Owners have filed 184 complaints
about the 1994 Jeep Wrangler with NHTSA between 1995 and 2022.
The largest single group is the fuel & propulsion.
Across this model's run it ranks 30 of 33 worst.
The letter says how bad. This says what kind — whether this year drew
an unusual number of complaints, unusually dangerous
ones, or failures that arrived unusually early.
The dashed ring is 50 — the national norm. Further out is worse.
Complaint volume — 14
Against the median year of the Jeep Wrangler. 50 means typical for this
model; 100 means roughly double.
Severity — 90
17.4% of these complaints
involved a crash, fire, injury or death, against a national rate of
9.7%.
Early failure — 10
6% of failures with a mileage on record happened under
36,000 miles, against a national rate of
29%.
NHTSA files every complaint against a named sub-assembly, not just a
system. This is the difference between knowing it was "the engine" and
knowing which part of it — the list to hand a mechanic.
Fuel Pump
1318.6%
Tank Assembly
1217.1%
Conventional
1014.3%
Catalytic Convertor
912.9%
Engine
710.0%
Retractor
710.0%
Latch
68.6%
Buckle Assembly
68.6%
When it fails
Odometer readings owners gave when they filed. About half of all
complaints include one.
10,000 – 24,999 miles
15.9%
75,000 – 99,999 miles
423.5%
100,000 – 149,999 miles
1058.8%
150,000+ miles
211.8%
When owners complained
A spike years after the car went on sale usually means a part wearing
out on schedule across the whole fleet — the kind of pattern no single
owner can see from inside their own car.
Jan 1995peak 9Mar 2022
NHTSA investigations into the 1994 Jeep Wrangler
An investigation is the step before a recall: the agency has seen enough
complaints to look into a pattern itself. An open one means it thinks
something may be wrong and nothing has been fixed yet.
EA01003Opened 11 Jan 2001Closed 25 Mar 2002SERVICE BRAKES, HYDRAULIC
PARKING BRAKE RESULTING IN ROLLAWAY
PE00038Opened 15 Sep 2000Closed 11 Jan 2001SERVICE BRAKES, HYDRAULIC
PARKING BRAKE
ALLEGED THE THE PARKING BRAKE FAIL TO HOLD THE VEHICLE STATIONARY WHEN APPLIED, AND THE VEHICLE ROLLED AWAY
EA99014Opened 28 Jun 1999Closed 28 Mar 2000SERVICE BRAKES, HYDRAULIC
BRAKE ROTER DISC/HUD SEPARATION
RQ97016Opened 27 Oct 1997Closed 30 Jun 1998FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
FUEL LEAKAGE
ODI HAS RECEIVED 6 REPORTS ON FUEL LEAKAGE AND 3 REPORTS ON ALLEGED REMEDY FAILURE REPORTS
PE95049Opened 17 Aug 1995Closed 26 Jan 1996SUSPENSION
REAR AXLE SHAFT SEPARATION
THIS INVESTIGATION WAS OPENED TO EXAMINE THE FAILURE MODE AND THE RISK TO MOTOR VEHICLE SAFETY POSED BY ALLEGATIONS OF REAR AXLE SEPARATIONS.THE REAR AXLE SHAFT AND HOUSING DESIGN IS TYPICAL OF THOSE IN WHICH THE WEIGHT OF THE VEHICLE IS CARRIED ON THE AXLE HOUSING.THE LEFT AND RIGHT AXLE SHAFTS, SUPPORTED BY ROLLER BEARINGS, ARE SITUATED INSIDE THE AXLE HOUSING.THE INBOARD SPLINED END OF THE AXLE SHAFT RECEIVES POWER TRANSMITTED FROM THE DIFFERENTIAL ASSEMBLY, PROVIDING TORQUE TO THE REAR WHEELS.THE ALLEGATIONS ARE THAT THE AXLE SHAFT FAILS, RESULTING IN THE SEPARATION OF A WHEEL AND AXLE HUB...
Recalls on the 1994 Jeep Wrangler
A complaint is one owner's allegation. A recall is the point at which
the manufacturer or a regulator agreed the defect is real and dangerous
enough to fix for free — however old the car is.
