Owners have filed 58 complaints
about the 2023 Ford F-350 SD with NHTSA between 2023 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 18 of 28 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 16
Against the median year of the Ford F-350 SD. 50 means typical for this
model; 100 means roughly double.
Severity — 53
10.3% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
73% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
654.5%
10,000 – 24,999 miles
218.2%
50,000 – 74,999 miles
19.1%
150,000+ miles
218.2%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
May 2023peak 8Aug 2026
Recalls on the 2023 Ford F-350 SD
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
26V204000
VISIBILITY:WINDSHIELD WIPER/WASHER:LINKAGES
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Risk: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
26V104000
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Risk: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
25V455000
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Risk: An engine stall increases the risk of a crash.
25V315000
BACK OVER PREVENTION:SOFTWARE
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Risk: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
25V157000
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Ford Motor Company (Ford) is recalling certain 2023 Super Duty F-250 and F-350 vehicles previously repaired incorrectly under recall number 23V-507. The driver and front passenger windows may fail to detect an obstacle while closing and not reverse direction as intended.
Risk: A window that does not automatically reverse when an obstruction is encountered increases the risk of injury.
25V134000
BACK OVER PREVENTION:SOFTWARE
Ford Motor Company (Ford) is recalling certain 2023 F-Super Duty F-250, F-350, and F-450 vehicles previously repaired incorrectly under recall number 23V-573. The default rearview camera image may not be displayed when using the Pro Trailer Hitch Assist feature.
Risk: An incorrect rearview camera image can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash or injury.
24V806000
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2023-2024 F-250, F-350, and F-450 vehicles. Water may enter the Tailgate Park Assist Sensor Interface Module (TPASIM) and cause the rearview camera image to display intermittently or appear blue or black.
Risk: A rearview camera image that does not display can decrease the driver's visibility, increasing the risk of injury or crash.
23V847000
STEERING:COLUMN
Ford Motor Company (Ford) is recalling certain 2023 F-150 and Ford SD F250, F350, F450, F550, and F600 vehicles. The steering wheel clock spring may have an insufficient weld, causing a loss of electrical connection to the driver's frontal air bag.
Risk: A deactivated air bag will not deploy during a crash, increasing the risk of injury.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 1,000 milesDanville, ILCrash2 injured
SERVICE BRAKES, HYDRAULIC
The contact owns a 2023 Ford F-350 SD. The contact stated that the adaptive cruise control mode was inoperable. Additionally, the contact stated that while driving 50-55 MPH to the dealer, the contact noticed that the vehicle in front of the vehicle had stopped abruptly with no brake lights activated. The contact stated that upon depressing the brake pedal, the vehicle failed to respond. The contact attempted to veer to the left to avoid the other vehicle, but the passenger's side front end crashed into the rear of the other vehicle. There was no warning light illuminated. The contact stated that the six air bags of the vehicle deployed, and there was blinding smoke in the vehicle. The contact was transported to the hospital by ambulance and was hospitalized for 7 days. The contact was then transferred to a rehabilitation facility, where he was currently receiving care. The contact sustained a broken right hand and toe. The contact also sustained breathing complications as the contact's underlying cardiac and pulmonary health issues were triggered. The other driver sustained unknown injuries and was transported to the hospital by ambulance. Both vehicles sustained significant damage and could not be driven away from the scene. The contact's vehicle sustained front-end fender and hood damage and other unknown damage. The vehicle was towed to the collision repair shop for an estimate of the damage. A police report was filed. The dealer was notified of the brake failure and informed the contact that the VIN was not included in a related recall. The manufacturer was not notified of the failure. The failure mileage was 1,000.
NHTSA complaint #11689223 — an unverified report by a vehicle owner.
