Owners have filed 161 complaints
about the 2005 Chevrolet Suburban with NHTSA between 2004 and 2023.
The largest single group is the electrical system.
Across this model's run it ranks 28 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 26
Against the median year of the Chevrolet Suburban. 50 means typical for this
model; 100 means roughly double.
Severity — 32
6.2% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 21
13% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2005 compares with every other Chevrolet Suburban
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
10.9%
1,000 – 9,999 miles
21.8%
10,000 – 24,999 miles
98.1%
25,000 – 49,999 miles
76.3%
50,000 – 74,999 miles
2724.3%
75,000 – 99,999 miles
2522.5%
100,000 – 149,999 miles
2421.6%
150,000+ miles
1614.4%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2005 Chevrolet Suburban 1500 4-DR. w/updated ESC
—
—
—
21.9% risk
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2004peak 9Mar 2023
Recalls on the 2005 Chevrolet Suburban
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06V289000
ENGINE AND ENGINE COOLING
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Risk: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
06E043000
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
05V163000
SEAT BELTS:REAR/OTHER
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Risk: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
05V103000
SERVICE BRAKES, HYDRAULIC:PEDALS AND LINKAGES
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE PEDAL PUSHROD RETAINER MAY BE MISSING. IF THE RETAINER IS MISSING, THE BRAKE BOOSTER PUSHROD COULD DISENGAGE FROM THE BRAKE PEDAL.
Risk: THIS COULD RESULT IN A LOSS OF BRAKES WHICH COULD RESULT IN A CRASH.
05V055000
POWER TRAIN:MANUAL TRANSMISSION:SHIFT PATTERN INDICATOR
CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH AN AUTOMATIC TRANSMISSION, FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 102, "TRANSMISSION SHIFT LEVER SEQUENCE, STARTER INTERLOCK AND TRANSMISSION BRAKING EFFECT." UNDER CERTAIN VEHICLE STARTING CONDITIONS, THE SHIFT LEVER POSITION INDICATOR LOCATED IN THE INSTRUMENT PANEL CLUSTER MAY NOT ILLUMINATE. IF THE SHIFT LEVER POSITION INDICATOR DOES NOT ILLUMINATE, THE DRIVER MAY NOT KNOW WHICH GEAR THE VEHICLE IS IN.
Risk: THE VEHICLE MAY MOVE IN AN UNINTENDED DIRECTION RESULTING IN POSSIBLE INJURY TO OTHERS OUTSIDE OF THE VEHICLE.
05V043000
SERVICE BRAKES, HYDRAULIC
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Risk: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
04V376000
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH 5.3L (RPO L59) V8 ENGINES, THE ENGINE FUEL RAIL CROSSOVER TUBE RETAINER SCREWS WERE NOT MANUFACTURED TO SPECIFICATIONS AND MAY BREAK.
Risk: IF THE TUBE RETAINER SCREW BREAKS, FUEL COULD LEAK FROM THE FUEL RAIL CROSSOVER JOINT, THE ENGINE MAY STALL AND, IF AN IGNITION SOURCE WERE PRESENT, AN ENGINE COMPARTMENT FIRE COULD OCCUR.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2011074190,310 units in Canada
Heater And Defroster
On certain vehicles, the interface between the electrical terminals of the Heating, Ventilation, and Air Conditioning (HVAC) blower relay resistor module and the wiring connector (which powers the module) may be incapable of conducting higher current levels for sustained periods of operation. In addition, moisture and other contaminants (such as road de-icing materials) may enter the fresh air intake plenum and contact the internal circuit of the module or corrode the terminals. These conditions may cause the relay resistor module or wiring connector to overheat, causing various symptoms such as: the HVAC blower may not function on certain or all blower speed settings; a burning-plastic smell or smoke may be present in the vehicle, or; the HVAC blower may run continually with the ignition in the OFF position. These warning signs could, in certain instances, be leading indicators of an impending vehicle fire, which could result in property damage and/or personal injury. Correction: Owners will be provided with additional warranty coverage for the blower motor resistor module/wiring connector overheating condition. Under this "special warranty coverage", should this condition occur within 10 years or 240,000 km from first vehicle registration, dealers will install a replacement blower motor resistor and resistor module connector.
