Owners have filed 235 complaints
about the 2001 Jeep Wrangler with NHTSA between 2000 and 2024.
The largest single group is the body & structure.
Across this model's run it ranks 26 of 33 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 17
Against the median year of the Jeep Wrangler. 50 means typical for this
model; 100 means roughly double.
Severity — 100
28.1% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 27
16% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Body
2434.3%
Engine
912.9%
Switch
811.4%
Frontal
710.0%
Gasoline
68.6%
Manual Transmission
68.6%
Defroster/Defogger/Hvac System
57.1%
Front Underhood
57.1%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
21.4%
1,000 – 9,999 miles
85.8%
10,000 – 24,999 miles
96.5%
25,000 – 49,999 miles
1812.9%
50,000 – 74,999 miles
2316.5%
75,000 – 99,999 miles
2014.4%
100,000 – 149,999 miles
3625.9%
150,000+ miles
2316.5%
NHTSA crash tests
The agency crash-tested this model year itself. These are its own
photographs and star ratings.
These stars come from the pre-2011 crash test programme. NHTSA
rebuilt the programme for the 2011 model year and states that
ratings either side of that change are not comparable — so do
not read these against a 2011-or-newer car's stars.
Frontal crash test
Photographs taken by NHTSA during its own New Car Assessment Program crash
tests of this model year. Public domain.
Configuration
Overall
Front
Side
Rollover
2001 Jeep Wrangler 2-DR.
—
—
—
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Dec 2000peak 14Apr 2024
Recalls on the 2001 Jeep Wrangler
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06E026000
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
06E022000
SERVICE BRAKES, HYDRAULIC
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
Risk: LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
06E011000
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.
Risk: IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
04E041000
EQUIPMENT
BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.
Risk: SHOULD THIS OCCUR, THE COCKPIT COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME A DISTRACTION OR AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A VEHICLE CRASH.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH A 4.0L ENGINE ONLY, THE DESIGN OF THE INTAKE AND EXHAUST MANIFOLDS COULD ALLOW DEBRIS TO ACCUMULATE AT THE #3 CYLINDER LOCATION.
Risk: THIS COULD RESULT IN A VEHICLE FIRE.
02V075000
ELECTRICAL SYSTEM:IGNITION:SWITCH
ON CERTAIN SPORT UTILITY VEHICLES, WATER AND IMPURITIES CAN ENTER INTO THE IGNITION SWITCH, CAUSING A SHORT CIRCUIT.
Risk: THIS COULD RESULT IN A VEHICLE FIRE.
00V366000
CHILD SEAT
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Risk: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Reports where the owner recorded a crash, a fire, an injury or a death.
at 108,000 milesBelleview, MOFire
UNKNOWN OR OTHER
SPONTANEOUS VEHICLE FIRE WHILE PARKED FOR TWO WEEKS
NHTSA complaint #11129652 — an unverified report by a vehicle owner.
at 181,000 milesHighspire, PA1 injured
STEERING
DEFINITELY HAD A BAD EXPERIENCE WITH THE DEATH WOBBLE IN MY JEEP ALMOST CAUSING ME TO BE IN A CAR ACCIDENT. I FEEL THE PAIN IN BACK AND NECK. WILL HAVE TO GO TO DOCTORS TO GET THAT CHECKED. I WAS DRIVING ON INTERSTATE 83 WHEN I HIT A BUMP ON THE ROAD NEAR CONSTRUCTION AREA WHEN JEEP BEGAN TO WOBBLE OUT OF CONTROL. LUCKILY ANOTHER JEEP ON THE ROAD SAW WHAT WAS GOING ON AND MADE SPACE FOR ME TO EXIT THE HIGHWAY. I CALLED THE TOW TRUCK AND HAD IT TOWED. *DSY
NHTSA complaint #11091605 — an unverified report by a vehicle owner.
at 181,000 milesHighspire, PA1 injured
ELECTRONIC STABILITY CONTROL (ESC)
DEFINITELY HAD A BAD EXPERIENCE WITH THE DEATH WOBBLE IN MY JEEP ALMOST CAUSING ME TO BE IN A CAR ACCIDENT. I FEEL THE PAIN IN BACK AND NECK. WILL HAVE TO GO TO DOCTORS TO GET THAT CHECKED. I WAS DRIVING ON INTERSTATE 83 WHEN I HIT A BUMP ON THE ROAD NEAR CONSTRUCTION AREA WHEN JEEP BEGAN TO WOBBLE OUT OF CONTROL. LUCKILY ANOTHER JEEP ON THE ROAD SAW WHAT WAS GOING ON AND MADE SPACE FOR ME TO EXIT THE HIGHWAY. I CALLED THE TOW TRUCK AND HAD IT TOWED. *DSY
NHTSA complaint #11091605 — an unverified report by a vehicle owner.
