Owners have filed 644 complaints
about the 2004 Honda Pilot with NHTSA between 2004 and 2025.
The largest single group is the transmission & drivetrain.
Across this model's run it ranks 9 of 24 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 59
Against the median year of the Honda Pilot. 50 means typical for this
model; 100 means roughly double.
Severity — 78
15.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 19
11% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Automatic Transmission
4442.7%
Body
2928.2%
Engine
87.8%
Seat Heater/Cooler
65.8%
Ignition
54.9%
Accelerator Pedal
43.9%
Tank Assembly
43.9%
Rear/Other
32.9%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
142.9%
1,000 – 9,999 miles
112.3%
10,000 – 24,999 miles
173.5%
25,000 – 49,999 miles
336.8%
50,000 – 74,999 miles
6212.8%
75,000 – 99,999 miles
8016.5%
100,000 – 149,999 miles
15231.3%
150,000+ miles
11623.9%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2004peak 14Aug 2025
NHTSA investigations into the 2004 Honda Pilot
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.C...
EA15001Opened 24 Feb 2015Still openAIR BAGS:FRONTAL
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE14016Opened 11 Jun 2014Closed 2 Mar 2015AIR BAGS:FRONTAL
Air Bag Inflator Rupture
The Office of Defects Investigation (ODI) opened PE14-016 in June 2014 based on six inflator rupture incidents involving consumer owned vehicles produced by five vehicle manufacturers.All six vehicles were operated in Florida or Puerto Rico at the time of the rupture and for the majority of their service life, and were equipped with inflators produced by Takata, a tier-one supplier of automotive air bag systems.During the course of PE14-016, ODI determined that five additional vehicle manufacturers used inflators of a similar design and vintage also supplied by Takata. No evidence of field fai...
PE12026Opened 2 Oct 2012Closed 14 Jan 2013ELECTRICAL SYSTEM:IGNITION
Ignition Interlock Failure - Rollaway
On December 10, 2012, Honda Motor Company submitted a defect information report to NHTSA regarding ignition interlocks in approximately 576,117 model year MY) 2003 through 2004 Honda Pilot and Odyssey vehicles that are the subject of this investigation and 231,044 MY 2003 through 2006 Acura MDX vehicles (Recall No. 12V-573).Honda's report states that a design change to the ignition switch used in the recalled vehicles reduced the range of rotation for the ignition switch from 160 degrees in earlier designs to 125 degrees without a corresponding change to the ignition interlock blocking mechani...
This investigation was prompted by Preliminary Evaluation (PE) 11-017, and was based on reports from consumers alleging that both low beam headlights stopped illuminating simultaneously.Some complainants also reported that the combination switch (switch) that controls the headlights and turn signals, and/or its electrical wiring harness connector were damaged by overheating.ODI's PE information request letter asked Honda for certain data on model years (MY) 2002-2006 CR-V, 2003-2008 Pilot, 2003-2008 Element, 2001-2005 Civic, and 2000-2001 S 2000 vehicles.Analysis of complaint and Honda data sh...
Recalls on the 2004 Honda Pilot
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
19V501000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2003-2006 Acura MDX, 2005-2012 RL, 2003-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2007-2008 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V499000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2003 Acura 3.2CL, 2002-2003 3.2TL, 2003-2006 MDX, 2001-2007 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot and 2006 Ridgeline vehicles. These vehicles are equipped with driver frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Risk: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
19V182000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling specific 2003 Acura 3.2CL, 2013-2016 ILX, 2013-2014 ILX Hybrid, 2003-2006 MDX, 2007-2016 RDX, 2002-2003 3.2TL, 2004-2006, and 2009-2014 TL, 2010-2013 ZDX and 2001-2007 and 2009 Honda Accord, 2001-2005 Civic, 2003-2005 Civic Hybrid, 2001-2005 Civic GX NGV, 2002-2007 and 2010-2011 CR-V, 2003-2011 Element, 2007 Fit, 2002-2004 Odyssey, 2003-2008 Pilot, and 2006-2014 Ridgeline vehicles. The affected vehicles received a replacement driver air bag inflator as part of a previous Takata inflator recall remedy or a replacement driver air bag module containing the same inflator type as a service part. Due to a manufacturing error, in the event of a crash necessitating deployment of the driver frontal air bag, these inflators may explode.
Risk: An explosion of an inflator within the driver frontal air bag module may result in sharp metal fragments striking the driver, front seat passenger or other occupants resulting in serious injury or death.
