Owners have filed 151 complaints
about the 2023 Chevrolet Suburban with NHTSA between 2022 and 2026.
The largest single group is the engine & cooling.
Across this model's run it ranks 19 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 24
Against the median year of the Chevrolet Suburban. 50 means typical for this
model; 100 means roughly double.
Severity — 21
4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 90
53% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2023 compares with every other Chevrolet Suburban
Odometer readings owners gave when they filed. About half of all
complaints include one.
1,000 – 9,999 miles
315.8%
10,000 – 24,999 miles
421.1%
25,000 – 49,999 miles
421.1%
50,000 – 74,999 miles
210.5%
100,000 – 149,999 miles
631.6%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
Configuration
Overall
Front
Side
Rollover
2023 Chevrolet Suburban SUV 4WD
2023 Chevrolet Suburban SUV 2WD
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Nov 2022peak 11Aug 2026
NHTSA investigations into the 2023 Chevrolet Suburban
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
2
investigations are
still open.
EA26005Opened 20 Aug 2026Still openENGINE
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s reca...
EA25007Opened 23 Oct 2025Still openENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
Loss of motive power due to engine failure
The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001). GM determined that these engine failures were due to...
RQ26001Opened 16 Jan 2026Closed 20 Aug 2026ENGINE
Loss of motive power due to engine failure post recall remedy
On January 16, 2026, the Office of Defects Investigation (ODI) opened Recall Query RQ26001. This investigation was opened to assess the remedy effectiveness of Recall 25V-274. ODI has received complaints alleging engine failure in vehicles after the recall remedy had been completed, whether that remedy involved an oil viscosity change or a complete engine replacement. General Motors (GM) issued Recall 25V-274 to address concerns of engine failure in the L87 engines produced between March 1, 2021 and May 31, 2024. GM cited the root cause as a supplier manufacturing and quality issue. GM’s reca...
PE25001Opened 16 Jan 2025Closed 23 Oct 2025ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
Loss of motive power due to engine failure
On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing...
Recalls on the 2023 Chevrolet Suburban
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
25V274000
ENGINE AND ENGINE COOLING:ENGINE:HARD PARTS INTERNAL/MECHANICAL
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Risk: Engine failure increases the risk of a crash.
23V642000
SUSPENSION:REAR
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
Risk: A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
22V903000
EXTERIOR LIGHTING:LIGHTING CONTROL MODULE:SOFTWARE
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Risk: DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 202522549,848 units in Canada
Engine
Issue: On certain vehicles, the connecting rods and/or crankshaft components may not have been manufactured properly. As a result, the engine could make abnormal noises and a warning light may turn on. If you continue to drive the vehicle with these symptoms, the engine could fail. Note: This recall only affects certain vehicles equipped with a 6.2 L V8 gas engine. Safety Risk: An engine failure could cause a sudden loss of power to the wheels and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to inspect and, if necessary, repair or replace the engine. For vehicles that pass the engine inspection, the dealer will replace the oil with a higher viscosity oil, install a new oil fill cap, replace the oil filter, and add an insert to the owner's manual.
Recall 202451938,382 units in Canada
Lights And Instruments
Issue: On certain vehicles, a software problem could cause the low brake fluid warning lamp not to turn on if the brake fluid level gets too low. A low brake fluid level can cause reduced braking. Safety Risk: A driver that isn't aware of a low brake fluid level could experience reduced braking and an increased risk of a crash. Corrective Actions: General Motors will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the electronic brake control module software. Alternatively, you may schedule an appointment to have the update performed at a GM dealership.
Recall 2024060273,306 units in Canada
Lights And Instruments
Issue: On certain vehicles, a software problem could cause the lower beam headlamps not to turn on as it becomes dark outside if the multi-function switch is in the "OFF" or "PARKING LAMP" position. This could also cause the daytime running lamps (DRLs) to turn off when the vehicle is moving. As a result, the vehicles may not meet certain requirements of Canadian regulations. Safety Risk: Headlamps and/or DRLs that don't turn on could reduce visibility, make the vehicle less visible to others and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and advise you to take your vehicle to a dealership to update the body control module (BCM)software.
