Owners have filed 311 complaints
about the 2018 Ford F-350 SD with NHTSA between 2018 and 2026.
The largest single group is the steering.
Across this model's run it ranks 3 of 28 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 85
Against the median year of the Ford F-350 SD. 50 means typical for this
model; 100 means roughly double.
Severity — 25
4.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
71% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
2369.7%
Latch
39.1%
Valve
26.1%
Software
13.0%
Warning
13.0%
Warnings
13.0%
Fuel Pump
13.0%
Camera
13.0%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
52.3%
1,000 – 9,999 miles
3114.2%
10,000 – 24,999 miles
7735.2%
25,000 – 49,999 miles
7835.6%
50,000 – 74,999 miles
156.8%
75,000 – 99,999 miles
31.4%
100,000 – 149,999 miles
83.7%
150,000+ miles
20.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2018peak 36Aug 2026
NHTSA investigations into the 2018 Ford F-350 SD
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
1
investigation is
still open.
PE24014Opened 9 May 2024Still openFUEL SYSTEM, DIESEL
Sogefi Secondary Diesel Fuel Filter Leak
The Office of Defect Investigations (ODI) has received 27 complaints alleging diesel fuel leaks due to a fracture in the secondary fuel filter housing in model year (MY) 2015-2021 Ford Motor Company (Ford) F-250, 350, 450, and 550 Super Duty vehicles equipped with 6.7L diesel engines. Of these complaints, 12 describe an engine compartment fire. The proximity of the secondary fuel filter to high heat sources creates a potential for autoignition thermal events and fires. ODI has contacted the vehicle manufacturer, Ford, and the filter manufacturer, Allevard Sogefi USA (Sogefi), and learned that...
RQ21001Opened 15 Jan 2021Closed 10 Jan 2024STRUCTURE:BODY:DOOR
Power Tailgate Release Systems
In January 2021, the Office of Defects Investigation (ODI) opened a Recall Query (RQ21-001) to assess allegations of post-recall remedy uncommanded tailgate openings in model year (MY) 2017-2019 F-250/350/450 Ford trucks. Besides the recall remedy launched in January 2020, Ford also implemented a production update in November 2019. At the time of the RQ opening, ODI had received eleven (11) Vehicle Owner Questionnaires (VOQs). ODI sent an Information Request (IR) to Ford in February 2021. In numerous meetings after receiving their IR response, Ford highlighted the drop in claims since the rec...
PE18011Opened 12 Oct 2018Closed 12 Dec 2019ELECTRICAL SYSTEM:WIRING
Power tailgate opens unintended
By letter dated December 4, 2019, Ford Motor Company (Ford) notified the Office of Defects Investigation (ODI) of a safety defect that may exist in model years (MY) 2017 through 2019 Ford Super Duty F-250, F-350, F-450 vehicles equipped with an electric tailgate. Following the receipt of five consumer complaints alleging unintended tailgate opening without vehicle operator knowledge, while the vehicles were in motion, NHTSA opened this investigation to assess the manufacturer's data including warranty claims, field reports, design changes, etc.In vehicles equipped with an electric tailgate, wa...
Recalls on the 2018 Ford F-350 SD
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V572000
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Risk: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
22V880000
POWER TRAIN:DRIVELINE:DRIVESHAFT
Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.
Risk: A fractured driveshaft can cause a loss of drive power. Additionally, a vehicle rollaway could occur while parked if the parking brake is not engaged. Either of these scenarios increases the risk of a crash.
22V644000
BACK OVER PREVENTION: SENSING SYSTEM: CAMERA
Ford Motor Company (Ford) is recalling certain 2017-2020 F-Super Duty F-250, F-350, F-450, and 2017-2020 Lincoln Continental vehicles equipped with the 360-degree camera system. Degradation of the camera's anit-reflective lens coating can lead to a foggy or cloudy rearview camera image.
Risk: Lack of a clear rearview camera image can reduce the driver's visibility of what is behind the vehicle, increasing the risk of a crash.
22V087000
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
Ford Motor Company (Ford) is recalling certain 2017-2022 F-250 and F-350 Super Duty vehicles equipped with gasoline engines and aluminum driveshafts. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Risk: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
21V155000
TIRES
Ford Motor Company (Ford) is recalling certain 2018 F-150, 2018-2020 F-250, F-350, and 2019 Escape vehicles equipped with Continental tires. On the affected vehicles, it is possible that one or more tires were cured for too long during tire production.