18V268000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain 2003-2012 Honda Accord and Pilot, 2010 Accord Crosstour, 2001-2011 Civic, 2002-2011 CR-V, 2003-2004, 2006-2008 and 2011 Element, 2007 and 2009-2013 Fit, 2010-2012 Insight, 2002-2004 Odyssey, and 2012 Ridgeline vehicles. The front passenger air bag may have been installed incorrectly during replacement.
Risk: An incorrectly installed air bag may deploy improperly in the event of a crash, increasing the risk of injury.
16V344000
AIR BAGS:FRONTAL:PASSENGER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain model year 2003-2006 Acura MDX, 2005-2011 Acura RL, 2005-2006 Honda CR-V, 2003-2011 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2011 Ridgeline vehicles originally sold, or that have ever been registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Honda is recalling certain model year 2003-2006 Acura MDX, 2005-2008 Acura RL, 2005-2006 Honda CR-V, 2003-2008 Element, 2007-2008 Fit, 2003-2008 Pilot, 2002-2004 Odyssey, and 2006-2008 Ridgeline vehicles originally sold, or that have ever been registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Lastly, unless included in "Zone A" or "Zone B" above, Honda is recalling model year 2002-2004 Odyssey and model year 2003-2004 Acura MDX, Honda El
Risk: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
15V320000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Honda (American Honda Motor Co.) is recalling certain model year 2001-2007 Accord, 2001-2005 Civic, 2001-2004 Honda Civic GX, 2003-2005 Honda Civic Hybrid, 2002-2006 CR-V, 2003-2011 Element, 2002-2004 Odyssey, 2003-2008 Pilot, 2006 Ridgeline, 2003 Acura 3.2CL, 2003-2006 Acura MDX, and 2002-2003 Acura 3.2TL vehicles. The affected vehicles are equipped with a dual-stage driver frontal air bag that may be susceptible to moisture intrusion and other factors, including manufacturing variability that, over time, could cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
14V700000
AIR BAGS
American Honda Motor Co. (Honda) is recalling certain model year 2001-2005 Honda Civic, 2003-2004 Civic CNG and Element, 2002-2005 CR-V, 2002-2004 Odyssey, 2003-2005 Accord, Pilot, Civic Hybrid, and Acura MDX, 2005 Acura RL and 2006 Honda Ridgeline vehicles originally sold, or ever registered, in geographic locations associated with high absolute humidity. Specifically, vehicles sold, or ever registered, in Alabama, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, U.S. Virgin Islands, Saipan, Guam, and American Samoa are addressed by this recall. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
14V353000
AIR BAGS
American Honda Motor Company, Inc.'s (Honda) is conducting a limited regional recall for certain model year 2003-2005 Accord, Civic, CR-V, Pilot and Acura MDX, model year 2003-2004 Odyssey and Element, and model year 2005 Acura RL, and 2006 Honda Ridgeline vehicles originally sold, or ever registered in California, and equipped with Takata-brand air bag inflators. Upon deployment of the passenger side frontal air bag, excessive internal pressure may cause the inflator to rupture.
Risk: In the event of a crash necessitating deployment of the passengers frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 201911783,977 units in Canada
Airbag
Issue: On certain vehicles, there could be a problem with the driver-front airbag inflator. This could cause the airbag to deploy with more force than normal. If the airbag inflator ruptures, pieces could be propelled toward the occupants. This could also cause damage to the airbag assembly and prevent it from inflating properly. Note: This recall only affects certain vehicles that had a Takata airbag inflator installed during a previous airbag recall or collision repair. Safety Risk: In a crash where the airbag deploys, there could be an increased risk of injury. Corrective Action: The company will notify owners by mail. Owners will be instructed to take their vehicle to a dealer to have the driver-front airbag inflator replaced.
Recall 201624928,929 units in Canada
Airbag
On certain vehicles, long-term exposure to high absolute humidity and temperature, combined with high temperature cycling, could eventually degrade the propellant contained in the passenger frontal airbag. This could cause the airbag to deploy with more force than normal. As a result, if the vehicle were involved in a collision that warrants airbag deployment, fragments could be propelled toward vehicle occupants, and the airbag assembly could be damaged, preventing proper function. These issues could increase the risk of injury. Correction: Dealers will replace the airbag inflator. Note: Canadian climate results in the propellant degrading slowly. The recall is being conducted as a precaution to address future risk, and is expected to replace airbag inflators before their function would be affected.
