974 of the
18,883 complaints filed about the Dodge Grand Caravan
are about the fuel system —
5% of everything owners reported.
The worst model year for it is 1996.
The contact owns a 2017 Dodge Grand Caravan. The contact stated while driving approximately 25 MPH, the vehicle stalled in the middle of the roadway an dfailed to restart. The contact stated that there was smoke coming from the engine bay. There was not warning light illuminated. The vehicle was towed to AAMCO Transmissions, where it was diagnosed that the water pump housing had split in half. The water pump was replaced. The contact stated that shortly after the repair, the thermostat gauge started fluctuating and the vehicle overheated. The vehicle was taken to JJ Auto Repair and Collisions, where it was diagnosed with catastrophic engine block failure. A new engine was purchased and installed on the vehicle; however, the vehicle suddenly stalled while driving 40 MPH. The vehicle was restarted and driven to the dealer, where it was diagnosed with alternator failure. The alternator and the battery were replaced. The contact stated that the vehicle failed to operate as needed. The vehicle was taken to AutoZone, where the battery was replaced. Additionally, AutoZone tested the newly installed alternator and determined that the alternator was faulty; however, several mechanics determined that the alternator was in good condition. The contact related the failures to NHTSA Campaign Numbers: 20V278000 (FUEL SYSTEM, GASOLINE) and 18V524000 (ELECTRICAL SYSTEM). The vehicle was not repaired. The manufacturer was notified of the failure but denied reimbursement for the expenses. The failure mileage was approximately 90,489.
NHTSA complaint #11742088 — an unverified report by a vehicle owner.
We purchased our 2012 Dodge Grand Caravan 1/2026. Only 85000 miles on it. After about a week or 2, when husband tried go start van to go to work early cold, morning, van wouldn't start easily. Sometimes he would wait up to a few hours and keep trying to start, eventually it would. But last 3 days, its gotten harder to start van.at all. Not cool. Why isn't this recalled, it seems ALOT of people have same issue..
NHTSA complaint #11731166 — an unverified report by a vehicle owner.
specifics unknown check engine light came on cpl seconds before it started overheating / leaking coolant and or transmission fluid and overheating. and I'm not sure what. started last year but I don't drive very often so the issue just started last year
NHTSA complaint #11729672 — an unverified report by a vehicle owner.
I am filing this complaint regarding the service department at Vaden Dodge Chrysler Jeep Ram. My complaint concerns a failure to properly diagnose a mechanical issue with my vehicle, misleading statements about the condition of the vehicle after repairs, and poor communication during the repair process. The vehicle is a 2017 Dodge Grand Caravan. Before bringing it to the dealership, the vehicle was jerking when slowing or coming to a stop. On February 19, 2026, a diagnostic scan showed code P0420 – Catalyst System Efficiency Below Threshold (Bank 1). At that time the vehicle was still drivable. On March 2, 2026, I brought the vehicle to the dealership and reported the jerking issue. I also asked that the throttle body and transmission be inspected. The dealership stated that the technician could not determine the cause of the problem but recommended maintenance repairs including tires, brakes, and rotor service. Based on their professional recommendation, I approved the repairs. On March 6, 2026, I picked up the vehicle and paid $1,416.21. I was told the vehicle passed inspection and a safety test drive. However, within approximately thirty minutes of leaving the dealership, the vehicle began jerking violently and shut off while I was driving. The vehicle had to be returned to the dealership. After the vehicle was returned, I was informed that the catalytic converter needed to be replaced. This was concerning because I had asked the dealership to check that component during the initial inspection. I was originally quoted about $2,800, and after discussions with management including Jim Fife, I paid $2,165 on March 14, 2026 for the catalytic converter repair. Despite paying a total of $3,581.21, the vehicle continued to show drivability problems. A new diagnostic scan showed codes P0420 and P219B (air-fuel ratio imbalance), suggesting the underlying issue may not have been properly diagnosed before replacing the catalytic converter. I attempted to resolve the issue.
NHTSA complaint #11724542 — an unverified report by a vehicle owner.
Am smells as if wires are burning and vehicle turns off whilst driving causing me to nearly hit a pole in one instance. Car will shut off also whilst parked or when reversing to park. Emergency Brake light come on at random times during driving as well. Or the seatbelt light will come on whilst seatbelt is engaged.
NHTSA complaint #11716641 — an unverified report by a vehicle owner.
My 2016 dodge grand caravan has all of a sudden lost power on half the fuse box making it so the key (fob) says iuyts A bad key a total of 3 times so far as well as this time will not turn over at all, also the last time I went to put fuel in it half the gas was on the ground due to a faulty gas line on the fuel neck. It also has a fluctuateing rpm at stop lights. And might turn off and be hard to restart in the middle of an intersection.I would hope to have these things fixed in a recall soon.
NHTSA complaint #11703393 — an unverified report by a vehicle owner.
Today, I was driving my van to work, and I stopped at a stop sign, went to go, and the van made a horrible clunk noise and wouldn't drive. I shifted through the gears, and each one made the van shake hard. I purchased this van 2 weeks ago from a used car lot. Earlier today, the check engine light came on, which I planned on going check it when I got off work. I had a mobile diagnostic worker come check it out, and he told me it was my transmission. I contacted the lot where I bought it, and am waiting to get it towed back there. This was dangerous because it stopped driving at a stop sign, and I didn't know what to do. I had to flag traffic to go around and wait for people to come help me push it out of the way of traffic. I am a single mother with a three year old.
