Owners have filed 265 complaints
about the 2004 Chevrolet Suburban with NHTSA between 2004 and 2026.
The largest single group is the electrical system.
Across this model's run it ranks 14 of 32 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 42
Against the median year of the Chevrolet Suburban. 50 means typical for this
model; 100 means roughly double.
Severity — 62
12.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 37
22% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
How 2004 compares with every other Chevrolet Suburban
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
41.9%
1,000 – 9,999 miles
157.1%
10,000 – 24,999 miles
178.1%
25,000 – 49,999 miles
3516.6%
50,000 – 74,999 miles
4219.9%
75,000 – 99,999 miles
3416.1%
100,000 – 149,999 miles
3516.6%
150,000+ miles
2913.7%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2004 Chevrolet Suburban 1500 4-DR. w/SAB
—
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 2004peak 9Mar 2026
NHTSA investigations into the 2004 Chevrolet Suburban
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA04012Opened 30 Apr 2004Closed 28 Feb 2005SERVICE BRAKES, HYDRAULIC:POWER ASSIST
HYDRAULIC PUMP FAILRES
GM IS CONDUCTING A RECALL ON ALL SUBJECT VEHICLES BUILD BETWEEN MAY 1999 AND OCTOBER 14, 1999.SIGNIFICANT CHANGES WERE INCORPORATED INTO PRODUCTION IN EARLY OCTOBER 1999, AND VEHICLES BUILT AFTER THAT DATE HAVE LOWER WARRANTY FAILURE RATES.THE COMPLAINT AND WARRANTY DATA APPEAR TO SUPPORT THE EFFECTIVENESS OF THESE CHANGES. GM MADE ADDITIONAL CHANGES IN NOVEMBER 1999, FEBRUARY 2000, MAY 2001, AND FEBRUARY 2004.ODI WILL CONTINUE TO MONITOR THIS PROBLEM AND WILL TAKE FURTHER ACTION, IF WARRANTED, IN THE FUTURE.FOR FURTHER TECHNICAL DETAILS SEE THE ATTACHED ENGINEERING ANALYSIS REPORT.
Recalls on the 2004 Chevrolet Suburban
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06V289000
ENGINE AND ENGINE COOLING
ON CERTAIN TRUCKS EQUIPPED WITH AN 8.1L V8 (RPO L8-VIN G) ENGINE HAVE A CONDITION IN WHICH THE ENGINE FUEL RAIL PULSE DAMPER RETAINER CLIP MAY FRACTURE RESULTING IN INADEQUATE RETENTION OF THE DAMPER.
Risk: IF THE DAMPER COMES LOOSE, A FUEL LEAK MAY RESULT. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
06E043000
FUEL SYSTEM, GASOLINE
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
Risk: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
06E026000
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
05V163000
SEAT BELTS:REAR/OTHER
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
Risk: A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
05V043000
SERVICE BRAKES, HYDRAULIC
CERTAIN TRUCKS, SPORT UTILITY VEHICLES, AND VANS EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
Risk: IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
04V045000
SERVICE BRAKES, HYDRAULIC
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
Risk: CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
Canada — Transport Canada
Canada runs its own recall programme, and its campaigns do not
always mirror the American ones.
Recall 2011074190,310 units in Canada
Heater And Defroster
On certain vehicles, the interface between the electrical terminals of the Heating, Ventilation, and Air Conditioning (HVAC) blower relay resistor module and the wiring connector (which powers the module) may be incapable of conducting higher current levels for sustained periods of operation. In addition, moisture and other contaminants (such as road de-icing materials) may enter the fresh air intake plenum and contact the internal circuit of the module or corrode the terminals. These conditions may cause the relay resistor module or wiring connector to overheat, causing various symptoms such as: the HVAC blower may not function on certain or all blower speed settings; a burning-plastic smell or smoke may be present in the vehicle, or; the HVAC blower may run continually with the ignition in the OFF position. These warning signs could, in certain instances, be leading indicators of an impending vehicle fire, which could result in property damage and/or personal injury. Correction: Owners will be provided with additional warranty coverage for the blower motor resistor module/wiring connector overheating condition. Under this "special warranty coverage", should this condition occur within 10 years or 240,000 km from first vehicle registration, dealers will install a replacement blower motor resistor and resistor module connector.
