Owners have filed 955 complaints
about the 2005 Honda Pilot with NHTSA between 2005 and 2026.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 3 of 24 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 88
Against the median year of the Honda Pilot. 50 means typical for this
model; 100 means roughly double.
Severity — 68
13.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 14
8% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
212.6%
1,000 – 9,999 miles
121.5%
10,000 – 24,999 miles
121.5%
25,000 – 49,999 miles
445.4%
50,000 – 74,999 miles
12114.8%
75,000 – 99,999 miles
15418.8%
100,000 – 149,999 miles
28434.7%
150,000+ miles
17020.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2005peak 32Jun 2026
NHTSA investigations into the 2005 Honda Pilot
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
EA15001Opened 24 Feb 2015Still openAIR BAGS:FRONTAL
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS:FRONTAL
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
EA13002Opened 21 Feb 2013Closed 29 Mar 2013ELECTRONIC STABILITY CONTROL
Vehicle Stability Assist Malfunction
On March 14, 2013, American Honda Motor Co., Inc. (Honda) submitted a Defect Information Report to NHTSA identifying a defect in the Vehicle Stability Assist (VSA) system in approximately 183,576 model year (MY) 2005 Honda Pilot, Acura RL and MY 2005-2006 Acura MDX vehicles (NHTSA Recall No 13V-092).The population and failure counts provided pertain only to the MY 2005 Honda Pilots that were the subject of this investigation.Honda's recall addresses two conditions in the VSA system that could result in inappropriate brake activation.The first condition is related to a manufacturing concern wit...
PE12028Opened 9 Oct 2012Closed 15 Mar 2013SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE
Vehicle Stability Assist Malfunction
The Vehicle Stability Assist (VSA) system in the model year (MY) 2005 Honda Pilot vehicles integrates braking control strategies for anti-lock braking, traction control, electronic stability control and brake assist functions. The system consists of a VSA modulator (an electronic control unit and electronic/hydraulic actuator) that receives data from an integral brake pressure sensor and from wheel speed sensors (four wheels), the steering wheel angle sensor and a combination yaw rate and lateral acceleration sensor.Allegations of unexpected braking appear to be related to inappropriate activa...
DP12002Opened 4 Jun 2012Closed 11 Oct 2012ELECTRONIC STABILITY CONTROL
Vehicle Stability Assist Malfunction
In a letter dated April 9, 2012, a consumer petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged stability control failures in model year (MY) 2005 Honda Pilot vehicles. The petitioner alleged that, in the malfunctioning of these systems, steering failures occur and the brakes apply involuntarily. On June 4, 2012 the Office of Defects Investigation (ODI) opened Defect Petition DP12-002 to evaluate whether to grant or deny the petition. The petition is hereby granted. The Vehicle Stability Assist (VSA) system in the MY 2005 Honda Pi...
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data sh...
Recalls on the 2005 Honda Pilot
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
19E068000
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL
Dorman Products, Inc. (Dorman) is recalling certain Accelerator Pedal Assemblies part numbers 699-114 and 825-5029-1, sold as replacement parts for 2003-2006 Acura MDX, 2004-2008 Acura TL and TSX, 2003-2007 Honda Accord, 2005-2006 Honda CR-V, 2007-2011 Honda Element, 2005-2008 Honda Pilot and 2006-2014 Honda Ridgeline vehicles. The rotating portion of the accelerator pedal assembly may bind. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 124, "Accelerator Control Systems."
Risk: If the accelerator pedal binds, the engine may not quickly return to idle after the pedal is no longer pressed, increasing the risk of a crash.
19V501000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V499000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V182000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.
Risk: An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.
18V268000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.
Risk: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.