Recall 2023472163,611 units in Canada
Lights And Instruments
Issue: On certain vehicles, the automatic headlamps may not turn on soon enough as it becomes dark outside. Canadian regulations require automatic headlamps to turn on when the ambient light level drops below a certain point (1000 lux). Safety Risk: Headlamps that don't turn on as it becomes dark outside could reduce visibility and increase the risk of a crash. Corrective Actions: General Motors will notify owners by mail and send a wireless over-the-air software update to eligible vehicles to update the body control module (BCM) software. Alternatively, you may schedule an appointment to have the update performed at a GM dealership.
Recall 202270085,685 units in Canada
Lights And Instruments
Issue: On certain vehicles, the daytime running lamps (DRLs) may stay on when the headlamps are on. Canadian regulations require the DRLs to turn off when the headlamps are on. Safety Risk: Daytime running lamps that stay on could cause glare for oncoming drivers and increase the risk of a crash. Corrective Action: General Motors will notify owners by mail and instruct you to take your vehicle to a dealership to update the body control module (BCM) software.
Reports where the owner recorded a crash, a fire, an injury or a death.
Levittown, NYCrash1 injured
AIR BAGS
My vehicle was met with an accident on June 28, 2026. The accident was very swear and driver get internal injuries like swelling on face pain in head and ribs due to the heavy shock. But non of the airbag has been activated for safety of driver.
NHTSA complaint #11749632 — an unverified report by a vehicle owner.
Levittown, NYCrash1 injured
UNKNOWN OR OTHER
My vehicle was met with an accident on June 28, 2026. The accident was very swear and driver get internal injuries like swelling on face pain in head and ribs due to the heavy shock. But non of the airbag has been activated for safety of driver.
NHTSA complaint #11749632 — an unverified report by a vehicle owner.
Middletown, PA2 injured
STRUCTURE:BODY
OEM Running boards, non powered. It is available for inspection. The running boards are slippery evetime they are wet. Does not matter what shoes you have. I have slipped 4 times since owned the vehicle and even broke the interior panel of my driver side door in 2023 which lead to a$500 repair bill. My wife and I both slipped today (1/26/26) and bruised pretty bad. Kids have also slipped in the past. No, it was not inspected or reproduced but dealer did say its a common problem they see with the OEM running boards. No, it was not inspected by the dealer. No warning lamps since it is a non powered part.
NHTSA complaint #11713404 — an unverified report by a vehicle owner.
Wesley Chapel, FL1 injured
SEAT BELTS
While driving a 2023 Chevrolet Suburban (VIN: [XXX] ), my [XXX] son was seated in the second-row center seat and was properly buckled in with the factory shoulder/lap belt. He turned around briefly to grab something from the back of the vehicle, and during that movement the seatbelt fully extended and then locked in the automatic locking mode. The retractor would not release tension afterward. The belt continued tightening around his torso, and no amount of slack could be pulled back out. The belt became so tight that he was unable to breathe comfortably or free himself, and the locking mechanism would not disengage even after the vehicle was stopped and turned off. The seatbelt remained fully cinched and would not retract or loosen under any circumstances. Because the belt created a serious entrapment hazard and my child could not safely be removed, I was forced to cut the seatbelt to free him. This appears to be a dangerous malfunction of the seatbelt retractor/locking system and presents a significant safety risk, especially for children who may shift or turn in their seats during normal use. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11701833 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Mountain Home, ID
ENGINE
My 2023 Chevrolet Suburban equipped with the 3.0L Duramax diesel engine (LM2) has experienced a recurring engine oil leak involving the rear main seal/lower timing cover area. The vehicle has required repeated dealer repairs for substantially the same oil-leak condition, including major engine-related disassembly, but the leak has returned after repair. This is a safety concern because failure of the rear main seal or lower timing cover sealing system can result in loss of engine oil while the vehicle is being operated. A significant oil loss could potentially cause loss of oil pressure, engine damage or engine failure and resulting loss of propulsion while driving. Leaking engine oil also has the potential to contact hot engine or exhaust components, creating an additional safety concern. The problem has been inspected and confirmed by authorized GM dealerships and documented on multiple repair orders. This does not appear to be an isolated occurrence on this vehicle because substantially the same engine oil leak has required repair more than once. GM has previously issued service information, including Bulletin PIP5795, concerning rear main oil leaks on 3.0L LM2 Duramax engines where the rear main oil seal may move or become severely shifted out of position in the timing chain lower cover. I am concerned that repeated repair of this condition may not adequately address the underlying cause and that the oil leak could recur while the vehicle is being driven. I am requesting that NHTSA review complaints and repair data involving rear main seal/lower timing cover oil leaks on GM 3.0L Duramax-equipped vehicles to determine whether a broader safety-related defect exists.