Risk: Over cured tires may develop a break in the sidewall, resulting in sudden air loss or belt edge separation which could lead to tread/belt loss. Either condition can cause a loss of vehicle control, increasing the risk of a crash.
20E090000
STEERING
Icon Vehicle Dynamics, LLC (Icon) is recalling all 05-UP FSD 2.5 Centerline Stabilizer Kits with part number 65050. The kits were sold as an accessory for certain 2005-2021 Ford F-250 4X4 and F-350 4X4 pickup trucks. The foam ring inside the stabilizer "through shaft" may block the piston ports, possibly causing the steering to lock up.
Risk: If the steering locks, it can increase the risk of a crash.
19V880000
STRUCTURE:BODY:ROOF AND PILLARS
Ford Motor Company (Ford) is recalling certain 2017-2019 F-Super Duty F-250, F-350, F-450, and F-550 SuperCrew Cab vehicles with carpet flooring. If a front seat belt pretensioner deploys as the result of a crash, the sparks may ignite materials such as carpeting or insulation within the B-pillar area.
Risk: A vehicle fire could result if materials ignite inside the vehicle.
19V864000
LATCHES/LOCKS/LINKAGES:TAILGATE:LATCH
Ford Motor Company (Ford) is recalling certain 2017-2019 Super Duty F-250, F-350, and F-450 trucks equipped with an electric tailgate latch release switch mounted in the tailgate handle. Water may enter the electrical wiring system and cause a short circuit, activating the switch and releasing the tailgate latches.
Risk: Unintended tailgate opening may allow unrestrained cargo to fall out of the truck bed and become a road hazard, increasing the risk of a crash.
Reports where the owner recorded a crash, a fire, an injury or a death.
Pebble Beach, CAFire
UNKNOWN OR OTHER
The car had not been driven and was only in use for about 20 minutes. Then, the check engine light came on. I was planning to take the next exit to investigate. About a minute after the check engine light came on, several other lights came on. They stopped about 20 seconds later. The car began to smoke and as I was pulling over, smoke began to enter the cab. When I pulled over, the car began was on fire. Highway patrol and Cal Fire arrived. Cal Fire put the fire out. It was a total loss. Highway 101 was shut down for a bit while the truck was on fire.
NHTSA complaint #11676364 — an unverified report by a vehicle owner.
Wilton, CAFire2 injured
ELECTRICAL SYSTEM
Unknown component that failed. Suspicion, the fuel system located at the back of the fire wall on drivers side. The fire started in that location and was extremely hot and fast moving. The truck was fully engulfed within 1.5 minutes then burnt the attached 5th wheel trailer and contents. It was a total loss of 3 vehicles 2018 Ford F350, 2021 Dutchman Voltage 5th wheel trailer, and a 2013 Polaris RZR side by side UTV. All was reduced to rubble within 15 Min. Our safety and lives were at risk, we had 30-45 seconds from smelling and seeing smoke to flames. We were traveling on Interstate 15 at highway speeds and had to stop as safe as possible on the shoulder of the road. The vehicle has not been inspected as far as I know, the frame is all what is left. There were no warning lights and all gauges read normal,
NHTSA complaint #11642894 — an unverified report by a vehicle owner.
Wilton, CAFire2 injured
ENGINE
Unknown component that failed. Suspicion, the fuel system located at the back of the fire wall on drivers side. The fire started in that location and was extremely hot and fast moving. The truck was fully engulfed within 1.5 minutes then burnt the attached 5th wheel trailer and contents. It was a total loss of 3 vehicles 2018 Ford F350, 2021 Dutchman Voltage 5th wheel trailer, and a 2013 Polaris RZR side by side UTV. All was reduced to rubble within 15 Min. Our safety and lives were at risk, we had 30-45 seconds from smelling and seeing smoke to flames. We were traveling on Interstate 15 at highway speeds and had to stop as safe as possible on the shoulder of the road. The vehicle has not been inspected as far as I know, the frame is all what is left. There were no warning lights and all gauges read normal,
NHTSA complaint #11642894 — an unverified report by a vehicle owner.