Recall 20061951,485 units in Canada
Fuel System
On certain vehicles, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of the damper. If the damper comes loose, a fuel leak may result. Fuel leakage in the presence of an ignition source could result in a fire. Correction: Dealers will replace the engine fuel rail pulse damper retainer clip.
Recall 200511973,473 units in Canada
Seats And Restraints
On certain vehicles, the 2nd row centre occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants. A lap portion of the seat belt routing that is not low and snug on the hips can allow unfavourable occupant kinetics in the event of a crash. Moreover, the higher routing allows the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury. Correction: Dealers will modify the guide loop.
Recall 20050335,014 units in Canada
Brakes
On certain vehicles, the hydraulic brake booster's pressure accumulator may crack and/or separate from the Hydro-Boost assembly during normal vehicle operating conditions. If a separation occurred and the hood of the vehicle was open, fragments from the accumulator could cause injury to people in the immediate area. In addition, the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort. Correction: Dealers will test and, if necessary, replace the Hydro-Boost assembly.
Recall 20040374,075 units in Canada
Brakes
On certain vehicles, the relief valve o-ring seal within the brake hydro-boost module could fail. If this happens during braking applications, the driver may be able to hear an engine compartment noise similar to the sound that occurs when the steering wheel is turned to a full stop position. The driver could also experience a slight increase in steering efforts while braking and parking. Under certain driving conditions, a slight increase in the applied brake pedal effort may be required to achieve the same vehicle deceleration rate as prior to the seal failure. Correction: Dealers will inspect the hydro-boost module, and replace it, if necessary.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 200,000 milesHuntington, WV1 injured
AIR BAGS
The contact owns a 2004 Chevrolet Suburban. The contact stated that while driving approximately 45 mph he noticed the temperature gauge increased to the high indicator. The engine coolant hot message was displayed. The contact stated that while attempting to pull over there was an abnormal popping noise and smoke was detected. The air bag warning light illuminated and the driver's side air bag deployed without impact or crash and struck the driver in the face, chest, and right hand. There was no medical attention provided, or a fire or police report filed. The vehicle was left on the side of the road. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.
NHTSA complaint #11499926 — an unverified report by a vehicle owner.
at 200,000 milesHuntington, WV1 injured
ENGINE AND ENGINE COOLING
The contact owns a 2004 Chevrolet Suburban. The contact stated that while driving approximately 45 mph he noticed the temperature gauge increased to the high indicator. The engine coolant hot message was displayed. The contact stated that while attempting to pull over there was an abnormal popping noise and smoke was detected. The air bag warning light illuminated and the driver's side air bag deployed without impact or crash and struck the driver in the face, chest, and right hand. There was no medical attention provided, or a fire or police report filed. The vehicle was left on the side of the road. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.
NHTSA complaint #11499926 — an unverified report by a vehicle owner.
at 149,587 milesSilver Spring, MDCrash
SERVICE BRAKES
WHILE AVOIDING ANOTHER VEHICLE I APPLIED MY BRAKES SUDDENLY. THE BAKE LIKE CONNECTING THE ABS UNIT AND THE REAR BRAKES FAILED DUE TO CORROSION/RUST THAT WAS NOT OBSERVABLE DUE TO THE LINE BEING RAN BETWEEN THE VEHICLES FRAME AND BODY AND GAS TANK. ALTHOUGH THIS LOCATION MIGHT HAVE MADE FOR EASY MANUFACTURING IT HAS LED TO THE LINE BEING IN A LOCATION THAT CANNOT BE VISUALLY INSPECTED TO PREVENT DANGEROUS CONDITIONS FROM BUILDING UP FROM LACK OF AWARENESS. .
NHTSA complaint #10927389 — an unverified report by a vehicle owner.