Belle, WVCrash
SUSPENSION
FRAME RUSTING FROM INSIDE REAR CONTROL ARM FELL OFF CAUSING WRECK
NHTSA complaint #11055526 — an unverified report by a vehicle owner.
at 117,803 milesWhitehouse, TXFire
ELECTRICAL SYSTEM
I WAS DRIVING WITH THE AIR CONDITIONER ON WHEN I SMELLED BURNING PLASTIC, THEN SMOKE CAME OUT OF THE AIR VENTS. I PULLED OVER AND TURNED OFF THE AIR CONDITIONER AND GOT OUT OF THE VEHICLE. AFTER ABOUT 15 MIN THE SMELL DISSIPATED AND I CONTINUED ON WITHOUT THE AIR CONDITIONING. LATER I REMOVED THE COVERS AND FOUND THAT THERE HAD BEEN A FIRE IN THE PLUG THAT GOES TO THE BLOWER MOTOR RESISTOR
NHTSA complaint #11019377 — an unverified report by a vehicle owner.
West Grove, PAFire
ELECTRICAL SYSTEM
I HAD A FIRE DUE TO A RECALLED IGNITION SWITCH THAT WAS NEVER REPAIRED, I HAD NO IDEA WHEN I BOUGHT THE USED JEEP FROM THE DEALER. CHRYSLER IS NOW DENYING ANY REQUEST TO FIX THE PARTS DAMAGED BY THE FIRE
NHTSA complaint #10916812 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Carson City, NV
AIR BAGS
The airbag clock spring has failed causing an airbag light and shut down of airbag system. The part, Airbag clock spring with speed control has been discontinued by Jeep and nobody makes the 2001-2002 clock springs aftermarket.
NHTSA complaint #11584347 — an unverified report by a vehicle owner.
Wake Forest, NC
ELECTRICAL SYSTEM
There is a known problem with the electrical wiring to the climate control panel including the blower motor fan switch. The wiring attached to the assembly gets too hot and melts the blower motor fan switch. When this happens, you are unable to turn on any heat/ac/air speeds. You are not able to select any speed to turn on the air which means you can’t use it to defrost the windshield. This can lead to a poor visibility situation. I am the original owner of my 2001 TJ and I’ve had to have this problem fixed multiple times. There are several videos & discussions about this problem in Jeep forums. Chrysler should’ve recalled it years ago..
NHTSA complaint #11492073 — an unverified report by a vehicle owner.
Wake Forest, NC
VISIBILITY/WIPER
There is a known problem with the electrical wiring to the climate control panel including the blower motor fan switch. The wiring attached to the assembly gets too hot and melts the blower motor fan switch. When this happens, you are unable to turn on any heat/ac/air speeds. You are not able to select any speed to turn on the air which means you can’t use it to defrost the windshield. This can lead to a poor visibility situation. I am the original owner of my 2001 TJ and I’ve had to have this problem fixed multiple times. There are several videos & discussions about this problem in Jeep forums. Chrysler should’ve recalled it years ago..
NHTSA complaint #11492073 — an unverified report by a vehicle owner.