Recall 2015225704,770 units in Canada
Airbag
On certain vehicles, the driver frontal airbag inflator could produce excessive internal pressure during airbag deployment. Increased pressure may cause the inflator to rupture, which could allow fragments to be propelled toward vehicle occupants, increasing the risk of injury. This could also damage the airbag module, which could prevent proper deployment. Failure of the airbag to fully deploy during a crash (where deployment is warranted) could increase the risk of personal injury to the seat occupant. Note: This recall supersedes special service campaign 2014567. Correction: Dealers will inspect/replace the driver's frontal airbag inflator. All vehicles having received a replacement inflator as part of any previous driver's inflator campaign will have a replacement inflator installed. Note: Honda Canada has created a special Airbag Inflator Hotline for immediate assistance. For more information, please contact: For Honda Owners: 1-877-445-7754 For Acura Owners: 1-877-445-9844
Recall 2014567704,770 units in Canada
Airbag
Honda Canada is conducting a voluntary Safety Improvement Campaign concerning the driver's airbag inflator on certain vehicles equipped with Takata airbags. Honda will replace the driver's inflator on affected vehicles. This action is not being conducted under the requirements of the Motor Vehicle Safety Act. Note: This special service campaign was replaced by recall 2015225. Please see recall 2015225 for more information: <a href="http://wwwapps.tc.gc.ca/Saf-Sec-Sur/7/VRDB-BDRV/search-recherche/detail.aspx?lang=eng&&rn=2015225">Click here for more information</a>
Recall 201241552,441 units in Canada
Powertrain
On certain vehicles, the ignition interlock blocking mechanism could become damaged if excessive force is applied to the ignition key. If this occurs, it may become possible for the driver to remove the ignition key when the gear selector is in a position other than the Park position. This could allow the vehicle to roll away, increasing the risk of a crash causing personal injury and/or damage to property. Correction: Dealers will install an updated ignition interlock lever and replace the ignition lock cylinder if necessary.
Recall 200414385,184 units in Canada
Powertrain
Certain operating conditions can result in heat build-up between the countershaft and secondary shaft second gears in the automatic transmission, eventually leading to gear tooth chipping or, in very rare cases, gear breakage can occur. Gear failure could result in transmission lock-up. Correction: On vehicles with 24 000 kms or less, the dealer will update the transmission with a simple revision to the oil cooler return line to increase lubrication to second gear. On vehicles with more than 24 000 kms, the dealer will inspect the transmission to identify gears that have already experienced discoloration due to overheating. If discolouration exists, the transmission will be replaced. If discolouration is not present, the dealer will perform the revision to the oil cooler return line.
Reports where the owner recorded a crash, a fire, an injury or a death.
Durham, NCCrash
WHEELS
The steering became extremely loose over time on my Honda Pilot posing significant safety concerns because of it. The tires adamantly follow all the divets, lines, grooves, and bumps in the road causing me to lose control of the vehicle very easily in poor driving conditions. This is especially exaggerated during inclement weather such as snow or rain. Recently, due to the steering looseness, I lost control of the vehicle and hit a mailbox damaging the entire right side of the vehicle. Please help to work with Honda to resolve this issue. Thank you!
NHTSA complaint #11664243 — an unverified report by a vehicle owner.
Durham, NCCrash
STEERING
The steering became extremely loose over time on my Honda Pilot posing significant safety concerns because of it. The tires adamantly follow all the divets, lines, grooves, and bumps in the road causing me to lose control of the vehicle very easily in poor driving conditions. This is especially exaggerated during inclement weather such as snow or rain. Recently, due to the steering looseness, I lost control of the vehicle and hit a mailbox damaging the entire right side of the vehicle. Please help to work with Honda to resolve this issue. Thank you!
NHTSA complaint #11664243 — an unverified report by a vehicle owner.
Durham, NCCrash
SUSPENSION
The steering became extremely loose over time on my Honda Pilot posing significant safety concerns because of it. The tires adamantly follow all the divets, lines, grooves, and bumps in the road causing me to lose control of the vehicle very easily in poor driving conditions. This is especially exaggerated during inclement weather such as snow or rain. Recently, due to the steering looseness, I lost control of the vehicle and hit a mailbox damaging the entire right side of the vehicle. Please help to work with Honda to resolve this issue. Thank you!
