Owners have filed 53 complaints
about the 2024 Chevrolet Suburban with NHTSA between 2024 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 24 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 8
Against the median year of the Chevrolet Suburban. 50 means typical for this
model; 100 means roughly double.
Severity — 19
3.8% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 100
88% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2024 compares with every other Chevrolet Suburban
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
112.5%
1,000 – 9,999 miles
225.0%
10,000 – 24,999 miles
337.5%
25,000 – 49,999 miles
112.5%
50,000 – 74,999 miles
112.5%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Oct 2024peak 8Jul 2026
NHTSA investigations into the 2024 Chevrolet Suburban
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
2
investigations are
still open.
EA26005Opened 20 Aug 2026Still openENGINE
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s reca...
EA25007Opened 23 Oct 2025Still openENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to...
RQ26001Opened 16 Jan 2026Closed 20 Aug 2026ENGINE
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s reca...
PE25001Opened 16 Jan 2025Closed 23 Oct 2025ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing...
Recalls on the 2024 Chevrolet Suburban
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V274000
ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Risk: Engine failure increases the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202522549,848 units in Canada
Engine
Issue: On certain vehicles, the connecting rods and/or crankshaft components may not have been manufactured properly. As a result, the engine could make abnormal noises and a warning light may turn on. If you continue to drive the vehicle with these symptoms, the engine could fail. Note: This recall only affects certain vehicles equipped with a 6.2 L V8 gas engine. Safety Risk: An engine failure could cause a sudden loss of power to the wheels and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to inspect and, if necessary, repair or replace the engine. For vehicles that pass the engine inspection, the dealer will replace the oil with a higher viscosity oil, install a new oil fill cap, replace the oil filter, and add an insert to the owner's manual.
Recall 202451938,382 units in Canada
Lights And Instruments
Issue: On certain vehicles, a software problem could cause the low brake fluid warning lamp not to turn on if the brake fluid level gets too low. A low brake fluid level can cause reduced braking. Safety Risk: A driver that isn't aware of a low brake fluid level could experience reduced braking and an increased risk of a crash. Corrective Actions: General Motors will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the electronic brake control module software. Alternatively, you may schedule an appointment to have the update performed at a GM dealership.
Recall 2024060273,306 units in Canada
Lights And Instruments
Issue: On certain vehicles, a software problem could cause the lower beam headlamps not to turn on as it becomes dark outside if the multi-function switch is in the "OFF" or "PARKING LAMP" position. This could also cause the daytime running lamps (DRLs) to turn off when the vehicle is moving. As a result, the vehicles may not meet certain requirements of Canadian regulations. Safety Risk: Headlamps and/or DRLs that don't turn on could reduce visibility, make the vehicle less visible to others and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to a dealership to update the body control module (BCM)software.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 58,277 milesFredericksburg, VACrash
STEERING
The contact owns a 2024 Chevrolet Suburban. The contact stated that while driving at approximately 30 MPH, the steering wheel locked at an angle, and the message "Power Steering Not Active" was displayed, causing the vehicle to strike a curb. The steering column, control arm, radiator, fender, and wheel were significantly damaged due to the incident. The vehicle was then towed to a dealer, where it was diagnosed that the power steering module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and an investigation was completed. The failure mileage was 58,277.
NHTSA complaint #11742905 — an unverified report by a vehicle owner.
Omak, WAFire
ENGINE
I parked at my home, approximately 5 minutes after arriving home my grandson ran in yelling papa your car is on fire. The engine was on fire, shooting flames onto the windsheild. The cause of fire is unknown at this time.
NHTSA complaint #11655369 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Saint Cloud, FL
POWER TRAIN
Transmission faulty, loud, clunky and hard shifting! Service transmission now alert and code P0747
NHTSA complaint #11751709 — an unverified report by a vehicle owner.
Saint Cloud, FL
ENGINE
Transmission faulty, loud, clunky and hard shifting! Service transmission now alert and code P0747
NHTSA complaint #11751709 — an unverified report by a vehicle owner.
Saint Cloud, FL
FUEL/PROPULSION SYSTEM
Transmission faulty, loud, clunky and hard shifting! Service transmission now alert and code P0747
NHTSA complaint #11751709 — an unverified report by a vehicle owner.
at 58,277 milesFredericksburg, VACrash
STEERING
The contact owns a 2024 Chevrolet Suburban. The contact stated that while driving at approximately 30 MPH, the steering wheel locked at an angle, and the message "Power Steering Not Active" was displayed, causing the vehicle to strike a curb. The steering column, control arm, radiator, fender, and wheel were significantly damaged due to the incident. The vehicle was then towed to a dealer, where it was diagnosed that the power steering module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and an investigation was completed. The failure mileage was 58,277.