at 93,267 milesUpper Marlboro, MDCrash
SERVICE BRAKES
TOTAL BRAKE FAILURE (VEHICLE HAS 95,387) MILES) AT 40 MPH IN MOTION. STABIL-TRAC LIGHT INDICATED AT THE TIME OF FAILURE, SERVICE BRAKE INDICATOR ON DISPLAY INFORMATION CONSOLE. . DEPLOYED 4WD LOW, DROPPED TO LOWER GEAR AND HIT EMERGENCY BRAKE TO STOP THE VEHICLE ON SHOULDER OF ROAD. GOT OUT OF VEHICLE SAW BRAKE FLUID ALL OVER THE SKIDS AND FRAME. CAUSE: TOWED TO LOCAL SHOP INDICATED THAT BRAKE LINES ON DRIVER SIDE AND LINES GOING TO FRONT WHEEL WERE COMPLETELY RUSTY AND "LIKE PAPER". THIS WAS UNSETTLING I DON'T LIVE NEAR SALTWATER BUT DRIVE THE VEHICLE A LOT IN WINTER. HAD I BEEN IN A DENSELY POPULATED AREA, THERE CERTAINLY WOULD HAVE BEEN LOSS OF LIFE. THIS VEHICLE WEIGHS OVER 6000 LBS AND NO BRAKES IS LIKE TO TRYING TO STOP A TRAIN. PLEASE INVESTIGATE SIMILAR FAILURES AS THIS FAILURE IN SIMILAR VEHICLES/ANY VEHICLE COULD CAUSE LOSS OF LIFE.
NHTSA complaint #10914923 — an unverified report by a vehicle owner.
at 93,267 milesUpper Marlboro, MDCrash
ELECTRONIC STABILITY CONTROL (ESC)
TOTAL BRAKE FAILURE (VEHICLE HAS 95,387) MILES) AT 40 MPH IN MOTION. STABIL-TRAC LIGHT INDICATED AT THE TIME OF FAILURE, SERVICE BRAKE INDICATOR ON DISPLAY INFORMATION CONSOLE. . DEPLOYED 4WD LOW, DROPPED TO LOWER GEAR AND HIT EMERGENCY BRAKE TO STOP THE VEHICLE ON SHOULDER OF ROAD. GOT OUT OF VEHICLE SAW BRAKE FLUID ALL OVER THE SKIDS AND FRAME. CAUSE: TOWED TO LOCAL SHOP INDICATED THAT BRAKE LINES ON DRIVER SIDE AND LINES GOING TO FRONT WHEEL WERE COMPLETELY RUSTY AND "LIKE PAPER". THIS WAS UNSETTLING I DON'T LIVE NEAR SALTWATER BUT DRIVE THE VEHICLE A LOT IN WINTER. HAD I BEEN IN A DENSELY POPULATED AREA, THERE CERTAINLY WOULD HAVE BEEN LOSS OF LIFE. THIS VEHICLE WEIGHS OVER 6000 LBS AND NO BRAKES IS LIKE TO TRYING TO STOP A TRAIN. PLEASE INVESTIGATE SIMILAR FAILURES AS THIS FAILURE IN SIMILAR VEHICLES/ANY VEHICLE COULD CAUSE LOSS OF LIFE.
NHTSA complaint #10914923 — an unverified report by a vehicle owner.
at 160,000 milesPeyton, CO2 injured
AIR BAGS
TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. AFTER TURNING THE IGNITION KEY TO START THE ENGINE, BOTH THE DRIVER AND PASSENGER SIDE AIR BAGS ERRONEOUSLY DEPLOYED. DURING THE INCIDENT, THE DRIVER SUSTAINED CHEST AND FACIAL BRUISES AND LACERATIONS. THE FRONT PASSENGER SUSTAINED BRUISES AND LACERATIONS TO BOTH ARMS AND HANDS. MEDICAL ATTENTION WAS NOT RECEIVED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
NHTSA complaint #10736186 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Goldsboro, NC
AIR BAGS
Front passenger dash airbag spontaneously deployed without any inciting event. The vehicle is at the Team Chevrolet Goldsboro dealership. A case has been opened with General Motors Case Number XXX. No prior warning - it smoked for a few seconds then deployed. No prior warning lights.
NHTSA complaint #11728354 — an unverified report by a vehicle owner.
at 150,000 milesBrownfield, TX
ELECTRICAL SYSTEM: INSTRUMENT CLUSTER/PANEL
The contact owns a 2004 Chevrolet Suburban. The contact stated that while driving at an undisclosed speed at night, the instrument panel gauges, and warning lights functionality became inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.
NHTSA complaint #11584565 — an unverified report by a vehicle owner.
at 200,000 milesHuntington, WV1 injured
AIR BAGS
The contact owns a 2004 Chevrolet Suburban. The contact stated that while driving approximately 45 mph he noticed the temperature gauge increased to the high indicator. The engine coolant hot message was displayed. The contact stated that while attempting to pull over there was an abnormal popping noise and smoke was detected. The air bag warning light illuminated and the driver's side air bag deployed without impact or crash and struck the driver in the face, chest, and right hand. There was no medical attention provided, or a fire or police report filed. The vehicle was left on the side of the road. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.