17V029000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2011 Honda Element vehicles, 2005-2012 Acura RL vehicles, 2006-2012 Honda Ridgeline vehicles, 2007-2008 Honda Fit vehicles and 2005-2008 Honda Pilot vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles, 2005-2009 Acura RL and Honda Element vehicles, 2007-2008 Honda Fit vehicles, 2005-2008 Honda Pilot vehicles and 2006-2009 Honda Ridgeline vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone A" or "Zone B" above, Honda is recalling certain 2005-2006 Acura MDX and Honda CR-V vehicles
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
16V344000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda El
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
15V320000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201911783,977 units in Canada
Airbag
Issue: On certain vehicles, there could be a problem with the driver-front airbag inflator. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, pieces could be propelled toward the occupants. This could also cause damage to the airbag assembly and prevent it from inflating properly. Note: This recall only affects certain vehicles that had a Takata airbag inflator installed during a previous airbag recall or collision repair. Safety Risk: In a crash where the airbag deploys, there could be an increased risk of injury. Corrective Action: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to have the driver-front airbag inflator replaced.
Recall 2017009428,641 units in Canada
Airbag
On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the passenger frontal airbag inflator. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Dealers will replace the passenger frontal airbag inflator. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected.
Recall 2015225704,770 units in Canada
Airbag
On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall supersedes special service campaign 2014567. Correction: Dealers will inspect/replace the driver's frontal airbag inflator. All vehicles having received a replacement inflator as part of any previous driver's inflator campaign will have a replacement inflator installed. Note: Honda Canada has created a special Airbag Inflator Hotline for immediate assistance. For more information, please contact: For Honda Owners: 1-877-445-7754 For Acura Owners: 1-877-445-9844
Recall 2014567704,770 units in Canada
Airbag
Honda Canada is conducting a voluntary Safety Improvement Campaign concerning the driver's airbag inflator on certain vehicles equipped with Takata airbags. Honda will replace the driver's inflator on affected vehicles. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This special service campaign was replaced by recall 2015225. Please see recall 2015225 for more information: <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015225">Click here for more information</a>
Recall 20130787,794 units in Canada
Brakes
Certain vehicles may experience a malfunction of the Vehicle Stability Assist (VSA) system, which could apply a small amount of brake force for a fraction of a second, even if the brake pedal has not been depressed. If the driver applies the brakes during a malfunction, the VSA system may employ the brake assist feature, which would increase braking force, exceeding the driver’s intended input. In either instance, an unexpected and unnecessary brake application could increase the risk of a crash causing property damage and/or personal injury. Correction: Dealers will install a partial wiring harness containing a capacitor for the VSA modulator.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 150,000 milesRichmond, CACrash1 injured
AIR BAGS
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.
NHTSA complaint #11695419 — an unverified report by a vehicle owner.
at 150,000 milesRichmond, CACrash1 injured
VEHICLE SPEED CONTROL
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.
NHTSA complaint #11695419 — an unverified report by a vehicle owner.
at 150,000 milesRichmond, CACrash1 injured
SERVICE BRAKES
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.
NHTSA complaint #11695419 — an unverified report by a vehicle owner.
Susquehanna, PACrash
SUSPENSION
The rear subframe attaches to the unibody has rotted and almost fell off the car
NHTSA complaint #11527807 — an unverified report by a vehicle owner.
Oxnard, CAFire
ELECTRICAL SYSTEM
I parked my car in front of my house at 10pm the following morning my neighbor came to tell me my car was on fire. It had been raining the previous night. My driver window was not completely closed so rain got in my car. There was black smoke coming out of the window. When I opened my door, the driver seat & driver door was on fire. I grabbed the hose & put out the fire.
NHTSA complaint #11495975 — an unverified report by a vehicle owner.
at 290,000 milesBluffton, SCCrash
EXTERIOR LIGHTING
The contact owns a 2005 Honda Pilot. The contact stated while driving at 20 MPH, the low beams of the vehicle went out inadvertently, almost causing the contact to crash into another vehicle that was coming from the opposite direction. There were no warning lights illuminated. The contact stated she turned on her high beams and was able to continue to drive the vehicle. The vehicle was taken to the independent mechanic who diagnosed that the terminal ends had melted within the wiring harness connector and the wiring harness connector or the lighting switch needed to be replaced. An unknown dealer was notified of the failure and informed the contact that her vehicle could not be repaired under the recall for NHTSA Campaign Number: 12V136000 (EXTERIOR LIGHTING) as her VIN was not included in the recall. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 290,000.
