1995 Dodge Grand Caravan problems

ENGINE AND ENGINE COOLING

TL* THE CONTACT OWNS A 1995 DODGE GRAND CARAVAN. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS JUMP STARTED AND TAKEN TO A DEALER WHO OFFERED NO ASSISTANCE. THE MANUFACTURER WAS CONTACTED AND THEY ALSO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000. UPDATED 12/20/11

NHTSA complaint #10430450 — an unverified report by a vehicle owner.

TIRES:TREAD/BELT

IN 2003 I BOUGHT 8 FUTURA PLUS TIRES MADE BY COOPER AND SOLD BY PEP BOYS. THEY WENT ON 2 DIFFERENT VEHICLES. ALL 8 EVENTUALLY SEPARATED. ONE WAS REPLACED BY ANOTHER FUTURA PLUS AND IT HAS JUST SEPARATED ALSO. EACH AROUND 20000 TO 30000 MILES OF USE. IN EACH INSTANCE PEP BOYS REFUSED TO ACKNOWLEDGE THE TIRES WERE SEPARATED EVEN THOUGH YOU CLEARLY COULD FEEL THE BUMP IN THE TIRE , AND DRIVING WITH THE TIRE CAUSED THE STEERING WHEEL TO ROCK BACK AND FORTH AS YOU TOOK OFF THE TO INCREASE TO A BAD VIBRATION. WITH SOME OF THE TIRES THEY REFUSED TO REPLACE THEM, AND I HAD TO GO TO ANOTHER STORE. THE LATEST INCIDENT , WAYNE DOUGLAS AT THE ORANGE PARK FL STORE REFUSED TO REPLACE THE TIRES AND TRIED TO BLAME ME, BUT I QUOTED THE WARRANTY TO HIM, AND ASKED WHERE HE FOUND HIS STATEMENTS IN THE WARRANTY AND HE REFUSED TO ANSWER.

NHTSA complaint #10196551 — an unverified report by a vehicle owner.

VEHICLE SPEED CONTROL

1995 DODGE GRAND CARAVAN WENT TO FULL THROTTLE AND NO BRAKES DUE TO A PLASTIC BREAK IN RESTRICTOR JAMMING IN THROTTLE BODY HOLDING VALVE OPEN. RESULT WAS FULL THROTTLE AND NO VACUUM FOR BRAKES. CAR WAS FINALLY STOPPED BY TURNING OFF IGNITION.

NHTSA complaint #10138081 — an unverified report by a vehicle owner.

SEAT BELTS:REAR/OTHER

AS I WAS BUCKLING MY CHILD INTO THE FAR REAR, CENTER SEAT, THE SEAT BELT DETACHED FROM THE SEAT, RENDERING THE SEATBELT UNUSABLE. A COUPLE OF WEEKS LATER, WHEN BUCKLING MY CHILD INTO THE FAR REAR, LEFT SEAT, THE LOCKING MECHANISM PART OF THE SEAT BELT DETACHED FROM THE SEAT, RENDERING THAT SEATBELT UNUSABLE AS WELL. NEITHER PART HAS BEEN REPAIRED OR REPLACED.

NHTSA complaint #10102600 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

DOOR STRUCTURE : HINGE AND ASSEMBLY.

NHTSA complaint #10007191 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL

A CROSS OVER IN THE FUEL RAIL WAS LEAKING. RECALL 00V268000 WAS ISSUED ON THIS PROBLEM. CONSUMER WAS CONCERNED BECAUSE VEHICLE WAS SHOOTING OUT FUEL.WHEN IT FIRST STARTED HAPPENING IT WAS ON THE LEFT SIDE, AND CURRENTLY IT IS ON THE RIGHT SIDE. THERE WERE NO LIGHTS ILLUMINATING ON THE DASHBOARD.