Wilton, CAFire2 injured
FUEL/PROPULSION SYSTEM
Unknown component that failed. Suspicion, the fuel system located at the back of the fire wall on drivers side. The fire started in that location and was extremely hot and fast moving. The truck was fully engulfed within 1.5 minutes then burnt the attached 5th wheel trailer and contents. It was a total loss of 3 vehicles 2018 Ford F350, 2021 Dutchman Voltage 5th wheel trailer, and a 2013 Polaris RZR side by side UTV. All was reduced to rubble within 15 Min. Our safety and lives were at risk, we had 30-45 seconds from smelling and seeing smoke to flames. We were traveling on Interstate 15 at highway speeds and had to stop as safe as possible on the shoulder of the road. The vehicle has not been inspected as far as I know, the frame is all what is left. There were no warning lights and all gauges read normal,
NHTSA complaint #11642894 — an unverified report by a vehicle owner.
Rocklin, CAFire
FUEL/PROPULSION SYSTEM
The fuel filter under the engine began leaking diesel fuel on the hot engine which ignited a fire.
NHTSA complaint #11513775 — an unverified report by a vehicle owner.
Madison, IN1 injured
SUSPENSION
I lost control of my F350 when I was at 50 MPH. It started to shake uncontrollably when I hit a bump in the road… I tried to break and it got worse.. so I took my foot off the gas, ended up of the side of the road. I called back to our mechanic and he said it was safe to drive under 40 MPH. (He looked up the problem and found all the related incidents with the f series trucks…) Since then the have replaced the parts that Ford said to replace… and the truck is still up drivable.
NHTSA complaint #11444235 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Northglenn, CO
UNKNOWN OR OTHER
Ford Motor Company deployed an over-the-air software update to my 2018 Ford F350 that corrupted the Body Control Module. The software error permanently locked the vehicle into a speed-restricted 'MyKey' safety mode, leaving me with an altered vehicle and no admin access to bypass it. Ford Corporate is refusing to fix the corrupted software deployment. I do not and never have had a second key and they are now saying I must purchase this and pay for my truck to be reset.
NHTSA complaint #11757550 — an unverified report by a vehicle owner.
Brea, CA
FUEL/PROPULSION SYSTEM
Our 2018 Ford F-350 Super Duty diesel with the 6.7L Power Stroke engine has a well-known, massive fuel system concern involving the Bosch CP4 high-pressure fuel pump. This pump failed and it sheds metal shavings throughout the entire fuel system. Repair cost $13k. Per other consumer and google results: The CP4 Fuel Pump Issue. The Defect: The Bosch CP4 pump is designed for European diesel fuel, which has more lubrication than American diesel. When it lacks sufficient lubrication, it can score itself and self-destruct. The Damage: Metal debris floods the fuel rails, lines, and injectors, requiring a complete replacement of the fuel system components.
NHTSA complaint #11755489 — an unverified report by a vehicle owner.
Ocala, FL
FUEL/PROPULSION SYSTEM
My wife reported a strong smell fuel in the passenger compartment of my 2018 F350 6.7L Diesel vehicle while returning home from work. Upon inspection under the hood when power was turned on I discovered a strong stream of fuel from the filter cap.
NHTSA complaint #11724348 — an unverified report by a vehicle owner.
Severn, MD
UNKNOWN OR OTHER
My truck's tailgate has started opening on its own while driving, again. Previous recalls on this issue were performed when parts were available. This is a safety hazard to anyone behind me if anything falls out of the truck bed while driving. Today, 2/3/2026, it opened again. A bucket fell out of the truck bed. Fortunately no one was behind me. My truck is available for inspection. I have not contacted the dealer yet for their inspection/diagnosis. There are no warnings when this happens. It has forced me to strap the tailgate so it can't open unexpectedly.
NHTSA complaint #11715342 — an unverified report by a vehicle owner.
Mercer Island, WA
STEERING
Steering Effort Control Module failed. This is a known concern with these vehicles. Many Super Duty's have this happen. It is a very expensive repair. The steering effort changes, the vehicle becomes out of alignment and other things like cruise control, wipers, etc may fail as part of this issue.
NHTSA complaint #11710914 — an unverified report by a vehicle owner.
Mercer Island, WA
LANE DEPARTURE: WARNING
Steering Effort Control Module failed. This is a known concern with these vehicles. Many Super Duty's have this happen. It is a very expensive repair. The steering effort changes, the vehicle becomes out of alignment and other things like cruise control, wipers, etc may fail as part of this issue.