Parkville, MD
STRUCTURE:BODY
MY JEEP WAS MAKING GRINDING SOUNDS WHEN I SHIFTED GEARS. AT FIRST IT WAS JUST A QUICK GRIND (METAL AGAINST METAL). THEN IT GOT PROGRESSIVELY WORSE AS THIS LAST WEEK WENT BY. IT BECAME ALMOST IMPOSSIBLE TO SHIFT INTO REVERSE AND IT WOULD POP OUT OF GEAR UNEXPECTEDLY WHILE GOING DOWN THE ROAD.LUCKILY I DIDN'T DRIVE IT MUCH. I TOOK IT TO MY MECHANIC AND HE SAID I WAS LUCKY- MY TRANSMISSION(?) WAS TILTED AND SITTING ON SOMETHING AND THAT WAS CAUSING THE NOISE (THE LUCK WAS THAT THE TRANSMISSION DIDN'T FALL ALL THE WAY DOWN). THE DESCRIPTION OF THE PROBLEM FROM PRESTIGE HI-TECH IS "CHECK FOR NOISE/ GRINDING IN DRIVETRAIN. FRAME BADLY RUSTED OUT, CROSS MEMBER UNDER TRANSFER CASE, BOLTS PULLED OUT OF RUSTED FRAME." I WAS THEN TOLD IT WAS UNSAFE TO DRIVE. VISUALLY IT IS IN GREAT CONDITION WITHOUT RUST ON THE BODY. PRESTIGE SAID BOTH SIDES OF THE FRAME ARE RUSTED THROUGH BECAUSE OF POOR DESIGN. THERE WERE NO HOLES FOR TRAPPED WATER TO ESCAPE THROUGH.
NHTSA complaint #11258675 — an unverified report by a vehicle owner.
at 56,468 milesSaint Augustine, FL
AIR BAGS
TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEED, THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO JACKSONVILLE CHRYSLER DODGE JEEP RAM ARLINGTON (9600 ATLANTIC BLVD, JACKSONVILLE, FL 32225) WHERE IT WAS DIAGNOSED THAT THE PASSENGER AIR BAG NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, YEARS LATER THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,468.
NHTSA complaint #11207181 — an unverified report by a vehicle owner.
at 198,000 milesRockford, IL
UNKNOWN OR OTHER
FRAME ROTTED BY TRAIL ARMS AND CENTER BY SKID PLATE WHY DID CHRYSLER NEVER RECALL THESE FAULTY FRAMES?
NHTSA complaint #11156043 — an unverified report by a vehicle owner.
at 100,000 milesNorton, MA
UNKNOWN OR OTHER
FRAME BEGAN ROTTING OUT AT ROUGHLY 100,000 MILES. I DISCOVERED THIS WHILE DRIVING DOWN THE HIGHWAY ON MY COMMUTE HOME FROM WORK. WHILE ACCELERATING I FELT A SUDDEN POWER LOSS. THIS WENT ON FOR ANOTHER ROUNDTRIP THE FOLLOWING DAY. UPON RETURNING HOME THE FOLLOWING DAY I SAW SOMETHING HANGING FROM UNDERNEATH THE VEHICLE. IT WAS THE SKID PLATE, HANGING BY THE PASSENGER'S SIDE BOLTS, SUPPORTING THE ENTIRE WEIGHT OF THE DRIVETRAIN. THE DRIVESHAFT BEING AT THAT UNNATURAL ANGLE IS WHAT CAUSED THE LOSS OF POWER. TO THINK THAT I HAD DRIVEN 100 MILES THAT WAY WAS SLIGHTLY UNSETTLING. SINCE THEN I HAVE HAD THE FRAME WELDED, WHICH RAN $1,200. I HAVE SINCE HAD THE REAR RAILS (BEHIND REAR WHEELS) REPAIRED FOR AN ADDITIONAL $400. MY FRONT BODY MOUNT HAS ALSO ROTTED OUT, WHICH I FIXED MYSELF FOR $10, BUT SHOULD PROBABLY BE WELDED BY A PROFESSIONAL. BOTH MECHANIC AND WELDER SUGGESTED THAT FRAME ROT OCCURRED DUE TO LACK OF HOLES FOR WATER TO DRAIN OUT AND THAT THE SITTING WATER AND SALT JUST ATE AWAY AT EVERYTHING. THE CAR NOW HAS 215,000 MILES ON IT. I AM OTHERWISE HAPPY WITH THE CAR, BUT IT UPSETS ME THAT I COULD HAVE HAD A MAJOR ACCIDENT DUE TO THE POOR DESIGN OF THE FRAME. SEEMS STRANGE THAT THERE HAS NOT BEEN A FIX FOR THE ISSUE, NOR A RESPONSE FROM CHRYSLER TO ADDRESS THE FACT THAT PEOPLE CAN DIE AS A RESULT OF THE FRAME ROTTING OUT. MAYBE THAT'S WHAT HAS TO HAPPEN FOR A FIX?!? AT 200,000+ MILES YOU WOULD THINK I WOULD GO STRAIGHT BACK TO A WRANGLER ONCE THIS ONE BITES IT, BUT I WILL NEVER BUY A JEEP AGAIN BASED ON THIS ISSUE. I BOUGHT THIS AS A 25 YEAR OLD WITHOUT KIDS. WITH A 2 AND 4 YEAR OLD AT HOME, I WOULD NOT TRUST A JEEP TO TRANSPORT THEM (TOO BAD, AS MY SON LOVES MY JEEP DESPITE NEVER BEING IN IT). I LIVE IN THE NORTHEAST, SO RUST/ROT EXPECTED TO AN EXTENT. MY BROTHER OWNS A FORD F-250 USED FOR PLOWING..SAME YEAR, SAME MILAGE...NO ROT!