United States — NHTSA
06E026000
EXTERIOR LIGHTING
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
04E041000
EQUIPMENT
BESTOP AFTERMARKET REAR SHELL ROOF RACKS,MANUFACTURED BETWEEN APRIL 27 AND MAY 20, 2004, DESIGNED FOR USE WITH THE BESTOP HARDTOP MADE FOR THE 1986-1995 AND 1997-2003 JEEP WRANGLER. THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK BECAUSE THE LATCH BRACKET MISPOSITIONS THE ROTARY LATCH TO THE COCKPIT COVER. AS A RESULT, THE COCKPIT COVER MAY NOT STAY LATCHED TO THE ROOF RACK AND COULD SEPARATE FROM THE ROOF RACK. THIS RECALL ONLY PERTAINS TO AFTERMARKET REAR SHELL ROOF RACKS AND HAS NO RELATION TO ANY ORIGINAL EQUIPMENT INSTALLED ON JEEP WRANGLER VEHICLES BY DAIMLERCHRYSLER.
Risk: SHOULD THIS OCCUR, THE COCKPIT COULD CAUSE INJURY BY STRIKING PERSONS OUTSIDE THE VEHICLE OR COULD BECOME A DISTRACTION OR AN OBSTACLE TO OTHER DRIVERS, POSSIBLY RESULTING IN A VEHICLE CRASH.
02V041000
PARKING BRAKE:CONVENTIONAL
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS, THE PARKING BRAKE CAN SELF-RELEASE WITHOUT WARNING.
Risk: THIS COULD ALLOW THE VEHICLE TO ROLL AWAY, INCREASING THE RISK OF A CRASH.
94V106000
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
VEHICLE DESCRIPTION: MULTIPURPOSE PASSENGER VEHICLES EQUIPPED WITH PLASTIC FUEL TANKS. THE FUEL TANK SENDING UNIT GASKET CAN CRACK CAUSING FUEL AND FUEL VAPOR LEAKS.
Risk: FUEL AND FUEL VAPOR LEAKED FROM THE FUEL TANK CAN RESULT IN FIRE WHEN EXPOSED TO A SOURCE OF IGNITION.
Reports where the owner recorded a crash, a fire, an injury or a death.
Cypress, CACrash1 injured
SUSPENSION
The jeep flipped going down an accessway and bent the entire roll bar.
NHTSA complaint #11459001 — an unverified report by a vehicle owner.
Cypress, CACrash1 injured
STRUCTURE:BODY
The jeep flipped going down an accessway and bent the entire roll bar.
NHTSA complaint #11459001 — an unverified report by a vehicle owner.
Annapolis, MDCrashFire1 killed
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
1994 JEEP WRANGLER. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE FUEL TANK LOCATION THAT CAUSED A FAMILY MEMBER DEATH OF THE CLIENTS, HE IS REPRESENTING. *SMD THE DECEDENT WAS A PASSENGER IN THE VEHICLE. THE DRIVER LOST CONTROL OF THE VEHICLE, JUMPED A CURBED, HIT A POLE, THEN A TREE AND BURST INTO FLAMES. THE DECEDENT DID NOT DIE FROM THE IMPACT, RATHER HE DIED OF THERMAL INJURIES CAUSED BY THE VEHICLE BURSTING INTO FLAMES...UPDATED 02/13/17 *BF
NHTSA complaint #10524432 — an unverified report by a vehicle owner.
Annapolis, MDCrashFire1 killed
FUEL SYSTEM, GASOLINE
1994 JEEP WRANGLER. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE FUEL TANK LOCATION THAT CAUSED A FAMILY MEMBER DEATH OF THE CLIENTS, HE IS REPRESENTING. *SMD THE DECEDENT WAS A PASSENGER IN THE VEHICLE. THE DRIVER LOST CONTROL OF THE VEHICLE, JUMPED A CURBED, HIT A POLE, THEN A TREE AND BURST INTO FLAMES. THE DECEDENT DID NOT DIE FROM THE IMPACT, RATHER HE DIED OF THERMAL INJURIES CAUSED BY THE VEHICLE BURSTING INTO FLAMES...UPDATED 02/13/17 *BF
NHTSA complaint #10524432 — an unverified report by a vehicle owner.
