FaultScore report
Owners have filed 167 complaints about the 1994 Volkswagen Jetta with NHTSA between 1995 and 2008. The largest single group is the equipment & accessories. Across this model's run it ranks 19 of 33 worst.
FaultScore 48/100
Higher is worse. Measured against the other years of the Volkswagen Jetta.
How this is worked out167
Complaints
9
Crashes reported
11
Fires reported
11
Injuries reported
The letter says how bad. This says what kind — whether this year drew an unusual number of complaints, unusually dangerous ones, or failures that arrived unusually early.
Click any bar to open that year's report.
Every complaint is filed against a part. Follow any row for the complaints about that part alone.
0 crashes, 1 fires · median 59,000 mi
3 crashes, 0 fires
1 crashes, 0 fires
2 crashes, 0 fires · median 91,800 mi
1 crashes, 0 fires
NHTSA files every complaint against a named sub-assembly, not just a system. This is the difference between knowing it was "the engine" and knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all complaints include one.
A spike years after the car went on sale usually means a part wearing out on schedule across the whole fleet — the kind of pattern no single owner can see from inside their own car.
An investigation is the step before a recall: the agency has seen enough complaints to look into a pattern itself. An open one means it thinks something may be wrong and nothing has been fixed yet.
FUEL TANK PUNCTURE
FUEL TANK PUNCTURE
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON AUGUST 10, 2000 BASED ON 9 REPORTS REGARDING PUNCTURED FUEL TANKS INVOLVING THE JETTA, PASSAT, AND CABRIO MODELS.THE REPORTS INDICATE ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION.THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.
A complaint is one owner's allegation. A recall is the point at which the manufacturer or a regulator agreed the defect is real and dangerous enough to fix for free — however old the car is.
EXTERIOR LIGHTING
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Risk: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE REAR BRAKE LINE ON THE PASSENGER SIDE WAS ROUTED TOO CLOSE TO THE CORNER OF THE FUEL TANK. THE LINE COULD BE DAMAGED BY CHAFING AGAINST THE FUEL TANK.
Risk: REPEATED CHAFING COULD EVENTUALLY RESULT IN A LEAKING BRAKE LINE CAUSING DIMINISHED BRAKING IN ONE BRAKE CIRCUIT INCREASING THE VEHICLE'S STOPPING DISTANCE.
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE BOLTS SECURING THE FRONT HOOD LATCH CAN LOOSEN OVER TIME. THE LATCH WOULD MOVE CAUSING DISENGAGEMENT OF THE HOOD STRIKER FROM THE LATCH.
Risk: UNEXPECTED OPENING OF THE HOOD COULD OCCUR OBSTRUCTING THE DRIVER'S VIEW OF THE ROAD WHILE DRIVING, INCREASING THE RISK OF A CRASH.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
THE SHEET METAL PANELS OF BOTH REAR DOORS HAVE OPENINGS FOR THE ROUTING OF THE ELECTRICAL WINDOW REGULATOR WIRING. THE PANEL OPENINGS HAVE SHARP EDGES THAT CAN DAMAGE THE INSULATION OF THE WIRING HARNESS.
Risk: AN ELECTRICAL SHORT IN THE WIRING CAN OCCUR RESULTING IN A POSSIBLE FIRE.
ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
IMPROPER MATERIAL WAS USED IN MANUFACTURING THE RADIATOR FAN MOTOR SHAFT CAUSING THE SHAFT TO WEAR AND BECOME NOISY.
Risk: A WORN AND NOISY FAN MOTOR SHAFT CAN SEIZE RENDERINGTHE FAN MOTOR INOPERATIVE, EVENTUALLY CAUSING THE ENGINE TO OVERHEAT AND STALL. A STALLED VEHICLE IN TRAFFIC CAN INCREASE THE POTENTIAL FOR A VEHICLE ACCIDENT.