NHTSA complaint #11152472 — an unverified report by a vehicle owner.
at 108,000 milesBelleview, MOFire
UNKNOWN OR OTHER
SPONTANEOUS VEHICLE FIRE WHILE PARKED FOR TWO WEEKS
NHTSA complaint #11129652 — an unverified report by a vehicle owner.
at 107,000 milesDaniels, WV
STRUCTURE:FRAME AND MEMBERS:UNDERBODY SHIELDS
TL* THE CONTACT OWNS A 2001 JEEP WRANGLER. UPON INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRAME OF THE VEHICLE WAS COMPLETELY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THAT THE VEHICLE'S FRAME WAS RUSTED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE FRAME WAS NO LONGER BEING MANUFACTURED. THE FAILURE MILEAGE WAS 107,000.
NHTSA complaint #11110632 — an unverified report by a vehicle owner.
at 2 milesOwensboro, KY
UNKNOWN OR OTHER
THE FRAME ROTTED OUT WHERE THE SUSPENSION CONNECT TO THE FRAME
NHTSA complaint #11100467 — an unverified report by a vehicle owner.
Farmington Hills, MI
STRUCTURE:BODY
MY JEEP FRAME RUSTED OUT, FORCING US TO PURCHASE A NEW VEHICLE IN 2015. I AM THE ORIGINAL OWNER, FEMALE, NEVER WENT OFF-ROAD WITH IT AND IT WAS GARAGE KEPT. LESS THAN 90,000 MILES ON IT TODAY. UPSET THAT I CANNOT DRIVE IT BECAUSE OF THE FRAME AND CANNOT FIND FRAME TO REPLACE IT. I STILL OWN IT AND STILL WAITING TO FIND A FRAME FOR IT. NOW SITTING IN MY DRIVEWAY. EXCELLENT CONDITION, EXCEPT FOR THE FRAME! SEE PHOTO AS PROOF.
NHTSA complaint #11096825 — an unverified report by a vehicle owner.
at 181,000 milesHighspire, PA1 injured
STEERING
DEFINITELY HAD A BAD EXPERIENCE WITH THE DEATH WOBBLE IN MY JEEP ALMOST CAUSING ME TO BE IN A CAR ACCIDENT. I FEEL THE PAIN IN BACK AND NECK. WILL HAVE TO GO TO DOCTORS TO GET THAT CHECKED. I WAS DRIVING ON INTERSTATE 83 WHEN I HIT A BUMP ON THE ROAD NEAR CONSTRUCTION AREA WHEN JEEP BEGAN TO WOBBLE OUT OF CONTROL. LUCKILY ANOTHER JEEP ON THE ROAD SAW WHAT WAS GOING ON AND MADE SPACE FOR ME TO EXIT THE HIGHWAY. I CALLED THE TOW TRUCK AND HAD IT TOWED. *DSY
NHTSA complaint #11091605 — an unverified report by a vehicle owner.
at 181,000 milesHighspire, PA1 injured
ELECTRONIC STABILITY CONTROL (ESC)
DEFINITELY HAD A BAD EXPERIENCE WITH THE DEATH WOBBLE IN MY JEEP ALMOST CAUSING ME TO BE IN A CAR ACCIDENT. I FEEL THE PAIN IN BACK AND NECK. WILL HAVE TO GO TO DOCTORS TO GET THAT CHECKED. I WAS DRIVING ON INTERSTATE 83 WHEN I HIT A BUMP ON THE ROAD NEAR CONSTRUCTION AREA WHEN JEEP BEGAN TO WOBBLE OUT OF CONTROL. LUCKILY ANOTHER JEEP ON THE ROAD SAW WHAT WAS GOING ON AND MADE SPACE FOR ME TO EXIT THE HIGHWAY. I CALLED THE TOW TRUCK AND HAD IT TOWED. *DSY
NHTSA complaint #11091605 — an unverified report by a vehicle owner.
at 5 milesNorthford, CT
STRUCTURE:BODY
ENTIRE FRAME IS RUSTED CAUSING THE TRANSMISSION TO FALL OUT. ALMOST MADE MY SON CRASH INTO A TREE AFTER LOSING CONTROL OF THE VEHICLE.