NHTSA complaint #11710914 — an unverified report by a vehicle owner.
at 72,000 milesElma, WA
ENGINE
The contact owns a 2018 Ford F-350. The contact stated while driving 55 MPH and hauling a boat, the vehicle made abnormal banging sounds and stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road. The vehicle was restarted but was undrivable. The vehicle was towed to a dealer, but the diesel mechanic was unavailable to service the vehicle. The vehicle was then towed to a certified mechanic and was diagnosed with a blown engine. The contact was informed that the engine needed to be replaced. The vehicle was being repaired. The contact stated that the failure had occurred in Vancouver Island, Canada, where the vehicle remained for the repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 72,000.
NHTSA complaint #11680411 — an unverified report by a vehicle owner.
Pebble Beach, CAFire
UNKNOWN OR OTHER
The car had not been driven and was only in use for about 20 minutes. Then, the check engine light came on. I was planning to take the next exit to investigate. About a minute after the check engine light came on, several other lights came on. They stopped about 20 seconds later. The car began to smoke and as I was pulling over, smoke began to enter the cab. When I pulled over, the car began was on fire. Highway patrol and Cal Fire arrived. Cal Fire put the fire out. It was a total loss. Highway 101 was shut down for a bit while the truck was on fire.
NHTSA complaint #11676364 — an unverified report by a vehicle owner.
Columbia, TN
POWER TRAIN
Truck went into limp mode wile driving on highway had to have trailer towed 980 miles egr cooler rubbing on wire harness on firewall staffing wires ro short out fuel injection this is a manufacturer defect.why would egr cooler and electrical wire harness be placed so close is a big safety and fire hazard ....cost of repairs at ford dealer in Columbia Tennessee $800 for repairs
NHTSA complaint #11673394 — an unverified report by a vehicle owner.
Columbia, TN
ELECTRICAL SYSTEM
Truck went into limp mode wile driving on highway had to have trailer towed 980 miles egr cooler rubbing on wire harness on firewall staffing wires ro short out fuel injection this is a manufacturer defect.why would egr cooler and electrical wire harness be placed so close is a big safety and fire hazard ....cost of repairs at ford dealer in Columbia Tennessee $800 for repairs
NHTSA complaint #11673394 — an unverified report by a vehicle owner.
Columbia, TN
ENGINE
Truck went into limp mode wile driving on highway had to have trailer towed 980 miles egr cooler rubbing on wire harness on firewall staffing wires ro short out fuel injection this is a manufacturer defect.why would egr cooler and electrical wire harness be placed so close is a big safety and fire hazard ....cost of repairs at ford dealer in Columbia Tennessee $800 for repairs
NHTSA complaint #11673394 — an unverified report by a vehicle owner.
Marysville, WA
UNKNOWN OR OTHER
The panoramic vista sunroof began allowing air while driving. Then the mechanism began not working properly. This all resulted in the track breaking and caused the entire system to stop working. While driving on highway or freeways, the glass would open and could not be secured properly. Could have caused the glass to become a projectile object. Upon researching this issue, I found several complaints for the panoramic vista sunroof for Ford/Lincoln's from 2017 to 2019. TSB # 18-2374. We have a 2018. To be clear; this was a progressive issue that started in 2021 and simply thought it to be the windy conditions outside the vehicle. Then the issue became worse even after being regularly serviced and repaired. By 2024, the track broke completely. Resulting in a complete replacement.
NHTSA complaint #11670982 — an unverified report by a vehicle owner.
at 138,000 milesAtwater, CA
FUEL SYSTEM, DIESEL
The contact owns a 2018 Ford F-350. The contact stated while driving 50 MPH and coming to a stop, the vehicle stalled in the middle to the road. There was no warning light illuminated. The vehicle failed to restart and was pushed to side of the road. The vehicle was towed to the dealer, where it was diagnosed that the high-pressure fuel pump had exploded, causing metal shavings intrusion in the fuel system. The dealer determined that the entire fuel system needed to be replaced. The vehicle was in the process of being repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 138,000.
NHTSA complaint #11668566 — an unverified report by a vehicle owner.
