Owners have filed 798 complaints
about the 2009 Dodge Grand Caravan with NHTSA between 2009 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 13 of 28 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 61
Against the median year of the Dodge Grand Caravan. 50 means typical for this
model; 100 means roughly double.
Severity — 25
4.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 32
19% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2009 compares with every other Dodge Grand Caravan
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Pressure Monitoring AND Regulating Systems
2043.5%
Valve
919.6%
Body
510.9%
Ignition
510.9%
Automatic Transmission
48.7%
Mid/Rear Assembly
12.2%
Hatchback/Liftgate
12.2%
Control Module (Tcm/Pcm/Tecm)
12.2%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
20.4%
1,000 – 9,999 miles
214.4%
10,000 – 24,999 miles
336.8%
25,000 – 49,999 miles
7515.6%
50,000 – 74,999 miles
9820.3%
75,000 – 99,999 miles
11624.1%
100,000 – 149,999 miles
9319.3%
150,000+ miles
449.1%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Apr 2009peak 53May 2026
NHTSA investigations into the 2009 Dodge Grand Caravan
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
DP14004Opened 25 Sep 2014Closed 24 Jul 2015ELECTRICAL SYSTEM
Totally Integrated Power Module Failure
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to...
RQ14002Opened 16 Jun 2014Closed 2 Mar 2015AIR BAGS
Air Bag Non-Deployment/Engine Stall
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of...
Recalls on the 2009 Dodge Grand Caravan
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
20V396000
AIR BAGS:FRONTAL:DRIVER SIDE:INFLATOR MODULE
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Risk: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
16V047000
AIR BAGS:FRONTAL
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Risk: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
14V373000
ELECTRICAL SYSTEM:IGNITION:SWITCH
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Risk: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
14V055000
SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Risk: Failure of the rear axle may increase the risk of a crash.
10V235000
ELECTRICAL SYSTEM:WIRING
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
Risk: A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
09V351000
SERVICE BRAKES, HYDRAULIC
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Risk: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
09V046000
ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERS
CHRYSLER IS RECALLING 6,138 MY 2009 TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. UNUSED ELECTRICAL CONNECTORS FOR THE BLIND SPOT DETECTION SYSTEM MAY BECOME CORRODED AND COULD SHORT CIRCUIT, WHICH CAN CAUSE A VARIETY OF CONDITIONS.
Risk: IF THE FUSE FOR THIS CIRCUIT DOES NOT BLOW, THE CONNECTORS COULD OVERHEAT AND POTENTIALLY CATCH FIRE.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2020311188,249 units in Canada
Airbag
Issue: On certain vehicles, the emblem on the steering wheel could become loose. If this happens, the emblem or its retainers could become projectiles when the airbag inflates in a crash. Safety Risk: Loose parts that are projected toward the occupants when an airbag deploys could increase the risk of an injury. Corrective Actions: FCA Canada will notify owners by mail and instruct you to take your vehicle to a dealer to replace the airbag cover on the steering wheel.
Recall 20194205,327 units in Canada
Other
Issue: This recall is for aftermarket replacement rear window glass produced by Vitro Automotriz. Certain rear window glass may not have been properly tempered. If the window breaks, the glass may separate into large pieces instead of very small ones. Note: This is a voluntary recall that is not being conducted under the requirements of the Motor Vehicle Safety Act. Safety Risk: Glass that breaks in to large pieces could create a risk of injury. Corrective Actions: The company will notify consumers by mail and instruct them to inspect the designation code marked on the rear window glass. Products affected by this recall have the designation “DOT 287” along with the lettering “VMR” (Replacement Market) and a date code that is before July 2019. This information is printed on the bottom corner of the glass. Consumers should contact Vitro's customer service at 1-412-995-6457 or argbacklites@vitro.com to arrange for replacement of the glass.
Recall 201604430,284 units in Canada
Airbag
On certain vehicles, a defect in the Occupant Restraint Control (ORC) system could result in inadvertent airbag / seatbelt pretensioner deployment, or prevent airbags / seatbelt pretensioners from deploying when warranted. Unintended airbag / seatbelt pretensioner deployment, in a non-warranted (non-impact) situation, could startle the driver, and could result in a vehicle crash causing injury and/or property damage. Furthermore, failure of the airbags / seatbelt pretensioners to deploy in a crash when warranted could increase the risk of injury to vehicle occupants. Correction: Dealers will replace the Occupant Restraint Control (ORC) module.