NHTSA complaint #10099309 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM:FUEL RAIL

FUEL INJECTION RACKS ON MY 1995 GRAND CARAVAN [XXX] SPLIT, SPILLING FUEL OVER ENGINE. I WAS TOLD THAT OTHER GRAND CARAVANS WERE COVERED BY A RECALL, BUT THAT MINE WAS NOT. FUEL RACKS WERE REPLACED AT A COST OF $560.71 BUT CHRYSLER REFUSES TO REIMBURSE ME EVEN THOUGH THIS FAILURE IS SIMILAR TO THE RECALL. I WOULD LIKE THE NHTSA TO RECONSIDER THE LIMITS OF ITS RECALL FOR THIS FAILURE ON GRAND CARAVANS.*AK UPDATED 07/25/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA complaint #10086488 — an unverified report by a vehicle owner.

UNKNOWN OR OTHER

TWO PROBLEMS EXIST WITH OUR GRAND CARAVAN--THE 1ST ONE, I DO NOT KNOW IF IT WOULD BE UNDER THE COMPUTER ASPECTS OF THE VAN OR NOT, BUT THE WINDSHIELD WIPERS COME ON FOR ONE SWIPE WHENEVER THEY WANT TO DO SO. WE TOOK THE VAN IN SHORTLY AFTER PURCHASE AND THEY SUPPOSIDLY PUT A PART ON IT TO CORRECT THE PROBLEM. IT DID NOT WORK, IT WAS DONE ONCE OR TWICE MORE AND TO NO AVAIL IT STILL SWEEPS THE WINDSHIELD AT RANDOM TIMES WITH THE SWITCH NOT IN THE ONE POSITION. WE HAVE HEARD OF THIS PROBLEM FROM OTHER DODGE GRAND CARAVAN OWNERS BUT HAVE NEVER SEEN THE ISSUE ADDRESSED. THE 2ND PROBLEM IS THAT THE HEADLIGHT COVERS ON THE FRONT OF THE VAN ARE VERY DISCOLOURED--TO THE POINT OF BEING YELLOW--THIS HAS NOT ONLY HAPPENED TO US, BUT TO MY SECRETARY'S DODGE GRAND CARAVAN. IT SURE MAKES FOR DULLER LIGHT WHEN THE HEADLIGHTS ARE ON. IT MAKES YOU WONDER IF OTHER PEOPLE ARE DEALING WITH THE SAME PROBLEM. THANK YOU FOR YOU ATTENTION INTO THIS MATTER.

NHTSA complaint #10070907 — an unverified report by a vehicle owner.

EQUIPMENT:ELECTRICAL

TWO PROBLEMS EXIST WITH OUR GRAND CARAVAN--THE 1ST ONE, I DO NOT KNOW IF IT WOULD BE UNDER THE COMPUTER ASPECTS OF THE VAN OR NOT, BUT THE WINDSHIELD WIPERS COME ON FOR ONE SWIPE WHENEVER THEY WANT TO DO SO. WE TOOK THE VAN IN SHORTLY AFTER PURCHASE AND THEY SUPPOSIDLY PUT A PART ON IT TO CORRECT THE PROBLEM. IT DID NOT WORK, IT WAS DONE ONCE OR TWICE MORE AND TO NO AVAIL IT STILL SWEEPS THE WINDSHIELD AT RANDOM TIMES WITH THE SWITCH NOT IN THE ONE POSITION. WE HAVE HEARD OF THIS PROBLEM FROM OTHER DODGE GRAND CARAVAN OWNERS BUT HAVE NEVER SEEN THE ISSUE ADDRESSED. THE 2ND PROBLEM IS THAT THE HEADLIGHT COVERS ON THE FRONT OF THE VAN ARE VERY DISCOLOURED--TO THE POINT OF BEING YELLOW--THIS HAS NOT ONLY HAPPENED TO US, BUT TO MY SECRETARY'S DODGE GRAND CARAVAN. IT SURE MAKES FOR DULLER LIGHT WHEN THE HEADLIGHTS ARE ON. IT MAKES YOU WONDER IF OTHER PEOPLE ARE DEALING WITH THE SAME PROBLEM. THANK YOU FOR YOU ATTENTION INTO THIS MATTER.

