Owners have filed 756 complaints
about the 2005 Jeep Wrangler with NHTSA between 2005 and 2023.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 22 of 33 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 56
Against the median year of the Jeep Wrangler. 50 means typical for this
model; 100 means roughly double.
Severity — 25
4.9% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 55
32% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Front
1018.9%
Filler Pipe AND CAP
815.1%
Manual Transmission
713.2%
Body
611.3%
Rotor
611.3%
Automatic Transmission
611.3%
Engine
59.4%
Tank Assembly
59.4%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
Under 1,000 miles
294.7%
1,000 – 9,999 miles
264.2%
10,000 – 24,999 miles
7111.5%
25,000 – 49,999 miles
18429.8%
50,000 – 74,999 miles
17227.8%
75,000 – 99,999 miles
8213.3%
100,000 – 149,999 miles
437.0%
150,000+ miles
111.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Mar 2005peak 26Oct 2023
Recalls on the 2005 Jeep Wrangler
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06E022000
SERVICE BRAKES, HYDRAULIC
CERTAIN AFTERMARKET BRAKE HYDRAULIC MASTER CYLINDERS SOLD AS REPLACEMENT BRAKE CYLINDERS FOR CERTAIN FORD, DAIMLERCHRYSLER, AND JEEP PASSENGER VEHICLES. THESE BRAKE CYLINDERS WERE SOLD UNDER THE BRAND NAMES OF NAPA, RAYBESTOS, AIMCO, AC DELCO, CARQUEST, BENDIX, AND WAGNER. ONLY PRODUCTS THAT WERE MANUFACTURED FROM JULY 27, 2005 THROUGH JANUARY 17, 2006 (DATE CODES 0529 THROUGH 0602) ARE SUBJECT TO THIS RECALL. WHEN SUBJECT TO VERY COLD TEMPERATURES, AN INTERNAL SEAL IN THE MASTER CYLINDER COULD LOSE FLEXIBILITY AND MAY CAUSE BRAKE FLUID TO LEAK.
Risk: LOSS OF BRAKE FLUID CAN LEAD TO A DECREASE IN BRAKE LINE PRESSURE AND AN INCREASE IN STOPPING DISTANCE, WHICH CAN RESULT IN A VEHICLE CRASH.
05V460000
POWER TRAIN:AUTOMATIC TRANSMISSION
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Risk: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Reports where the owner recorded a crash, a fire, an injury or a death.
Warren, MI2 injured
FUEL/PROPULSION SYSTEM
At every fuel fill up, gasoline splashes back out onto the vehicle, the person filling the vehicle and creates a very unsafe puddle of gasoline on the ground. There is never a time that it does not happen. I would be readily available to make my vehicle available for inspection of this concern. Chrysler has issued recalls for this exact problem on several of their vehicle models all within the same time period of manufacturing. The fuel tank inlet check valve is a widely known and dangerous issue that should be seriously considered to repair the remaining vehicles on the road with this problem. It has been documented by numerous owners of Jeep Wranglers from 2005-2006 while the same issue forced a recall of the same Jeeps in later model years, 2007-2008. The Jeep has been inspected by a certified mechanic where I was notified of much of this information. With the amount of gasoline that spills out and the motorist re-enters their vehicle, there could be a static charge that could ignite the gasoline and cause extreme personal harm and property damage. There is no indication or warning sign to alert you that it is going to splash out gasoline. I am left to rarely fill my fuel tank to the maximum level to avoid being soaked in gasoline and irritating my skin or worse. I have owned this Jeep for going on 4 years and it has been a concern since day 1. I am noting this report of having been injured but the injuries at this point are only skin irritations as a result of gasoline coming in contact with our skin. I also noted the date as the first time this happened but as mentioned before, it happens or will happen at every fill up.