Recall 20061951,485 units in Canada
Fuel System
On certain vehicles, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of the damper. If the damper comes loose, a fuel leak may result. Fuel leakage in the presence of an ignition source could result in a fire. Correction: Dealers will replace the engine fuel rail pulse damper retainer clip.
Recall 200511973,473 units in Canada
Seats And Restraints
On certain vehicles, the 2nd row centre occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants. A lap portion of the seat belt routing that is not low and snug on the hips can allow unfavourable occupant kinetics in the event of a crash. Moreover, the higher routing allows the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Correction: Dealers will modify the guide loop.
Recall 2005038260 units in Canada
Lights And Instruments
Certain vehicles equipped with an automatic transmission fail to comply with the requirements of CMVSS 101 - Location, identification and illumination of displays. Under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. In subsequent vehicle start-ups, this condition may or may not occur again. If the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in and the vehicle may move in an unintended direction, resulting in possible injury to others outside of the vehicle. Correction: Dealers will reprogram the instrument panel cluster.
Recall 20050335,014 units in Canada
Brakes
On certain vehicles, the hydraulic brake booster's pressure accumulator may crack and/or separate from the Hydro-Boost assembly during normal vehicle operating conditions. If a separation occurred and the hood of the vehicle was open, fragments from the accumulator could cause injury to people in the immediate area. In addition, the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort. Correction: Dealers will test and, if necessary, replace the Hydro-Boost assembly.
Recall 200428163 units in Canada
Fuel System
On certain vehicles, the fuel rail crossover tube retainer screws were not manufactured to specifications and may break. If a tube retainer screw breaks, fuel could leak from the fuel rail crossover joint, the engine may stall and, if an ignition source were present, an engine compartment fire could occur. Correction: Dealers will inspect the fuel rail crossover tube assembly and, if necessary, replace the two tube retainer screws.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 90,780 milesPoquoson, VACrash1 injured
SERVICE BRAKES
TOTAL BRAKE FAILURE DUE TO STEEL LINE CORROSION OR RUST.
NHTSA complaint #10534135 — an unverified report by a vehicle owner.
at 90,180 milesFort Worth, TXCrash2 injured
VEHICLE SPEED CONTROL
THE DRIVER WAS SITTING AT THE STOP LIGHT FOR APPROXIMATELY ONE MINUTE. BOTH THE DRIVER AND PASSENGER HEARD A REVVING NOISE. THE DRIVER'S RIGHT FOOT REMAINED ON THE BRAKE. SHE NEVER PUT HER FOOT ON THE GAS PEDAL, YET THE VEHICLE ACCELERATED FORWARD INTO THE INTERSECTION. THE SUBURBAN WAS STRUCK ON THE DRIVER'S SIDE BY A TRUCK, SPUN AND WAS HIT AGAIN ON THE FRONT OF THE VEHICLE. THE DRIVER SITTING AT THE LIGHT BEHIND OUR SUBURBAN AGREED THAT OUR CAR WAS AT A COMPLETE STOP WHEN IT SUDDENLY WENT INTO THE INTERSECTION. THE SUBURBAN WAS DEEMED TOTALED BY OUR INSURANCE COMPANY.
