Dodge Grand Caravan tire problems

TIRES

Tires 225/65R17 Cooper driving on interstate and stared bumping at 55mph.van towed and tires replaced.. no warning lights.. Whitten Brothers in Ashland VA inspected tires and indicated on a video that passenger side tires had come apart.. I had all four tires replaced because I was afraid the other two would come apart.. I think the safety of myself and my sister in the car with me. Also other people on the highway if the tires had blown.. Thanks for your help and thoughtfulness.

NHTSA complaint #11597812 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

The contact owns a 2013 Dodge Grand Caravan. The contact stated that while the vehicle was parked, the front driver's seat headrest deployed independently without impact. The check engine and TPMS warning lights were illuminated. No injuries were sustained, and no medical attention was received. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 143,000.

NHTSA complaint #11594765 — an unverified report by a vehicle owner.

TIRES

The contact owns a 2005 Dodge Grand Caravan. The contact stated while driving 30 MPH, the front driver’s side tire detached from the vehicle. The contact stated that the vehicle was towed to the residence and then towed to an independent mechanic. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the independent mechanic was unable to duplicate the failure. The contact was provided a cost for the repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 157,000.

NHTSA complaint #11541257 — an unverified report by a vehicle owner.

TIRES

At approximately 70 MPH on the highway, a loud thumping noise was heard near the passenger rear area. Vehicle was rocking back and forth and became very unstable to drive safely. Tire pressure was checked and confirmed to be at 38 PSI. However, upon observation, the tire was shaped into a oval with a marked bulge in the tread on one side of the tire. 225/65 R16 SL

NHTSA complaint #11536844 — an unverified report by a vehicle owner.

TIRES

The contact owns a 2007 Dodge Grand Caravan equipped with Cooper Tires, Tire Line: Evolution Tour, Tire Size: 215/65/R16, DOT Number: (not available). The contact stated while driving 60 MPH, the driver’s side front tire experienced a blowout causing the steering wheel to shake. The contact was able to pull over safely and replace the tire. The failure reoccurred while driving however, the front passenger’s side the tire experienced the blowout. The dealer was contacted and stated that the tire was not under warranty. The manufacturer had been notified of the failure. The failure mileage was approximately 112,393.

NHTSA complaint #11472773 — an unverified report by a vehicle owner.

TIRES

IN REGARDS TO COOPER TIRES THE MANUFACTURER INFO AND DOT NUMBER TO FOLLOW. I HAVE HAD TWO TIRES WITH FAILURE TO THE RADIAL BELT SHIFT. ONE TIRE BLEW OUT ON A TRIP TO TEXAS, I DO NOT HAVE IT, BUT THE TOW TRUCK DRIVER SAID IT HAD A "BULGE" AND FAILED. UNDER STRESSFUL CONDITIONS ON A HIGHWAY I DID NOT TAKE A PICTURE. THE SECOND TIRE FAILED LOCALLY AND I HAVE KEPT THE TIRE AND CAN SEND A PIC AND ALSO HAVE A STATEMENT ON THE RECEIPT FROM WHERE I PURCHASED THE VEHICLE THAT HAD PUT THE TIRES ON SAYING IT WAS A "BELT SHIFT" THERE IS A PROMINENT "BULGE" IN THE TIRE. I HAD ORIGINALLY CONTACTED COOPER TIRES JULIE CALL REF # 23-167554 ON 9/23/20 11:02 AM, REGARDING THE DEFECTIVE TIRES AND THEY DENIED KNOWLEDGE OR RESPONSIBILITY AND TOLD ME TO TAKE THE VEHICLE BACK TO WHERE I BOUGHT IT WHICH WAS NISSAN AUTO NATION BECAUSE THEY WERE UNDER WARRANTY. AUTO NATION PAMELA CARTER SAID ON 9/24/20 THEY THAT THEY WILL NOT HONOR THE WARRANTY DUE TO THE FACT THEY PURCHASED THE TIRES AND I PURCHASED THE VEHICLE AFTER THE TIRES WERE INSTALLED SO I WAS NOT THE PURCHASER. THEY DO ADMIT THE TIRE WAS DEFECTIVE, WHICH I HAVE IN WRITING ON INVOICE 1236567. I LOOKED ONLINE FOR THE DOT NUMBER FOR RECALL AND IT IS LISTED ONLINE BUT THE MANUFACTURER AS BRIDGESTONE, WHICH IS POSSIBLY A TYPOGRAPHICAL ERROR. HERE IS THE INFO: DOT U94C 1CW 0715 COOPER M+S 235/60R16 GRAND TOURING

NHTSA complaint #11362968 — an unverified report by a vehicle owner.