NHTSA complaint #11758857 — an unverified report by a vehicle owner.
Twin Bridges, MT
ENGINE
Car died in middle of nowhere at high speeds
NHTSA complaint #11758796 — an unverified report by a vehicle owner.
Austin, TX
ENGINE
6.2 V8 while operating threw multiple error codes, went into crawl mode unexpectedly.
NHTSA complaint #11755148 — an unverified report by a vehicle owner.
at 25,300 milesDenver, CO
ENGINE AND ENGINE COOLING
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, the transmission erroneously shifted to neutral(N), and the vehicle decelerated unexpectedly. The vehicle was pulled off the freeway and parked on the shoulder of the road, and the police were contacted and arrived at the scene and assisted with removing the small children from the vehicle. The vehicle was later towed to a nearby towing lot. The contact later received messages on the App for transmission and engine failures. The cause of the failures was not yet determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The contact stated that the vehicle was previously serviced under the NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); even though the vehicle had experienced the failure listed in the recall. The failure mileage was 25,300.
NHTSA complaint #11754537 — an unverified report by a vehicle owner.
at 100,000 milesBluff Dale, TX
WHEELS:RIM
The contact owns a 2023 Chevrolet Suburban. The contact stated that the front passenger’s and rear driver’s side rims were cracked. The front passenger’s side rim was replaced by the dealer under warranty, while the rear driver’s side rim was replaced with an aftermarket part. The manufacturer was notified of the failures but declined assistance. The owner expressed concerns that the remaining factory rims might also crack and were prone to failure while driving. The failure mileage was approximately 100,000.
NHTSA complaint #11753928 — an unverified report by a vehicle owner.
Bowie, MD
SUSPENSION
I brought my Chevrolet Suburban High Country in to the dealer pursuant to a recall for engine issues due to a manufacturing defect in connecting rods and crankshafts that can cause catastrophic engine failure. The service center changed the oil viscosity and fill cap and stated that the change should eliminate the issue. I have had persistent engine knocking upon acceleration since then and it is getting louder and more prominent. A suspension warning intermittently flashes as well. Please advise, thank you
NHTSA complaint #11752309 — an unverified report by a vehicle owner.
Bowie, MD
ENGINE
I brought my Chevrolet Suburban High Country in to the dealer pursuant to a recall for engine issues due to a manufacturing defect in connecting rods and crankshafts that can cause catastrophic engine failure. The service center changed the oil viscosity and fill cap and stated that the change should eliminate the issue. I have had persistent engine knocking upon acceleration since then and it is getting louder and more prominent. A suspension warning intermittently flashes as well. Please advise, thank you
NHTSA complaint #11752309 — an unverified report by a vehicle owner.
Greenville, KY
ENGINE
We purchased a 2023 Chevy Suburban in January of 2026. In May the vehicle shut off on me at a stop light. The check engine light flashed after I was able to restart it. I took it to the dealer and they said they "couldn't recreate the issue" even though there was an engine misfire code on all cylinders. They told me to come pick it up and bring it back if I had further issues. The second time this happened I had issues getting the vehicle started. This was June 2026 Once I finally got it started and was driving all the service lights started going off and the check engine light started flashing. I took it to a different chevy dealer and was told the same thing. This time I had 23 different service codes that showed up. Including the engine misfire code. So we picked it up and continued to drive it. On July 10th we were towing a 7k lb camper home when we lost all power. Thankfully we weren't driving fast and we're able to stop. This left us stranded at a busy intersection for 2 hours. The car would not go out of neutral. Had we been going 70 on an interstate we could have very seriously been hurt. The car had to be towed back to the dealership where we were told the engine locked up and needed to be replaced. My husband and I had our [XXX] child in the backseat with us. This was a family car that we purchased and told twice that they couldn't find anything wrong with it. The vehicle has been at the dealership waiting on a motor since July 11th. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11751691 — an unverified report by a vehicle owner.
Peachtree City, GA
FUEL/PROPULSION SYSTEM
The fuel pump module on this vechicle failed, and there's a recall for 2021 I believe other years should be considered as well since this was a known issue as soon as we arrived at the dealership and they wanted over $400 to replace this part which is only $45.