NHTSA complaint #11691921 — an unverified report by a vehicle owner.
The vehicle randomly and dangerously stalls while driving at various speeds and locations. The vehicle will not restart until battery is disconnected and then reconnected. It then starts right up and runs fine until the next episode of stalling. This has been addressed by NHTSA campaign # 19V813 recall for bad fuel pump relay but my VIN # has not been included in this recall even though the vehicle is in the same year as the other vans covered under the recall. This is a very dangerous condition that keeps happening even after leaving the van with the Chrysler dealer for a week to diagnose and they say they don't have a definitive fix for it but offered to replace the entire TIPM for $1700 without a guarantee that the problem will be permanently fixed! The faulty fuel pump relay is well known and has been addressed with an external fuel pump relay kit covered by this recall. Please help us get our vehicle covered under this recall as we are retirees on a fixed income and have already spent too much money (close to $1000) trying to fix this known problem. Already replaced the ignition module which was another known possible cause but the problem still remains.
NHTSA complaint #11689334 — an unverified report by a vehicle owner.
I have a 2014 Dodge Caravan.The van only has 48 k miles. The battery went bad so I replaced the battery. Then the problem started. 1st the car will NOT turn off. I remove the key and the engine is still running and won't turn off. I had to remove the ASD relay which was very hot. Once I was able to shut down ,now the dashboard shows the car in reverse but it is actually in park and won't come out of gear. The check engine light is on, the tire is low light is on, and the car with tire tracks is on,(abs). I looked up recalls and they have had a recall on the fuelpump relay .
NHTSA complaint #11685434 — an unverified report by a vehicle owner.
this is the fourth time i am filing a complaint. My 2013 dodge grand caravan completely dies and looses all power going over 50 miles per hour. no warning, no codes appear, nothing. looses all power, power steering, brakes, etc. have to get to side of road, wait 20 minutes, then car will start. this has happened now over 25 times. The latest time i was driving on the expressway and the vehicle behind me almost crashed into me. this continues to be a safety issue and it is unclear as to why dodge is doing nothing about this despite multiple complaints by hundreds of drivers. I have spent $3000 so far trying to fix this to no avail, new battery, fuel pump, fuel filter, TPM relay, new keys, new programming, still happens. case manager from 2023 told me to take to dodge dealer, spent additional $800, but they had no root cause. happened again. case manager told me to take to a different dodge dealer for second opinion. No codes, no root cause, but charged $400 diagnostic fee. When is Dodge going to do something about this? How many complaints are needed? does someone have to get injured? just tell me how to fix it, that is what i and thousands of others this happens to need to know before someone gets killed.
NHTSA complaint #11683960 — an unverified report by a vehicle owner.
Car will crank but not start. Can cannot be started intermittently which could be dangerous considering location of vehicle, adverse weather conditions, etc. There are no warning lamps or messages related to the problem. This is a known problem with other Chrysler models and model years. TIMP fuel pump relay has failed. Bypassing the fuel pump relay will allow car to start. See attached file of Vertical Vissions' bypass solutions to this problem.
NHTSA complaint #11679016 — an unverified report by a vehicle owner.
My wife was stopped at a drive through window in DRIVE when the engine stalled. It wouldn’t crank over and needed to be pushed out of the way and towed. The TIPM failed and needed to be replaced. The repair was done at a Chrysler dealer and they took the faulty part after repair. Safety was at risk because if this had happened in the middle of the road it could have caused an accident. My wife was lucky it happened at the drive through. Vehicle not inspected by police or insurance. No warning lights or other symptoms, just engine stalled
NHTSA complaint #11665496 — an unverified report by a vehicle owner.
Van is driven a few thousand miles per year since we purchased. Routine maintenance up kept and has just over 100K miles. Replaced coils, plugs as routine for maintenance but having a Cylinder 2 misfire, then it became #6 and now is "multiple random misfire" codes. vehicle shutters dangerously when driving and engine light comes on intermittently. EVERY person I know with this pentastar v6 has had identical problems!
NHTSA complaint #11660593 — an unverified report by a vehicle owner.
My car shuts down while idling at a stop light. Before that happens, the rpm drops down, the car shakes a bit, and then the engine dies. What could be the problem?
NHTSA complaint #11656578 — an unverified report by a vehicle owner.
When I pump gas in the tank. It keeps stopping and it will not allow me to put more gas in the tank. Also the gas hand on the dashboard stays at half full. I don’t know how much gas is really in the tank. And electrical the passenger window will not let down on the driver side. I can’t let the window down from the driver side.
NHTSA complaint #11644913 — an unverified report by a vehicle owner.
The oil filter housing for Jeep Dodge Chrysler 3.6 is originally made with plastic. Now its made with metal. My van is leaking oil. I went to get an oil change and was told from the shop that I had a oil leak. Oil is all over the engine. They were telling me that they see this so often, and that it should be recalled. Jeep has the exact same issue and has a recall. I can actually smell it inside the car. This is the second time I was told this. The leak is getting worst. Times are super hard out here. I would love if someone could look into this.
NHTSA complaint #11641021 — an unverified report by a vehicle owner.