at 130,000 milesBeach Lake, PAFire
ELECTRICAL SYSTEM
I PARKED MY 1994 JEEP WRANGLER OUTSIDE MY WORKPLACE AT 6AM THE MORNING OF 4/4/12... AT 11AM I FINISHED FOR THE DAY, LEFT MY JEEP WHERE IT WAS, AND WENT FOR A RUN AROUND WHERE I WORK. AT 11:27AM MY OFFICE MANAGER CALLED MY CELLPHONE AND BEGGED ME TO COME BACK RIGHT AWAY "YOUR JEEP IS ON FIRE!!! OH MY GOD, IT'S GONE!!! NOW THE WOODS ARE ON FIRE!!!". I RAN BACK TO FIND 3 FIRE TRUCKS, MY JEEP NOTHING BUT A CHARRED SHELL STILL ON FIRE. I SPOKE WITH MY OFFICE MANAGER, SHE HEARD AN ALARM (MY HORN HAD I GUESS MELTED AND WENT OFF), WHEN SHE RAN OUTSIDE SHE SAW SMOKE BILLOWING FROM UNDER THE HOOD AND FIRE DRIPPING FROM UNDER THE FRONT (MELTING PLASTIC OF MY DASHBOARD). THE JEEP WAS DRIVING ITSELF UPHILL IN REVERSE! SHE RAN TO IT, TRYING TO STOP IT AND ATTEMPTING TO SAVE MY BELONGINGS FROM INSIDE OF IT (SHE COULD NOT). SHE SAID THERE WAS FIRE SHOOTING FROM UNDER MY DASHBOARD. IT DROVE ITSELF ALL THE WAY ACROSS THE PARKING LOT WHERE IT EVENTUALLY STOPPED ON A TREE. IT WAS COMPLETELY ENGULFED IN FLAMES, AND THEN EXPLODED. (I HEARD THE EXPLOSION AS I WAS RUNNING THROUGH THE WOODS TRYING TO GET BACK). MY JEEP IS GONE NOW... NOTHING SALVAGEABLE. I NEVER HAD ANY ELECTRICAL PROBLEMS WITH IT IN THE PAST... BUT AFTER SOME INTERNET SEARCHING I'VE FOUND THAT JEEPS ARE NOTORIOUS FOR GOING UP IN FLAMES.
NHTSA complaint #10454600 — an unverified report by a vehicle owner.
at 130,000 milesBeach Lake, PAFire
ENGINE AND ENGINE COOLING
I PARKED MY 1994 JEEP WRANGLER OUTSIDE MY WORKPLACE AT 6AM THE MORNING OF 4/4/12... AT 11AM I FINISHED FOR THE DAY, LEFT MY JEEP WHERE IT WAS, AND WENT FOR A RUN AROUND WHERE I WORK. AT 11:27AM MY OFFICE MANAGER CALLED MY CELLPHONE AND BEGGED ME TO COME BACK RIGHT AWAY "YOUR JEEP IS ON FIRE!!! OH MY GOD, IT'S GONE!!! NOW THE WOODS ARE ON FIRE!!!". I RAN BACK TO FIND 3 FIRE TRUCKS, MY JEEP NOTHING BUT A CHARRED SHELL STILL ON FIRE. I SPOKE WITH MY OFFICE MANAGER, SHE HEARD AN ALARM (MY HORN HAD I GUESS MELTED AND WENT OFF), WHEN SHE RAN OUTSIDE SHE SAW SMOKE BILLOWING FROM UNDER THE HOOD AND FIRE DRIPPING FROM UNDER THE FRONT (MELTING PLASTIC OF MY DASHBOARD). THE JEEP WAS DRIVING ITSELF UPHILL IN REVERSE! SHE RAN TO IT, TRYING TO STOP IT AND ATTEMPTING TO SAVE MY BELONGINGS FROM INSIDE OF IT (SHE COULD NOT). SHE SAID THERE WAS FIRE SHOOTING FROM UNDER MY DASHBOARD. IT DROVE ITSELF ALL THE WAY ACROSS THE PARKING LOT WHERE IT EVENTUALLY STOPPED ON A TREE. IT WAS COMPLETELY ENGULFED IN FLAMES, AND THEN EXPLODED. (I HEARD THE EXPLOSION AS I WAS RUNNING THROUGH THE WOODS TRYING TO GET BACK). MY JEEP IS GONE NOW... NOTHING SALVAGEABLE. I NEVER HAD ANY ELECTRICAL PROBLEMS WITH IT IN THE PAST... BUT AFTER SOME INTERNET SEARCHING I'VE FOUND THAT JEEPS ARE NOTORIOUS FOR GOING UP IN FLAMES.
NHTSA complaint #10454600 — an unverified report by a vehicle owner.
The most recent complaints
In the owners' own words, exactly as filed with NHTSA.