NHTSA complaint #11420994 — an unverified report by a vehicle owner.
at 75,000 milesMiami, FLCrash
VEHICLE SPEED CONTROL
: I AM THE OWNER OF A 2005 JEEP WRANGLER. FOR THE LAST 10+ YEARS MY ACCELERATOR HAS STUCK AT FULL THROTTLE 5-7 TIMES. EVERY TIME I HAVE TAKEN IT TO A SHOP - THEY HAVE TEST DRIVEN IT BUT NO STICKING. LAST WEDNESDAY (5/22) AT A 4 WAY STOP SIGN MY ACCELERATOR STUCK AGAIN AT FULL THROTTLE & I HIT A CAR. NO ONE WAS HURT, BUT I WAS GIVEN A CITATION WITH WITNESSES TO THE ACCELERATOR BEING STUCK. THE MAN AT THE SHOP TOLD ME HIS JEEP WRANGLER HAD A RECALL FOR THE SAME ISSUE. I CONTACTED JEEP CORPORATION & FILED A REPORT (CASE [XXX]) WITH A WORKER "ALY". SHE TOLD ME TO PARK MY JEEP AND AN INSPECTOR WOULD BE THERE TO INVESTIGATE. THAT WAS MORE THAN A WEEK AGO & 5 CALLS TO 1-877-426-5337. CAN YOU HELP ME? MY INSURANCE CO. WANTS ME TO GET ESTIMATES FOR MY DAMAGE BUT I DON'T KNOW IF I CAN DRIVE ON THE ROAD DUE TO THE ACCELERATOR STICKING & NOT BEING INSPECTED BY JEEP RECALL INSPECTORS. PLEASE HELP ME...'. (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11218770 — an unverified report by a vehicle owner.
at 74,711 milesFranklin, NCFire
POWER TRAIN
THE 2005 JEEP WRANGLER SPORT WAS A TOTAL LOSS AFTER IT CAUGHT ON FIRE AND SEVERELY DAMAGED THE ENGINE AND THE INSIDE OF THE VEHICLE. IT JUST HAD THE TRANSMISSION REPLACED THE DAY BEFORE THE INCIDENT. THE VEHICLE CONTINUED TO DEMONSTRATE TRANSMISSION ISSUES DESPITE THE NEW TRANSMISSION (INCLUDING DIFFICULTY SHIFTING AND A LOSS OF POWER WHILE GOING UPHILL). WHILE DRIVING UPHILL, THE VEHICLE'S TRANSMISSION SLIPPED AND SMOKE STARTED POURING OUT OF THE ENGINE. THE DRIVER IMMEDIATELY PUT IT IN PARK AND TURNED OFF THE ENGINE. THE DRIVER RAN FROM THE VEHICLE AND SAW THAT THERE WAS A FIRE UNDERNEATH THE CAR - NEAR THE TRANSMISSION PAN. THE ENTIRE VEHICLE WENT UP IN FLAMES WITHIN 2 MINUTES. UNFORTUNATELY, IT WAS A TOTAL LOSS BY THE TIME THE FIRE DEPARTMENT ARRIVED TO PUT OUT THE FIRE. AN INVESTIGATION WILL BE COMPLETED TO DETERMINE IF A TRANSMISSION FLUID LEAK CAUSED THE FIRE. THE JEEP WRANGLER WAS A RIGHT HAND DRIVE THAT WAS BEING USED ON THE MAIL ROUTE THE DAY THAT THE FIRE OCCURRED.
NHTSA complaint #11013992 — an unverified report by a vehicle owner.
at 67,560 milesFairhope, ALFire
ELECTRICAL SYSTEM
2014: DASH AND REAR LIGHTS STOPPED WORKING. HAD TO REPLACE MULTI-FUNCTION SWITCH. MODULE AND WIRING MELTED AND FUSED TOGETHER. 2017: DURING INSTALL OF NEW STEREO, MECHANIC DISCOVERED MULTI-FUNCTION SWITCH AND MODULE MELTED AGAIN. REPLACED ALL WIRING WITH HEAVIER GAUGE, REPLACED ALL BULBS WITH LOWER WATTAGE LEDS. WONDERING WHEN NEXT ELECTRICAL PROBLEM WILL SURFACE.
NHTSA complaint #11001549 — an unverified report by a vehicle owner.