NHTSA complaint #10070907 — an unverified report by a vehicle owner.

VISIBILITY:DEFROSTER/DEFOGGER/HVAC SYSTEM:REAR WINDOW

WHILE DRIVING AT APPROXIMATELY 55 MPH, WITH THE REAR DEFROSTER ON, BACK WINDOW BLASTED OUT OF THE TAILGATE. THERE WAS NO EVIDENCE OF FOUL PLAY, SUCH AS A PELLET GUN OR STONES.

NHTSA complaint #10057753 — an unverified report by a vehicle owner.

VISIBILITY:WINDSHIELD WIPER/WASHER

WINDSHIELD WIPERS MALFUNCTION. THEY WILL EITHER COME ON OR GO OFF WITHOUT TURNING THE SWITCH. THIS IS A COMMON PROBLEM, AND THERE'S A TSB ON THIS ISSUE, INDICATING THAT THE FAILING PART IS THE BCM (NOT FOUND IN ARTEMIS), PER THE DEALERSHIP.

NHTSA complaint #10052255 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR

THERE IS A STRUCTURAL WEAKNESS IN THE FRONT DOORS OF DODGE/CHRYSLER MINIVANS THAT CAUSES DOOR FAILURE. THE DOORS BECOME IMPROPERLY ALIGNED WITH THE DOOR FRAME, MAKING THEM DIFFICULT OR IMPOSSIBLE TO OPEN AND CLOSE. THE DOOR ALSO FAILS TO LATCH PROPERLY AS A RESULT OF MISALIGNMENT. THIS CAN CAUSE THE DOOR TO FLY OPEN SUDDENLY WHILE THE VEHICLE IS MOVING, PARTICULARLY WHEN TURNING A CORNER. IT HAPPENED TO ME, BUT FORTUNATELY MY PASSENGER WAS WEARING HIS SEATBELT AND WAS NOT THROWN OUT OF THE CAR. OTHERS MIGHT NOT BE SO LUCKY. TWO AND A HALF YEARS AGO, WHEN THE DOORS ON MY 1995 GRAND CARAVAN BEGAN TO FAIL, I WENT TO AN AUTOBODY SHOP FOR REPAIR, THINKING IT WAS A SIMPLE MATTER OF REPAIRING WELDS. I WAS TOLD THAT THE DOOR HAD BEEN REPAIRED BEFORE (BY A PREVIOUS OWNER). I HAVE SINCE LEARNED THAT MY LOCAL DODGE/CHRYSLER DEALER HAS REPAIRED MANY DOORS, SO THIS IS NOT AN UNCOMMON PROBLEM. UNFORTUNATELY, AT LEAST IN THE CASE OF MY VEHICLE, THE DOORS WERE BRAISED, MAKING IT IMPOSSIBLE, I UNDERSTAND, TO WELD THEM. IT LOOKS TO ME AS IF THE ONLY LASTING REPAIR WOULD INVOLVE REINFORCING THE DOOR FRAME, WHICH WOULD INVOLVE EXTENSIVE BODY WORK. MY DOORS ARE FAILING AGAIN, AND I WANT A FIX THAT WILL LAST! IT SCARES ME TO DRIVE THE CAR, BECAUSE I'M AFRAID I WON'T BE ABLE TO GET OUT OF IT IN AN EMERGENCY. *NLM

NHTSA complaint #10049202 — an unverified report by a vehicle owner.

CHILD SEAT:HARNESS BUCKLE:INFANT

INTEGRATED CHILD SEAT LOCATED IN THE MIDDLE ROW HAD A FIVE POINT HARNESS SYSTEM. THE CABLE THAT LOCKED THE SEAT BELT IN PLACE BROKE, AND SEAT BELT WILL NOT STAY FASTENED.