Cypress, CACrash1 injured
SUSPENSION
The jeep flipped going down an accessway and bent the entire roll bar.
NHTSA complaint #11459001 — an unverified report by a vehicle owner.
Cypress, CACrash1 injured
STRUCTURE:BODY
The jeep flipped going down an accessway and bent the entire roll bar.
NHTSA complaint #11459001 — an unverified report by a vehicle owner.
at 100,800 milesLake Havasu City, AZ
SERVICE BRAKES
PARKING BREAK SELF RELEASES. ACCORDING TO CHRYSLER THE RECALL WAS DONE MORE THAN 10 YEARS AGO AND IS THEREFORE NO LONGER COVERED. HOW CAN CHRYSLER NOT COVER THIS DANGEROUS PROBLEM. THE VEHICLE WILL UNEXPECTEDLY BEGIN ROLLING DOWN A SLOPE WITH NO WARNING. THE BREAK WILL HOLD FOR A FEW MINUTES OR EVEN LONGER AND THEN RELEASE.. IF THIS REPLACEMENT PART IS OF THIS FAULTY A DESIGN WHY CAN IT NOT BE NOT BE REPLACED WITH A MORE DEPENDABLE ONE. IS THERE A REPLACEMENT "KIT" FOR THE RECALL? FURTHERMORE I WAS UNAWARE OF THE RECALL FOR THE FUEL PUMP/SENSOR GASKET AT TOP OF FUEL TANK AND THE CATALYTIC CONVERTER RECALL. I REPLACED THAT GASKET TWICE WITHOUT THE DEALER ADVISING ME OF THE RECALL. AS I PREPARED MY BOAT FOR LAUNCHING THE BREAK RELEASED AND BEGAN TO ROLL BACKWARDS INTO THE LAKE, NEARLY RUNNING ME OVER. A NARROW ESCAPE.
NHTSA complaint #10860848 — an unverified report by a vehicle owner.
at 100,800 milesLake Havasu City, AZ
FUEL/PROPULSION SYSTEM
PARKING BREAK SELF RELEASES. ACCORDING TO CHRYSLER THE RECALL WAS DONE MORE THAN 10 YEARS AGO AND IS THEREFORE NO LONGER COVERED. HOW CAN CHRYSLER NOT COVER THIS DANGEROUS PROBLEM. THE VEHICLE WILL UNEXPECTEDLY BEGIN ROLLING DOWN A SLOPE WITH NO WARNING. THE BREAK WILL HOLD FOR A FEW MINUTES OR EVEN LONGER AND THEN RELEASE.. IF THIS REPLACEMENT PART IS OF THIS FAULTY A DESIGN WHY CAN IT NOT BE NOT BE REPLACED WITH A MORE DEPENDABLE ONE. IS THERE A REPLACEMENT "KIT" FOR THE RECALL? FURTHERMORE I WAS UNAWARE OF THE RECALL FOR THE FUEL PUMP/SENSOR GASKET AT TOP OF FUEL TANK AND THE CATALYTIC CONVERTER RECALL. I REPLACED THAT GASKET TWICE WITHOUT THE DEALER ADVISING ME OF THE RECALL. AS I PREPARED MY BOAT FOR LAUNCHING THE BREAK RELEASED AND BEGAN TO ROLL BACKWARDS INTO THE LAKE, NEARLY RUNNING ME OVER. A NARROW ESCAPE.
NHTSA complaint #10860848 — an unverified report by a vehicle owner.
Annapolis, MDCrashFire1 killed
FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
1994 JEEP WRANGLER. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE FUEL TANK LOCATION THAT CAUSED A FAMILY MEMBER DEATH OF THE CLIENTS, HE IS REPRESENTING. *SMD THE DECEDENT WAS A PASSENGER IN THE VEHICLE. THE DRIVER LOST CONTROL OF THE VEHICLE, JUMPED A CURBED, HIT A POLE, THEN A TREE AND BURST INTO FLAMES. THE DECEDENT DID NOT DIE FROM THE IMPACT, RATHER HE DIED OF THERMAL INJURIES CAUSED BY THE VEHICLE BURSTING INTO FLAMES...UPDATED 02/13/17 *BF
NHTSA complaint #10524432 — an unverified report by a vehicle owner.