Madisonville, LACrash2 injured2 killed
AIR BAGS
TL* THE CONTACT OWNED A 2005 JEEP WRANGLER. WHILE DRIVING VARIOUS SPEEDS, THE FRONT DRIVER SIDE WHEEL FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE. THE DRIVER CRASHED INTO A CULVERT. THE VEHICLE ROLLED OVER AND LANDED ON ITS ROOF IN A DITCH. THE DRIVER SIDE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED FATAL INJURIES TO THE HEAD. THE PASSENGER WAS ALSO FATALLY INJURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE. ...UPDATED 10/19/16 *BF .. ..UPDATED 03/31/17 *BF ...UPDATED 04/11/17 *BF UPDATED 08/08/2017*JS UPDATED 09/19/2017*JS
NHTSA complaint #10904484 — an unverified report by a vehicle owner.
Madisonville, LACrash2 injured2 killed
WHEELS
TL* THE CONTACT OWNED A 2005 JEEP WRANGLER. WHILE DRIVING VARIOUS SPEEDS, THE FRONT DRIVER SIDE WHEEL FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE. THE DRIVER CRASHED INTO A CULVERT. THE VEHICLE ROLLED OVER AND LANDED ON ITS ROOF IN A DITCH. THE DRIVER SIDE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED FATAL INJURIES TO THE HEAD. THE PASSENGER WAS ALSO FATALLY INJURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE. ...UPDATED 10/19/16 *BF .. ..UPDATED 03/31/17 *BF ...UPDATED 04/11/17 *BF UPDATED 08/08/2017*JS UPDATED 09/19/2017*JS
NHTSA complaint #10904484 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Tonopah, NV
ENGINE
Engine warning light has been coming on since about 70k miles(190k now). Scanner says O2 sensor is bad. After replacement of the O2 sensor, the fault continues to show up randomly. I carry a scanner to reset the engine code on the road. All wiring has been checked and is ok. When I clear the code, the error does not show up again for anywhere from 125 miles to around 300 miles. Clearing the code starts the process all over.
NHTSA complaint #11548495 — an unverified report by a vehicle owner.
Belle Mead, NJ
STEERING
As I was driving home from work on Feb. 14, 2023, in Rocky Hill, NJ. the vehicle developed a sudden loss of steering control. I had it towed to Chrysler Dodge Jeep RAM of Princeton, NJ. The service manager informed me that the area of the frame to which the steering gear box is bolted had completely rotted, and the steering box had separated. The car was not driveable and could not be repaired. The vehicle will be available for inspection until April 15, 2023.
NHTSA complaint #11510341 — an unverified report by a vehicle owner.
Nederland, TX
POWER TRAIN
Ecm computer , o2 heater sensor from ecm and controls transmission shift points . Replaced o2 sensors and transmission is controlled by ecm not shifting correctly will stay in first gear and hard shift to second can create loss of control in wet weather conditions.
NHTSA complaint #11481555 — an unverified report by a vehicle owner.
Syracuse, NY
POWER TRAIN
Keep wobble almost caused head on collision afraid to drive vehicle over 55 mph
NHTSA complaint #11478517 — an unverified report by a vehicle owner.
Syracuse, NY
STEERING
Keep wobble almost caused head on collision afraid to drive vehicle over 55 mph
NHTSA complaint #11478517 — an unverified report by a vehicle owner.
Syracuse, NY
SUSPENSION
Keep wobble almost caused head on collision afraid to drive vehicle over 55 mph
NHTSA complaint #11478517 — an unverified report by a vehicle owner.
Brooklyn, MD
POWER TRAIN
The dashboard will display odd behavior and all of a sudden the ignition will cut. Total loss of power. This has happened in the past with children in the vehicle. Very dangerous. Resetting the key will reset but it is random.
NHTSA complaint #11424836 — an unverified report by a vehicle owner.
Brooklyn, MD
ELECTRICAL SYSTEM
The dashboard will display odd behavior and all of a sudden the ignition will cut. Total loss of power. This has happened in the past with children in the vehicle. Very dangerous. Resetting the key will reset but it is random.
NHTSA complaint #11424836 — an unverified report by a vehicle owner.
Brooklyn, MD
ENGINE
The dashboard will display odd behavior and all of a sudden the ignition will cut. Total loss of power. This has happened in the past with children in the vehicle. Very dangerous. Resetting the key will reset but it is random.
NHTSA complaint #11424836 — an unverified report by a vehicle owner.