NHTSA complaint #11499926 — an unverified report by a vehicle owner.
at 200,000 milesHuntington, WV1 injured
ENGINE AND ENGINE COOLING
The contact owns a 2004 Chevrolet Suburban. The contact stated that while driving approximately 45 mph he noticed the temperature gauge increased to the high indicator. The engine coolant hot message was displayed. The contact stated that while attempting to pull over there was an abnormal popping noise and smoke was detected. The air bag warning light illuminated and the driver's side air bag deployed without impact or crash and struck the driver in the face, chest, and right hand. There was no medical attention provided, or a fire or police report filed. The vehicle was left on the side of the road. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 200,000.
NHTSA complaint #11499926 — an unverified report by a vehicle owner.
Ore City, TX
STEERING
Brake/abs light on and ecbm for abs not working no anti lock brake system and for the electrical vehicle has all kinds of electrical issues had to remove fuse to radio because of it going bonkers and it wouldn't turn off or down sounds like a fax machine or old school dial up internet sounds all the time and siren sounds were coming from radio and speakers only way to make it stop was to pull the fuse and have had to get multiple four wheel alignments because of steering and steering has to much play in it before suburban turns
NHTSA complaint #11471888 — an unverified report by a vehicle owner.
Ore City, TX
ELECTRICAL SYSTEM
Brake/abs light on and ecbm for abs not working no anti lock brake system and for the electrical vehicle has all kinds of electrical issues had to remove fuse to radio because of it going bonkers and it wouldn't turn off or down sounds like a fax machine or old school dial up internet sounds all the time and siren sounds were coming from radio and speakers only way to make it stop was to pull the fuse and have had to get multiple four wheel alignments because of steering and steering has to much play in it before suburban turns
NHTSA complaint #11471888 — an unverified report by a vehicle owner.
Ore City, TX
SERVICE BRAKES
Brake/abs light on and ecbm for abs not working no anti lock brake system and for the electrical vehicle has all kinds of electrical issues had to remove fuse to radio because of it going bonkers and it wouldn't turn off or down sounds like a fax machine or old school dial up internet sounds all the time and siren sounds were coming from radio and speakers only way to make it stop was to pull the fuse and have had to get multiple four wheel alignments because of steering and steering has to much play in it before suburban turns
NHTSA complaint #11471888 — an unverified report by a vehicle owner.
at 238,239 milesLake View, SC
SUSPENSION
TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE SHIFTING GEARS, THERE WAS AN ABNORMAL CLUNKING SOUND COMING FROM UNDERNEATH THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THERE WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 238,239.
NHTSA complaint #11413497 — an unverified report by a vehicle owner.
at 238,239 milesLake View, SC
STRUCTURE:BODY
TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT WHILE SHIFTING GEARS, THERE WAS AN ABNORMAL CLUNKING SOUND COMING FROM UNDERNEATH THE VEHICLE. THERE WERE NO WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THERE WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 238,239.
NHTSA complaint #11413497 — an unverified report by a vehicle owner.
at 270,000 milesFort Worth, TX
STEERING
THE HYDRO BOOSTER IS DEFECTIVE. THE CAR TRIGGERS MY BREAKS AND MAKES NOISES MAKE STEERING BRAKING DIFFICULT. IT HAPPENS EVERYFAY THROUGHT THE DAY WHILE IM DRIVING
NHTSA complaint #11352858 — an unverified report by a vehicle owner.
at 270,000 milesFort Worth, TX
SERVICE BRAKES
THE HYDRO BOOSTER IS DEFECTIVE. THE CAR TRIGGERS MY BREAKS AND MAKES NOISES MAKE STEERING BRAKING DIFFICULT. IT HAPPENS EVERYFAY THROUGHT THE DAY WHILE IM DRIVING
NHTSA complaint #11352858 — an unverified report by a vehicle owner.