Annapolis, MDCrashFire1 killed
FUEL SYSTEM, GASOLINE
1994 JEEP WRANGLER. ATTORNEY REPRESENTING CONSUMER WRITES IN REGARDS TO VEHICLE FUEL TANK LOCATION THAT CAUSED A FAMILY MEMBER DEATH OF THE CLIENTS, HE IS REPRESENTING. *SMD THE DECEDENT WAS A PASSENGER IN THE VEHICLE. THE DRIVER LOST CONTROL OF THE VEHICLE, JUMPED A CURBED, HIT A POLE, THEN A TREE AND BURST INTO FLAMES. THE DECEDENT DID NOT DIE FROM THE IMPACT, RATHER HE DIED OF THERMAL INJURIES CAUSED BY THE VEHICLE BURSTING INTO FLAMES...UPDATED 02/13/17 *BF
NHTSA complaint #10524432 — an unverified report by a vehicle owner.
at 144,500 milesLincolnshire, IL
FUEL/PROPULSION SYSTEM
TL* THE CONTACT OWNS A 1994 JEEP WRANGLER. THE CONTACT STATED THE SMELL OF FUEL EMITTED INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP TWICE. THE LOCAL REPAIR SHOP MECHANIC CONFIRMED THAT THE GAS CAP FUEL SENDING UNIT AND CRACKED FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THE THAT THE VIN FAILED TO QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 94V106000(FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP) THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 144,500.
NHTSA complaint #10472358 — an unverified report by a vehicle owner.
at 130,000 milesBeach Lake, PAFire
ELECTRICAL SYSTEM
I PARKED MY 1994 JEEP WRANGLER OUTSIDE MY WORKPLACE AT 6AM THE MORNING OF 4/4/12... AT 11AM I FINISHED FOR THE DAY, LEFT MY JEEP WHERE IT WAS, AND WENT FOR A RUN AROUND WHERE I WORK. AT 11:27AM MY OFFICE MANAGER CALLED MY CELLPHONE AND BEGGED ME TO COME BACK RIGHT AWAY "YOUR JEEP IS ON FIRE!!! OH MY GOD, IT'S GONE!!! NOW THE WOODS ARE ON FIRE!!!". I RAN BACK TO FIND 3 FIRE TRUCKS, MY JEEP NOTHING BUT A CHARRED SHELL STILL ON FIRE. I SPOKE WITH MY OFFICE MANAGER, SHE HEARD AN ALARM (MY HORN HAD I GUESS MELTED AND WENT OFF), WHEN SHE RAN OUTSIDE SHE SAW SMOKE BILLOWING FROM UNDER THE HOOD AND FIRE DRIPPING FROM UNDER THE FRONT (MELTING PLASTIC OF MY DASHBOARD). THE JEEP WAS DRIVING ITSELF UPHILL IN REVERSE! SHE RAN TO IT, TRYING TO STOP IT AND ATTEMPTING TO SAVE MY BELONGINGS FROM INSIDE OF IT (SHE COULD NOT). SHE SAID THERE WAS FIRE SHOOTING FROM UNDER MY DASHBOARD. IT DROVE ITSELF ALL THE WAY ACROSS THE PARKING LOT WHERE IT EVENTUALLY STOPPED ON A TREE. IT WAS COMPLETELY ENGULFED IN FLAMES, AND THEN EXPLODED. (I HEARD THE EXPLOSION AS I WAS RUNNING THROUGH THE WOODS TRYING TO GET BACK). MY JEEP IS GONE NOW... NOTHING SALVAGEABLE. I NEVER HAD ANY ELECTRICAL PROBLEMS WITH IT IN THE PAST... BUT AFTER SOME INTERNET SEARCHING I'VE FOUND THAT JEEPS ARE NOTORIOUS FOR GOING UP IN FLAMES.
NHTSA complaint #10454600 — an unverified report by a vehicle owner.