Recall 2015250161,349 units in Canada
Electrical
On certain vehicles, the Wireless Ignition Node (a.k.a ignition switch) may allow the ignition key to inadvertently move from the ON position to the accessory (ACC) position while driving, causing the engine to shut off. This would result in a loss of motive power, power steering and power brakes, and would disable the airbags as well as other supplemental restraint systems (SRS). Increased steering and braking effort and a loss of motive power could increase the risk of a crash causing injury and/or damage to property. Loss of airbag / SRS function in a crash that warrants airbag deployment and/or other supplemental restraint system function could increase the risk of injury to vehicle occupants. Correction: Dealers will install a revised WIN module and frequency operated button ignition key (FOBIK). Note: Until the correction is performed, owners are advised to remove all objects from the FOBIK (Ignition Key) such as additional keys, key chains, etc, leaving only the FOBIK (ignition key). After starting the vehicle, drivers should ensure that the key is securely and correctly aligned in the “ON” position before driving the vehicle. Note: This recall supersedes recalls 2011096 and 2014261. Vehicles having been serviced as part of these previous recalls will require re-inspection and repair.
Recall 201426197,496 units in Canada
Electrical
On certain vehicles, the Wireless Ignition Node (a.k.a ignition switch) may allow the ignition key to inadvertently move from the ON position to the accessory (ACC) position while driving, causing the engine to shut off. This would result in a loss of motive power, power steering and power brakes, and would disable the airbags as well as other supplemental restraint systems (SRS). Increased steering and braking effort and a loss of motive power could increase the risk of a crash causing injury and/or damage to property. Loss of airbag / SRS function in a crash that warrants airbag deployment and/or other supplemental restraint system function could increase the risk of injury to vehicle occupants. Correction: Dealers will install a revised WIN module and frequency operated button ignition key (FOBIK). Note: Until the correction is performed, owners are advised to remove all objects from the FOBIK (Ignition Key) such as additional keys, key chains, etc, leaving only the FOBIK (ignition key). After starting the vehicle, drivers should ensure that the key is securely and correctly aligned in the “ON” position before driving the vehicle. Note: This recall is superseded by recall 2015-250.
Recall 2014031166 units in Canada
Structure
On certain vehicles modified for wheelchair accessibility by the Liberty Motor Company Inc., the rear axle may fracture due to a combination of corrosion damage and operation on rough roads. If the rear axle fractures, vehicle handling may be adversely affected, creating the risk of a crash and increasing the risk of injury and/or property damage. Correction: Freedom Motors assigned service shops will inspect axles and reinforce or replace as necessary.
Recall 201018615,300 units in Canada
Electrical
On certain vehicles equipped with power sliding doors, the sliding door wiring harness may have been routed improperly and chafe on the lower sliding door hinge bracket. This could result in a fire within the sliding door assembly, which could lead to property damage or personal injury. Correction: Dealers will inspect the sliding door wire track harness and power drive unit wiring harness assemblies for damage. The harnesses will be repaired or replaced as necessary, and rerouted under the sliding door weatherstrip.
Recall 2009037268 units in Canada
Electrical
On certain vehicles, an unused electrical connector may become corroded and eventually short circuit, affecting operation of the compass display, rear heater/AC blower, courtesy lamps and integral flashlight. Should the circuit fuse not blow, the connector could overheat and cause a vehicle fire. Correction: Dealers will seal the power circuit at the unused connector and replace the fuse if necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
Waconia, MN1 injured
TIRES
225/65 R 16 100 My van is available for inspection; the left front driver’s-side tire was repaired (under warranty) on 6 August 2022; a plug was installed to repair a ticking sound, which ended up being a nail imbedded in the tire. Once on the road again, I still heard an annoying sound( I realized the mechanic may not have cut the plug flush). I intended to go back to have them cut it off, but forgot due to my recent part-time work activities & starting College at night.(as well as getting Covid on 28 September 2022. I was scheduled to work at Davanni’s on 21 October 2022. I got into work around 12:33. I use an App on my phone to deliver pizza’ & hoagies. I took a large order around 15:30. I was nervous driving, because my van(previously reported on this site)was having the electrical issues, even when I put my vehicle in park. I messaged my customer when I was 2-3 minutes away(I was extra cautious because my signals wouldn’t show drivers behind me that I was turning, so my 1st text would usually be at a semi-fore, then when I park in driveway, I send a text I am there. The customer had a pretty high incline when I parked. After sending the text I proceeded to exit my vehicle. (my phone was in my right hand). I stepped out with my left foot, then the right; I was fully standing when all of a sudden I felt my door pushing on my left side, I braced my left arm, looked down & noticed the van was rolling back. I felt the tire start to hit my toe then instantly brought my right foot up to step on the brake. In doing so I had my right buttocks wedged against my seat base. I slammed my elbow & ribs onto the threshold of the door and my right arm/pit against the seat. I looked up by the steering wheel where the shift stick is, & realized it was down. I reached up with my left arm & pushed up 2- notches, couldn’t reach park. I texted the person that I need help. He came out swiftly, put it in park & help me arise from my wedged position. I went to ER next day
NHTSA complaint #11491257 — an unverified report by a vehicle owner.