at 270,000 milesFort Worth, TX
ELECTRONIC STABILITY CONTROL (ESC)
THE HYDRO BOOSTER IS DEFECTIVE. THE CAR TRIGGERS MY BREAKS AND MAKES NOISES MAKE STEERING BRAKING DIFFICULT. IT HAPPENS EVERYFAY THROUGHT THE DAY WHILE IM DRIVING
NHTSA complaint #11352858 — an unverified report by a vehicle owner.
at 150,000 milesMorgantown, WV
SERVICE BRAKES
ABS BREAKS KICKING IN AT LOW SPEED AND NOT STOPPING ALMOST WRECKED SEVERAL TIMES
NHTSA complaint #11209447 — an unverified report by a vehicle owner.
at 130,050 milesPort Saint Lucie, FL
VISIBILITY/WIPER
REAR TAILGATE GLASS HAS SEPARATED FROM THE GLUED ON HINGES AND DROPPED DOWN ON THE DRIVERS SIDE. THIS APPEARS TO BE AN ONGOING DESIGN, QUALITY ISSUE AND HAS HAPPENED ON A LARGE NUMBER OF SUV STYLE CHEVROLET VEHICLES AS CAN BE SEEN USING A SIMPLE INTERNET SEARCH CONCERNING THIS ISSUE.
NHTSA complaint #11209173 — an unverified report by a vehicle owner.
at 128,000 milesMinneapolis, MN
AIR BAGS
TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. WHILE THE VEHICLE WAS IN MOTION, THE DRIVER'S SIDE AIR BAG DEPLOYED WITH FORCE. A YELLOW SUBSTANCE EMITTED INSIDE THE VEHICLE WHEN THE FAILURE OCCURRED. THE DEPLOYMENT OCCURRED WITHOUT WARNING OR AN IMPACT. THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.
NHTSA complaint #11191828 — an unverified report by a vehicle owner.
at 192,000 milesIrving, TX
SERVICE BRAKES
TL* THE CONTACT OWNS A 2004 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING THE SAME FAILURE AS LISTED IN NHTSA CAMPAIGN NUMBER: 04V045000 (SERVICE BRAKES, HYDRAULIC). THERE WERE NO WARNING INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE BRAKE BOOSTER SYSTEM NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 192,000.
NHTSA complaint #11183550 — an unverified report by a vehicle owner.
at 158,000 milesJanesville, WI
ELECTRICAL SYSTEM
THE TRUCK FAILS TO RESTART AFTER DRIVING IT AN AT FIRST IT WOULD RESTART AFTER 15 - 20 MINUTES AFTER IT SITS AN NOW IT DOES NOT START AT ALL SO FAR I KNOW IT IS HAPPENING TO MORE THAN 20 VEHICLES INCLUDING THE STATE PATROL 2016 SUBURBANS AND SEVERAL OF THE PICKUPS
NHTSA complaint #11160856 — an unverified report by a vehicle owner.
Venice, FL
UNKNOWN OR OTHER
CRACKED DASH, NEVER REMOVED, GARAGE KEPT. CRACKED RUNS THROUGH DASH FROM FRONT WINDOW TOWARDS RADIO CLUSTER. DASH HAS SHARP PIECES THAT IN ACCIDENT CAN EASILY BE BROKEN OFF.
NHTSA complaint #11062873 — an unverified report by a vehicle owner.
at 170,000 milesAnnapolis, MD
FUEL/PROPULSION SYSTEM
THE EXHAUST MANIFOLD BOLTS HAVE SNAPPED OFF, 4 OF THEM TO BE EXACT. EXHAUST FUMES CAN NOW LEAK INTO TO THE CAB AND POISON OCCUPANTS.
NHTSA complaint #10966725 — an unverified report by a vehicle owner.