NHTSA complaint #11742905 — an unverified report by a vehicle owner.
Granbury, TX
ENGINE
On May 2, 2026, while the vehicle was in operation, the engine suddenly shut off without warning. At the time of failure, the instrument panel remained illuminated; however, the vehicle would not restart. In an effort to resolve the issue, the battery was replaced, but this did not correct the problem. The vehicle was then towed to a local Chevrolet dealership for further inspection and diagnosis. Following their assessment, I was informed by the dealership’s service department that the engine had seized and that metal debris was present in the engine oil, indicating significant internal engine failure. I was further advised that a replacement engine has been ordered. At no point prior to this incident were there any warning indicators, abnormal noises, or performance issues that would have suggested an impending engine failure. The sudden nature of this incident raises concerns regarding the cause of failure and whether it may be related to a defect or internal mechanical issue.
NHTSA complaint #11737261 — an unverified report by a vehicle owner.
Boiling Springs, PA
UNKNOWN OR OTHER
1. Sunroof 2. Driving on 81 N slightly past the Middlesex exit at highway speeds. My 4 minor children and I heard what sounded like a large balloon popping inside my car. Upon further inspection, my sunroof spontaneously exploded. Absolutely nothing hit our car. The more research I’m doing, this is a known issue with GM manufactures and they have done nothing to correct this issue. 3. I’m working on getting a repair scheduled, once we figure out if it’s under warranty or we have to pay for it through insurance. 4. No warnings
NHTSA complaint #11736953 — an unverified report by a vehicle owner.
Charlotte, NC
VISIBILITY/WIPER
Windshield wipers stopped working
NHTSA complaint #11736233 — an unverified report by a vehicle owner.
Flora, MS
POWER TRAIN
The vehicle would jerk when changing gears and would have a rattle and vibration when accelerating.
NHTSA complaint #11735937 — an unverified report by a vehicle owner.
Flora, MS
ENGINE
The vehicle would jerk when changing gears and would have a rattle and vibration when accelerating.
NHTSA complaint #11735937 — an unverified report by a vehicle owner.
Afton, WY
UNKNOWN OR OTHER
The glass of the front movable sun roof shattered. The glass shattered while driving on hwy 89 in Wyoming with no traffic or no identifiable reason for the event. While some glass was saved most of it blew out when is shattered. The problem has not been reproduced or confirmed by the dealer. The dealer blames a flying rock or other object impacting the glass even though no vehicles or source of incident impact was perceived. No one was interested in taking a report. There was a build up of pressure inside the vehicle prior to the blow out of the glass which caused the drivers ear's to pop when the sun roof blew. The remaining glass was visibly pushed upwards away from the vehicle. A picture is available.
NHTSA complaint #11735323 — an unverified report by a vehicle owner.
at 5,000 milesRockport, TX
ELECTRICAL SYSTEM: INTEGRATED TRAILER BRAKE CONTROL
The contact owns a 2024 Chevrolet Suburban. The contact stated that while towing a trailer, the message "Trailer Brakes Disconnected" was displayed. Due to the failure, the trailer brakes locked up and the trailer came to an abrupt and rough stop. Upon investigation, the contact discovered Technical Service Bulletin: 23-NA-149; which was related to the solar panel battery charger or generator on the trailer. The trailer battery was fully charged and had a higher charge than the battery needed and could back feed into the trailer brake power module and cause it to shut down. The dealer was notified of the failure, and the contact was informed that the vehicle was not under recall. The manufacturer was also notified of the failure, and the contact was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 5,000.
NHTSA complaint #11728081 — an unverified report by a vehicle owner.
Ponte Vedra, FL
POWER TRAIN
Upon stepping on brakes, the car shifts into Neutral and says “press start Button again.” This happened to me 2x now.
NHTSA complaint #11723167 — an unverified report by a vehicle owner.