VEHICLE SPEED CONTROL
WHEN INSTALLED IN THE VEHICLES, A TIE WRAP IS USED TO GUIDE THE CRUISE CONTROL CABLE IN THE ENGINE COMPARTMENT. SOME TIE WRAPS HAVE BEEN INSTALLED WITH A LARGE LOOP OPENING IMPROPERLY GUIDING THE CABLE WHICH COULD PREVENT THE THROTTLE FROM RETURNING TO ITS FULL IDLE POSITION.
Risk: THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THEPOTENTIAL FOR A VEHICLE COLLISION.
EQUIPMENT:MECHANICAL:ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT
THE JACKS SUPPLIED WITH THESE VEHICLES WERE ASSEMBLED WITH AN IMPROPERLY MACHINED SPINDLE, SO THAT A SHARP RIDGE ON THE EDGE OF SPINDLE'S THREAD WOULD HAVE REMAINED.
Risk: THIS RIDGE CAN DAMAGE THE INSIDE THREAD OF THE JACK'S SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING CLOSE TO THE VEHICLE COULD BE INJURED.
Canada runs its own recall programme, and its campaigns do not always mirror the American ones.
Brakes
On certain vehicles, the rear brake line on the passenger side could be routed too close to the corner of the fuel tank. An improperly routed brake line could be damaged by chafing against the fuel tank during extreme axle movement. Such chafing could result in a leaking brake line causing a partial brake system failure and increased stopping distances. Correction: Dealers will check the routing of the right rear brake line and replace any damaged brake line.
Structure
THE BOLTS SECURING THE FRONT HOOD LATCH MAY LOSE THEIR SPECIFIED FASTENING TORQUE OVER TIME. SHOULD THIS HAPPEN, THE LATCH COULD MOVE OUT OF ITS DESIGN POSITION AND CAUSE DISENGAGEMENT OF THE HOOD STRIKER FROM THE LATCH. IN SOME VEHICLES THE LATCH MAY NOT HAVE BEEN PROPERLY ALIGNED DURING PRODUCTION. REPEATED OPENING AND CLOSING OF THE HOOD WITH AN IMPROPERLY ALIGNED LATCH COULD RESULT IN DAMAGE TO THE LATCH. EITHER CONDITION COULD RESULT IN HOOD FLY UP AND OBSTRUCTION OF THE DRIVER'S VISION. CORRECTION: HOOD LATCHES AND SECURING BOLTS WILL BE INSPECTED AND REPLACED IF NECESSARY.
Engine
NOTE: INCLUDES PASSAT, GOLF AND JETTA TURBO DIESEL. ON 1993-94 MODELS, THE RADIATOR FAN MOTOR SHAFT COULD SEIZE AND RENDER THE FAN MOTOR INOPERATIVE. 1994-95 MODELS COULD EXPERIENCE A CONDITION WHEREBY THE LOCK NUT SECURING THE RADIATOR FAN BLADE HUB TO THE MOTOR COULD LOSE ITS REQUIRED TORQUE. A LOOSE LOCK NUT COULD CAUSE THE FAN HUB TO LOOSEN FROM THE SHAFT AND CAUSE THE BELT PULLEY TO RUN "OFF-CENTER". THIS IN TURN COULD CAUSE THE FAN BELT TO DISCONNECT OR BREAK. EITHER OF THE ABOVE CONDITIONS COULD RESULT IN ENGINE OVERHEATING AND STALLING. A VEHICLE STALLING IN TRAFFIC COULD CAUSE AN ACCIDENT. CORRECTION: VEHICLES WITH EITHER HAVE THE COMPLETE COOLING FAN ASSEMBLY REPLACED OR A NEW FAN BLADE WITH A NEW LOCK NUT INSTALLED.