NHTSA complaint #11436668 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Huntington Station, NY
STEERING
A stuck ignition lock cylinder on a 2005 Honda Pilot. Hello I purchased this car from the second owner and they had the ignition lock replaced less than 2 years ago. This device has now failed again. Its a poor design by honda and was never fixed or recalled. This has lead countless people to be stranded. With repairs upwords of $500.
NHTSA complaint #11744233 — an unverified report by a vehicle owner.
Winfield, KS
STEERING
Power steering high pressure line leaking on exhaust and almost caused fire Dangerous. Lines need to be recall or replace
NHTSA complaint #11708565 — an unverified report by a vehicle owner.
at 150,000 milesRichmond, CACrash1 injured
AIR BAGS
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.
NHTSA complaint #11695419 — an unverified report by a vehicle owner.
at 150,000 milesRichmond, CACrash1 injured
VEHICLE SPEED CONTROL
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.
NHTSA complaint #11695419 — an unverified report by a vehicle owner.
at 150,000 milesRichmond, CACrash1 injured
SERVICE BRAKES
The contact owns a 2005 Honda Pilot. The contact stated that shortly after refueling, the vehicle suddenly experienced unintended acceleration, causing the speed to increase to approximately 45 MPH while approaching stopped traffic. While pressing the brake pedal to avoid a collision, the vehicle continued to accelerate and crashed into the rear of a second vehicle. During the air bag deployment, the air was deflated, causing the driver's head to contact the steering wheel. Also, the contact indicated that metal fragments were present during the air bag deployment. The contact sustained a lacerated left wrist and lacerations to the chest area. The driver also sustained contusions and bruised to the head, ankles, and legs, along with neck and back stiffness, which will all require medical treatment. No other injuries were known regarding the second vehicle occupants. A Police Report was taken at the scene, and the vehicle was towed away. The cause of the failures was not determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was 150,000.
NHTSA complaint #11695419 — an unverified report by a vehicle owner.
at 173,273 milesApex, NC
STEERING
The contact owns a 2005 Honda Pilot. The contact stated that while driving 25-35 MPH, the vehicle slowed down unexpectedly, and the brake pedal was hard and slow to respond when depressed. The contact stated that the steering wheel was pulling to the left, and it was difficult to correct the steering wheel. The vehicle was difficult to control. The VSA light was illuminated. There was a triangle with an exclamation mark symbol displayed on the instrument cluster. The vehicle was taken to the local dealer, where it was diagnosed and determined that the VSA module had failed and needed to be replaced. The vehicle was not repaired because the parts were on backorder. The manufacturer was not notified of the failure. The approximate failure mileage was 173,273.
NHTSA complaint #11691189 — an unverified report by a vehicle owner.
at 173,273 milesApex, NC
SERVICE BRAKES, HYDRAULIC
The contact owns a 2005 Honda Pilot. The contact stated that while driving 25-35 MPH, the vehicle slowed down unexpectedly, and the brake pedal was hard and slow to respond when depressed. The contact stated that the steering wheel was pulling to the left, and it was difficult to correct the steering wheel. The vehicle was difficult to control. The VSA light was illuminated. There was a triangle with an exclamation mark symbol displayed on the instrument cluster. The vehicle was taken to the local dealer, where it was diagnosed and determined that the VSA module had failed and needed to be replaced. The vehicle was not repaired because the parts were on backorder. The manufacturer was not notified of the failure. The approximate failure mileage was 173,273.