Middlefield, CT
ELECTRICAL SYSTEM
Engine failed, speedometer, tach went to 0, all gauges went to 0, power steering failed after I declutched and then coasted to a full stop (power brakes failed but still had some brake input) safely on the shoulder of an off ramp. (This not the first time this has happened, however it was the first time pulling a full trailer, so I drive as if it could happen again) Vehicle was at Branhaven Jeep in Branford, CT last July @ 64429 miles... they were unable to duplicate. It is now at Gengras Jeep in East Hartford, CT, same story. I've asked Gengras to replace the ignition switch again. I have the ignition switch from Branhaven which I found the copper plate worn off to steel and evidence of arcing on the contacts
NHTSA complaint #11422633 — an unverified report by a vehicle owner.
at 66,666 milesMiddlefield, CT
ENGINE
The contact owns a 2005 Jeep Wrangler. The contact stated while driving approximately 65 mph, the vehicle loss motive power. Several gauges became inoperable with unknown warning lights illuminated. The contact pulled over and waited approximately 15 minutes before the vehicle was restarted. The vehicle was towed to the dealer but was not yet diagnosed or repaired. The ignition switch was replaced. The manufacturer was not made aware of the failure. The approximate failure mileage was 66,666.
NHTSA complaint #11422619 — an unverified report by a vehicle owner.
Middlefield, CT
ENGINE
Engine failed, speedometer, tach went to 0, all gauges went to 0, power steering failed after I declutched and then coasted to a full stop (power brakes failed but still had some brake input) safely on the shoulder of an off ramp. (This not the first time this has happened, however it was the first time pulling a full trailer, so I drive as if it could happen again) Vehicle was at Branhaven Jeep in Branford, CT last July @ 64429 miles... they were unable to duplicate. It is now at Gengras Jeep in East Hartford, CT, same story. I've asked Gengras to replace the ignition switch again. I have the ignition switch from Branhaven which I found the copper plate worn off to steel and evidence of arcing on the contacts
NHTSA complaint #11422633 — an unverified report by a vehicle owner.
Warren, MI2 injured
FUEL/PROPULSION SYSTEM
At every fuel fill up, gasoline splashes back out onto the vehicle, the person filling the vehicle and creates a very unsafe puddle of gasoline on the ground. There is never a time that it does not happen. I would be readily available to make my vehicle available for inspection of this concern. Chrysler has issued recalls for this exact problem on several of their vehicle models all within the same time period of manufacturing. The fuel tank inlet check valve is a widely known and dangerous issue that should be seriously considered to repair the remaining vehicles on the road with this problem. It has been documented by numerous owners of Jeep Wranglers from 2005-2006 while the same issue forced a recall of the same Jeeps in later model years, 2007-2008. The Jeep has been inspected by a certified mechanic where I was notified of much of this information. With the amount of gasoline that spills out and the motorist re-enters their vehicle, there could be a static charge that could ignite the gasoline and cause extreme personal harm and property damage. There is no indication or warning sign to alert you that it is going to splash out gasoline. I am left to rarely fill my fuel tank to the maximum level to avoid being soaked in gasoline and irritating my skin or worse. I have owned this Jeep for going on 4 years and it has been a concern since day 1. I am noting this report of having been injured but the injuries at this point are only skin irritations as a result of gasoline coming in contact with our skin. I also noted the date as the first time this happened but as mentioned before, it happens or will happen at every fill up.
NHTSA complaint #11420994 — an unverified report by a vehicle owner.
Gold Canyon, AZ
ENGINE
The camshaft sensor upper bushing does not get lubricated seizes up causes camshaft to wear out. In my jeep I replaced three of them on the inline 4.0 6cyl. I only have 66,660 miles on my jeep. June 4, 2021.
NHTSA complaint #11419621 — an unverified report by a vehicle owner.
at 149,000 milesDanbury, CT
ELECTRICAL SYSTEM
ECU STOPED WORKING NO REASON.