NHTSA complaint #10049925 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

PROBLEMS WITH 1995 DODGE GRAND CARAVAN CUTTING OFF WHILE IN MOTION. *MR MANIFOLD AIR PRESSURE (MAP) SENSOR HAD TO BE REPLACED. *TT

NHTSA complaint #10025062 — an unverified report by a vehicle owner.

FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM

THE CONSUMER SMELLED GAS COMING FROM THE TRUCK, HE OPENED THE HOOD AND DISCOVERED A FUEL LEAK. IT WAS CONFIRMED BY A MECHANIC, THERE WAS A FUEL INJECTION RAIL CROSSOVER TUBE LEAK AND THE FUEL RAIL NEEDED TO BE REPLACED. *JB PH

NHTSA complaint #10019524 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

WHILE DRIVING, THE VEHICLE STALLED AND COULD NOT BE RESTARTED FOR ABOUT TEN MINUTES. *NLM THE FIRST OCCURRENCE WAS DIAGNOSED AS A GLITCH, THEN THE PROBLEM WAS DIAGNOSED AS MAP SENSOR. THE CONSUMER HADN'T EXPERIENCE ANOTHER PROBLEM SINCE. *SCC

NHTSA complaint #10018004 — an unverified report by a vehicle owner.

ENGINE AND ENGINE COOLING:ENGINE

WHILE DRIVING THE VEHICLE LEAKED OIL FROM UNDERNEATH THE HOOD. *NLM

NHTSA complaint #10018017 — an unverified report by a vehicle owner.

ELECTRICAL SYSTEM

INTERMITTENTLY, THE CRUISE CONTROL, WINDSHIELD WIPERS, AND HORN CAME ON BY THEMSELVES.

NHTSA complaint #10016004 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

THE HINGE AND ATTACHMENTS BROKE ON THE VEHICLE. *AK

NHTSA complaint #10007190 — an unverified report by a vehicle owner.

STRUCTURE:BODY:DOOR:HINGE AND ATTACHMENTS

THE FRONT DRIVER DOOR FRAME IS BREAKING OFF METAL. TS THE DRIVER DOOR MOUNTING POINT ON THE BODY, IS CRACKING FROM THE FLEX OF THE DOOR AND WILL EVENTUALLY BREAK COMPLETELY OFF. SCC

NHTSA complaint #10001757 — an unverified report by a vehicle owner.

STEERING:LINKAGES:TIE ROD ASSEMBLY

WHILE DRIVING AROUND A CIRCLE AT NIGHT, CONSUMER FELT A BUMP AND VEHICLE STOPPED. CONSUMER THOUGHT VEHICLE HAD HIT A TREE. VEHICLE WAS TOWED TO MECHANIC, MECHANIC STATES TIE ROD WAS BROKEN. PLEASE PROVIDE ANY FURTHER INFORMATION. MR

NHTSA complaint #8022550 — an unverified report by a vehicle owner.

POWER TRAIN:AUTOMATIC TRANSMISSION

WHILE TRAVELING ON THE HIGHWAY WITHOUT PRIOR WARNING. THE VEHICLE SHUT DOWN SHE HEARD A KNOCKING NOISE COMING FROM THE FRONT REAR OF THE VEHICLE. THE DEALERSHIP IS AWARE OF THE PROBLEM. MR

NHTSA complaint #8020988 — an unverified report by a vehicle owner.

CHILD SEAT

IN THE BUILT-IN CARSEATS FOR CHILDREN, THE SEAT BELT THAT LATCHES ACROSS THE CHEST AREA IS ABLE TO BE PULLED APART WITH YOUR HANDS. IN FACT, MY DAUGHTER, WHO WAS 4 YEARS AT THE TIME, JUST STRETCHED AND THE SEAT BELT POPPED OPEN WITH HER CHEST. WE RECENTLY WENT CAR SHOPPING AND PULLED ON OTHER BUILT-IN CAR SEAT SEATBELTS AND THEY TOO WERE EASILY PULLED APART WITH OUR HANDS.

NHTSA complaint #766208 — an unverified report by a vehicle owner.