NHTSA complaint #11691189 — an unverified report by a vehicle owner.
at 173,273 milesApex, NC
ELECTRONIC STABILITY CONTROL (ESC)
The contact owns a 2005 Honda Pilot. The contact stated that while driving 25-35 MPH, the vehicle slowed down unexpectedly, and the brake pedal was hard and slow to respond when depressed. The contact stated that the steering wheel was pulling to the left, and it was difficult to correct the steering wheel. The vehicle was difficult to control. The VSA light was illuminated. There was a triangle with an exclamation mark symbol displayed on the instrument cluster. The vehicle was taken to the local dealer, where it was diagnosed and determined that the VSA module had failed and needed to be replaced. The vehicle was not repaired because the parts were on backorder. The manufacturer was not notified of the failure. The approximate failure mileage was 173,273.
NHTSA complaint #11691189 — an unverified report by a vehicle owner.
Cedar Falls, IA
SUSPENSION
The rear trailing arm, normally attached to the rear suspension is clearly corroded and came detached when driving under 25 mph up a road. The SAME issue Honda had to do a recall on their 2005 CRV model. Researched Honda Pilots, in our (Midwest) area, EVERY SINGLE 2005 Pilot had the corrosion. Also cause the muffler pipe to detach from the catalytic converter (included in the photos attached).
NHTSA complaint #11628163 — an unverified report by a vehicle owner.
Colleyville, TX
SEATS
I was leaning back looking backwards while reversing and the front left seat bracket on the driver’s seat cracked and separated resulting in my seat turning into a rocking chair and my feet coming off of the pedals. It could have ended in an accident.
NHTSA complaint #11618909 — an unverified report by a vehicle owner.
Blacksburg, VA
AIR BAGS
Airbag is deactivated due to failure of both crash sensors on the vehicle. Replacement parts are on national backorder.
NHTSA complaint #11577511 — an unverified report by a vehicle owner.
Blacksburg, VA
ELECTRICAL SYSTEM
Airbag is deactivated due to failure of both crash sensors on the vehicle. Replacement parts are on national backorder.
NHTSA complaint #11577511 — an unverified report by a vehicle owner.
Palatine, IL
UNKNOWN OR OTHER
The rear suspension got detached from a collapsed/rusted Frame. Item # 11 Sub-Frame, Rear Suspension Part # 50300-S9V-A01 The suspension is rubbing against the rear tires since the Bolt Flange (14x125 item# 14 part # 90160-S0X-A00) can’t be supported by the rusted/ collapsed Frame affecting the rest of suspension parts item # 12 washer E subframe part# 50354-S3V-A00 and item#13 part# 50456-S3V-A00 Washer F subframe Mounting.
NHTSA complaint #11574041 — an unverified report by a vehicle owner.
Palatine, IL
SUSPENSION
The rear suspension got detached from a collapsed/rusted Frame. Item # 11 Sub-Frame, Rear Suspension Part # 50300-S9V-A01 The suspension is rubbing against the rear tires since the Bolt Flange (14x125 item# 14 part # 90160-S0X-A00) can’t be supported by the rusted/ collapsed Frame affecting the rest of suspension parts item # 12 washer E subframe part# 50354-S3V-A00 and item#13 part# 50456-S3V-A00 Washer F subframe Mounting.
NHTSA complaint #11574041 — an unverified report by a vehicle owner.
at 220,000 milesMagnolia, DE
EXTERIOR LIGHTING
The contact owns a 2005 Honda Pilot. The contact stated that while waiting in line at a gas station, she smelled a burning odor, and there was smoke coming from the steering wheel. The contact was turned off and restarted the vehicle. The contact stated that upon activating the low-beam headlights, the failure reoccurred. The contact stated that upon restarting the vehicle without activating the low-beam headlights, the steering wheel stopped smoking. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 12V136000 (Exterior Lighting). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was approximately 220,000.
NHTSA complaint #11557678 — an unverified report by a vehicle owner.