NHTSA complaint #11750581 — an unverified report by a vehicle owner.
Levittown, NYCrash1 injured
AIR BAGS
My vehicle was met with an accident on June 28, 2026. The accident was very swear and driver get internal injuries like swelling on face pain in head and ribs due to the heavy shock. But non of the airbag has been activated for safety of driver.
NHTSA complaint #11749632 — an unverified report by a vehicle owner.
Levittown, NYCrash1 injured
UNKNOWN OR OTHER
My vehicle was met with an accident on June 28, 2026. The accident was very swear and driver get internal injuries like swelling on face pain in head and ribs due to the heavy shock. But non of the airbag has been activated for safety of driver.
NHTSA complaint #11749632 — an unverified report by a vehicle owner.
New Rochelle, NY
STRUCTURE:BODY
The sunroof drains continue to fail. I’ve had multiple occasions where the car has had drains back up or be disconnected.. This is a safety issue because it creates mold as water falls in the headliner and then the cabin. It also creates rust, particularly behind the dashboard. That’s not rust proof. Despite being under warranty, the dealers are useless and helping address the issue because it’s la design flaw. The multiple water intrusions also affect the electronics in the vehicle., potentially disabling critical features like airbags and safety systems.
NHTSA complaint #11744913 — an unverified report by a vehicle owner.
Atchison, KS
ELECTRICAL SYSTEM
The engine of this car has been under recall for multiple issues during the time we have owned it. The most recent issue that was experienced was total engine failure and electrical malfunction while driving on a busy street near train tracks. The vehicle was making a loud banging sound moments before this occurred. I wasn't even given time to get to a safe spot to investigate the issue. When it shut down, a quick message flashed across the dash board--stating ability to shift had been lost (or something to that effect)--the vehicle then flipped into neutral and immediately lost power. My safety was put at great risk due to the fact that the entire vehicle shut down moments after I crossed over a very busy railway track. The vehicle had to be towed to a nearby Chevrolet dealership where it has been confirmed there was total engine failure as well as blown main electrical fuse.
NHTSA complaint #11744096 — an unverified report by a vehicle owner.
Atchison, KS
ENGINE
The engine of this car has been under recall for multiple issues during the time we have owned it. The most recent issue that was experienced was total engine failure and electrical malfunction while driving on a busy street near train tracks. The vehicle was making a loud banging sound moments before this occurred. I wasn't even given time to get to a safe spot to investigate the issue. When it shut down, a quick message flashed across the dash board--stating ability to shift had been lost (or something to that effect)--the vehicle then flipped into neutral and immediately lost power. My safety was put at great risk due to the fact that the entire vehicle shut down moments after I crossed over a very busy railway track. The vehicle had to be towed to a nearby Chevrolet dealership where it has been confirmed there was total engine failure as well as blown main electrical fuse.
NHTSA complaint #11744096 — an unverified report by a vehicle owner.
Buffalo, WY
ENGINE
My 2023 Chevrolet Suburban Premier is covered under GM recall 25V-274 for the 6.2L L87 engine defect (loss of propulsion from connecting rod and crankshaft failure). In XXX, the dealer notified me my vehicle required a full engine replacement under this recall. Wareing Sheridan Chevrolet in [XXX] replaced the engine, and the vehicle was out of service approximately 12 to 14 days. Approximately 6,000 miles later, on XXX, the replacement engine failed while I was driving on the interstate highway near Billings, Montana. There were no warning indicators of any kind until I suddenly lost power. Only at the moment power was lost did the check engine light come on and a low oil pressure warning appear. I was barely able to get the vehicle off the interstate before it died. I had my family in the vehicle, and losing power on the interstate with no warning created a serious risk of a crash. The vehicle had to be towed to Denny Menholt Chevrolet in Billings, MT. On June 13, 2026, the dealer confirmed the vehicle needs a second complete engine replacement under the same recall. This is the second L87 engine failure and second full engine replacement on this vehicle under recall 25V-274. No crash or injuries occurred. I have an open case with GM (#XXX). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11743908 — an unverified report by a vehicle owner.