NHTSA complaint #11664243 — an unverified report by a vehicle owner.
at 116,000 milesMonte Sereno, CA1 injured
AIR BAGS
PASSENGER SIDE AIRBAG DEPLOYED WHILE VEHICLE IN OPERATION. MY HUSBAND WAS DRIVING ON THE FREEWAY, 65 MPH, NO IMPACT, NOTHING HIT OUR CAR, NO REASON. I WAS SITTING IN PASSENGER SEAT. THE AIRBAG BLEW, SOME BURNING AND BRUISING TO MY ARM, EAR IS RINGING. NO REASON FOR THE AIRBAG TO DEPLOY! VERY DANGEROUS. CALLED HONDA, CAR [XXX]. WE'VE HAD OUR FRONT AIRBAGS RECALLED. DO THE SIDES HAVE PROBLEMS TOO? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11324575 — an unverified report by a vehicle owner.
at 183,559 milesWhittier, CA2 injured
STRUCTURE:BODY
WHILE ON THE 605N FREEWAY CLOSE TO THE 10 FREEWAYSPLIT OUR ENTIRE SUNROOF WHICH THE GLASS AND COVER DITACHED FROM OUR VEHICLE AND FLEW OFF. LUCKILY THE CAR BEHIND WAS NOT HIT FROM WHAT I SEE IN THE RECORDING BUT WE CAN'T SEE IF IT FLEW ON THE OTHER SIDE OF THE FREEWAY. MY CHILDREN WERE SEATING IN THE MIDDLE ROW AND SMALL DEBRI HIT THEIR FACE. WE PULLED OVER TO THE EMERGENCY SIDE OF THE FREEWAY TO CHECK DAMAGE. ALL THAT'S LEFT FROM THE SUNROOF IS THE GLUE.
NHTSA complaint #11287897 — an unverified report by a vehicle owner.
at 183,559 milesWhittier, CA2 injured
VISIBILITY/WIPER
WHILE ON THE 605N FREEWAY CLOSE TO THE 10 FREEWAYSPLIT OUR ENTIRE SUNROOF WHICH THE GLASS AND COVER DITACHED FROM OUR VEHICLE AND FLEW OFF. LUCKILY THE CAR BEHIND WAS NOT HIT FROM WHAT I SEE IN THE RECORDING BUT WE CAN'T SEE IF IT FLEW ON THE OTHER SIDE OF THE FREEWAY. MY CHILDREN WERE SEATING IN THE MIDDLE ROW AND SMALL DEBRI HIT THEIR FACE. WE PULLED OVER TO THE EMERGENCY SIDE OF THE FREEWAY TO CHECK DAMAGE. ALL THAT'S LEFT FROM THE SUNROOF IS THE GLUE.
NHTSA complaint #11287897 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Kansas City, MO
SUSPENSION
Honda sold America cars that they knew were rusted less than five years and they still letting people drive these cars that are rusted at the bottom
NHTSA complaint #11679046 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2004 Honda Pilot. The contact stated that at the time of purchase, the odometer mileage reading was 160,000. After obtaining a Carfax Report it was discovered that the previous mileage was 337,000. The contact also indicated that the instrument cluster had been replaced and the air bag and check engine warning lights were inoperable, and the driver’s side air bag had been removed from the vehicle. The VIN was not available.
NHTSA complaint #11679076 — an unverified report by a vehicle owner.
Durham, NCCrash
WHEELS
The steering became extremely loose over time on my Honda Pilot posing significant safety concerns because of it. The tires adamantly follow all the divets, lines, grooves, and bumps in the road causing me to lose control of the vehicle very easily in poor driving conditions. This is especially exaggerated during inclement weather such as snow or rain. Recently, due to the steering looseness, I lost control of the vehicle and hit a mailbox damaging the entire right side of the vehicle. Please help to work with Honda to resolve this issue. Thank you!
NHTSA complaint #11664243 — an unverified report by a vehicle owner.
Durham, NCCrash
STEERING
The steering became extremely loose over time on my Honda Pilot posing significant safety concerns because of it. The tires adamantly follow all the divets, lines, grooves, and bumps in the road causing me to lose control of the vehicle very easily in poor driving conditions. This is especially exaggerated during inclement weather such as snow or rain. Recently, due to the steering looseness, I lost control of the vehicle and hit a mailbox damaging the entire right side of the vehicle. Please help to work with Honda to resolve this issue. Thank you!