TIRES

IN REGARDS TO COOPER TIRES THE MANUFACTURER INFO AND DOT NUMBER TO FOLLOW. I HAVE HAD TWO TIRES WITH FAILURE TO THE RADIAL BELT. ON 8/4/19 I WAS ON MY WAY TO FT. WORTH TEXAS WHEN I THE FRONT LEFT TIRE ON THE DRIVER'S SIDE STARTED THUMPING. I WAS ON HWY 10 IN EAST TEXAS NEAR CANTON AND IN A CONSTRUCTION ZONE THERE WAS NO WHERE TO PULL OVER SO I CONTINUED DRIVING SLOWLY WHICH WAS VERY STRESSFUL. THE TIRE DID BLOW BUT I WAS ABLE TO GET OFF AT A REST AREA (THANK YOU JESUS). I CALLED AAA AND THEY SENT A FAMILY OWNED TOW TRUCK SERVICE OUT. THE MAN SAID I HAD A BULGE IN THE WHAT REMAINED AND TOWED MY VAN TO A WALMART 13 MILES AWAY IN CANTON, I OWED HIM AT THAT POINT $27 OUT OF POCKET FOR THE TOW. HE THEN DROVE ME TO A PET FRIENDLY BEST WESTERN BECAUSE I HAD MY DOG WITH ME. I SPENT APPOX. $120 FOR THE ROOM, PLUS MEAL OF APPROX. $21. THE NEXT DAY I GOT A RIDE FROM AN EMPLOYEE AT THE HOTEL TO WALMART, PAID $128.66 FOR A NEW TIRE, THEN LATER THAT WEEK BALANCING OF $40 AT DISCOUNT TIRE IN DALLAS, TX. BECAUSE WALMART COULD NOT BALANCE THE NEW TIRE DUE TO EQUIPMENT BEING BROKEN. I HAD ANOTHER TIRE GO BAD, WITH TREAD SHIFT A YEAR LATER IN ANOTHER CLAIM FILED WITH YOU. THE REMAINING TWO TIRES I LEFT AT WALMART, AFTER PURCHASING FOUR NEW MATCHING GOODYEAR I SPENT $312.66 ON 9/26/20. AFTER THE SECOND TIRE WENT BAD I CONTACTED JULIE AT COOPER CALL REF# 23-167554 AND WAS TOLD THE TIRES WERE UNDER WARRANTY AND TO RETURN THEM TO WHERE I BOUGHT THE VEHICLE WITH THE NEW COOPER'S ON IT WHICH WAS IN 2018. I DID AND WAS TOLD BY PAMELA CARTER THAT THEY WOULD NOT HONOR THE WARRANTY BECAUSE AUTO NATION ORIGINALLY BOUGHT THE TIRES, BUT DID ADMIT THAT THE TIRE WAS DEFECTIVE. ALL FILED ON A SEPARATE INCIDENT REPORT WITH NHTSA #11362968. IN CONCLUSION, TTWO BAD COOPER TIRES, THE REMAINING TWO I GAVE TO WALMART AS I AM CONCERNED THAT THEY WILL ALSO BLOW OUT. IT IS MY HOPE THAT YOU WILL RECALL THESE TIRES BEFORE SOMEONE IS INJURED OR DIES: DOT U94C 1CW 0715 COOPER M+S 235/60R16 GRAND TOURING

NHTSA complaint #11362974 — an unverified report by a vehicle owner.

TIRES

2006 DODGE CARAVANS HAVE A DUMMY SPARE TIRE LOCATED NEAR THE GAS TANK SUBJECT TO ALL WEATHER CONDITIONS AND THEY BECOME DRY ROTTED AND CAN EXPLODE.THERE IS NO PROTECTION COVER THAT PREVIOUS DODGE CARS HAD. I HAD ONE BLOW AS I WAS ABOUT TO USE IT ON THE VAN. I SINCERELY NO ONE HAS ONE BLOW WHILE MOUNTED NEAR THE GAS TANK.