at 190,000 milesTacoma, VA
POWER TRAIN
INSTRUMENT CLUSTER SHORTS OUT AND GEAR INDICATOR GOES BLANK. NO MESSAGE CENTER INFORMATION WARNINGS ARE DISPLAYED. PART IS DEFECTIVE AND CAR MAKERS SHOULD REPLACE IT. NOT KNOWING WHAT GEAR VEHICLE IS IN CAN LEAD TO DEATH IF VEHICLE LEFT IN NEUTRAL AND ROLLS AWAY. GM NEEDS TO FIX THIS EXPENSIVE PROBLEM. ALSO 4L60E TRANSMISSION ON THESE VEHICLES FAILS AND STARTS SLIPPING BECAUSE OF DEFECTIVE SUN SHELL AND REAL PISTON SEAL. GM SHOULD RECALL ALL THESE BAD TRANSMISSIONS. WARRANTY SHOULD HAVE BEEN FOR LIFE. WHY SHOULD SUCH AN EXPENSIVE PART TO REPAIR FAIL UNDER NORMAL USE? RECALL ! BOTH THESE PARTS FAIL WHEN DRIVING. ALL WARNING OF VEHICLE CONDITIONS ARE SENT TO FAILED CLUSTER. VEHICLE WAS MADE IN MEXICO FOR RE-IMPORTATION AND SALE IN USA AND MAYBE PARTS SUPPLIERS IN MEXICO PROVIDED DEFECTIVE PARTS. MANY PEOPLE HAVE SUFFERED FINANCIAL LOSS TRYING TO FIX THESE PROBLEMS, LASTLY, THE EMISSION SOLENOID NEAR THE TANK ALSO FAILS. VEHICLE MAY NOT PASS EMISSION.
NHTSA complaint #10945428 — an unverified report by a vehicle owner.
at 190,000 milesTacoma, VA
ELECTRICAL SYSTEM
INSTRUMENT CLUSTER SHORTS OUT AND GEAR INDICATOR GOES BLANK. NO MESSAGE CENTER INFORMATION WARNINGS ARE DISPLAYED. PART IS DEFECTIVE AND CAR MAKERS SHOULD REPLACE IT. NOT KNOWING WHAT GEAR VEHICLE IS IN CAN LEAD TO DEATH IF VEHICLE LEFT IN NEUTRAL AND ROLLS AWAY. GM NEEDS TO FIX THIS EXPENSIVE PROBLEM. ALSO 4L60E TRANSMISSION ON THESE VEHICLES FAILS AND STARTS SLIPPING BECAUSE OF DEFECTIVE SUN SHELL AND REAL PISTON SEAL. GM SHOULD RECALL ALL THESE BAD TRANSMISSIONS. WARRANTY SHOULD HAVE BEEN FOR LIFE. WHY SHOULD SUCH AN EXPENSIVE PART TO REPAIR FAIL UNDER NORMAL USE? RECALL ! BOTH THESE PARTS FAIL WHEN DRIVING. ALL WARNING OF VEHICLE CONDITIONS ARE SENT TO FAILED CLUSTER. VEHICLE WAS MADE IN MEXICO FOR RE-IMPORTATION AND SALE IN USA AND MAYBE PARTS SUPPLIERS IN MEXICO PROVIDED DEFECTIVE PARTS. MANY PEOPLE HAVE SUFFERED FINANCIAL LOSS TRYING TO FIX THESE PROBLEMS, LASTLY, THE EMISSION SOLENOID NEAR THE TANK ALSO FAILS. VEHICLE MAY NOT PASS EMISSION.
NHTSA complaint #10945428 — an unverified report by a vehicle owner.
at 149,587 milesSilver Spring, MDCrash
SERVICE BRAKES
WHILE AVOIDING ANOTHER VEHICLE I APPLIED MY BRAKES SUDDENLY. THE BAKE LIKE CONNECTING THE ABS UNIT AND THE REAR BRAKES FAILED DUE TO CORROSION/RUST THAT WAS NOT OBSERVABLE DUE TO THE LINE BEING RAN BETWEEN THE VEHICLES FRAME AND BODY AND GAS TANK. ALTHOUGH THIS LOCATION MIGHT HAVE MADE FOR EASY MANUFACTURING IT HAS LED TO THE LINE BEING IN A LOCATION THAT CANNOT BE VISUALLY INSPECTED TO PREVENT DANGEROUS CONDITIONS FROM BUILDING UP FROM LACK OF AWARENESS. .