Other
A SHARP RIDGE ON THE JACK SPINDLE COULD DAMAGE THE INSIDE THREAD OF THE SCISSOR SHOE WHEN THE JACK IS USED TO LIFT THE VEHICLE. IF THE DAMAGE TO THE THREAD OF THE SCISSOR SHOE IS SERIOUS ENOUGH, THE JACK COULD COLLAPSE WITH THE POSSIBILITY THAT A PERSON STANDING TOO CLOSE THE VEHICLE COULD BE INJURED. CORRECTION: JACKS WILL BE REPLACED ON AFFECTED VEHICLES.
Recalls cover specific build ranges, so check your own vehicle by VIN at nhtsa.gov/recalls or, in Canada, Transport Canada.
Reports where the owner recorded a crash, a fire, an injury or a death.
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
WHILE OPERATING MY VEHICLE (1994 VW JETTA) THE HOOD LATCH BROKE AND HOOD DETACHED FROM LOCK FLEW UP CRACKING MY WINDSHIELD, BRAKING WIPERS, I LOST CONTROL OF VEHICLE CRASHING INTO DIVIDER OF HIGHWAY. BY THE GRACE OF GOD I WAS ABLE TO AVOID TRAFFIC AND DROVE TO SAFETY AS MY HOOD COVERED THE WINDSHIELD. THE GLASS SHATTERED OVER THE FRONT DRIVING AREA. THANK GOD MY CHILDREN WERE NOT WITH ME AT THIS TRAUMATIC TIME. I HAD TO CALL FOR HELP AND USE FIRST AID FOR CUTS. I WAS UNAWARE OF RECALL AND REPAIRED WINDSHIELD,WIPERS AND TEMPORARILY STABILIZED HOOD.
NHTSA complaint #10161216 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
WHEN SLOWING DOWN VEHICLE ACCELERATED AT A HIGH SPEED, CAUSING AN ACCIDENT.*AK THE VEHICLE ACCELERATED ON ITS OWN AND STRUCK A MANURE TANK SPREADER, THERE WAS ONE INJURY.
NHTSA complaint #8014140 — an unverified report by a vehicle owner.
AIR BAGS
AIR BAGS INFLATED LEAVING A POWDERY RESIDUE ON EVERYTHING INSIDE VEHICLE. CONSUMERS MOTHER HAD A SEVERE ALLERGIC REACTION TO THE RESIDUE. CONSUMER WOULD LIKE TO SEE WARNINGS FOR PEOPLE WHO ARE ALLERGIC TO THE AIR BAG RESIDUE.
NHTSA complaint #564720 — an unverified report by a vehicle owner.
AIR BAGS
AIR BAGS INFLATED LEAVING A POWDERY RESIDUE ON EVERYTHING INSIDE VEHICLE. CONSUMERS MOTHER HAD A SEVERE ALLERGIC REACTION TO THE RESIDUE. CONSUMER WOULD LIKE TO SEE WARNINGS FOR PEOPLE WHO ARE ALLERGIC TO THE AIR BAG RESIDUE.
NHTSA complaint #564720 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
BLOWER SWITCH GETS EXTREMELY HOT WHEN AIR CONDITIONING IS RUNNING. ACTUALLY BEGAN TO SMOKE FROM THE DASH AND MELTED THE SWITCH BEZEL. I WAS ABLE TO EXTINGUISH THE HEAT WITH MINIMAL DAMAGE ONLY TO THE BLOWER SWITCH AND DASH FASCIA. I'M NOT POSITIVE THAT IT RESULTED IN FIRE, BUT I AM POSITIVE IT WOULD HAVE IF I HAD NOT SHUT THE CAR OFF IMMEDIATELY. THIS SEEMS TO BE A VERY COMMON PROBLEM AMONG THIS MODEL YEAR JETTA.
NHTSA complaint #750985 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
THE ELECTRICAL WIRING IN THE DASH FAILED RESULTING IN VEHICLE FIRE. (OHIO TRAFFIC CRASH REPORT) *MJS
NHTSA complaint #559642 — an unverified report by a vehicle owner.
In the owners' own words, exactly as filed with NHTSA.