Douglasville, GA
POWER TRAIN
The contact owns a 2018 Ford F-350. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shifted hard into gear, and the vehicle was shaking erratically. Additionally, the engine overheated. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.
NHTSA complaint #11646440 — an unverified report by a vehicle owner.
Douglasville, GA
ENGINE
The contact owns a 2018 Ford F-350. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shifted hard into gear, and the vehicle was shaking erratically. Additionally, the engine overheated. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.
NHTSA complaint #11646440 — an unverified report by a vehicle owner.
Wilton, CAFire2 injured
ELECTRICAL SYSTEM
Unknown component that failed. Suspicion, the fuel system located at the back of the fire wall on drivers side. The fire started in that location and was extremely hot and fast moving. The truck was fully engulfed within 1.5 minutes then burnt the attached 5th wheel trailer and contents. It was a total loss of 3 vehicles 2018 Ford F350, 2021 Dutchman Voltage 5th wheel trailer, and a 2013 Polaris RZR side by side UTV. All was reduced to rubble within 15 Min. Our safety and lives were at risk, we had 30-45 seconds from smelling and seeing smoke to flames. We were traveling on Interstate 15 at highway speeds and had to stop as safe as possible on the shoulder of the road. The vehicle has not been inspected as far as I know, the frame is all what is left. There were no warning lights and all gauges read normal,
NHTSA complaint #11642894 — an unverified report by a vehicle owner.
Wilton, CAFire2 injured
ENGINE
Unknown component that failed. Suspicion, the fuel system located at the back of the fire wall on drivers side. The fire started in that location and was extremely hot and fast moving. The truck was fully engulfed within 1.5 minutes then burnt the attached 5th wheel trailer and contents. It was a total loss of 3 vehicles 2018 Ford F350, 2021 Dutchman Voltage 5th wheel trailer, and a 2013 Polaris RZR side by side UTV. All was reduced to rubble within 15 Min. Our safety and lives were at risk, we had 30-45 seconds from smelling and seeing smoke to flames. We were traveling on Interstate 15 at highway speeds and had to stop as safe as possible on the shoulder of the road. The vehicle has not been inspected as far as I know, the frame is all what is left. There were no warning lights and all gauges read normal,
NHTSA complaint #11642894 — an unverified report by a vehicle owner.
Wilton, CAFire2 injured
FUEL/PROPULSION SYSTEM
Unknown component that failed. Suspicion, the fuel system located at the back of the fire wall on drivers side. The fire started in that location and was extremely hot and fast moving. The truck was fully engulfed within 1.5 minutes then burnt the attached 5th wheel trailer and contents. It was a total loss of 3 vehicles 2018 Ford F350, 2021 Dutchman Voltage 5th wheel trailer, and a 2013 Polaris RZR side by side UTV. All was reduced to rubble within 15 Min. Our safety and lives were at risk, we had 30-45 seconds from smelling and seeing smoke to flames. We were traveling on Interstate 15 at highway speeds and had to stop as safe as possible on the shoulder of the road. The vehicle has not been inspected as far as I know, the frame is all what is left. There were no warning lights and all gauges read normal,
NHTSA complaint #11642894 — an unverified report by a vehicle owner.
at 76,000 milesTucker, GA
STEERING
The contact owns a 2018 Ford F-350. The contact stated while driving 65 MPH and driving over a bump on the road, the steering wheel started vibrating and shaking abnormally. The contact stated that the failure had occurred approximately twelve times. The contact stated that an independent mechanic and a dealer were contacted. The vehicle was taken to the independent mechanic to be diagnosed. The contact was informed that the steering dampener needed to be replaced. The vehicle was then taken to a dealer where it was diagnosed and determined that the steering dampener, the pitman arm, and the inner and outer drag links needed to be replaced; however, the vehicle was not repaired. The contact related the failure to the death wobble. The manufacturer was notified of the failure and informed the contact that the inner and outer drag link and pitman's arm were worn and that only the steering dampener replacement would be covered. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 76,000.
NHTSA complaint #11638271 — an unverified report by a vehicle owner.
at 125,000 milesSalem, AL
FUEL SYSTEM, DIESEL
The contact owns a 2018 Ford F-350. The contact stated that while driving at an undisclosed speed, the "Engine Power reduced" message was displayed on the instrument panel before the vehicle lost automotive power. The check engine warning light was illuminated. The contact stated that the vehicle was previously towed on several occasions for the failure and the fuel system was replaced. The vehicle was recently towed to a dealer where it was diagnosed and determined that the fuel pump needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The manufacturer was not made aware of the failure. The failure mileage was approximately 125,000.