NHTSA complaint #11365817 — an unverified report by a vehicle owner.
at 138,000 milesDunedin, FL
ELECTRICAL SYSTEM
THE PCM HAS A KNOWN HIGH FAILURE RATE DUE TO THE VIBRATION. THE COMPONENTS ARE COVERED IN A RESIN THAT YOU CAN NOT REMOVE. THE PCM IS 500-1300 TO GET A REPAIRED AND REPROGRAMED ONE. I HAVE A 2005 AND THE PCM HAS FAILED AND GIVES BAD PERFORMANCE AND DOES NOT RUN ON TEH 14.7 STOKES FOR AIR/FUEL/ IT DUMPS FUELS AND I DO NOT THINK IT MEETS EMISSON LEVELS IN THIS CONDITION.
NHTSA complaint #11361908 — an unverified report by a vehicle owner.
at 55,000 milesLake Havasu City, AZ
STEERING
STEERING STABILIZER GOES OUT ON AVERAGE ABOUT 20,000 TO 30,000 MILES WITH NORMAL STREET OR HIGHWAY DRIVING. STEERING WHEEL STARTS SHAKING BACK AND FORTH AND WHEELS SHAKE VIOLENTLY . I SEE JEEP IS NOW RECALLING SOME 2018-2019 JEEPS AND WOULD LIKE MINE FIXED TOO .
NHTSA complaint #11243391 — an unverified report by a vehicle owner.
at 68,000 milesMinneapolis, MN
STRUCTURE:BODY
HOOD FLUTTER WHEN DRIVING AT HIGHWAY SPEEDS AT OR ABOVE 50MPH. HAD TO REPLACE LATCHES WITH A NEW SYSTEM TO ELIMINATE THE FLUTTER AND POSSIBILITY OF IMPENDING FAILURE.
NHTSA complaint #11232533 — an unverified report by a vehicle owner.
at 75,000 milesMiami, FLCrash
VEHICLE SPEED CONTROL
: I AM THE OWNER OF A 2005 JEEP WRANGLER. FOR THE LAST 10+ YEARS MY ACCELERATOR HAS STUCK AT FULL THROTTLE 5-7 TIMES. EVERY TIME I HAVE TAKEN IT TO A SHOP - THEY HAVE TEST DRIVEN IT BUT NO STICKING. LAST WEDNESDAY (5/22) AT A 4 WAY STOP SIGN MY ACCELERATOR STUCK AGAIN AT FULL THROTTLE & I HIT A CAR. NO ONE WAS HURT, BUT I WAS GIVEN A CITATION WITH WITNESSES TO THE ACCELERATOR BEING STUCK. THE MAN AT THE SHOP TOLD ME HIS JEEP WRANGLER HAD A RECALL FOR THE SAME ISSUE. I CONTACTED JEEP CORPORATION & FILED A REPORT (CASE [XXX]) WITH A WORKER "ALY". SHE TOLD ME TO PARK MY JEEP AND AN INSPECTOR WOULD BE THERE TO INVESTIGATE. THAT WAS MORE THAN A WEEK AGO & 5 CALLS TO 1-877-426-5337. CAN YOU HELP ME? MY INSURANCE CO. WANTS ME TO GET ESTIMATES FOR MY DAMAGE BUT I DON'T KNOW IF I CAN DRIVE ON THE ROAD DUE TO THE ACCELERATOR STICKING & NOT BEING INSPECTED BY JEEP RECALL INSPECTORS. PLEASE HELP ME...'. (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
NHTSA complaint #11218770 — an unverified report by a vehicle owner.