at 130,000 milesBeach Lake, PAFire
ENGINE AND ENGINE COOLING
I PARKED MY 1994 JEEP WRANGLER OUTSIDE MY WORKPLACE AT 6AM THE MORNING OF 4/4/12... AT 11AM I FINISHED FOR THE DAY, LEFT MY JEEP WHERE IT WAS, AND WENT FOR A RUN AROUND WHERE I WORK. AT 11:27AM MY OFFICE MANAGER CALLED MY CELLPHONE AND BEGGED ME TO COME BACK RIGHT AWAY "YOUR JEEP IS ON FIRE!!! OH MY GOD, IT'S GONE!!! NOW THE WOODS ARE ON FIRE!!!". I RAN BACK TO FIND 3 FIRE TRUCKS, MY JEEP NOTHING BUT A CHARRED SHELL STILL ON FIRE. I SPOKE WITH MY OFFICE MANAGER, SHE HEARD AN ALARM (MY HORN HAD I GUESS MELTED AND WENT OFF), WHEN SHE RAN OUTSIDE SHE SAW SMOKE BILLOWING FROM UNDER THE HOOD AND FIRE DRIPPING FROM UNDER THE FRONT (MELTING PLASTIC OF MY DASHBOARD). THE JEEP WAS DRIVING ITSELF UPHILL IN REVERSE! SHE RAN TO IT, TRYING TO STOP IT AND ATTEMPTING TO SAVE MY BELONGINGS FROM INSIDE OF IT (SHE COULD NOT). SHE SAID THERE WAS FIRE SHOOTING FROM UNDER MY DASHBOARD. IT DROVE ITSELF ALL THE WAY ACROSS THE PARKING LOT WHERE IT EVENTUALLY STOPPED ON A TREE. IT WAS COMPLETELY ENGULFED IN FLAMES, AND THEN EXPLODED. (I HEARD THE EXPLOSION AS I WAS RUNNING THROUGH THE WOODS TRYING TO GET BACK). MY JEEP IS GONE NOW... NOTHING SALVAGEABLE. I NEVER HAD ANY ELECTRICAL PROBLEMS WITH IT IN THE PAST... BUT AFTER SOME INTERNET SEARCHING I'VE FOUND THAT JEEPS ARE NOTORIOUS FOR GOING UP IN FLAMES.
NHTSA complaint #10454600 — an unverified report by a vehicle owner.
at 200,000 milesLafayette, LA
FUEL SYSTEM, GASOLINE
EVERY TIME I FILL UP MY 94 YJ, GAS SPILLS OUT THE BACK OF IT. THE PUMP KICKS OFF BUT AS IT KICKS OFF IT SPILLS AND I HAVE TO CLEAN THE GAS RUNNING DOWN THE BACK OF THE JEEP. IT SEEMS TO ME THERE'S SOMETHING WRONG WITH THE BACK PRESSURE THAT KICKS OFF THE PUMP. I'M GUESSING THE FUEL COMPLETELY FILLS UP THE TUBE AND ONLY WHEN THE GAS HITS THE NOZZLE DOES IT SHUT OFF. IT IS VERY DIFFICULT TO FILL MY TANK UP AND IS ALSO VERY UNSAFE TO DO SO, AS GAS SPILLING OUT THE BACK IS A FIRE HAZARD. IT SEEMS I'M NOT THE ONLY JEEP OWNER DEALING WITH THIS PROBLEM. (HTTP://WWW.JEEPFORUM.COM/FORUM/F176/HAVE-FUEL-SPILL-PROBLEMS-LIKE-MANY-US-SUBMIT-COMPLAINT-FORCE-RECALL-974337/) SO HERE I AM FILING MY COMPLAINT, I HOPE SOMETHING WILL BE DONE. BECAUSE I'M TIRED OF BEING SOAKED IN GAS EVERY TIME I TRY TO FILL MY TANK.
NHTSA complaint #10442218 — an unverified report by a vehicle owner.
at 122,000 milesAlbuquerque, NM
FUEL SYSTEM, GASOLINE
FAILURE OF FUEL TANK SEAL CREATING FIRE HAZARD. INTERNET SEARCH REVEALS THIS A COMMON FAILURE, EITHER AT FILLER NEXT OR FUEL PUMP SEAL.
NHTSA complaint #10384886 — an unverified report by a vehicle owner.
at 91,656 milesLathrop, CA
FUEL SYSTEM, GASOLINE
TL*THE CONTACT OWNS A 1994 JEEP WRANGLER. DURING AN EMISSIONS TEST, THE CONTACT WAS INFORMED THAT HER GAS TANK WAS LEAKING. THE VEHICLE WAS TAKEN TO A SERVICE STATION AND SEVERAL DIAGNOSTICS WERE PERFORMED TO LOCATE THE CAUSE OF THE LEAK. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 91,656.