Honaker, VACrash
POWER TRAIN
Parked vehicle and put gear in park.Vehicle rolled down hill through chain link fence and did front end damage. No person was inside vehicle at time it rolled off.
NHTSA complaint #11473652 — an unverified report by a vehicle owner.
at 95,000 milesWhite Bear Lake, MNFire
ELECTRICAL SYSTEM
The contact owns a 2009 Dodge Grand Caravan. The contact stated that while the vehicle was parked at his residence, a fire started from the drivers side tail light. The tail light, the rear bumper, and part of the rear seat were melted, additionally the rear windshield shattered. The fire department was called and they extinguished the fire using chemical powder and water. The fire marshal wrote an incident report. The contact stated no warning light was illuminated. The contact did not take the vehicle to a local dealer to be diagnosed. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 95,000.
NHTSA complaint #11455620 — an unverified report by a vehicle owner.
at 107,000 milesNorton, OHCrash1 injured
UNKNOWN OR OTHER
MY VEHICLE WAS PUT IN PARK AND ABOUT 10 MINUTES LATER IT JOLTED BACKWARDS AND HIT A RETAINING WALL IN THE DRIVEWAY.
NHTSA complaint #11255149 — an unverified report by a vehicle owner.
at 107,000 milesNorton, OHCrash1 injured
STRUCTURE:BODY
MY VEHICLE WAS PUT IN PARK AND ABOUT 10 MINUTES LATER IT JOLTED BACKWARDS AND HIT A RETAINING WALL IN THE DRIVEWAY.
NHTSA complaint #11255149 — an unverified report by a vehicle owner.
at 200,000 milesFraser, MIFire
ELECTRICAL SYSTEM
TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN. WHILE DRIVING 30 MPH, THE CONTACT SMELLED AN ABNORMAL ODOR AND NOTICED SMOKE COMING FROM THE AUTOMATIC WINDOW BUTTONS. THE CONTACT STATED THAT THE DRIVER'S DOOR CAUGHT ON FIRE AND WAS EXTINGUISHED BY THE FIRE DEPARTMENT. NEITHER A FIRE NOR A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT INDICATED THAT IT WAS AN ELECTRICAL FIRE. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 200,000.
NHTSA complaint #11122761 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Smithfield, VA
AIR BAGS
In August 2024, the airbag system in a 2009 Dodge Grand Caravan (VIN: [XXX] ) deployed unexpectedly while the vehicle was parked and not in operation. There was no collision, impact, or known external trigger at the time of deployment. The malfunction involved the airbag restraint system and/or related electrical or control components. An unexpected airbag deployment creates a serious safety concern because it could injure vehicle occupants or bystanders and indicates a potential defect in the restraint system. The vehicle was immediately taken to Banister Chrysler Dodge Jeep Ram in Hampton, Virginia, where it has remained since the incident. To the best of our knowledge, the vehicle has remained in dealership/manufacturer custody and should be available for inspection. The manufacturer indicated they were reviewing the matter and determining the value of the vehicle; however, despite extended time passing, no repair, replacement, or written resolution has been provided. The issue has not been reproduced because the vehicle has remained out of service since the incident. It is UNKNOWN whether the precise cause has been formally confirmed by the manufacturer or dealership. No injuries occurred, but the incident placed the safety of the owners and others at risk because a critical safety restraint system deployed without warning while the vehicle was stationary. Documented NHTSA recalls affecting Dodge Grand Caravan airbag systems and related models demonstrate prior manufacturer awareness of airbag-related safety defects. Although this VIN currently shows no open recall, the spontaneous deployment raises concern regarding unresolved or inadequately corrected airbag system defects. No known warning lamps or dashboard messages were specifically recalled prior to the incident. Any additional warning indicators are UNKNOWN. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11738233 — an unverified report by a vehicle owner.