at 70,000 milesAkron, OH
POWER TRAIN
THE VEHICLE WAS IN MOTION AND PULLING FROM MY DRIVEWAY ONTO A CITY STREET WHEN THIS HAPPENED. BOTH DRIVERS AND PASSENGER CENTER SECTIONS OF THE FRAME RUSTED FROM THE INSIDE OUT WITH NO VISIBLE INDICATION ON THE OUTSIDE OF THE FRAME RAILS. WATER AND DEBRIS ENTER THROUGH HOLES USED IN THE MANUFACTURING PROCESS AND DUE TO NO DRAIN HOLES IN ANY OF THE LOWER POINTS THE WATER AND DEBRIS ROT THE FRAME AWAY. IN MY CASE THE TRANSMISSION PAN ON THE DRIVERS SIDE OF THE VEHICLE FELL FREE WHEN THE BOTTOM OF THE FRAME RAIL ON THAT SIDE CRUMBLED WHILE ENTERING A CITY ROAD FROM A PRIVATE DRIVE AT LESS THAN 5 MPH. DAMAGE WAS DONE TO THE TRANSMISSION, TRANSFER CASE, ONE AXLE, AND THE REAR DRIVE SHAFT. THE VEHICLE WAS TOWED TO A PRIVATE GARAGE BUT THEY WERE UNABLE TO PLACE IT ON A LIFT TO INSPECT THE DAMAGE AS THE FRAME WOULD HAVE CRUMBLED AND SNAPPED IN ADDITIONAL PLACES THUS CREATING A HAZARD AND POSSIBLY DEADLY SITUATION THE TECHNICIAN INSPECTING THE DAMAGE. THE VEHICLE WAS THEN PLACED ON A FLATBED AND BROUGHT BACK TO MY HOME.
NHTSA complaint #11206892 — an unverified report by a vehicle owner.
at 70,000 milesAkron, OH
STRUCTURE:BODY
THE VEHICLE WAS IN MOTION AND PULLING FROM MY DRIVEWAY ONTO A CITY STREET WHEN THIS HAPPENED. BOTH DRIVERS AND PASSENGER CENTER SECTIONS OF THE FRAME RUSTED FROM THE INSIDE OUT WITH NO VISIBLE INDICATION ON THE OUTSIDE OF THE FRAME RAILS. WATER AND DEBRIS ENTER THROUGH HOLES USED IN THE MANUFACTURING PROCESS AND DUE TO NO DRAIN HOLES IN ANY OF THE LOWER POINTS THE WATER AND DEBRIS ROT THE FRAME AWAY. IN MY CASE THE TRANSMISSION PAN ON THE DRIVERS SIDE OF THE VEHICLE FELL FREE WHEN THE BOTTOM OF THE FRAME RAIL ON THAT SIDE CRUMBLED WHILE ENTERING A CITY ROAD FROM A PRIVATE DRIVE AT LESS THAN 5 MPH. DAMAGE WAS DONE TO THE TRANSMISSION, TRANSFER CASE, ONE AXLE, AND THE REAR DRIVE SHAFT. THE VEHICLE WAS TOWED TO A PRIVATE GARAGE BUT THEY WERE UNABLE TO PLACE IT ON A LIFT TO INSPECT THE DAMAGE AS THE FRAME WOULD HAVE CRUMBLED AND SNAPPED IN ADDITIONAL PLACES THUS CREATING A HAZARD AND POSSIBLY DEADLY SITUATION THE TECHNICIAN INSPECTING THE DAMAGE. THE VEHICLE WAS THEN PLACED ON A FLATBED AND BROUGHT BACK TO MY HOME.
NHTSA complaint #11206892 — an unverified report by a vehicle owner.
at 140,000 milesClarksville, TN
POWER TRAIN
TAKATA RECALL, OIL PUMP DRIVE GEAR, PCM POWERTERRAIN CONTROL MODULE I BELIEVE NEEDS TO BE REPROGRAMMED I HAVE A FAILURE OF POWER WHILE DRIVING DOWN THE ROAD LIKE ITS GETTING TO MUCH OR TO LITTLE FUEL AND LAST WEEK MY OIL PRESSURE WILL NOT BUDGE MY GAUGES ARE SLOWLY GOING OUT ON MY DASH AND THE AIRBAG LIGHT ON DASH BLINKS RAPIDLY WITH THE CHECK GAUGES BECAUSE OF MY OLD PRESSURE I HAVE TAKEN IT TO MULTIPLE PLACES TO GET IT DIAGNOSED AND THEY SAY IT IS THE OIL PUMP DRIVE GEAR AND THE PCM NEEDING TO BE REPROGRAMMED ALONG WITH THAT BEING OUT OF LINE MY GROUND CONNECTIONS