at 1,000 milesDanville, ILCrash2 injured
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The contact owns a 2023 Ford F-350 SD. The contact stated that the adaptive cruise control mode was inoperable. Additionally, the contact stated that while driving 50-55 MPH to the dealer, the contact noticed that the vehicle in front of the vehicle had stopped abruptly with no brake lights activated. The contact stated that upon depressing the brake pedal, the vehicle failed to respond. The contact attempted to veer to the left to avoid the other vehicle, but the passenger's side front end crashed into the rear of the other vehicle. There was no warning light illuminated. The contact stated that the six air bags of the vehicle deployed, and there was blinding smoke in the vehicle. The contact was transported to the hospital by ambulance and was hospitalized for 7 days. The contact was then transferred to a rehabilitation facility, where he was currently receiving care. The contact sustained a broken right hand and toe. The contact also sustained breathing complications as the contact's underlying cardiac and pulmonary health issues were triggered. The other driver sustained unknown injuries and was transported to the hospital by ambulance. Both vehicles sustained significant damage and could not be driven away from the scene. The contact's vehicle sustained front-end fender and hood damage and other unknown damage. The vehicle was towed to the collision repair shop for an estimate of the damage. A police report was filed. The dealer was notified of the brake failure and informed the contact that the VIN was not included in a related recall. The manufacturer was not notified of the failure. The failure mileage was 1,000.
NHTSA complaint #11689223 — an unverified report by a vehicle owner.
Joliet, ILCrash
WHEELS
See attached document for complaint.
NHTSA complaint #11651674 — an unverified report by a vehicle owner.
Joliet, ILCrash
TIRES
See attached document for complaint.
NHTSA complaint #11651674 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Santa Rosa Beach, FL
FORWARD COLLISION AVOIDANCE
See attached document for complaint.
NHTSA complaint #11758549 — an unverified report by a vehicle owner.
NHTSA complaint #11758549 — an unverified report by a vehicle owner.
Bloomville, OH
POWER TRAIN
Vehicle randomly hesitates to shift (slip/flare), usually from 3-4 or 8-9 gears. It is sometimes accompanied by a clunk/slam before/after engaging the higher numbered gear. It seems to happen more often when the transmission is at/approaching normal operating temperature. The slip/flare has been becoming more frequent and is now randomly accompanied by the clunk/slam. I first noticed the slip/flare changing from gears 3-4. At that time the vehicle had 43,000mi on it.
NHTSA complaint #11756450 — an unverified report by a vehicle owner.
Mcalester, OK
STEERING
I am hearing and feeling snaps coming from my vehicle steering. It feels like the steering column is not functioning correctly. I can feel the truck getting more sloppy turning and traveling differently than it did at 35,000 miles. Ford wants to charge me $185 to investigate and then they may take action. There is a recall on this problem, but my truck’s vin isn’t listed. I’m worried that it may come apart or cause an accident.
NHTSA complaint #11754345 — an unverified report by a vehicle owner.
Millbrook, AL
STRUCTURE:BODY
Overhead clearance lights leaking water when it rains.
NHTSA complaint #11735508 — an unverified report by a vehicle owner.
Laredo, TX
ELECTRICAL SYSTEM
All cameras went out on the F350 with a blue screen there’s a recall on this but my truck is not included and needs to be expanded.
NHTSA complaint #11725098 — an unverified report by a vehicle owner.
Laredo, TX
VISIBILITY/WIPER
All cameras went out on the F350 with a blue screen there’s a recall on this but my truck is not included and needs to be expanded.
NHTSA complaint #11725098 — an unverified report by a vehicle owner.
Louisville, KY
STRUCTURE
The contact owns a 2023 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V806000 (Back Over Prevention, Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
NHTSA complaint #11697750 — an unverified report by a vehicle owner.
Louisville, KY
BACK OVER PREVENTION
The contact owns a 2023 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V806000 (Back Over Prevention, Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
NHTSA complaint #11697750 — an unverified report by a vehicle owner.
at 1,000 milesDanville, ILCrash2 injured
SERVICE BRAKES, HYDRAULIC
The contact owns a 2023 Ford F-350 SD. The contact stated that the adaptive cruise control mode was inoperable. Additionally, the contact stated that while driving 50-55 MPH to the dealer, the contact noticed that the vehicle in front of the vehicle had stopped abruptly with no brake lights activated. The contact stated that upon depressing the brake pedal, the vehicle failed to respond. The contact attempted to veer to the left to avoid the other vehicle, but the passenger's side front end crashed into the rear of the other vehicle. There was no warning light illuminated. The contact stated that the six air bags of the vehicle deployed, and there was blinding smoke in the vehicle. The contact was transported to the hospital by ambulance and was hospitalized for 7 days. The contact was then transferred to a rehabilitation facility, where he was currently receiving care. The contact sustained a broken right hand and toe. The contact also sustained breathing complications as the contact's underlying cardiac and pulmonary health issues were triggered. The other driver sustained unknown injuries and was transported to the hospital by ambulance. Both vehicles sustained significant damage and could not be driven away from the scene. The contact's vehicle sustained front-end fender and hood damage and other unknown damage. The vehicle was towed to the collision repair shop for an estimate of the damage. A police report was filed. The dealer was notified of the brake failure and informed the contact that the VIN was not included in a related recall. The manufacturer was not notified of the failure. The failure mileage was 1,000.