NHTSA complaint #10237079 — an unverified report by a vehicle owner.
at 10,000 milesIone, CA
FUEL SYSTEM, GASOLINE
GAS AND FUMES THAT HAVE BEEN FOUND TO BE COMING FROM TOP OF PLASTIC FUEL TANK. THE ODOR HAS BEEN PRESENT FOR A NUMBER OF YEARS.
NHTSA complaint #10226328 — an unverified report by a vehicle owner.
at 264,725 milesMorgan Hill, CA
STEERING:COLUMN LOCKING:ANTI-THEFT DEVICE
STEERING WHEEL LOCKED WHILE THE AUTO WAS IN MOTION, STEERING WHEEL NO LONGER LOCKS WHEN PARKED.
NHTSA complaint #10211801 — an unverified report by a vehicle owner.
Huntersville, NC
FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
NHTSA CAMPAIGN ID NUMBER: 94V106000 FUEL VAPOR LEAKAGE VIA PLASTIC GAS TANK. DEALER/MANUFACTURER WILL NOT PAY FOR REPAIR.
NHTSA complaint #10183095 — an unverified report by a vehicle owner.
Lemont, PA
PARKING BRAKE
DESPITE MY JEEP WRANGLER HAVING BEEN RECALLED DUE TO FAULTY PARKING BRAKES RECALL # 02V- 041000, THIS PROBLEM PERSISTS. I HAVE TAKEN MY CAR TO THE DEALERSHIP NUMEROUS TIMES WHERE THEY TIGHTEN THE PARKING BRAKE AND EACH TIME IT EVENTUALLY SLIPS AGAIN. I NO PARK MY CAR IN GEAR WHICH KEEPS IT STATIONARY BUT EVERY TIME I AM NOT PARKED IN GEAR MY CAR ROLLS AWAY. MANY TIMES THE BRAKE IS ON AND SUDDENLY COME OFF BUT PLENTY OF OTHER TIMES THE CAR MOVES EVEN WHEN THE BRAKE IS ON. I HAVE TAKEN IT TO THE DEALER SEVERAL TIMES AND THERE'S NOTHING THEY CAN DO. THE ONLY REASON THIS CAR EVEN PASSES INSPECTION IS THAT THE BRAKE IS TIGHTENED AND IMMEDIATELY TESTED. WITHIN A FEW DAYS, THE BRAKE IS BACK TO IT'S USUAL NON HOLDING SELF.
NHTSA complaint #10162891 — an unverified report by a vehicle owner.
Peyton, CO
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
1994 JEEP WRANGLER PURCHASED 24 APR 94. FUEL SHOOTS OUT OF FUEL TANK AT FUEL LINE CONNECTION WHEN ENGINE IS TURNED ON. FIRST TIME OCCURRED ON 30 JULY 97, REPAIRED BY JEEP DEALERSHIP. SECOND OCCURRENCE HAPPENED FEBRUARY 3 2004 REPAIRED BY LOCAL MECHANIC. THIRD OCCURRENCE, 15 NOV 05, TAKING JEEP INTO CHRYSLER DEALERSHIP FOR REPAIR ON 25 MAY 06. CONTACTED CHRYSLER CORPORATION SEVERAL TIMES TO FIX DEFECT, EACH TIME EXPLAINED CHRYSLER WILL NOT PAY FOR FIX AS VEHICLE IS OUT OF WARRANTY AND PART IS "MAN MADE." MOST RECENT CONVERSATION WITH CHRYSLER IN APRIL '06 WAS INFORMED THAT 2ND TIME COULD HAVE BEEN FIXED DUE TO DRIVE TRAIN WARRANTY BUT THEY WOULD NOT PAY FOR REPAIR AS IT WAS LAST FIXED BY NON-DEALERSHIP MECHANIC. ALSO INFORMED THAT THIS VEHICLE DOES NOT FALL UNDER 3 JAN 95 RECALL NOTICE FOR UNKNOWN REASON.
NHTSA complaint #10158229 — an unverified report by a vehicle owner.