Apex, NC
FUEL/PROPULSION SYSTEM
Car will crank but not start. Can cannot be started intermittently which could be dangerous considering location of vehicle, adverse weather conditions, etc. There are no warning lamps or messages related to the problem. This is a known problem with other Chrysler models and model years. TIMP fuel pump relay has failed. Bypassing the fuel pump relay will allow car to start. See attached file of Vertical Vissions' bypass solutions to this problem.
NHTSA complaint #11679016 — an unverified report by a vehicle owner.
Collierville, TN
ELECTRICAL SYSTEM
While driving on major (multi-lane) city street (40 mph) the vehicle began to slow, steering became difficult and a single amber caution for the traction control was illuminated. Tachometer indicated 0 RPM. After pulling over, the vehicle was restarted and driven without further issue. Recall on the ignition switch was addressed in 2009. Unexpected engine shutdown could have significantly reduced safety margins in heavy traffic. No third party inspected vehicle after incident. Owner notes that key fob does not have anything hanging of it that could aggravate unwanted movement of ignition switch
NHTSA complaint #11631919 — an unverified report by a vehicle owner.
Sugar Grove, PA
UNKNOWN OR OTHER
I had a flat tire (drivers front). I Parked on a level parking lot. I put bricks behind other tires to prevent movement. Next I loosened lug nuts, I then removed the spare and original equipment jack. I began jacking the car up with the jack in the area indicated for jacking by the instructions. The tire was off the ground. I was beginning to spin off the lug nuts when the car dropped with a brrrrrt sound. The main screw in the scissors jack pulled through the threaded nut on the end. The jack was still upright but the screw threads failed. No one was hurt but the potential is high for the jack to fail suddenly and without warning. Note the van was not occupied or in any way loaded. The second picture attempts to show the screw threads deformed after pulling through the nut.
NHTSA complaint #11590602 — an unverified report by a vehicle owner.
at 160,000 milesOrlando, FL
AIR BAGS
The contact owns a 2009 Dodge Grand Caravan. The contact stated that while parked with the keys out of the ignition, the contact heard a loud pop coming from the passenger’s side of the vehicle. The contact stated that the driver’s and passenger’s side deployed without impact. The dealer was contacted and advised the contact to inform the manufacturer of the failure. The vehicle was towed to the dealer who had not diagnosed or repaired the vehicle. The manufacturer was made aware of the failure and opened a case. The contact stated that the vehicle was not inspected. The approximate failure mileage was 160,000.
NHTSA complaint #11559091 — an unverified report by a vehicle owner.
Paducah, KY
ELECTRICAL SYSTEM
It started out as the van would not start almost everytime I got ready to leave and would have someone jump my battery, and it would start right back up. after a few weeks of having to do this, i had help jumping my battery once again but this time my wind shield wipers wouldnt shut off resulting in me having to take the fuse out and back in when it rains. when this happened the what i believe is called the "multi functional shift " (the stick on the left side of steering wheel that controls my wipers, wiper fluid, turn signals, bright lights, etc.) completely stopped working with no sign of it having problems previously. Along with that the stereo keeps flickering and switching channels on its own. Lastly, when i am pumping gas, i can barely pull up the trigger without the pump shutting off like as if my tank was full. This has all happened in the last 6 or 7 months or so and has not yet been investigated.
NHTSA complaint #11511690 — an unverified report by a vehicle owner.
Paducah, KY
VISIBILITY/WIPER
It started out as the van would not start almost everytime I got ready to leave and would have someone jump my battery, and it would start right back up. after a few weeks of having to do this, i had help jumping my battery once again but this time my wind shield wipers wouldnt shut off resulting in me having to take the fuse out and back in when it rains. when this happened the what i believe is called the "multi functional shift " (the stick on the left side of steering wheel that controls my wipers, wiper fluid, turn signals, bright lights, etc.) completely stopped working with no sign of it having problems previously. Along with that the stereo keeps flickering and switching channels on its own. Lastly, when i am pumping gas, i can barely pull up the trigger without the pump shutting off like as if my tank was full. This has all happened in the last 6 or 7 months or so and has not yet been investigated.