FUEL SYSTEM, GASOLINE
THE IN TANK FUEL PUMP DESIGN HAS THE ACTUAL PUMP SITTING IN A PLASTIC HOUSING WITH RUBBER SEALS AT THE TOP AND BOTTOM TO KEEP FUEL AROUND THE PUMP FOR COOLING, EVEN WHEN THE TANK QUANTITY GETS LOW. THE RUBBER SEALS ON MY FUEL PUMP ROTTED AND DISINTEGRATED. THIS WOULD ALLOW THE PUMP TO OPERATE WITHOUT THE DESIGNED COOLING OF THE PUMP AT LOW GAS LEVELS. OVERHEATING OF THE PUMP BECAUSE OF THIS COULD RESULT IN A GAS TANK FIRE OR EXPLOSION.
NHTSA complaint #10235254 — an unverified report by a vehicle owner.
AIR BAGS:FRONTAL:SENSOR/CONTROL MODULE
AIRBAG CONTROL MODULE FAILURE WITHOUT WARNING. I NOTICED THE RED LIGHT FOR THE AIRBAG DID NOT GO OFF (NOT NOTICEABLE IN DAYLIGHT) THIS COULD BE A SIGNIFICANT PUBLIC SAFETY ISSUE. THE CAR ONLY HAS 92K MILES. THE WARNING LIGHT IS VIRTUALLY IMPOSSIBLE TO SEE IN BRIGHT DAYLIGHT. IF IT FAILS IN THE MIDDLE OF A JOURNEY THERE IS NO WARNING SOUND.... CONSUMERS CAN BE KILLED OR MAIMED IF AN ACCIDENT OCCURS WITHOUT REALIZING THIS PART HAS STOPPED FUNCTIONING, DRIVERS MAY GET A FALSE SENSE OF SECURITY. I TOOK THE CAR TO A VW DEALER WAS TOLD THAT THE CONTROL MODULE FOR THE AIRBAG HAD STOPPED WORKING. WE, (MY HUSBAND AND I), CALLED VW OF AMERICA, BUT WAS TOLD THAT BECAUSE THE CAR WAS 1. OUT OF WARRANTY, 2. 'OLD' (13 YRS) AND 3. 92, 000 MILES THAT THERE WAS NOTHING THAT WOULD BE DONE TO RECTIFY THE ISSUE. WE DISAGREED; THIS IS NOT A PART THAT SHOULD WEAR OUT, ESPECIALLY IF THE CAR HAS NEVER BEEN IN AN ACCIDENT. IT'S NOT THE SAME AS ENGINE PARTS, TIRES, BODY, ETC. THAT SHOULD BE EXPECTED TO WEAR AFTER TIME AND MILEAGE. THEIR CUSTOMER SERVICE REPRESENTATIVE SEEMED ONLY CONCERNED ABOUT IT IF THE CAR IS WITHIN THE WARRANTY PERIOD. I AM SUPPOSED TO GET BACK TO DEALER WITH A DECISION TO REPLACE THE MODULE.
NHTSA complaint #10184488 — an unverified report by a vehicle owner.
LATCHES/LOCKS/LINKAGES:HOOD:LATCH
WHILE OPERATING MY VEHICLE (1994 VW JETTA) THE HOOD LATCH BROKE AND HOOD DETACHED FROM LOCK FLEW UP CRACKING MY WINDSHIELD, BRAKING WIPERS, I LOST CONTROL OF VEHICLE CRASHING INTO DIVIDER OF HIGHWAY. BY THE GRACE OF GOD I WAS ABLE TO AVOID TRAFFIC AND DROVE TO SAFETY AS MY HOOD COVERED THE WINDSHIELD. THE GLASS SHATTERED OVER THE FRONT DRIVING AREA. THANK GOD MY CHILDREN WERE NOT WITH ME AT THIS TRAUMATIC TIME. I HAD TO CALL FOR HELP AND USE FIRST AID FOR CUTS. I WAS UNAWARE OF RECALL AND REPAIRED WINDSHIELD,WIPERS AND TEMPORARILY STABILIZED HOOD.