NHTSA complaint #10495242 — an unverified report by a vehicle owner.
at 90,180 milesFort Worth, TXCrash2 injured
STRUCTURE:BODY
THE DRIVER WAS SITTING AT THE STOP LIGHT FOR APPROXIMATELY ONE MINUTE. BOTH THE DRIVER AND PASSENGER HEARD A REVVING NOISE. THE DRIVER'S RIGHT FOOT REMAINED ON THE BRAKE. SHE NEVER PUT HER FOOT ON THE GAS PEDAL, YET THE VEHICLE ACCELERATED FORWARD INTO THE INTERSECTION. THE SUBURBAN WAS STRUCK ON THE DRIVER'S SIDE BY A TRUCK, SPUN AND WAS HIT AGAIN ON THE FRONT OF THE VEHICLE. THE DRIVER SITTING AT THE LIGHT BEHIND OUR SUBURBAN AGREED THAT OUR CAR WAS AT A COMPLETE STOP WHEN IT SUDDENLY WENT INTO THE INTERSECTION. THE SUBURBAN WAS DEEMED TOTALED BY OUR INSURANCE COMPANY.
NHTSA complaint #10495242 — an unverified report by a vehicle owner.
at 80,000 milesHOT Springs, ARCrash1 injured
AIR BAGS
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, SHE CRASHED INTO THE REAR OF A TRASH TRUCK. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUSTAINED INJURIES TO THE LEFT ARM AND LEFT LEG. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THEY DEEMED THE VEHICLE AS BEING DESTROYED. THE MANUFACTURER WAS CONTACTED AND AFTER DIAGNOSING THE VEHICLE, THEY ADVISED HER THAT THE VEHICLE WAS NOT TRAVELING FAST ENOUGH AT THE TIME OF IMPACT FOR THE AIRBAGS TO DEPLOY. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
NHTSA complaint #10455110 — an unverified report by a vehicle owner.
at 55,000 milesWhitehouse, TXFire
EQUIPMENT:APPLIANCE:AIR CONDITIONER
TL* THE CONTACT OWNS A 2005 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE BLOWER MOTOR OF THE AIR CONDITIONER INTERMITTENTLY FAILS. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN REPLACED THE BLOWER RESISTOR, BECAUSE IT MELTED IN SIDE OF THE INSTRUMENT CONTROL PANEL. THE MANUFACTURER WAS NOTIFIED. THE FAILURE AND CURRENT MILEAGES WERE 55,000.
NHTSA complaint #10285281 — an unverified report by a vehicle owner.
at 101,000 milesHouston, TXCrash
SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
2001 CHEVROLET SUBURBAN K-1500 4WD; WAS DRIVING AT LOW SPEED ~10-15 MPH AND APPLIED BRAKES HARD WITH SUDDEN AND UNEXPECTE LOSS OF BRAKES RESULTING IN MVA AND DAMAGE TO THREE VEHICLES, INCLUDING MY OWN
NHTSA complaint #10120032 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Jacksonville, AR
SERVICE BRAKES
The vehicle was idle for about 4 months. I took it to a carwash to clean the dust off. Upon returning (abt a 2 mile trip) the brakes failed and steam was coming out from under the hood. I opened the hood and brake fluid was sprayed all over the driver's side of the engine and wheel well. A brake line had rusted through and burst. Fortunately, I made it home carefully because I had noticed the brakes were soft.
NHTSA complaint #11513528 — an unverified report by a vehicle owner.
Highland Lakes, NJ
STEERING
This vehicle has less than 84,000 miles on it, and the chassis or frame is rotted. The rear anti sway bar already rotted off it, and the front bar is hanging down on the passenger side. I have photos of this, but don't know how to download them. The body has a little rot here, and there, but that is repairable. I spent a lot of money in purchasing this vehicle, and I expected it to last a very long time. The interior is almost like new. I am thinking about putting a tort claim about this to GM. Please help me all you can. I forgot to write that I also spent extra money for it to be undercoated, and it is supposed to be a lifetime warranty. I called that company, and they said it was only for 10 years. When I buy a new vehicle, I expect it to last.
NHTSA complaint #11512604 — an unverified report by a vehicle owner.