SEEM TO BE BAD BUT I REPLACE ALL OF THEM FROM THE BATTERY TO THE ENGINE BLOCK THE DASH AND A COUPLE MORE IT HAS PRESSURE BUT DOESN'T SOUND LIKE IT. ALL OF THIS STARTED HAPPENING AT ABOUT 143,000 MILES I HAVE REPLACED MULTIPLE PARTS INCLUDING THE OIL PUMP OIL SENSOR ALL OF THE GROUND WIRES AND TERMINALS AND CHECKED AS MANY RELAYS AS I CAN. ALONG WITH MY DASH WHEN I HAD GOT IT IT HAD 130,000 MILES ON AND THE AIRBAG LIGHT HAS ALWAYS BLINKED AND NOTICED A LOSS IN POWER WHEN I DRIVE SINCE I'VE HAD IT, IT RUNS THROUGH SPARK PLUGS AND COILS PACKS MONTHLY AND HAS SINCE I'VE GOTTEN IT I DROVE IT TO GEORGIA AND BACK AND IT SOUNDED LIKE IT WAS GETTING WORSE AND JUST KEPT GETTING WORSE AND WORSE UNTIL LAST WEEK MY OIL PRESSURE GAUGE SAYS I HAVE NO PRESSURE AND THE ENGINE HAS OIL PRESSURE BUT YOU CAN TELL IT'S GOING MORE AND MORE OUT OF LINE. I KNOW WHEN I LOOK UP MY VIN NUMBER IT SAYS IT'S BEEN UPDATED SINCE MARCH 14, 2019 BUT WHEN I LOG INTO ANOTHER APP IT SAYS I HAVE RECALLS I DON'T KNOW WHAT TO DO OR HOW TO FIX IT BUT IT DEFINITELY IS THE THREE RECALLS THAT WAS PUT ON THE 2005 JEEP WRANGLER TJ.
NHTSA complaint #11186910 — an unverified report by a vehicle owner.
at 140,000 milesClarksville, TN
AIR BAGS
TAKATA RECALL, OIL PUMP DRIVE GEAR, PCM POWERTERRAIN CONTROL MODULE I BELIEVE NEEDS TO BE REPROGRAMMED I HAVE A FAILURE OF POWER WHILE DRIVING DOWN THE ROAD LIKE ITS GETTING TO MUCH OR TO LITTLE FUEL AND LAST WEEK MY OIL PRESSURE WILL NOT BUDGE MY GAUGES ARE SLOWLY GOING OUT ON MY DASH AND THE AIRBAG LIGHT ON DASH BLINKS RAPIDLY WITH THE CHECK GAUGES BECAUSE OF MY OLD PRESSURE I HAVE TAKEN IT TO MULTIPLE PLACES TO GET IT DIAGNOSED AND THEY SAY IT IS THE OIL PUMP DRIVE GEAR AND THE PCM NEEDING TO BE REPROGRAMMED ALONG WITH THAT BEING OUT OF LINE MY GROUND CONNECTIONS SEEM TO BE BAD BUT I REPLACE ALL OF THEM FROM THE BATTERY TO THE ENGINE BLOCK THE DASH AND A COUPLE MORE IT HAS PRESSURE BUT DOESN'T SOUND LIKE IT. ALL OF THIS STARTED HAPPENING AT ABOUT 143,000 MILES I HAVE REPLACED MULTIPLE PARTS INCLUDING THE OIL PUMP OIL SENSOR ALL OF THE GROUND WIRES AND TERMINALS AND CHECKED AS MANY RELAYS AS I CAN. ALONG WITH MY DASH WHEN I HAD GOT IT IT HAD 130,000 MILES ON AND THE AIRBAG LIGHT HAS ALWAYS BLINKED AND NOTICED A LOSS IN POWER WHEN I DRIVE SINCE I'VE HAD IT, IT RUNS THROUGH SPARK PLUGS AND COILS PACKS MONTHLY AND HAS SINCE I'VE GOTTEN IT I DROVE IT TO GEORGIA AND BACK AND IT SOUNDED LIKE IT WAS GETTING WORSE AND JUST KEPT GETTING WORSE AND WORSE UNTIL LAST WEEK MY OIL PRESSURE GAUGE SAYS I HAVE NO PRESSURE AND THE ENGINE HAS OIL PRESSURE BUT YOU CAN TELL IT'S GOING MORE AND MORE OUT OF LINE. I KNOW WHEN I LOOK UP MY VIN NUMBER IT SAYS IT'S BEEN UPDATED SINCE MARCH 14, 2019 BUT WHEN I LOG INTO ANOTHER APP IT SAYS I HAVE RECALLS I DON'T KNOW WHAT TO DO OR HOW TO FIX IT BUT IT DEFINITELY IS THE THREE RECALLS THAT WAS PUT ON THE 2005 JEEP WRANGLER TJ.