NHTSA complaint #11511690 — an unverified report by a vehicle owner.
Paducah, KY
FUEL/PROPULSION SYSTEM
It started out as the van would not start almost everytime I got ready to leave and would have someone jump my battery, and it would start right back up. after a few weeks of having to do this, i had help jumping my battery once again but this time my wind shield wipers wouldnt shut off resulting in me having to take the fuse out and back in when it rains. when this happened the what i believe is called the "multi functional shift " (the stick on the left side of steering wheel that controls my wipers, wiper fluid, turn signals, bright lights, etc.) completely stopped working with no sign of it having problems previously. Along with that the stereo keeps flickering and switching channels on its own. Lastly, when i am pumping gas, i can barely pull up the trigger without the pump shutting off like as if my tank was full. This has all happened in the last 6 or 7 months or so and has not yet been investigated.
NHTSA complaint #11511690 — an unverified report by a vehicle owner.
Lexington, SC
UNKNOWN OR OTHER
Key stuck in the ignition does not turn properly
NHTSA complaint #11510924 — an unverified report by a vehicle owner.
Grand Haven, MI
ELECTRICAL SYSTEM
Key in into slips from run to accsry and causes van to stall. Has happened a few times. Very dangerous to have van stall while driving
NHTSA complaint #11505286 — an unverified report by a vehicle owner.
at 180,000 milesLos Alamitos, CA
ENGINE
The contact owns a 2009 Dodge Grand Caravan. The contact stated while driving 5 MPH, the vehicle started to stall with the Anti-theft lock warning light illuminated. The vehicle lost motive power and stalled and failed to restart. The contact was able to push the vehicle into a gas station and the vehicle however, the vehicle would not restart. The vehicle was towed to the dealer and the contact was informed that the vehicle needed a new computer. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 180,000.
NHTSA complaint #11496574 — an unverified report by a vehicle owner.
at 113,000 milesBellflower, CA
POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
The contact owns a 2009 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power with the traction control, ABS, and check engine warning lights illuminated. The contact reset the PCM; however, the failure recurred. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 113,000.
NHTSA complaint #11494171 — an unverified report by a vehicle owner.
Waconia, MN1 injured
TIRES
225/65 R 16 100 My van is available for inspection; the left front driver’s-side tire was repaired (under warranty) on 6 August 2022; a plug was installed to repair a ticking sound, which ended up being a nail imbedded in the tire. Once on the road again, I still heard an annoying sound( I realized the mechanic may not have cut the plug flush). I intended to go back to have them cut it off, but forgot due to my recent part-time work activities & starting College at night.(as well as getting Covid on 28 September 2022. I was scheduled to work at Davanni’s on 21 October 2022. I got into work around 12:33. I use an App on my phone to deliver pizza’ & hoagies. I took a large order around 15:30. I was nervous driving, because my van(previously reported on this site)was having the electrical issues, even when I put my vehicle in park. I messaged my customer when I was 2-3 minutes away(I was extra cautious because my signals wouldn’t show drivers behind me that I was turning, so my 1st text would usually be at a semi-fore, then when I park in driveway, I send a text I am there. The customer had a pretty high incline when I parked. After sending the text I proceeded to exit my vehicle. (my phone was in my right hand). I stepped out with my left foot, then the right; I was fully standing when all of a sudden I felt my door pushing on my left side, I braced my left arm, looked down & noticed the van was rolling back. I felt the tire start to hit my toe then instantly brought my right foot up to step on the brake. In doing so I had my right buttocks wedged against my seat base. I slammed my elbow & ribs onto the threshold of the door and my right arm/pit against the seat. I looked up by the steering wheel where the shift stick is, & realized it was down. I reached up with my left arm & pushed up 2- notches, couldn’t reach park. I texted the person that I need help. He came out swiftly, put it in park & help me arise from my wedged position. I went to ER next day
NHTSA complaint #11491257 — an unverified report by a vehicle owner.