Highland Lakes, NJ
SUSPENSION
This vehicle has less than 84,000 miles on it, and the chassis or frame is rotted. The rear anti sway bar already rotted off it, and the front bar is hanging down on the passenger side. I have photos of this, but don't know how to download them. The body has a little rot here, and there, but that is repairable. I spent a lot of money in purchasing this vehicle, and I expected it to last a very long time. The interior is almost like new. I am thinking about putting a tort claim about this to GM. Please help me all you can. I forgot to write that I also spent extra money for it to be undercoated, and it is supposed to be a lifetime warranty. I called that company, and they said it was only for 10 years. When I buy a new vehicle, I expect it to last.
NHTSA complaint #11512604 — an unverified report by a vehicle owner.
White Bear Lake, MN
AIR BAGS
Air bag sensors went out making air bag inoperable.
NHTSA complaint #11503051 — an unverified report by a vehicle owner.
Brimley, MI
VEHICLE SPEED CONTROL
Speedometer stops working intermittently. This is a safety hazard as the operator cannot tell the speed that the vehicle is operating. It seems to occur randomly.
NHTSA complaint #11490845 — an unverified report by a vehicle owner.
Brimley, MI
ELECTRICAL SYSTEM
This defect pertains to gear indicator on the instrument panel. During the daylight hours the light indicating the gear the car is in (park, neutral, drive, etc.) is impossible to read. At night you can just barely read the gear indicators. The dimness of the lights behind this gear indicator gauge is a safety hazard because you cannot tell what gear you are in during the day. It is an expensive repair because the instrument panel needs to be removed to fix the problem.
NHTSA complaint #11490846 — an unverified report by a vehicle owner.
at 84,000 milesHighland Lakes, NJ
STRUCTURE
The contact owns a 2005 Chevrolet Suburban. The contact stated upon taking the vehicle to an independent mechanic for tire replacement, he was informed that the entire chassis was severely corroded. The dealer was notified of the failure and referred the contact to the manufacturer for assistance. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The vehicle was not diagnosed or repaired. The failure mileage was approximately 84,000.
NHTSA complaint #11483289 — an unverified report by a vehicle owner.
Cedar Springs, MI
SEATS
Started with driver side heated seat randomly turning on and off. Going from high, medium, low. No way to turn it off just comes back on. Can hear clicking coming from under dash. Lift gate wiring that goes into body, ground wire burnt. (Replaced) but ground wire has power. (Wiring issue) so rear wiper doesn’t work. “Reading” Lamps only work when door is open. After replacing life gate connector, says lift gate open. Started the repair, which leads to more wiring issues! Needs a recall! Unsafe
NHTSA complaint #11469495 — an unverified report by a vehicle owner.
Cedar Springs, MI
EXTERIOR LIGHTING
Started with driver side heated seat randomly turning on and off. Going from high, medium, low. No way to turn it off just comes back on. Can hear clicking coming from under dash. Lift gate wiring that goes into body, ground wire burnt. (Replaced) but ground wire has power. (Wiring issue) so rear wiper doesn’t work. “Reading” Lamps only work when door is open. After replacing life gate connector, says lift gate open. Started the repair, which leads to more wiring issues! Needs a recall! Unsafe
NHTSA complaint #11469495 — an unverified report by a vehicle owner.
Cedar Springs, MI
ELECTRICAL SYSTEM
Started with driver side heated seat randomly turning on and off. Going from high, medium, low. No way to turn it off just comes back on. Can hear clicking coming from under dash. Lift gate wiring that goes into body, ground wire burnt. (Replaced) but ground wire has power. (Wiring issue) so rear wiper doesn’t work. “Reading” Lamps only work when door is open. After replacing life gate connector, says lift gate open. Started the repair, which leads to more wiring issues! Needs a recall! Unsafe
NHTSA complaint #11469495 — an unverified report by a vehicle owner.
El Paso, TX
VEHICLE SPEED CONTROL
The speedometer issue started 1 year ago, the speedometer shows needle stuck on 0 or all the way down to right side. Now issues with the gas gauge and oil gauge are happening also Mechanic has checked on this and stated that replacement needed.
NHTSA complaint #11422993 — an unverified report by a vehicle owner.