Evanston, IL
ENGINE
Complete and sudden failure of the L87 V8 engine at 70 mph on the highway. Had to maneuver to the right shoulder and coast to a stop. Engine was seized and would not restart. Waited 4 hours on a dangerous highway for a tow truck which took the Chevy Suburban 200 miles to my home Chevrolet dealership. They have ordered a new engine but it is on backorder so no ETA. Vehicle was built 06-26-2024 and has not been recalled so Chevy says I do not get the extended warranty on the replacement engine.
NHTSA complaint #11721740 — an unverified report by a vehicle owner.
at 23,000 milesDacula, GA
POWER TRAIN
The contact owns a 2024 Chevrolet Suburban. The contact stated that while driving at various speeds, there was an abnormal sound coming from the rear of the vehicle. The sound became significantly louder while driving. The contact stated that while driving at highway speeds and depressing the brake pedal, the vehicle felt like the rear wheels would lock up. The contact stated that the rear wheels locked while reversing, causing the vehicle to jerk abnormally. The vehicle was taken to the dealer, where it was diagnosed with rear axle failure. The dealer determined that the rear axle needed to be replaced. The private warranty company declined to cover the repair unless the rear axle had completely failed. The manufacturer was notified of the failure and declined to cover the repair because the vehicle was no longer under warranty. The contact had previously reported the failure to the dealer, who could not duplicate the failure while the vehicle was still covered under warranty. Additionally, the contact stated that upon engaging the air recirculation, the contact smelled fumes. The vehicle was not repaired. The failure mileage was approximately 23,000.
NHTSA complaint #11715289 — an unverified report by a vehicle owner.
at 27,300 milesMaple Plain, MN
ENGINE AND ENGINE COOLING
The contact owns a 2024 Chevrolet Suburban. While driving at an undisclosed speed, the vehicle hesitated while accelerating. The vehicle was previously repaired under NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the failure persisted. The local dealer was contacted; however, the vehicle was not repaired. The manufacture was not notified of the failure. The failure mileage was 27,300.
NHTSA complaint #11714279 — an unverified report by a vehicle owner.
Troy, MI
ENGINE
The vehicle went into limp mode! Everything associated with it happened so quickly,no brakes,no steering ,it was terrifying. We got safely to a gas station. We were advised to take it to a certified Chevrolet dealer which we did We had it towed to the certified Chevrolet dealer in Charlevoix, Michigan.They hooked it up to the diagnostics and said they found absolutely nothing wrong with the vehicle.Very Frustrating! After experiencing this terrible incident will never feel safe in this vehicle!
NHTSA complaint #11713441 — an unverified report by a vehicle owner.
Troy, MI
SERVICE BRAKES
The vehicle went into limp mode! Everything associated with it happened so quickly,no brakes,no steering ,it was terrifying. We got safely to a gas station. We were advised to take it to a certified Chevrolet dealer which we did We had it towed to the certified Chevrolet dealer in Charlevoix, Michigan.They hooked it up to the diagnostics and said they found absolutely nothing wrong with the vehicle.Very Frustrating! After experiencing this terrible incident will never feel safe in this vehicle!
NHTSA complaint #11713441 — an unverified report by a vehicle owner.
Troy, MI
FUEL/PROPULSION SYSTEM
The vehicle went into limp mode! Everything associated with it happened so quickly,no brakes,no steering ,it was terrifying. We got safely to a gas station. We were advised to take it to a certified Chevrolet dealer which we did We had it towed to the certified Chevrolet dealer in Charlevoix, Michigan.They hooked it up to the diagnostics and said they found absolutely nothing wrong with the vehicle.Very Frustrating! After experiencing this terrible incident will never feel safe in this vehicle!
NHTSA complaint #11713441 — an unverified report by a vehicle owner.
Overland Park, KS
ENGINE
Sudden power loss on highway. Engine would not respond. We were fortunate to have been able to pull over to the side of the road but in an unsafe merging area. Vehicle restarted after multiple attempts, but engine would not exceed 3000 rpm causing unsafe speed on highway. Engine died again causing total power loss. I was able to coast down the hill to safely park out of the way of traffic. Tow truck was needed. Vehicle was towed to dealer where it was purchased. After inspection, the engine was confirmed to have failed. The dealer advised for engine replacement as part of the L87 recall. This engine was previously inspected less than 10,000 miles prior as part of the same recall, and the higher-weight oil had been used since per the manufacturer's recommendation. However the inspected engine appears to have failed regardless. This sudden loss of power happened about two weeks prior, with the driver able to pull to safety and restart. It was dismissed as a fluke since it did not occur for the next two weeks.