Waconia, MN
ELECTRICAL SYSTEM
On 10 October 2022 @ 21:05 hours, I was driving home (to Waconia) from Academy College (Bloomington, MN). Upon entering I35 W North entrance ramp, I had engaged my left turn signal; looking in my driver-side mirror as I merged, I seen the headlights behind me & proceeded to accelerate on the freeway. I was partially in the lane when I heard a horn & wheels screeching to my left. I was close enough to the shoulder & quickly turned sharp then the vehicle blew by me, barely colliding with my vehicle. (I stayed steady & did box breathing as I tried to calm myself). The next day I was driving my van and when I used my left turn signal, I noticed on my instrument panel it was not reflecting my turn signal light, so when I had the near collision the night before, they did not see my turn signal light! The electrical problem with this 2009 Dodge Grand Caravan while driving; at 4-7 minute intervals, this happens while driving; headlights; wipers all instrument panel lights come on; chime rings all at the same time! Days before the near collision, I brought my van in to the mechanics shop and told the owner what was happening. He knew right away that it was the TIP Module needs replacement, due to corrosion under the fuse panel. He sends customers to the Chrysler dealer, which costs $3000 to install & there is a waiting period for the part.(had put $1900 into the ATV-multi vehicle reseal side cover; oil pan gasket & water pump; l/r & r/r calipers; brake fluid; engine coolant/conditioner kit & cooling system flush(which I had to borrow from a friend, as I am only on SSDI). I looked up the part # online & order it, from my friend again; $410. Since it has to be programmed; I watched a You tube video on how to do it. I have not gotten it fixed yet, as I hurt myself at my part-time Davanni’s pizza delivery job, involving my brakes failing, nearly rolling over me. I file Work comp, then made a PIP Claim with my auto insurance for lost wages. I have 2-weeks off/Doctor. The contact stated the vehicle was taken to the d
NHTSA complaint #11491252 — an unverified report by a vehicle owner.
Clinton Township, MI
ELECTRICAL SYSTEM
While driving all electrical systems fail, warning lights flash on and off, power steering and brakes fail, all lights go out. If I do not pull over and turn the car off as soon as it starts, I will stall out in the middle of the road. This has been happening for months and every mechanic I take my car to states everything tests fine.
NHTSA complaint #11487948 — an unverified report by a vehicle owner.
Colonial Beach, VA
ELECTRICAL SYSTEM
While driving all electrical systems fail, warning lights flash on and off, power steering and brakes fail, all lights go out. Can shift to neutral and restart, drive on until it repeats.
NHTSA complaint #11479287 — an unverified report by a vehicle owner.
Colonial Beach, VA
ENGINE
While driving all electrical systems fail, warning lights flash on and off, power steering and brakes fail, all lights go out. Can shift to neutral and restart, drive on until it repeats.
NHTSA complaint #11479287 — an unverified report by a vehicle owner.
Colonial Beach, VA
SERVICE BRAKES
While driving all electrical systems fail, warning lights flash on and off, power steering and brakes fail, all lights go out. Can shift to neutral and restart, drive on until it repeats.
NHTSA complaint #11479287 — an unverified report by a vehicle owner.
Honaker, VACrash
POWER TRAIN
Parked vehicle and put gear in park.Vehicle rolled down hill through chain link fence and did front end damage. No person was inside vehicle at time it rolled off.
NHTSA complaint #11473652 — an unverified report by a vehicle owner.
at 95,000 milesWhite Bear Lake, MNFire
ELECTRICAL SYSTEM
The contact owns a 2009 Dodge Grand Caravan. The contact stated that while the vehicle was parked at his residence, a fire started from the drivers side tail light. The tail light, the rear bumper, and part of the rear seat were melted, additionally the rear windshield shattered. The fire department was called and they extinguished the fire using chemical powder and water. The fire marshal wrote an incident report. The contact stated no warning light was illuminated. The contact did not take the vehicle to a local dealer to be diagnosed. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 95,000.
NHTSA complaint #11455620 — an unverified report by a vehicle owner.