NHTSA complaint #11664243 — an unverified report by a vehicle owner.
Durham, NCCrash
SUSPENSION
The steering became extremely loose over time on my Honda Pilot posing significant safety concerns because of it. The tires adamantly follow all the divets, lines, grooves, and bumps in the road causing me to lose control of the vehicle very easily in poor driving conditions. This is especially exaggerated during inclement weather such as snow or rain. Recently, due to the steering looseness, I lost control of the vehicle and hit a mailbox damaging the entire right side of the vehicle. Please help to work with Honda to resolve this issue. Thank you!
NHTSA complaint #11664243 — an unverified report by a vehicle owner.
Odometer Fraud. The contact purchased a 2004 Honda Pilot. The contact stated that while attempting to register the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase September 2024, the vehicle mileage was 139,020. The contact stated that after a mechanic had informed the contact that the frame was severely rusted, the contact retrieved the Carfax report history of the vehicle and discovered that the vehicle mileage was 196,000 on August 11, 2018.
NHTSA complaint #11659679 — an unverified report by a vehicle owner.
DES Moines, IA
UNKNOWN OR OTHER
When I took my car for tire installation at Walmart on [XXX] , the technician declined to install the tires, he stated "your vehicle is unsafe to lift up for tire installation because of rust". I was on my driving it to a body shop when something snapped near the right rear tire after I hit pot holes. I felt it was unsafe to continue I decided to drive it slowly back home and parked it. I fear to drive it again to avoid causing accidents to myself and to other motorists. The car engine runs good and there are no problem lights on my car dashboard. The car interior is still good. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11647498 — an unverified report by a vehicle owner.
Nipomo, CA
ELECTRICAL SYSTEM:IGNITION
The contact owns a 2004 Honda Pilot. The contact stated that while attempting to start the vehicle, the ignition briefly failed to turn. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown. The VIN was not available.
NHTSA complaint #11574322 — an unverified report by a vehicle owner.
at 125,000 milesSeattle, WA
SEAT BELTS:FRONT:RETRACTOR
The contact owns a 2004 Honda Pilot. The contact stated while the vehicle was parked, the contact entered the vehicle and the front passenger attempted to secure the seat belt however, the seat belt failed to retract. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was 125,000.
NHTSA complaint #11567823 — an unverified report by a vehicle owner.
Austin, TX
SEATS
I heard a loud pop come from under my driver's seat and the seat started rocking backwards. I got out of my car and checked underneath the seat. The front-left bracket securing the seat to the seat frame had completely sheared in half and the seat was no longer securely attached to the seat frame. This is a significant safety issue. When the car accelerates the driver's seat rocks backwards by ~45 degrees, making it extremely difficult to stay in control of the vehicle and safely steer the vehicle. It is also extremely unsafe in the case of an accident because A) the seat would not hold the driver securely in place, B) the driver would not be properly in position and restrained for the air bags to deploy, C) the seat belt is attached to the seat base and would not be able to fully function properly, and D) any passengers sitting in the 2nd row behind the driver's seat would be in danger of having the full force of the driver and the driver's seat slamming back against them. This is a known issue widely reported in Honda Pilot owners' forums. Yet Honda has not issued a recall. I took the vehicle into a Honda dealership to inspect the issue. They said that Honda no longer makes the part that would be required to fix this safety issue. This issue affects all 2003-2008 model year Honda Pilots. There were over 800,000 2003-2008 model year pilots sold and because of Honda vehicle's longevity there is a massive number of these vehicles still on the roads.
NHTSA complaint #11563917 — an unverified report by a vehicle owner.
Austin, TX
SEAT BELTS
I heard a loud pop come from under my driver's seat and the seat started rocking backwards. I got out of my car and checked underneath the seat. The front-left bracket securing the seat to the seat frame had completely sheared in half and the seat was no longer securely attached to the seat frame. This is a significant safety issue. When the car accelerates the driver's seat rocks backwards by ~45 degrees, making it extremely difficult to stay in control of the vehicle and safely steer the vehicle. It is also extremely unsafe in the case of an accident because A) the seat would not hold the driver securely in place, B) the driver would not be properly in position and restrained for the air bags to deploy, C) the seat belt is attached to the seat base and would not be able to fully function properly, and D) any passengers sitting in the 2nd row behind the driver's seat would be in danger of having the full force of the driver and the driver's seat slamming back against them. This is a known issue widely reported in Honda Pilot owners' forums. Yet Honda has not issued a recall. I took the vehicle into a Honda dealership to inspect the issue. They said that Honda no longer makes the part that would be required to fix this safety issue. This issue affects all 2003-2008 model year Honda Pilots. There were over 800,000 2003-2008 model year pilots sold and because of Honda vehicle's longevity there is a massive number of these vehicles still on the roads.