Susquehanna, PACrash
SUSPENSION
The rear subframe attaches to the unibody has rotted and almost fell off the car
NHTSA complaint #11527807 — an unverified report by a vehicle owner.
Jeffersonville, IN
SEATS
The drivers side seat bracket has a broken weld causing the seat to wobble & rock while driving the vehicle. From the Pilot Driver’s online forum it’s been known as a common complaint that Honda is not willing to confess to or interested in resolving as a safety design flaw as it seems to be related to multiple yrs 2004 & up of the Pilot vehicle & happens over time.
NHTSA complaint #11527465 — an unverified report by a vehicle owner.
Riverside, CA
ELECTRICAL SYSTEM:IGNITION
Ignition switch locked will not turn.
NHTSA complaint #11522276 — an unverified report by a vehicle owner.
at 149,000 milesRoseville, CA
POWER TRAIN
The contact owns a 2005 Honda Pilot. The contact stated while driving at various speeds on several occasions, there was a cranking sound coming from underneath the vehicle. No warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic, where it was diagnosed that several unknown components needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the vehicle was towed to another independent mechanic, where it was diagnosed that the shocks, control arms, drive train and other unknown components needed to be replaced. The contact referenced the failure to NHTSA Campaign Number: 23V228000 (Structure); however, neither the VIN nor the year, make, or model was included. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 149,000.
NHTSA complaint #11519514 — an unverified report by a vehicle owner.
at 149,000 milesRoseville, CA
SUSPENSION
The contact owns a 2005 Honda Pilot. The contact stated while driving at various speeds on several occasions, there was a cranking sound coming from underneath the vehicle. No warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic, where it was diagnosed that several unknown components needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that the vehicle was towed to another independent mechanic, where it was diagnosed that the shocks, control arms, drive train and other unknown components needed to be replaced. The contact referenced the failure to NHTSA Campaign Number: 23V228000 (Structure); however, neither the VIN nor the year, make, or model was included. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 149,000.
NHTSA complaint #11519514 — an unverified report by a vehicle owner.
Jeffersonville, IN
SUSPENSION
My Honda pilot has rust on one of the subframe mounts causing it to come loose from body. Honda issued a technical service bulletin about it for an investigation from nhtsa. But, the dealer is acting like there is no such thing with the known issue and repair kit they made to fix the issue. I will attach the service bulletin below to about the issue of what Honda put out supposedly to fix the problem. They keep saying this bulletin does not exist for my vehicle but the bulletin states all years not VIN specific.
NHTSA complaint #11518827 — an unverified report by a vehicle owner.
Gallatin, TN
EXTERIOR LIGHTING
Was traveling down the road, had an electrical burning smell coming from my dash and around steering wheel. Low beams then shut off going down road pulled over but still had high beams but no low beams.
NHTSA complaint #11510523 — an unverified report by a vehicle owner.
Gallatin, TN
ELECTRICAL SYSTEM
Was traveling down the road, had an electrical burning smell coming from my dash and around steering wheel. Low beams then shut off going down road pulled over but still had high beams but no low beams.
NHTSA complaint #11510523 — an unverified report by a vehicle owner.
Oxnard, CAFire
ELECTRICAL SYSTEM
I parked my car in front of my house at 10pm the following morning my neighbor came to tell me my car was on fire. It had been raining the previous night. My driver window was not completely closed so rain got in my car. There was black smoke coming out of the window. When I opened my door, the driver seat & driver door was on fire. I grabbed the hose & put out the fire.
NHTSA complaint #11495975 — an unverified report by a vehicle owner.
Vacaville, CA
UNKNOWN OR OTHER
My vsa light came on when I was on the freeway and made my vehicle jerk almost pushing me into the next lane. It has been coming on and turns off when I restart the car and other cars of my same modal and year have recalls for this same issue but my vin yields no results for a recall.
NHTSA complaint #11469249 — an unverified report by a vehicle owner.