Jersey City, NJ
ELECTRICAL SYSTEM
Heated seats randomly turn on and off and goes thorugh the diffeent levels of heat and then off and then back on repeat for hours while driving and is very distracting as have to turn off every 10 sec and have almost crashed multiple times taking me eyes off the road but have to turn off as heat is too much in summer months, this is a known issue in almost ever suburban 01 to 05, how is this not a recall yet, there is massive amount of documentation of this issue online.
NHTSA complaint #11422855 — an unverified report by a vehicle owner.
Lowgap, NC
POWER TRAIN
Gear status indicator does not display selected gear.
NHTSA complaint #11417528 — an unverified report by a vehicle owner.
at 200,000 milesOzark, MO
AIR BAGS
THE WIRING FOR THE LIGHTERS, POWER PORTS AND COMPUTER LINK MELTED. IT'S ALL PART OF THE UNDER-DASH WIRING HARNESS.
NHTSA complaint #11396677 — an unverified report by a vehicle owner.
at 200,000 milesOzark, MO
UNKNOWN OR OTHER
THE WIRING FOR THE LIGHTERS, POWER PORTS AND COMPUTER LINK MELTED. IT'S ALL PART OF THE UNDER-DASH WIRING HARNESS.
NHTSA complaint #11396677 — an unverified report by a vehicle owner.
at 200,000 milesOzark, MO
ELECTRICAL SYSTEM
THE WIRING FOR THE LIGHTERS, POWER PORTS AND COMPUTER LINK MELTED. IT'S ALL PART OF THE UNDER-DASH WIRING HARNESS.
NHTSA complaint #11396677 — an unverified report by a vehicle owner.
West Palm Beach, FL
POWER TRAIN
TRUCK DOOR IS NOT OPENING, FUEL GAS DEFECTIVE, REAR LIGHT SYSTEM HAS ELECTRICAL PROBLEM ALL THE TIMES, A/C SYSTEM ELECTRICAL PROBLEM.
NHTSA complaint #11342278 — an unverified report by a vehicle owner.
West Palm Beach, FL
AIR BAGS
TRUCK DOOR IS NOT OPENING, FUEL GAS DEFECTIVE, REAR LIGHT SYSTEM HAS ELECTRICAL PROBLEM ALL THE TIMES, A/C SYSTEM ELECTRICAL PROBLEM.
NHTSA complaint #11342278 — an unverified report by a vehicle owner.
West Palm Beach, FL
UNKNOWN OR OTHER
TRUCK DOOR IS NOT OPENING, FUEL GAS DEFECTIVE, REAR LIGHT SYSTEM HAS ELECTRICAL PROBLEM ALL THE TIMES, A/C SYSTEM ELECTRICAL PROBLEM.
NHTSA complaint #11342278 — an unverified report by a vehicle owner.
at 160,000 milesPasadena, MD
ENGINE
OIL PUMP OIL RINGS TO LEAD TO OIL PICKUP TUBE FAILED CAUSING DROP IN OIL PRESSURE. THIS HAPPENS WHEN DRIVING VEHICLE 2 HOURS PLUS.
NHTSA complaint #11337806 — an unverified report by a vehicle owner.
Pensacola, FL
UNKNOWN OR OTHER
AIR CONDITIONING WILL RANDOMLY SWITCH TO HOT AIR WHILE DRIVING. IF YOU STOP AND RESTART THE CAR AIR CONDITIONING WILL WORK AGAIN.
NHTSA complaint #11331460 — an unverified report by a vehicle owner.