Sikeston, MO
ELECTRICAL SYSTEM
THE WINDOW TRACK BROKE ON THE DRIVER SIDE WINDOW. THE MOTOR WAS GOOD BECAUSE IT STILL WORKED TO ROLLS DOWN ALL WINDOWS EXCEPT THE WING WINDOWS! SO WE REPLACE THE TRACK GOT IT ALL IN EVERY WINDOW WORKED EXCEPT THE WING WINDOWS AGAIN! THEN IT BROKE 2 WEEKS LATER AGAIN SO WE BOUGHT THE WHOLE SET UP FOR DRIVER WINDOW TRACK & MOTOR, SILL WING WINDOWS WON'T WORK AND THE TRACK ON THE DRIVER WINDOW BROKE LESS THAN A WEEK AFTER PUTTING IT IN! NOW I HAVE WOOD HOLDING THE DRIVER SIDE WINDOW UP AND MY WING WINDOWS STILL WON'T OPEN! I'M NOT SURE SPECIFIC DATES SO I'M GONNA GUESS BELOW I CAN GET RECORD FROM AUTOZONE TO PROVE I'VE BOUGHT THE PARTS 2 TIMES!
NHTSA complaint #11398218 — an unverified report by a vehicle owner.
at 166,000 milesLexington, SC
STEERING
I WAS DRIVING AT ABOUT 30 MPH ON A TOWN ROAD AND THE CAR RANDOMLY SHUT OFF. THERE WAS A TRACTION CONTROL LIGHT THAT CAME ON. ALL ELECTRICAL STILL WORKED BUT NO ACCELERATION, POWER STEERING OR POWER BRAKES. I HAD TO SLOW DOWN, PUT THE CAR IN PARK AND RESTART THE CAR. WHAT IF I WAS ON THE HIGH WAY? WHAT IF I WAS CROSSING AN INTERSECTION? MY WIFE DRIVES MY 3 CHILDREN AROUND IN THIS CAR. THIS HAS HAPPENED 3 TIMES THIS PAST WEEK. NEVER DID IT BEFORE. AND I'VE ALREADY HAD THE IGNITION SWITCH REPLACED THAT DODGE SENT OUT A RECALL FOR.
NHTSA complaint #11375148 — an unverified report by a vehicle owner.
at 166,000 milesLexington, SC
ENGINE
I WAS DRIVING AT ABOUT 30 MPH ON A TOWN ROAD AND THE CAR RANDOMLY SHUT OFF. THERE WAS A TRACTION CONTROL LIGHT THAT CAME ON. ALL ELECTRICAL STILL WORKED BUT NO ACCELERATION, POWER STEERING OR POWER BRAKES. I HAD TO SLOW DOWN, PUT THE CAR IN PARK AND RESTART THE CAR. WHAT IF I WAS ON THE HIGH WAY? WHAT IF I WAS CROSSING AN INTERSECTION? MY WIFE DRIVES MY 3 CHILDREN AROUND IN THIS CAR. THIS HAS HAPPENED 3 TIMES THIS PAST WEEK. NEVER DID IT BEFORE. AND I'VE ALREADY HAD THE IGNITION SWITCH REPLACED THAT DODGE SENT OUT A RECALL FOR.
NHTSA complaint #11375148 — an unverified report by a vehicle owner.
at 166,000 milesLexington, SC
SERVICE BRAKES
I WAS DRIVING AT ABOUT 30 MPH ON A TOWN ROAD AND THE CAR RANDOMLY SHUT OFF. THERE WAS A TRACTION CONTROL LIGHT THAT CAME ON. ALL ELECTRICAL STILL WORKED BUT NO ACCELERATION, POWER STEERING OR POWER BRAKES. I HAD TO SLOW DOWN, PUT THE CAR IN PARK AND RESTART THE CAR. WHAT IF I WAS ON THE HIGH WAY? WHAT IF I WAS CROSSING AN INTERSECTION? MY WIFE DRIVES MY 3 CHILDREN AROUND IN THIS CAR. THIS HAS HAPPENED 3 TIMES THIS PAST WEEK. NEVER DID IT BEFORE. AND I'VE ALREADY HAD THE IGNITION SWITCH REPLACED THAT DODGE SENT OUT A RECALL FOR.
NHTSA complaint #11375148 — an unverified report by a vehicle owner.
at 140,000 milesButte, MT
ENGINE
THERE IS A LEAK IN THE HEATING COOLANT HOSE. THIS MAKES A TOXIC SMELL INSIDE THE VEHICLE WHILE DRIVING.
NHTSA complaint #11372864 — an unverified report by a vehicle owner.