NHTSA complaint #11192517 — an unverified report by a vehicle owner.

TIRES

KUMHO SOLUS KH16 TIRES CAME ON MY NEW 2015 DODGE CARAVAN. ONLY 21000 MILES LATER, 3 OF THE 4 TIRES HAD PIECES OF TREAD CHUCKING OFF. TWO OF THE TIRES APPEAR TO HAVE SPLITTING IN THE RIM AREA AS IF THE CASING IS SEPARATING. I WAS 220 MILES FROM HOME ON CHRISTMAS VACATION WHEN I HAD ALL FOUR TIRES REPLACED. MY EXTENDED FAMILY HAS 2 CARAVANS WITH THE SAME KUMHO TIRES AND ALL SHOW THE SAME ISSUES. THE TIRE DEALER NOTED THE TIRES WERE MANUFACTURED IN 2014 (P225/65 R17 H100, CAB502C, 0261971, 011341SW). AFTER READING OTHER TIRE REVIEWS IT APPEARS THERE ARE MANY SAFETY AND WEAR ISSUES WITH THIS TIRE BRAND. I COULD NOT LOCATE AN AUTHORIZED KUMHO DEALER IN THE AMELIA ISLAND AREA THE DAY AFTER CHRISTMAS BUT DID NOT CARE AS I WOULD NEVER HAVE THIS BRAND ON ANY CAR I OWNED AFTER THIS EXPERIENCE. REALLY, HOW CAN THIS TIRE BE SOLD AT ALL?

NHTSA complaint #11164667 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TL* THE CONTACT OWNS A 2014 DODGE GRAND CARAVAN. WHEN THE VEHICLE WAS STARTED, THE TIRE PRESSURE WARNING INDICATOR ILLUMINATED. THE DEALER (B & B CHRYSLER DODGE JEEP RAM, 125 GRANDVIEW AVE, HONESDALE, PA) WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V632000 (TIRES), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS 87,000.

NHTSA complaint #11098432 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TL* THE CONTACT OWNS A 2011 DODGE GRAND CARAVAN. WHILE DRIVING UNKNOWN SPEEDS, THE TIRE PRESSURE MONITORING SYSTEM (TPMS) INDICATOR SPONTANEOUSLY ILLUMINATED. ADDITIONALLY, THE CONTACT HEARD AN ABNORMAL NOISE. THE CONTACT WAS UNABLE TO DETERMINE IF THERE WAS A FAILURE WITH THE TIRES SINCE THE TPMS INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO FERRARIO CHRYSLER TOWANDA (168 GOLDEN MILE RD, TOWANDA, PA 18848, (570) 485-0072) WHERE IT WAS DIAGNOSED THAT THE CODES NEEDED TO BE RESET. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED AND OPENED CASE NUMBER: 33719903. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 50,000.

NHTSA complaint #11097202 — an unverified report by a vehicle owner.