Spout Spring, VA
POWER TRAIN
FIRST THE TRANSMISSION FAILED RIGHT AFTER I PURCHASED THE VEHICLE 2 YEARS AGO. I HAD TO BUY A NEW TRANSMISSION THAT WASN'T CHEAP AROUND $3,500. THEN THE FRONT WHEEL BEARINGS STARTED WITH THE RIGHT SIDE LAST YEAR JUST HAD A TON OF PLAY IN IT MY MECHANIC FOUND IT WHEN LIFTING UP MY TRUCK FOR A TIRE ROTATION. THEN THE LEFT FRONT WHEEL BEARING JUST STARTED MAKING A LOAD ROARING NOISE BUT HAD NO PLAY IN IT AT ALL THAT I COULD FEEL WHEN CHECKING IT OUT. BOTH COST AROUND $250 A WHEEL TO REPLACE. NOW MY 5.3 LITER ENGINE IS HAVING A KNOCKING SOUND WHEN AT A STOP AFTER DRIVING ABOUT 30 MINUTES OR WHEN THE ENGINE IS HOT. ALSO I AM HEARING A SLIGHT TICKING SOUND FROM THE ENGINE COLD OR HOT. I HAVE 4 SMALL KIDS SO I NEED A VERY RELIABLE LARGE VEHICLE AND THIS IS SUBURBAN IS DRIVING ME AND MY WIFE CRAZY HAVING TO POOR MONEY IN THIS VEHICLE EVERY YEAR. I AM THE SOIL PROVIDER FOR MY FAMILY I CANT AFFORD PUTTING ALL MY MONEY INTO A VEHICLE LIKE THIS.
NHTSA complaint #11322481 — an unverified report by a vehicle owner.
Spout Spring, VA
WHEELS
FIRST THE TRANSMISSION FAILED RIGHT AFTER I PURCHASED THE VEHICLE 2 YEARS AGO. I HAD TO BUY A NEW TRANSMISSION THAT WASN'T CHEAP AROUND $3,500. THEN THE FRONT WHEEL BEARINGS STARTED WITH THE RIGHT SIDE LAST YEAR JUST HAD A TON OF PLAY IN IT MY MECHANIC FOUND IT WHEN LIFTING UP MY TRUCK FOR A TIRE ROTATION. THEN THE LEFT FRONT WHEEL BEARING JUST STARTED MAKING A LOAD ROARING NOISE BUT HAD NO PLAY IN IT AT ALL THAT I COULD FEEL WHEN CHECKING IT OUT. BOTH COST AROUND $250 A WHEEL TO REPLACE. NOW MY 5.3 LITER ENGINE IS HAVING A KNOCKING SOUND WHEN AT A STOP AFTER DRIVING ABOUT 30 MINUTES OR WHEN THE ENGINE IS HOT. ALSO I AM HEARING A SLIGHT TICKING SOUND FROM THE ENGINE COLD OR HOT. I HAVE 4 SMALL KIDS SO I NEED A VERY RELIABLE LARGE VEHICLE AND THIS IS SUBURBAN IS DRIVING ME AND MY WIFE CRAZY HAVING TO POOR MONEY IN THIS VEHICLE EVERY YEAR. I AM THE SOIL PROVIDER FOR MY FAMILY I CANT AFFORD PUTTING ALL MY MONEY INTO A VEHICLE LIKE THIS.
NHTSA complaint #11322481 — an unverified report by a vehicle owner.
Spout Spring, VA
ENGINE
FIRST THE TRANSMISSION FAILED RIGHT AFTER I PURCHASED THE VEHICLE 2 YEARS AGO. I HAD TO BUY A NEW TRANSMISSION THAT WASN'T CHEAP AROUND $3,500. THEN THE FRONT WHEEL BEARINGS STARTED WITH THE RIGHT SIDE LAST YEAR JUST HAD A TON OF PLAY IN IT MY MECHANIC FOUND IT WHEN LIFTING UP MY TRUCK FOR A TIRE ROTATION. THEN THE LEFT FRONT WHEEL BEARING JUST STARTED MAKING A LOAD ROARING NOISE BUT HAD NO PLAY IN IT AT ALL THAT I COULD FEEL WHEN CHECKING IT OUT. BOTH COST AROUND $250 A WHEEL TO REPLACE. NOW MY 5.3 LITER ENGINE IS HAVING A KNOCKING SOUND WHEN AT A STOP AFTER DRIVING ABOUT 30 MINUTES OR WHEN THE ENGINE IS HOT. ALSO I AM HEARING A SLIGHT TICKING SOUND FROM THE ENGINE COLD OR HOT. I HAVE 4 SMALL KIDS SO I NEED A VERY RELIABLE LARGE VEHICLE AND THIS IS SUBURBAN IS DRIVING ME AND MY WIFE CRAZY HAVING TO POOR MONEY IN THIS VEHICLE EVERY YEAR. I AM THE SOIL PROVIDER FOR MY FAMILY I CANT AFFORD PUTTING ALL MY MONEY INTO A VEHICLE LIKE THIS.