NHTSA complaint #11563917 — an unverified report by a vehicle owner.
Hollister, CA
AIR BAGS
AIR BAG WARNING LIGHT IS ACTIVATED. I TOOK MY 2004 HONDA PILOT WITH CALIFORNIA LICENSE PLATE NUMBER [XXX] TO THE HONDA DEALERSHIP IN HEMET CALIFORNIA ON DECEMBER 14 2022 TO CHECK THE AIR BAG SYSTEM. I WAS TOLD THERE WAS A $100.00 DIAGNOSTIC FEE BECAUSE THE REPAIR IS NOT COVERED UNDER THE AIRBAG RECALL PROGRAM. MY VEHICLE IS 20 YEARS OLD AND I'M WORRIED THE DRIVERS SIDE AIR BAG IS UNSAFE AND COULD BE ACCIDENTLY ACTIVATED AND CAUSE INJURY OR DEATH. MY VEHICLE HAS OVER 300,000 MILES. AS OF TODAY, SEPTEMBER 6, 2023, THE AIR BAG WARNING LAMP IS STILL ON. IS THE ACTIVATED AIR BAG WARNING LAMP COVERED UNDER THE AIR BAG RECALL PROGRAM? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11542991 — an unverified report by a vehicle owner.
Magnolia, DE
POWER TRAIN
Transmission locks up when vehicle has been driven for a short time
NHTSA complaint #11540740 — an unverified report by a vehicle owner.
Hollister, CA
AIR BAGS
AIR BAG WARNING LIGHT HAS BEEN ACTIVATED. THE HONDA DEALERSHIP CHARGES $100.00 TO DIAGNOSE THE CAUSE. I WAS TOLD IT'S NOT PART OF THE AIRBAG RECALL AND I WILL HAVE TO PAY. MY VEHICLE IS 20 YEARS OLD. I BELEIVE ANYTHING TO DO WITH AIRBAGS SHOULD BE COVERED BY THE RECALL. IN THE CASE OF AN AIRBAG ACTIVATION AND I AM INJURIED OR KILLED FROM A DEFECTIVE AIR BAG. I HAVE PROOF THAT THE HONDA DEALERSHIP WAS ADVISED ON DECEMBER 14, 2022. THE AIR BAG WARNING LIGHT HAS BEEN ON FOR SIX (6) MONTHS AND CANNOT GET IT CORRECTED.
NHTSA complaint #11523899 — an unverified report by a vehicle owner.
Newport, TN
SEATS
Brakes seem to stop suddenly Must brake slowly to avoid a sudden stop Seatbelt locks up if I do not pull it forward and leave room in the belt so that it isn't completely holding me in Also the driver seat will only adjust sideways.
NHTSA complaint #11522936 — an unverified report by a vehicle owner.
Newport, TN
SEAT BELTS
Brakes seem to stop suddenly Must brake slowly to avoid a sudden stop Seatbelt locks up if I do not pull it forward and leave room in the belt so that it isn't completely holding me in Also the driver seat will only adjust sideways.
NHTSA complaint #11522936 — an unverified report by a vehicle owner.
Newport, TN
SERVICE BRAKES
Brakes seem to stop suddenly Must brake slowly to avoid a sudden stop Seatbelt locks up if I do not pull it forward and leave room in the belt so that it isn't completely holding me in Also the driver seat will only adjust sideways.
NHTSA complaint #11522936 — an unverified report by a vehicle owner.
at 180,000 milesVidalia, GA
POWER TRAIN
The contact owns a 2004 Honda Pilot. The contact stated that while driving at 60 MPH, the transmission was shifted into drive(D) and the vehicle shuddered. The contact related the failure to NHTSA Campaign Number: 04V176000 (Power Train). The vehicle was taken to an independent mechanic, where the transmission fluid was flushed 3 times; however, the failure persisted. The contact stated that the failure recurred while the vehicle is shifted into drive(D) and D3. The manufacturer was not made aware of the failure. The failure mileage was approximately 180,000.