NHTSA complaint #11090323 — an unverified report by a vehicle owner.
at 174,000 milesLinden, PA
UNKNOWN OR OTHER
FRAME ROTTING FROM INSIDE OUT.THIS IS A SEVERE SAFETY CONCERN.THIS IS A PROBLEM RELATED TO CERTAIN YEARS OF WRANGLERS. THE SEVERITY OF THE PROBLEM SHOULD RESULT IN A RECALL AS HAS BEEN WITH OTHER MANUFACTURERS WITH SAME PROBLEM TO RESOLVE THIS VERY UNSAFE CONDITION.
NHTSA complaint #11085152 — an unverified report by a vehicle owner.
at 139,000 milesCharleston, SC
AIR BAGS
TL-CONTACT OWNS A 2001 JEEP WRANGLER--- SPOKE WITH CHRYSLER --- CHRSYLER STATED NO RECALLS ON VEHICLE---HORN IN VEHICLE DOES NOT WORK AT ALL AND AIRBAG LIGHT IS ON... CONTACT WAS GIVEN NUMBER TO JEEP REGARDING AIR BAG LIGHT....0 RECALLS ASSOCIATED WITH THIS VIN
NHTSA complaint #11055688 — an unverified report by a vehicle owner.
at 139,000 milesCharleston, SC
ELECTRICAL SYSTEM
TL-CONTACT OWNS A 2001 JEEP WRANGLER--- SPOKE WITH CHRYSLER --- CHRSYLER STATED NO RECALLS ON VEHICLE---HORN IN VEHICLE DOES NOT WORK AT ALL AND AIRBAG LIGHT IS ON... CONTACT WAS GIVEN NUMBER TO JEEP REGARDING AIR BAG LIGHT....0 RECALLS ASSOCIATED WITH THIS VIN
NHTSA complaint #11055688 — an unverified report by a vehicle owner.
Belle, WVCrash
SUSPENSION
FRAME RUSTING FROM INSIDE REAR CONTROL ARM FELL OFF CAUSING WRECK
NHTSA complaint #11055526 — an unverified report by a vehicle owner.
at 90,000 milesCincinnati, OH
STRUCTURE:BODY
FRAME IS COMPLETELY RUSTED ONLY 90K MILES. THE TRANSMISSION DROPPED BECAUSE THE STRUCTURE HOLDING IT UP WAS BOLTED TO THE FRAME AND BECAUSE THE ENTIRE FRAME IS COMPLETELY RUSTED IT CANT BE FIXED. ITS SO BAD A NO BODY SHOP WILL FIX IT, RUST KIT IS NO HELP WITH HOW BAD THIS FRAME IS RUSTED. THIS IS COMPLETELY RIDICULES THAT A FRAME IS THIS BADLY RUSTED AT 90K MILES.
NHTSA complaint #11046953 — an unverified report by a vehicle owner.
at 117,803 milesWhitehouse, TXFire
ELECTRICAL SYSTEM
I WAS DRIVING WITH THE AIR CONDITIONER ON WHEN I SMELLED BURNING PLASTIC, THEN SMOKE CAME OUT OF THE AIR VENTS. I PULLED OVER AND TURNED OFF THE AIR CONDITIONER AND GOT OUT OF THE VEHICLE. AFTER ABOUT 15 MIN THE SMELL DISSIPATED AND I CONTINUED ON WITHOUT THE AIR CONDITIONING. LATER I REMOVED THE COVERS AND FOUND THAT THERE HAD BEEN A FIRE IN THE PLUG THAT GOES TO THE BLOWER MOTOR RESISTOR
NHTSA complaint #11019377 — an unverified report by a vehicle owner.
at 123,406 milesHartselle, AL
FUEL/PROPULSION SYSTEM
FUEL LEAKS FROM UNDER TANK AFTER FILLING UP WITH GAS AT GAS STATION
NHTSA complaint #10980979 — an unverified report by a vehicle owner.