NHTSA complaint #11712278 — an unverified report by a vehicle owner.
Dryden, VA
POWER TRAIN
Both front CV axles have had to be replaced multiple times. Less than 70,000 miles on the vehicle.
NHTSA complaint #11706012 — an unverified report by a vehicle owner.
Freehold, NJ
ENGINE
I took my 2024 Chevrolet Suburban to get repairs associated with GM safety recall N252494000 - L87 Engine Loss of Propulsion. My vehicle "passed" the test, so the "correction" employed by GM is that "vehicles that pass inspection will be provided a higher viscosity oil, which will also require a new oil fill cap, an oil filer replacement, and an owner's manual insert." All of this was done free of charge. However, the owner's manual insert states that "For future engine oil changes, use SAE OW 40" oil. This updated owner's manual insert, which is provided as a solution to GM's recall of a faulty connecting road and/or crankshaft, causes the future costs of oil changes to increase from $160.00 to $230.00. Assuming quarterly oil changes, this will increase the cost of operating this vehicle to increase by $2,800 over an estimated 10 year lifespan. This increase should be covered by GM. GM sent me a letter that states, "If your dealer fails or is unable to remedy this defect without charge, or within a reasonable amount of time, you may submit a written complaint to the Administrator, NHTSA." By passing on the cost of the increase in oil change for all future oil changes, GM failed to remedy this defect without charge. I submit this claim because GM filed to remedy this defect without charge. Please see highlighted portions of attached documents in support.
NHTSA complaint #11695541 — an unverified report by a vehicle owner.
at 16,600 milesHinesville, GA
ENGINE
The contact owns a 2024 Chevrolet Suburban. The contact stated that while depressing the accelerator pedal, there was a loud rattling sound coming from the engine. The contact stated that while depressing the brake pedal, the vehicle failed to respond as intended while driving with her grandchildren inside the vehicle. The brake failure warning light was illuminated. The contact stated that the vehicle lost power and coasted and slowed down, and the contact shifted into park(P). The contact stated that the failure had occurred on two separate occasions. A dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 16,600.
NHTSA complaint #11695445 — an unverified report by a vehicle owner.
Hinesville Ga, GA
ENGINE
i pulled on to the road and i heard a loud knocking and my vehicle started skipping and wouldn't go. the lights on the dash lit up and said, "brake failure" and "emergency brake failure" and i had no brakes. I managed to coast into a parking lot. The engine light was on. I turned the vehicle off and waited about 5 minutes and turned it back on, The engine light remained. The first time this happened I was going down the road and the vehicle started sputtering, the emergency brake light came on the dash and the car shut off. It has a rough idle when you start it. I am terrified of this car. I have grandbabies in the car with me, Had i been on the highway either time i would have caused a terrible accident. The dealer says they can't get the car to do it so they can't fix anything. It has happened twice so you know it will again.
NHTSA complaint #11695456 — an unverified report by a vehicle owner.
at 16,600 milesHinesville, GA
SERVICE BRAKES
The contact owns a 2024 Chevrolet Suburban. The contact stated that while depressing the accelerator pedal, there was a loud rattling sound coming from the engine. The contact stated that while depressing the brake pedal, the vehicle failed to respond as intended while driving with her grandchildren inside the vehicle. The brake failure warning light was illuminated. The contact stated that the vehicle lost power and coasted and slowed down, and the contact shifted into park(P). The contact stated that the failure had occurred on two separate occasions. A dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 16,600.
NHTSA complaint #11695445 — an unverified report by a vehicle owner.
Hinesville Ga, GA
SERVICE BRAKES
i pulled on to the road and i heard a loud knocking and my vehicle started skipping and wouldn't go. the lights on the dash lit up and said, "brake failure" and "emergency brake failure" and i had no brakes. I managed to coast into a parking lot. The engine light was on. I turned the vehicle off and waited about 5 minutes and turned it back on, The engine light remained. The first time this happened I was going down the road and the vehicle started sputtering, the emergency brake light came on the dash and the car shut off. It has a rough idle when you start it. I am terrified of this car. I have grandbabies in the car with me, Had i been on the highway either time i would have caused a terrible accident. The dealer says they can't get the car to do it so they can't fix anything. It has happened twice so you know it will again.
NHTSA complaint #11695456 — an unverified report by a vehicle owner.