NHTSA complaint #10161216 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING
WHILE DRIVING 25-55 MPH VEHICLE STALLED, DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM.
NHTSA complaint #10074118 — an unverified report by a vehicle owner.
POWER TRAIN:CLUTCH ASSEMBLY
CLUTCH CABLE.
NHTSA complaint #10043032 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
WIRES ARE BURNED OUT INSIDE DASHBOARD PANEL, CAUSING THE VEHICLE TO SHUTDOWN WITHOUT PRIOR WARNING. PLEASE FURNISH ADDITIONAL INFORMATION. DEALER IS AWARE OF PROBLEM.
NHTSA complaint #10006149 — an unverified report by a vehicle owner.
VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:WINDSHIELD:ELECTRICAL HEATING ELEMENT
CONSUMER STATES THAT HEATING/AIR CONDITIONING CONTROL UNIT IS DEFECTIVE. HAS HAD TO REPLACE 4X. ON TWO OCCASIONS, WAS DRIVING AND BEGAN TO SMELL A "WIRE" BURNING SMELL, NOTICED SMOKE EMITTED FROM VENTS. REACTION MELTED THE FRONT OF PANEL BOTH TIMES ALMOST CAUSING A FIRE. TS
NHTSA complaint #8024047 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
WHEN SLOWING DOWN VEHICLE ACCELERATED AT A HIGH SPEED, CAUSING AN ACCIDENT.*AK THE VEHICLE ACCELERATED ON ITS OWN AND STRUCK A MANURE TANK SPREADER, THERE WAS ONE INJURY.
NHTSA complaint #8014140 — an unverified report by a vehicle owner.
AIR BAGS
AIR BAGS INFLATED LEAVING A POWDERY RESIDUE ON EVERYTHING INSIDE VEHICLE. CONSUMERS MOTHER HAD A SEVERE ALLERGIC REACTION TO THE RESIDUE. CONSUMER WOULD LIKE TO SEE WARNINGS FOR PEOPLE WHO ARE ALLERGIC TO THE AIR BAG RESIDUE.
NHTSA complaint #564720 — an unverified report by a vehicle owner.
AIR BAGS
AIR BAGS INFLATED LEAVING A POWDERY RESIDUE ON EVERYTHING INSIDE VEHICLE. CONSUMERS MOTHER HAD A SEVERE ALLERGIC REACTION TO THE RESIDUE. CONSUMER WOULD LIKE TO SEE WARNINGS FOR PEOPLE WHO ARE ALLERGIC TO THE AIR BAG RESIDUE.
NHTSA complaint #564720 — an unverified report by a vehicle owner.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
REAR WINDOWS WORKING INTERMITTENTLY DUE TO A SHORT IN ELECTRIC WINDOW REGULATOR. RECALL 96V122000 WAS ISSUED; THIS VEHICLE NOT INCLUDED.
NHTSA complaint #8005578 — an unverified report by a vehicle owner.
VEHICLE SPEED CONTROL
INTERMITTENTLY CRUISE CONTROL BECOMES INOPERABLE, AND THROTTLE DOES NOT RETURN TO IDLE. RECALL 95E34000 WAS ISSUED; HOWEVER, THIS VEHICLE WAS NOT INCLUDED DUE TO VIN.
NHTSA complaint #8005576 — an unverified report by a vehicle owner.
STRUCTURE:BODY:DOOR
DRIVER AND PASSENGER POWER DOOR LOCKS DO NOT LOCK OR UNLOCK PROPERLY, CAUSE UNKNOWN. ALSO WINDOWS MALFUNCTIONED, WINDOWS WILL NOT GO UP OR DOWN.*AK. THE WINDOW REGULATOR WAS FOUND TO BE FAULTY, WAS MAKING A GRINDING NOISE. THE HOOD WILL NOT OPEN, THE CABLE CAME LOOSE FROM THE HOOD LATCH. THE SUNROOF WAS BROKEN THE CABLE AND WIND DEFLECTOR WAS INOPERABLE. THE RADIO HAD AN INTERNAL SHORT.