NHTSA complaint #11322481 — an unverified report by a vehicle owner.
at 225,000 milesFayetteville, NC
SERVICE BRAKES
ON 4/11/2020, WHILE TRAVELING NORTHBOUND ON N. MAIN STREET, FAYETTEVILLE, NC AND ACCELERATING FROM THE STOPLIGHT AT THE INTERSECTION OF CAMDEN ROAD, I WAS REQUIRED TO APPLY THE BRAKES FORCEFULLY AND SUDDENLY DUE TO THE ACTIONS OF ANOTHER MOTORIST. ALMOST IMMEDIATELY AFTER APPLYING THE BRAKES, I LOST ALL BRAKING POWER AND RESORTED TO UTILIZING THE MANUAL PARKING BRAKE TO BRING THE VEHICLE UNDER CONTROL AND DRIVE IT CAREFULLY BACK TO MY RESIDENCE. AT THE MOMENT OF FAILURE, THE DASHBOARD BRAKE INDICATOR LIGHT (AKA, IDIOT LIGHT) ILLUMINATED AND A "SERVICE BRAKE SYSTEM" MESSAGE APPEARED ON THE INSTRUMENT CLUSTER. THE BRAKE INDICATOR LIGHT CONTINUED TO ILLUMINATE SPORADICALLY DURING THE TRIP BACK TO MY RESIDENCE WHEN TESTING THE BRAKE PEDAL FOR RESUMED FUNCTIONALITY. AFTER ARRIVING HOME, I PERFORMED A QUICK INSPECTION OF THE BRAKING SYSTEM AND FOUND THAT THE PORTION OF THE BRAKES LINES LOCATED ON THE OUTBOARD PORTION OF THE DRIVER'S SIDE FRAME RAIL HAD RUSTED AND PERFORATED NEAR THE ABS MODULE, CAUSING THE FAILURE ALONG WITH MASSIVE FLUID LOSS (SEE ATTACHED PICS). I PERFORMED A CURSORY INTERNET SEARCH AND DISCOVERED THAT THE NHTSA HAS ALREADY PERFORMED AN INVESTIGATION INTO THIS EXACT ISSUE AND THE INVESTIGATION WAS SUBSEQUENTLY CLOSED WITH NO RECALL ISSUED BY GM. OF NOTE, GM VEHICLES USE A MANUAL PRESSURE DIFFERENTIAL SWITCH LOCATED WITHIN THE BRAKE COMBINATION VALVE THAT ISOLATES THE DAMAGED CIRCUIT IN THE EVENT OF FAILURE AND ALSO ILLUMINATES THE DASHBOARD BRAKE LIGHT. THIS SYSTEM DID NOT OPERATE IN THIS INSTANCE AS EVIDENCED BY LOSING ALL BRAKING, AS OPPOSED TO REDUCED BRAKING, AS WELL AS THE BRAKE LIGHT NOT REMAINING ILLUMINATED. BASED ON THE APPEARANCE OF THE UNDERCARRIAGE AND INDICATION OF RUST IN SEVERAL SPOTS ON THE BODY (E.G, TAILGATE), I BELIEVE THIS TRUCK WAS OPERATED IN ONE OF THE RUST BELT STATES FOR A PERIOD OF TIME BY A PRIOR OWNER.
NHTSA complaint #11320901 — an unverified report by a vehicle owner.