NHTSA complaint #10927389 — an unverified report by a vehicle owner.
at 93,267 milesUpper Marlboro, MDCrash
SERVICE BRAKES
TOTAL BRAKE FAILURE (VEHICLE HAS 95,387) MILES) AT 40 MPH IN MOTION. STABIL-TRAC LIGHT INDICATED AT THE TIME OF FAILURE, SERVICE BRAKE INDICATOR ON DISPLAY INFORMATION CONSOLE. . DEPLOYED 4WD LOW, DROPPED TO LOWER GEAR AND HIT EMERGENCY BRAKE TO STOP THE VEHICLE ON SHOULDER OF ROAD. GOT OUT OF VEHICLE SAW BRAKE FLUID ALL OVER THE SKIDS AND FRAME. CAUSE: TOWED TO LOCAL SHOP INDICATED THAT BRAKE LINES ON DRIVER SIDE AND LINES GOING TO FRONT WHEEL WERE COMPLETELY RUSTY AND "LIKE PAPER". THIS WAS UNSETTLING I DON'T LIVE NEAR SALTWATER BUT DRIVE THE VEHICLE A LOT IN WINTER. HAD I BEEN IN A DENSELY POPULATED AREA, THERE CERTAINLY WOULD HAVE BEEN LOSS OF LIFE. THIS VEHICLE WEIGHS OVER 6000 LBS AND NO BRAKES IS LIKE TO TRYING TO STOP A TRAIN. PLEASE INVESTIGATE SIMILAR FAILURES AS THIS FAILURE IN SIMILAR VEHICLES/ANY VEHICLE COULD CAUSE LOSS OF LIFE.
NHTSA complaint #10914923 — an unverified report by a vehicle owner.
at 93,267 milesUpper Marlboro, MDCrash
ELECTRONIC STABILITY CONTROL (ESC)
TOTAL BRAKE FAILURE (VEHICLE HAS 95,387) MILES) AT 40 MPH IN MOTION. STABIL-TRAC LIGHT INDICATED AT THE TIME OF FAILURE, SERVICE BRAKE INDICATOR ON DISPLAY INFORMATION CONSOLE. . DEPLOYED 4WD LOW, DROPPED TO LOWER GEAR AND HIT EMERGENCY BRAKE TO STOP THE VEHICLE ON SHOULDER OF ROAD. GOT OUT OF VEHICLE SAW BRAKE FLUID ALL OVER THE SKIDS AND FRAME. CAUSE: TOWED TO LOCAL SHOP INDICATED THAT BRAKE LINES ON DRIVER SIDE AND LINES GOING TO FRONT WHEEL WERE COMPLETELY RUSTY AND "LIKE PAPER". THIS WAS UNSETTLING I DON'T LIVE NEAR SALTWATER BUT DRIVE THE VEHICLE A LOT IN WINTER. HAD I BEEN IN A DENSELY POPULATED AREA, THERE CERTAINLY WOULD HAVE BEEN LOSS OF LIFE. THIS VEHICLE WEIGHS OVER 6000 LBS AND NO BRAKES IS LIKE TO TRYING TO STOP A TRAIN. PLEASE INVESTIGATE SIMILAR FAILURES AS THIS FAILURE IN SIMILAR VEHICLES/ANY VEHICLE COULD CAUSE LOSS OF LIFE.
NHTSA complaint #10914923 — an unverified report by a vehicle owner.
at 133,282 milesHenrico, VA
SERVICE BRAKES
2004 CHEVY SUBURBAN - SUDDEN & COMPLETE LOSS OF BRAKE PRESSURE AT HIGHWAY SPEED. VEHICLE BRAKES WERE INSPECTED IN JULY THROUGH THE VA STATE INSPECTION PROGRAM - NO ISSUES FOUND - TODAY ON 8/30/16 WHILE EXITING A FREEWAY RAMP AT 60MPH TRAFFIC CAME TO SUDDEN STOP. WHEN THE SERVICE BRAKE WAS APPLIED IN WHAT WOULD BE CONSIDERED A STAB/EMERGENCY BRAKING MANEUVER THERE WAS A COMPLETE AND SUDDEN LOSS OF BRAKE PRESSURE - PEDAL WENT TO FLOOR WITHOUT WARNING, BRAKE WOULD NOT PUMP UP ADEQUATE ENOUGH TO SLOW VEHICLE. I HAD TO USE A COMBINATION OF PARKING BRAKE APPLICATION AND UTILIZING THE SOFT SHOULDER AND DITCH TO STOP THE VEHICLE. THE BRAKE WARNING INDICATOR (RED) AND SERVICE INDICATOR DID NOT ILLUMINATE UNTIL AFTER THE THIRD OR FOURTH APPLICATION OF THE BRAKE PEDAL. SUBURBAN WAS TOWED. CAUSATIVE FACTORS = RUPTURED BRAKE LINE.
NHTSA complaint #10899445 — an unverified report by a vehicle owner.