NHTSA complaint #8003938 — an unverified report by a vehicle owner.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
DRIVER AND PASSENGER POWER DOOR LOCKS DO NOT LOCK OR UNLOCK PROPERLY, CAUSE UNKNOWN. ALSO WINDOWS MALFUNCTIONED, WINDOWS WILL NOT GO UP OR DOWN.*AK. THE WINDOW REGULATOR WAS FOUND TO BE FAULTY, WAS MAKING A GRINDING NOISE. THE HOOD WILL NOT OPEN, THE CABLE CAME LOOSE FROM THE HOOD LATCH. THE SUNROOF WAS BROKEN THE CABLE AND WIND DEFLECTOR WAS INOPERABLE. THE RADIO HAD AN INTERNAL SHORT.
NHTSA complaint #8003938 — an unverified report by a vehicle owner.
VISIBILITY:SUN/MOON ROOF ASSEMBLY
DRIVER AND PASSENGER POWER DOOR LOCKS DO NOT LOCK OR UNLOCK PROPERLY, CAUSE UNKNOWN. ALSO WINDOWS MALFUNCTIONED, WINDOWS WILL NOT GO UP OR DOWN.*AK. THE WINDOW REGULATOR WAS FOUND TO BE FAULTY, WAS MAKING A GRINDING NOISE. THE HOOD WILL NOT OPEN, THE CABLE CAME LOOSE FROM THE HOOD LATCH. THE SUNROOF WAS BROKEN THE CABLE AND WIND DEFLECTOR WAS INOPERABLE. THE RADIO HAD AN INTERNAL SHORT.
NHTSA complaint #8003938 — an unverified report by a vehicle owner.
EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
DRIVER AND PASSENGER POWER DOOR LOCKS DO NOT LOCK OR UNLOCK PROPERLY, CAUSE UNKNOWN. ALSO WINDOWS MALFUNCTIONED, WINDOWS WILL NOT GO UP OR DOWN.*AK. THE WINDOW REGULATOR WAS FOUND TO BE FAULTY, WAS MAKING A GRINDING NOISE. THE HOOD WILL NOT OPEN, THE CABLE CAME LOOSE FROM THE HOOD LATCH. THE SUNROOF WAS BROKEN THE CABLE AND WIND DEFLECTOR WAS INOPERABLE. THE RADIO HAD AN INTERNAL SHORT.
NHTSA complaint #8003938 — an unverified report by a vehicle owner.
STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS
DRIVER AND PASSENGER POWER DOOR LOCKS DO NOT LOCK OR UNLOCK PROPERLY, CAUSE UNKNOWN. ALSO WINDOWS MALFUNCTIONED, WINDOWS WILL NOT GO UP OR DOWN.*AK. THE WINDOW REGULATOR WAS FOUND TO BE FAULTY, WAS MAKING A GRINDING NOISE. THE HOOD WILL NOT OPEN, THE CABLE CAME LOOSE FROM THE HOOD LATCH. THE SUNROOF WAS BROKEN THE CABLE AND WIND DEFLECTOR WAS INOPERABLE. THE RADIO HAD AN INTERNAL SHORT.
NHTSA complaint #8003938 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
BLOWER SWITCH GETS EXTREMELY HOT WHEN AIR CONDITIONING IS RUNNING. ACTUALLY BEGAN TO SMOKE FROM THE DASH AND MELTED THE SWITCH BEZEL. I WAS ABLE TO EXTINGUISH THE HEAT WITH MINIMAL DAMAGE ONLY TO THE BLOWER SWITCH AND DASH FASCIA. I'M NOT POSITIVE THAT IT RESULTED IN FIRE, BUT I AM POSITIVE IT WOULD HAVE IF I HAD NOT SHUT THE CAR OFF IMMEDIATELY. THIS SEEMS TO BE A VERY COMMON PROBLEM AMONG THIS MODEL YEAR JETTA.
