERED NO ASSISTANCE. THE CURRENT MILEAGES WERE 65,000 AND THE FAILURE MILEAGES WERE 50,000. UPDATED 5/24/11 *CN UPDATED 06/10/11

NHTSA complaint #10398563 — an unverified report by a vehicle owner.

SUSPENSION:FRONT

MY 2003 F350 HAS ALL OF THE DEATH WOBBLE ISSUES, DRIVING AT 55 OR 70 ON THE HIGHWAY THE FRONT END WILL JUST GO INTO A CRAZY WOBBLE IN WHICH I HAVE TO SLOW DOWN TO TRY AND FIX. SOMETIMES WHEN I USE THE BRAKE PEDAL IT WILL ALSO GO INTO THE SAME EVENT. I'VE READ ALL THESE ISSUES ON THE NET AND CANNOT UNDERSTAND THAT IF ITS SUCH A HUGE PROBLEM WHY IS IT NOT BEING ADDRESSED. WILL IT TAKE ONE OF THESE VEHICLES KILLING A FAMILY MEMBER OF THE PEOPLE AT FORD TO GET THIS UNDER CONTROL OR MAYBE THEY JUST DON'T CARE AS LONG AS THEY ARE MAKING MONEY. TO THE FAMILY MEMBERS OF THE FORD PEOPLE AND EVERYONE ELSE I PRAY FOR YOU. I DO NOT KNOW WHAT TO DO FOR MY TRUCK TO FIX IT.

NHTSA complaint #10396559 — an unverified report by a vehicle owner.