NHTSA complaint #11186910 — an unverified report by a vehicle owner.
at 140,000 milesClarksville, TN
UNKNOWN OR OTHER
TAKATA RECALL, OIL PUMP DRIVE GEAR, PCM POWERTERRAIN CONTROL MODULE I BELIEVE NEEDS TO BE REPROGRAMMED I HAVE A FAILURE OF POWER WHILE DRIVING DOWN THE ROAD LIKE ITS GETTING TO MUCH OR TO LITTLE FUEL AND LAST WEEK MY OIL PRESSURE WILL NOT BUDGE MY GAUGES ARE SLOWLY GOING OUT ON MY DASH AND THE AIRBAG LIGHT ON DASH BLINKS RAPIDLY WITH THE CHECK GAUGES BECAUSE OF MY OLD PRESSURE I HAVE TAKEN IT TO MULTIPLE PLACES TO GET IT DIAGNOSED AND THEY SAY IT IS THE OIL PUMP DRIVE GEAR AND THE PCM NEEDING TO BE REPROGRAMMED ALONG WITH THAT BEING OUT OF LINE MY GROUND CONNECTIONS SEEM TO BE BAD BUT I REPLACE ALL OF THEM FROM THE BATTERY TO THE ENGINE BLOCK THE DASH AND A COUPLE MORE IT HAS PRESSURE BUT DOESN'T SOUND LIKE IT. ALL OF THIS STARTED HAPPENING AT ABOUT 143,000 MILES I HAVE REPLACED MULTIPLE PARTS INCLUDING THE OIL PUMP OIL SENSOR ALL OF THE GROUND WIRES AND TERMINALS AND CHECKED AS MANY RELAYS AS I CAN. ALONG WITH MY DASH WHEN I HAD GOT IT IT HAD 130,000 MILES ON AND THE AIRBAG LIGHT HAS ALWAYS BLINKED AND NOTICED A LOSS IN POWER WHEN I DRIVE SINCE I'VE HAD IT, IT RUNS THROUGH SPARK PLUGS AND COILS PACKS MONTHLY AND HAS SINCE I'VE GOTTEN IT I DROVE IT TO GEORGIA AND BACK AND IT SOUNDED LIKE IT WAS GETTING WORSE AND JUST KEPT GETTING WORSE AND WORSE UNTIL LAST WEEK MY OIL PRESSURE GAUGE SAYS I HAVE NO PRESSURE AND THE ENGINE HAS OIL PRESSURE BUT YOU CAN TELL IT'S GOING MORE AND MORE OUT OF LINE. I KNOW WHEN I LOOK UP MY VIN NUMBER IT SAYS IT'S BEEN UPDATED SINCE MARCH 14, 2019 BUT WHEN I LOG INTO ANOTHER APP IT SAYS I HAVE RECALLS I DON'T KNOW WHAT TO DO OR HOW TO FIX IT BUT IT DEFINITELY IS THE THREE RECALLS THAT WAS PUT ON THE 2005 JEEP WRANGLER TJ.
NHTSA complaint #11186910 — an unverified report by a vehicle owner.
at 65,000 milesSanta Rosa, CA
POWER TRAIN
I GET A CODE THAT POPS UP AFTER BEING ON THE HIGHWAY FOR A TIME THAT SAYS SOMETHING REGARDING TRANSMISSION. ALSO THE TRANSMISSION IS SLOW TO SHIFT BETWEEN DRIVE AND REVERSE SOMETIMES AND GRINDS (AUTO TRANS). THERE HAVE BEEN MULTIPLE REPORTS OF PCM ISSUES THAT REQUIRE REBUILD OR REPLACEMENT BUT AVAILABILITY IS SCARCE. COULD BE POOR DESIGN.
NHTSA complaint #11181802 — an unverified report by a vehicle owner.