TIRES

4 HIGH QUALITY TIRES FROM GOODYEAR: 2 SOLD IN 2016 AND 2 SOLD IN 2017 FOR THE SAME VEHICLE FOUND TO HAVE THE RUBBER COMPOUND CRACKING AND SHOWING PREMATURE AGEING. ALL 4 TITRES SOLD, BALANCED AND INSTALLED BY GOODYEAR OUTLETS. TIRE 1) PURCHASED 03/12/2016 DOT#DAVRCUER PRODUCTION DATE 0515 (WEEK 5 OF 2015) TIRE 2) PURCHASED 03/12/2016 DOT# DAVRCUER PRODUCTION DATE 4314 (WEEK 43 OF 2014) TIRE 3) PURCHASED 01/15/2017 DOT# DAV8CUER PRODUCTION DATE 1715 !WEEK 17 OF 2015 TIRE 4) PURCHASED 01/15/2017 DOT# DAV8CUER PRODUCTION DATE 3814 (WEEK 38 OF 2014 THE TIRE MODEL IS 99H SL EAGLE LS2 VSB AND WERE MOUNTED ON A DODGE GRAND CARAVAN FOR FAMILY USE. WE WENT BACK TO THE ORIGINAL GOODYEAR DEALER CONCERNING THIS PROBLEM AND WERE TOLD THAT THE TIRES WERE SUFFERING FROM PREMATURE WEAR AND SHOULD BE CHANGED.THE RECOMMENDATION FROM THEM WAS TO CHANGE THE TIRE AFTER 4 YEARS. THE ISSUE IS THAT THE THE TIRES WERE ALREADY 2 YEARS OLD AT THE TIME OF BEING PURCHASED AS PREMIUM NEW TIRES AT A TOTAL COST OF $667.45. SO AFTER JUST 2 YEARS OF USE WE ARE FACED WITH THE CRACKING AND PREMATURE WEAR OF THE RUBBER COMPOUND CAUSING THE TIRE TO BECOME UNRELIABLE AND SUBJECT TO A PREMATURE FAILURE. WE ARE NOW REQUIRED FOR OUR OWN SAFETY AND THAT OF OTHER ROAD USERS TO PURCHASE 4 REPLACEMENT TIRES AT A COST OF $640.00 WHY ARE MAJOR TIRE MANUFACTURERS AND THEIR RETAILERS ALLOWED TO SELL TO THE PUBLIC OLD TIRES AS "NEW" ?.

NHTSA complaint #11080292 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TL* THE CONTACT OWNS A 2009 DODGE GRAND CARAVAN EQUIPPED WITH UNIROYAL TIRES, SIZE: 225/65R16 (NA). WHILE DRIVING, THE TIRE SENSOR WARNING INDICATOR ILLUMINATED. THE CONTACT WAS ABLE TO PULL OVER AND, UPON INSPECTING THE VEHICLE, DISCOVERED THAT THE REAR PASSENGER TIRE WAS FLAT. THE CONTACT REPLACED THE FLAT TIRE WITH THE SPARE. THE VEHICLE WAS TAKEN TO OURISMAN CHRYSLER DODGE JEEP RAM (12430 AUTO DR, CLARKSVILLE, MD 21029 (301) 596-9990) WHERE THE REAR PASSENGER TIRE WAS REPLACED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE CONTACT STATED THAT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DIAGNOSED WITH A PRESSURE MONITOR SYSTEM AND A TIRE PRESSURE SENSOR FAILURE IN THE REAR. ALSO, THE NUT VALVE STINT WAS CORRODED. THE CONTACT STATED THAT THE SENSOR WAS REPLACED FIVE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE DOT NUMBER WAS UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS 81,725.

NHTSA complaint #11047044 — an unverified report by a vehicle owner.

TIRES

TL* THE CONTACT OWNS A 2010 DODGE CARAVAN. WHILE DRIVING 70 MPH, THE TIRE PRESSURE WARNING INDICATOR ILLUMINATED AND THE VEHICLE DROVE ABNORMALLY. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER SAFELY. WHEN THE CONTACT EXITED THE VEHICLE, SHE OBSERVED THAT THE FRONT PASSENGER TIRE FAILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE PRESSURE SENSOR, WHICH WAS CONNECTED TO THE STEM FRACTURED, AND CAUSED A FAST FLAT. THE TIRE WAS REPLACED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 45,400. *LN CONSUMER STATED 2 TIRES HAVE LOST THE COLLARS AROUND THE VALVE STEM DUE TO CORROSION. ONE TIRE HAS COLLAR ON VALVE STEM (IT IS CRACKED) UPDATED*JB

NHTSA complaint #11031573 — an unverified report by a vehicle owner.

TIRES:TREAD/BELT

TL* THE CONTACT OWNS A 2016 DODGE CARAVAN EQUIPPED WITH YOKOHAMA AVID S33 TIRES, SIZE: 225/65R17. WHILE THE VEHICLE WAS PARKED, THE CONTACT OBSERVED THAT THE FRONT DRIVER AND PASSENGER SIDE TIRE THREADS BEGAN TO SEPARATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT TIRE SHOP WHERE IT WAS DIAGNOSED THAT THE TIRES NEEDED TO BE REPLACED. THE TIRE MANUFACTURER INFORMED THE CONTACT THAT THE TIRES WERE MADE TO LAST BETWEEN 2,500-30,000 MILES. NO FURTHER ASSISTANCE WAS PROVIDED. THE DOT NUMBER WAS UNKNOWN. THE TIRE AND VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 28,100.