at 116,000 milesBallston SPA, NY
UNKNOWN OR OTHER
THIS 2001 JEEP WRANGLER TJ FAILED NY STATE SAFETY INSPECTION DUE TO FRAME RUST. PURCHASED NEW ON 06/01/2001 FROM A JEEP DEALERSHIP IN LINDENHURST, NY AND ONLY HAS 116,097 MILES ON A 4.0 ENGINE. THIS TUBULAR FRAME RUST IS PREMATURE DUE TO LACK OF "WEEP HOLES" THAT ALLOWS WATER TO EXIT THE FRAME, THEREBY PROMOTING RUST FROM THE INSIDE, OUT AND IS COSTLY TO REPAIR (SEE ATTACHMENT). NOTE... TOYOTA HAS HAD SIMILAR "RUSTY FRAME" ISSUES, BUT TOYOTA HAS DONE THE "RIGHT THING". SEE WRITE-UP AND VIDEO HERE: HTTP://AUTOWEEK.COM/ARTICLE/RECALLS/TOYOTA-FRAME-SETTLEMENT-COULD-COST-COMPANY-34-BILLION ... I LOVE MY WRANGLER, BUT IF JEEP REFUSES TO HELP WITH THIS (WIDE SPREAD) RUSTY FRAME ISSUE, I MAY VERY WELL MAKE A TOYOTA MY NEXT PURCHASE! THIS IS NOT JUST A CUSTOMER SERVICE ISSUE, THIS IS A BIG SAFETY ISSUE!!!
NHTSA complaint #10979803 — an unverified report by a vehicle owner.
at 116,000 milesBallston SPA, NY
STRUCTURE:BODY
THIS 2001 JEEP WRANGLER TJ FAILED NY STATE SAFETY INSPECTION DUE TO FRAME RUST. PURCHASED NEW ON 06/01/2001 FROM A JEEP DEALERSHIP IN LINDENHURST, NY AND ONLY HAS 116,097 MILES ON A 4.0 ENGINE. THIS TUBULAR FRAME RUST IS PREMATURE DUE TO LACK OF "WEEP HOLES" THAT ALLOWS WATER TO EXIT THE FRAME, THEREBY PROMOTING RUST FROM THE INSIDE, OUT AND IS COSTLY TO REPAIR (SEE ATTACHMENT). NOTE... TOYOTA HAS HAD SIMILAR "RUSTY FRAME" ISSUES, BUT TOYOTA HAS DONE THE "RIGHT THING". SEE WRITE-UP AND VIDEO HERE: HTTP://AUTOWEEK.COM/ARTICLE/RECALLS/TOYOTA-FRAME-SETTLEMENT-COULD-COST-COMPANY-34-BILLION ... I LOVE MY WRANGLER, BUT IF JEEP REFUSES TO HELP WITH THIS (WIDE SPREAD) RUSTY FRAME ISSUE, I MAY VERY WELL MAKE A TOYOTA MY NEXT PURCHASE! THIS IS NOT JUST A CUSTOMER SERVICE ISSUE, THIS IS A BIG SAFETY ISSUE!!!
NHTSA complaint #10979803 — an unverified report by a vehicle owner.
at 175,000 milesWarren, MI
SUSPENSION
COMPLETE CORROSION THROUGH THE FRAME JUST BEHIND THE REAR UPPER AND LOWER TRAILING ARMS MOUNT LOCATIONS. TWO LARGE HOLES APPROXIMATELY 1" IN DIAMETER. STRESS CONCENTRATIONS DUE TO CORRODED METAL AND CYCLICAL FATIGUE HAS CAUSED CRACK PROPAGATION AND CONNECTION OF THE TWO HOLES WITH ONE ANOTHER.
NHTSA complaint #10979294 — an unverified report by a vehicle owner.
at 175,000 milesWarren, MI
STRUCTURE:BODY
COMPLETE CORROSION THROUGH THE FRAME JUST BEHIND THE REAR UPPER AND LOWER TRAILING ARMS MOUNT LOCATIONS. TWO LARGE HOLES APPROXIMATELY 1" IN DIAMETER. STRESS CONCENTRATIONS DUE TO CORRODED METAL AND CYCLICAL FATIGUE HAS CAUSED CRACK PROPAGATION AND CONNECTION OF THE TWO HOLES WITH ONE ANOTHER.
NHTSA complaint #10979294 — an unverified report by a vehicle owner.