NHTSA complaint #11689223 — an unverified report by a vehicle owner.
at 1,000 milesDanville, ILCrash2 injured
FORWARD COLLISION AVOIDANCE: ADAPTIVE CRUISE CONTROL
The contact owns a 2023 Ford F-350 SD. The contact stated that the adaptive cruise control mode was inoperable. Additionally, the contact stated that while driving 50-55 MPH to the dealer, the contact noticed that the vehicle in front of the vehicle had stopped abruptly with no brake lights activated. The contact stated that upon depressing the brake pedal, the vehicle failed to respond. The contact attempted to veer to the left to avoid the other vehicle, but the passenger's side front end crashed into the rear of the other vehicle. There was no warning light illuminated. The contact stated that the six air bags of the vehicle deployed, and there was blinding smoke in the vehicle. The contact was transported to the hospital by ambulance and was hospitalized for 7 days. The contact was then transferred to a rehabilitation facility, where he was currently receiving care. The contact sustained a broken right hand and toe. The contact also sustained breathing complications as the contact's underlying cardiac and pulmonary health issues were triggered. The other driver sustained unknown injuries and was transported to the hospital by ambulance. Both vehicles sustained significant damage and could not be driven away from the scene. The contact's vehicle sustained front-end fender and hood damage and other unknown damage. The vehicle was towed to the collision repair shop for an estimate of the damage. A police report was filed. The dealer was notified of the brake failure and informed the contact that the VIN was not included in a related recall. The manufacturer was not notified of the failure. The failure mileage was 1,000.
NHTSA complaint #11689223 — an unverified report by a vehicle owner.
Havre, MT
STRUCTURE:BODY
The front doors come open while driving down the road in cold weather. Multiple dealerships have to me to just deal with it. My children have to hold the doors shut while we are going down the road or I have to hold the driver's door shut while driving. There was a recall issued for certain 2023 F-350's regarding a door latch mechanism malfunction but apparently it doesn't apply to my pickup even though me doors don't stay shut while driving and multiple dealerships tell me there is nothing, they can do to fix it. When one of us gets hurt, falls off, or has a door hit by oncoming traffic, what am I supposed to do? The safety of my children does not matter to Ford motor company or their Montana dealerships. It happens regularly, not just once. Speed is not a factor, I can be driving 5 mph or 75 mph when it happens.
NHTSA complaint #11686568 — an unverified report by a vehicle owner.
at 17,000 milesCape Coral, FL
ENGINE AND ENGINE COOLING
The contact owns a 2023 Ford F-350. The contact stated while driving at an undisclosed speed, the oil change warning light illuminated. The contact stated that the vehicle received an oil change; however, the oil change warning light remained illuminated. The contact stated that occasionally the oil change warning light was illuminated whenever the vehicle was started. The vehicle was taken to the dealer several times and the sensor was reset. In addition, the contact was informed that an unknown module needed to be reprogrammed; however, the parts were not yet available. The contact stated that the failure reoccurred. The manufacturer was not made aware of the failure. The failure mileage was approximately 17,000.
NHTSA complaint #11680582 — an unverified report by a vehicle owner.
North Highlands, CA
STRUCTURE
The contact owns a 2023 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V806000 (Back Over Prevention, Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11673460 — an unverified report by a vehicle owner.
North Highlands, CA
BACK OVER PREVENTION
The contact owns a 2023 Ford F-350 SD. The contact received notification of NHTSA Campaign Number: 24V806000 (Back Over Prevention, Structure); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
NHTSA complaint #11673460 — an unverified report by a vehicle owner.
Joliet, ILCrash
WHEELS
See attached document for complaint.
NHTSA complaint #11651674 — an unverified report by a vehicle owner.