Buffalo, WY
FUEL/PROPULSION SYSTEM
My 2023 Chevrolet Suburban Premier is covered under GM recall 25V-274 for the 6.2L L87 engine defect (loss of propulsion from connecting rod and crankshaft failure). In XXX, the dealer notified me my vehicle required a full engine replacement under this recall. Wareing Sheridan Chevrolet in [XXX] replaced the engine, and the vehicle was out of service approximately 12 to 14 days. Approximately 6,000 miles later, on XXX, the replacement engine failed while I was driving on the interstate highway near Billings, Montana. There were no warning indicators of any kind until I suddenly lost power. Only at the moment power was lost did the check engine light come on and a low oil pressure warning appear. I was barely able to get the vehicle off the interstate before it died. I had my family in the vehicle, and losing power on the interstate with no warning created a serious risk of a crash. The vehicle had to be towed to Denny Menholt Chevrolet in Billings, MT. On June 13, 2026, the dealer confirmed the vehicle needs a second complete engine replacement under the same recall. This is the second L87 engine failure and second full engine replacement on this vehicle under recall 25V-274. No crash or injuries occurred. I have an open case with GM (#XXX). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11743908 — an unverified report by a vehicle owner.
Derby, KS
POWER TRAIN
The vehicle was shaking and shuddering when trying to maintain highway speeds. Would have to slow down to maintain safety. The dealership advised the transmission needs replaced however we are seeing this is a widespread problem that GM has refused to admit fault for.
NHTSA complaint #11743051 — an unverified report by a vehicle owner.
at 56,000 milesLake Orion, MI
STEERING
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to turn and exhibited resistance, with no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that the steering wheel had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 56,000.
NHTSA complaint #11742984 — an unverified report by a vehicle owner.
Hopkinton, MA
POWER TRAIN
Transmission malfunction. This has appeared several times at highway speeds and low speeds. Driver to limp along in the slow lane to exit ramp and take back roads to get back to base. The current problem has been confirmed with error codes P0747. Check engine light comes on with a screen prompt “Reduced Acceleration Drive with Care”.
NHTSA complaint #11742124 — an unverified report by a vehicle owner.
Snellville, GA
POWER TRAIN
With out any warning engine shake and running roughly Loud engine noise more than ticking and losing power with reduce speed
NHTSA complaint #11740206 — an unverified report by a vehicle owner.
Wilmington, NC
ENGINE
The engine siezed up due to the issues that are related to the recall. Currently waiting for a new engine, it has been almost 5 weeks and no time frame on when it will be fixed.
NHTSA complaint #11738983 — an unverified report by a vehicle owner.
Sparta, TN
ENGINE
After performing all preventative, regular, and even proactive maintenance, the vehicle started shaking and shutting down with 2 miles. We are now being told (by 3 separate mechanics) that it needs an entirely new engine.
NHTSA complaint #11738667 — an unverified report by a vehicle owner.
at 104,849 milesLas Vegas, NV
ENGINE AND ENGINE COOLING
The contact owns a 2023 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the messages “Coolant Control Valve” and “Acceleration Reduced – Stop Vehicle” were displayed. The vehicle was taken to the dealer, where it was diagnosed and determined that the coolant control valve had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 104,849.
NHTSA complaint #11734824 — an unverified report by a vehicle owner.
Kenosha, WI
ENGINE
While driving on interstate XXX on 4/17/2026 my vehicle lost power I had to pull over on the shoulder thankfully I was able to do so. Restarted the vehicle for just a short bit and it said loss of engine oil pressure and died. would not restart. Ultimately had to be towed to a GM dealership Lynch Chevrolet in [XXX] . Was told the engine was shot and was covered under the safety recall. There was a recall on the motor I had brought it in to get rectified sept 2025.a heavier weight oil was added and filler cap replaced with 40 weight oil identification. . I just had an oil change the day before the incident on 4/16. What is concerning I'm worried about the long wait plus plus online blogs that indicate the engine failed numerous times even after replacement. I was told from the dealership that the engine was on back order and they cannot give me a time on when it's going to be available. But again I'm worried about this vehicle in general in moving forward or trying to anyway. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA complaint #11733473 — an unverified report by a vehicle owner.
Kuna, ID
UNKNOWN OR OTHER
The sound in the vehicle goes silent and I'm not able to verify audibly that my turn signals are working or not. Which has led to a couple of near misses while in traffic. Power has been cycled and the call hang up botton has been depressed to soft reset the system and it still isn't working.
NHTSA complaint #11731027 — an unverified report by a vehicle owner.