NHTSA complaint #11511628 — an unverified report by a vehicle owner.
Sioux Falls, SD
EXTERIOR LIGHTING
lights that illuminate the functions/buttons of the climate control system burned out
NHTSA complaint #11498240 — an unverified report by a vehicle owner.
Elkton, MD
SUSPENSION
Confirmed with local mechanic that the rear cross member of the sub-frame needs to be replaced immediately. Badly rusted and is a safety issue.
NHTSA complaint #11487723 — an unverified report by a vehicle owner.
Elkton, MD
STRUCTURE:BODY
Confirmed with local mechanic that the rear cross member of the sub-frame needs to be replaced immediately. Badly rusted and is a safety issue.
NHTSA complaint #11487723 — an unverified report by a vehicle owner.
Louisville, KY
SUSPENSION
I bought this 2004 Honda Pilot new in 2004 in Louisville. In 2018 I drove to Florida without incident. While here in Florida I have had a problem with oil leaking. Than the compressor for the air went out and I took it straight to the dealer here. They told me it was not worth fixing. Since then I have had 2 mechanics look underneath the car and said it was so rusted that the frame was dangerous and they could not risk fixing it. I have checked with other Honda owners only to find out this is a problem with numerous Honda years and no one fix this problems because of liability . I have photos of the rusted out rear-end and the frame is not attached. You can find owners trying to weld the rear-end back on. No one will repair my compressor because of the rust and damage. When I had it at the dealers they did not mention this problem at all. They just said it was not worth fixing. My car has about 200000 miles but has has its service. This has to be a major recall or replacement. We could have had a major accident over this and didn't know [XXX] Please call or forward communication. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11475588 — an unverified report by a vehicle owner.
Louisville, KY
ENGINE AND ENGINE COOLING
I bought this 2004 Honda Pilot new in 2004 in Louisville. In 2018 I drove to Florida without incident. While here in Florida I have had a problem with oil leaking. Than the compressor for the air went out and I took it straight to the dealer here. They told me it was not worth fixing. Since then I have had 2 mechanics look underneath the car and said it was so rusted that the frame was dangerous and they could not risk fixing it. I have checked with other Honda owners only to find out this is a problem with numerous Honda years and no one fix this problems because of liability . I have photos of the rusted out rear-end and the frame is not attached. You can find owners trying to weld the rear-end back on. No one will repair my compressor because of the rust and damage. When I had it at the dealers they did not mention this problem at all. They just said it was not worth fixing. My car has about 200000 miles but has has its service. This has to be a major recall or replacement. We could have had a major accident over this and didn't know [XXX] Please call or forward communication. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11475588 — an unverified report by a vehicle owner.
Louisville, KY
STRUCTURE
I bought this 2004 Honda Pilot new in 2004 in Louisville. In 2018 I drove to Florida without incident. While here in Florida I have had a problem with oil leaking. Than the compressor for the air went out and I took it straight to the dealer here. They told me it was not worth fixing. Since then I have had 2 mechanics look underneath the car and said it was so rusted that the frame was dangerous and they could not risk fixing it. I have checked with other Honda owners only to find out this is a problem with numerous Honda years and no one fix this problems because of liability . I have photos of the rusted out rear-end and the frame is not attached. You can find owners trying to weld the rear-end back on. No one will repair my compressor because of the rust and damage. When I had it at the dealers they did not mention this problem at all. They just said it was not worth fixing. My car has about 200000 miles but has has its service. This has to be a major recall or replacement. We could have had a major accident over this and didn't know [XXX] Please call or forward communication. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11475588 — an unverified report by a vehicle owner.
Fairfield, CT
POWER TRAIN
I was approaching a stop sign and slowing down to < 10 miles and the engine continued to slow down and the car started to push forward while I was totally pressing on the brake - it did not want to stop and kept pushing forward. I wasn't sure what was happening and quickly put it in neutral. My daughter who drives the car to school was sitting in the passenger seat and was completely shocked. I have been driving for 30+ years and at that moment felt things were totally out of my control. Extremely off to see a car keep going when you are trying to stop. I could 100% have hit someone if there was a car in front of me as I went two car lengths before realizing what was happening. I turned the car off. Started again and it was fine. This happened on Saturday, March 26th, 2022. I have not taken the car to the dealer. There were no lights or anything indicating any warning.
NHTSA complaint #11458734 — an unverified report by a vehicle owner.