NHTSA complaint #750985 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
WHILE DRIVING AT ANY SPEED, ENGINE SHUTS DOWN PARTICULARLY WHEN HOT (~190 F ). SOMETIMES WHEN ENGINE IS IDLE, WHILE HOT, VEHICLE STALLS AND SHUTS DOWN WITHOUT WARNING. VEHICLE HAS TO BE RESTARTED TO REGAIN POWER. EVIDENTLY THIS ENGINE PROBLEM CAUSES A SAFETY HAZARD, PARTICULARLY WHEN THE VEHICLE IS MOVING AT ANY SPEED. THIS CONDITION OCCURS FREQUENTLY: THAT IS WHILE ENGINE IS HOT, IT SHUTS DOWN, THEN RESTART ENGINE AFTER IT COOLS SOMEWHAT, VEHICLE MAY RESTART; BUT AGAIN THIS WILL REPEAT ITSELF EVEN FOR SHORT DRIVING DISTANCES. DEALER CLAIMS IT CANNOT FIND ANY ENGINE PROBLEM!!!!!.
NHTSA complaint #750626 — an unverified report by a vehicle owner.
STRUCTURE:FRAME AND MEMBERS
NO SUMMARY LISTED FOR ABOVE VEHICLE.
NHTSA complaint #747072 — an unverified report by a vehicle owner.
VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
RIGHT REAR WINOW INOPERATIVE/REPAIRED 3 TIMES IN PAST SAME PROBLEM-REGULATOR.
NHTSA complaint #744462 — an unverified report by a vehicle owner.
TIRES:SIDEWALL
INNER SIDEWALLS ON 3 OF 4 TIRES HAVE SPLIT - 2 OCCURRED WHILE NOT DRIVING AND THE OTHER OCCURED AT LOW SPEED. THEY HAVE ALL FAILED IN LESS THEN ONE MONTH. I HAVE THE THIRD FAILED TIRE AND THE FORTH ORIGINAL. THERE ARE NO VISIBLE SIGNS OF DAMAGE AROUND THE SPLITS. THE MANUFACTURER REPRESENTATIVE SAID THIS WAS NOT THE FIRST OCCURANCE BUT THERE IS NOTHING I CAN DO.*AK (TIRESIZE: 185/60R14)( DOT NUMBER: TIRE SIZE: 185/60R14 )
NHTSA complaint #741281 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH
THE ELECTRICAL WIRING IN THE DASH FAILED RESULTING IN VEHICLE FIRE. (OHIO TRAFFIC CRASH REPORT) *MJS
NHTSA complaint #559642 — an unverified report by a vehicle owner.
ELECTRICAL SYSTEM:IGNITION
INTERMITTENTLY VEHICLE BEEN EXPERIENCING ONGOING PROBLEM WITH ENGINE STALLING AT HIGHWAY SPEED. VEHICLE BEEN IN DEALER SHOP ON SIX OCCASIONS, AND THEY WERE UNABLE TO DUPLICATE PROBLEM. PLEASE FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER.
NHTSA complaint #877972 — an unverified report by a vehicle owner.
ENGINE AND ENGINE COOLING:ENGINE
TIMING BELT DETERIORATED, CAUSING DAMAGE TO ENGINE. MANUFACTURER HAS BEEN NOTIFIED.*AK THE TIMING BELT FAILURE DAMAGED THE ENGINE BECAUSE OF FAULTY ENGINE DESIGN. THE CONSUMER ALSO STATES THAT INNER TUBE WAS FOUND IN SUPPOSEDLY TUBELESS TIRE WHEN THE TIRE BECAME FLAT.
NHTSA complaint #877707 — an unverified report by a vehicle owner.