NHTSA complaint #11635623 — an unverified report by a vehicle owner.
at 38,320 milesCentennial, CO
STEERING
The contact owns a 2018 Ford F-350. The contact stated while driving at various speeds, the vehicle experienced a "death wobble". The contact then received notification for Customer Satisfaction Program: 20N04 (Steering Linkage Damper Extended Coverage). The vehicle was taken to the dealer where the repair was performed; however, the failure recurred approximately 5,000 miles after the repair. The manufacturer was made aware of the failure but offered no assistance. The contact was also referred to the NHTSA Hotline to file a safety complaint. The vehicle was not repaired. The failure mileage was 38,320.
NHTSA complaint #11611247 — an unverified report by a vehicle owner.
at 38,320 milesCentennial, CO
SUSPENSION
The contact owns a 2018 Ford F-350. The contact stated while driving at various speeds, the vehicle experienced a "death wobble". The contact then received notification for Customer Satisfaction Program: 20N04 (Steering Linkage Damper Extended Coverage). The vehicle was taken to the dealer where the repair was performed; however, the failure recurred approximately 5,000 miles after the repair. The manufacturer was made aware of the failure but offered no assistance. The contact was also referred to the NHTSA Hotline to file a safety complaint. The vehicle was not repaired. The failure mileage was 38,320.
NHTSA complaint #11611247 — an unverified report by a vehicle owner.
White Lake, MI
ELECTRICAL SYSTEM
Sync screen has gone black on radio causing all blind spots to be invisible while parking a large vehicle. I was told by ford tech support this is a recall in certain year ford explorers but not in the F series trucks! I looked up the issue on many of ford forums and it is an unresolved issue. If the rear camera is a recall the image projecting device “SYNC Radio” which is a brain to truck should be as well I would imagine. The laborer and parts for the repair are costly to the company and I’m extremely concerned with how I was treated when this is a known issue with ford. I paid 62000 for a vehicle that now has a recall for a foggy camera but no recall for the device to visually see 360 degrees around vehicle. Suburban Ford of Waterford wants to charge me upwards around 1000.00 for parts and laborer to fix a KNOWN SAFETY ISSUE. All attempts to update have been completed and any ford provided reset and install options have been performed. Downloaded the 3.4 update onto thumb drive in the right format and just black screen of death it’s now been named in forums. They push it off as an update but the years being monitored have faulty APIM modules. Causing screens to have no image, sound, and HANDSFREE safety features. Please help me resolve this concern! Thank you, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11604376 — an unverified report by a vehicle owner.
White Lake, MI
BACK OVER PREVENTION: WARNINGS
Sync screen has gone black on radio causing all blind spots to be invisible while parking a large vehicle. I was told by ford tech support this is a recall in certain year ford explorers but not in the F series trucks! I looked up the issue on many of ford forums and it is an unresolved issue. If the rear camera is a recall the image projecting device “SYNC Radio” which is a brain to truck should be as well I would imagine. The laborer and parts for the repair are costly to the company and I’m extremely concerned with how I was treated when this is a known issue with ford. I paid 62000 for a vehicle that now has a recall for a foggy camera but no recall for the device to visually see 360 degrees around vehicle. Suburban Ford of Waterford wants to charge me upwards around 1000.00 for parts and laborer to fix a KNOWN SAFETY ISSUE. All attempts to update have been completed and any ford provided reset and install options have been performed. Downloaded the 3.4 update onto thumb drive in the right format and just black screen of death it’s now been named in forums. They push it off as an update but the years being monitored have faulty APIM modules. Causing screens to have no image, sound, and HANDSFREE safety features. Please help me resolve this concern! Thank you, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11604376 — an unverified report by a vehicle owner.
at 42,600 milesAlbany, OH
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The contact owns a 2018 Ford F-350. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed that it was due for a software update and the code was reset. The vehicle was repaired but the check engine warning light illuminated on the way back to the residence. The vehicle was taken back to the same local dealer where it was diagnosed that the exhaust system and catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 42,600.
NHTSA complaint #11585486 — an unverified report by a vehicle owner.