NHTSA complaint #11029976 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

DRIVING STRAIGHT, APPROX 35 MPH ON 2-LANE STATE HIGHWAY PASSING THROUGH SMALL TOWN WITH RUSH HOUR TRAFFIC ON BOTH LANES AND NO SHOULDER. WITH NO PRIOR WARNING, ALL RED INSTRUMENT WARNING LIGHTS WENT ON AT ONCE, INCLUDING FUEL PUMP/THROTTLE, BRAKES AND OTHERS. CAR STALLED DEAD AND INSTANTANEOUSLY LOST POWER TO STEERING AND BRAKES, WAS IMPOSSIBLE TO CONTROL. WOULD NOT RESTART. FORTUNATELY DRIVER WAS ABLE TO STEER VEHICLE PARTLY OFF ROAD INTO A DRIVEWAY OF BUSY STORE, BLOCKING DRIVEWAY TO CUSTOMERS. STATE POLICE WERE UNABLE TO GET CAR IN NEUTRAL TO PUSH TO SAFE LOCATION. POLICE ORDERED CAR TOWED AND IT IS CURRENTLY AWAITING DIAGNOSIS FOR TOTALLY INTEGRATED POWER MODULE("TIPM") FAILURE AT DODGE DEALERSHIP. THIS WAS A LIFE-THREATENING FAILURE AND IF IT HAD HAPPENED AT NEARLY ANY OTHER LOCATION OR IN ADVERSE WEATHER THERE WOULD HAVE BEEN INJURY OR DEATH TO DRIVER AND PASSENGERS. WE HAVE TOW RECEIPT. WE DON'T KNOW WHETHER STATE POLICE FILED INCIDENT REPORT. MANY SIMILAR TIPM FAILURES OF DODGE AND CHRYSLER VEHICLES HAVE BEEN REPORTED TO NHTSA AND YOU HAVE RECENTLY REJECTED A CENTER FOR AUTO SAFETY PETITION FOR NHTSA INTERVENTION REGARDING THIS DEFECT. CHRYSLER/DODGE IS WELL AWARE OF THE PROBLEMS WITH THE TIPM BECAUSE 80,894 JEEP WRANGLERS AND DODGE NITRO VEHICLES WERE RECALLED IN 2007 FOR THE SAME PROBLEMS. IN THAT RECALL, DEFECTIVE TIPMS HAD A SOFTWARE PROBLEM THAT COULD CAUSE THE ENGINE TO STALL. NHTSA SHOULD REQUIRE DODGE TO RECALL EVERY MODEL THAT HAS THIS SAME TIPM INSTALLED AND TO IMMEDIATELY WARN THE PUBLIC THAT THEIR LIVES ARE IN DANGER EVERY TIME THEY DRIVE THEIR DODGE/CHRYSLER VEHICLE. IT IS UNCONSCIONABLE THAT THE MANUFACTURER AND NHTSA HAVE PREVIOUSLY BEEN INFORMED OF THIS DANGEROUS DEFECT AND FAILED TO PROTECT THE AMERICAN PUBLIC.

NHTSA complaint #10937195 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 11V394000 (AIR BAGS, EQUIPMENT) AND 14V373000 (AIR BAGS, ELECTRICAL SYSTEM); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIRS. THE CONTACT STATED THAT THE TIRE PRESSURE WARNING LIGHT ILLUMINATED. THE APPROXIMATE FAILURE MILEAGE WAS 67,912. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA complaint #10822633 — an unverified report by a vehicle owner.

TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS

TL* THE CONTACT OWNS A 2014 DODGE GRAND CARAVAN. WHILE DRIVING AT VARIOUS SPEEDS, THE TIRE PRESSURE MONITORING SYSTEM WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE TIRE PRESSURE WAS CHECKED AND AIR WAS PLACED IN THE TIRES, BUT THE WARNING REMAINED ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIRE PRESSURE MONITORING SYSTEM SENSOR FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000.

NHTSA complaint #10789265 — an unverified report by a vehicle owner.