Parkland, FL
EXTERIOR LIGHTING
This is a 2023 Ford F350 XLT vehicle. The low beam headlights do not put out sufficient light and are dangerous. I visited with the Ford dealership in Sunrise, Florida called Sawgrass Ford who told me that the previous owner changed the light source out to an LED light in an effort to gain more light. We both agreed that this did not help. In my research online it appears that this problem is limited to the XLT model. Apparently the Lariat, King Ranch, etc models have different headlights. There does not appear to be a recall on these headlights. I contacted Ford directly who advised me to go to a different dealer which won't help unless these are changed out. The vehicle currently has less than 35000 miles and is still under warranty.
NHTSA complaint #11651818 — an unverified report by a vehicle owner.
Joliet, ILCrash
TIRES
See attached document for complaint.
NHTSA complaint #11651674 — an unverified report by a vehicle owner.
at 63,000 milesCushing, TX
FUEL SYSTEM, DIESEL
The contact owns a 2023 Ford F-350 SD. The contact stated while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to a dealer where it was diagnosed and determined that metal shavings were found inside the fuel system and that the fuel system needed to be replaced. The contact stated that the Insurance Company inspected the vehicle and found metal shavings inside the fuel tank. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 63,000.
NHTSA complaint #11651729 — an unverified report by a vehicle owner.
Bridgewater, NJ
FUEL/PROPULSION SYSTEM
While driving on a highway on two occasions my truck suddenly displayed low fuel pressure. I lost complete engine power. First occasion ford said was fuel control module. Second occurrence same thing was on [XXX] low fuel pressure signal and engine stopped working. Been in touch with fullerton ford in somerville where vehicle was subsequently towed to. Representative stated it is the low pressure fuel pump that is causing the intermittently loss of pressure. Almost got killed on the highway trying to get over to the shoulder with the sudden loss of engine power due to loss of fuel pressure. Vehicle still at dealer unknown if part has been replaced. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11649619 — an unverified report by a vehicle owner.
Pearland, TX
ELECTRICAL SYSTEM
Multiple electrical issues related to dashboard controls, video sensors, head unit. Controls powering down while driving, sensors throwing multiple error messages. All since 1,500 miles. Ford could not figure out what the issue was so they replaced the wiring harness. After 2 months in the shop I got my vehicle back. 2 weeks later I am getting the same error messages in the dash and has to go back into the shop for the same reason.
NHTSA complaint #11647774 — an unverified report by a vehicle owner.
Pearland, TX
FORWARD COLLISION AVOIDANCE: WARNINGS
Multiple electrical issues related to dashboard controls, video sensors, head unit. Controls powering down while driving, sensors throwing multiple error messages. All since 1,500 miles. Ford could not figure out what the issue was so they replaced the wiring harness. After 2 months in the shop I got my vehicle back. 2 weeks later I am getting the same error messages in the dash and has to go back into the shop for the same reason.
NHTSA complaint #11647774 — an unverified report by a vehicle owner.
Havre, MT
STRUCTURE:BODY
Front doors will not close and latch when it is cold outside. Multiple dealerships have told me there is nothing that they can do to fix this issue. Doors will come open while driving if they don't latch. I often have to use a ratchet strap to keep doors shut from the inside while driving in cold weather. Apparently, according to Ford, I am a stupid girl that should just live with this issue and wait for my kids to fall out of my pickup.
NHTSA complaint #11646448 — an unverified report by a vehicle owner.
Melrose, WI
ELECTRICAL SYSTEM
The audio system “glitched” and all of the speakers started screeching at maximum volume. I was unable to get this to stop outside of turning the vehicle off. It is so loud my ear were ringing for hours. This is loud enough it could definitely cause someone to wreck and impairs driving ability. I could also smell the electrical in the speakers getting hot and was fearful of an electrical fire. No warning lights. Not reproducible.
NHTSA complaint #11641894 — an unverified report by a vehicle owner.
at 9,500 milesFort Worth, TX
POWER TRAIN
The contact owns a 2023 Ford F-350 SD. The contact stated that there was a whirring sound coming from the vehicle since the vehicle was purchased. There was no warning light illuminated. The vehicle was taken to the dealer, but the vehicle was not diagnosed. The contact stated that the failure persisted. The vehicle was taken to a second dealer; however, the vehicle was not diagnosed. The dealer informed the contact that there was no recall on the VIN for the issue and that the whirring sound did not shorten the life of the transmission. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 9,500.
NHTSA complaint #11640691 — an unverified report by a vehicle owner.