1994 JEEP WRANGLER PURCHASED 24 APR 94. FUEL SHOOTS OUT OF FUEL TANK AT FUEL LINE CONNECTION WHEN ENGINE IS TURNED ON. FIRST TIME OCCURRED ON 30 JULY 97, REPAIRED BY JEEP DEALERSHIP. SECOND OCCURRENCE HAPPENED FEBRUARY 3 2004 REPAIRED BY LOCAL MECHANIC. THIRD OCCURRENCE, 15 NOV 05, TAKING JEEP INTO CHRYSLER DEALERSHIP FOR REPAIR ON 25 MAY 06. CONTACTED CHRYSLER CORPORATION SEVERAL TIMES TO FIX DEFECT, EACH TIME EXPLAINED CHRYSLER WILL NOT PAY FOR FIX AS VEHICLE IS OUT OF WARRANTY AND PART IS "MAN MADE." MOST RECENT CONVERSATION WITH CHRYSLER IN APRIL '06 WAS INFORMED THAT 2ND TIME COULD HAVE BEEN FIXED DUE TO DRIVE TRAIN WARRANTY BUT THEY WOULD NOT PAY FOR REPAIR AS IT WAS LAST FIXED BY NON-DEALERSHIP MECHANIC. ALSO INFORMED THAT THIS VEHICLE DOES NOT FALL UNDER 3 JAN 95 RECALL NOTICE FOR UNKNOWN REASON.
NHTSA complaint #10158229 — an unverified report by a vehicle owner.
at 126,472 milesHarrisville, MI
STEERING:GEAR BOX (OTHER THAN RACK AND PINION)
NO EVENT TOOK PLACE THAT I AM AWARE OF. I WAS NOTIFIED IN THE MIDDLE OF SEPTEMBER 2005 DURING ROUTINE MAINTENANCE THAT THE VEHICLES STEERING GEAR BOX WAS LEAKING WHICH REQUIRES REPLACEMENT IN ADDITION TO THE STEERING SHAFT ASSEMBLY. A SCHEDULING DATE FOR REPAIR IS ON OCTOBER 20, 2005 WITH A SUBSTANTIAL COST.
NHTSA complaint #10139348 — an unverified report by a vehicle owner.
Lancaster, CACrash
PARKING BRAKE:CONVENTIONAL
1994 JEEP WRANGLER HAD FAULTY PARKING BRAKE EQUIPMENT WHICH RESULTED IN THE JEEP ROLLING INTO A WALL AFTER PARKING BRAKE WAS ENGAGED.*MR THE CONSUMER HAD THE ACCIDENT AND PAID FOR THE RECALL REPAIRS PRIOR TO RECEIVING THE RECALL NOTICE AND HE IS NOW REQUESTING REIMBURSEMENT. (RECALL #02V041000)
NHTSA complaint #10118939 — an unverified report by a vehicle owner.
Bellevue, NE
SEAT BELTS:FRONT
DRIVER'S SEAT BELT FAILED TO CLICK ON ITS OWN. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER, AND MECHANIC INFORMED CONSUMER THAT THE SEAT BELTS DID NOT HAVE A LIFE TIME WARRANTY. CONSUMER HAD TO RENDER PAYMENT FOR THE SEAT BELTS.
NHTSA complaint #10089475 — an unverified report by a vehicle owner.
at 135,000 milesBrunswick, OH
SEAT BELTS:FRONT:RETRACTOR
FRONT SEAT BELT RETRACTORS CONTINUALLY FAIL TO RETRACT SEATBELT FULLY, USUALLY LEAVING 8-10 INCHES OF BELT ON THE FLOOR AND SOMETIMES HANGING OUTSIDE THE DOOR FRAME. THIS HAS BEEN A RE-OCCURING PROBLEM WITH TOO MANY TO COUNT FAILURES. PROBLEM IS TEMPORARILY ALLEVIATED BY MANUALLY FEEDING THE BELT INTO THE RETRACTOR.
NHTSA complaint #10072863 — an unverified report by a vehicle owner.
at 120,000 milesLittleton, CO
SEAT BELTS:FRONT:BUCKLE ASSEMBLY
STARTING IN JAN 2004, MY DRIVERS SIDE SEATBELT DISENGAGED ON ITS OWN WHILE DRIVING. IN THE LAST TWO MONTHS IT HAS DONE THIS SEVERAL TIMES, ALWAYS WITHOUT WARNING. SOME TIMES THE BELT WILL STAY LATCHED FOR THE WHOLE TRIP, SOME TIMES IT WILL RELEASE BEFORE I CAN REACH THE END OF THE DRIVEWAY, MORE OFTEN IT WILL RELEASE WHILE I'M DRIVING ON THE HIGHWAY. I HAVE NOT YET HAD A CHANCE TO SPEAK WITH A DEALER ABOUT THE PROBLEM.
NHTSA complaint #10060191 — an unverified report by a vehicle owner.
at 112,000 milesBloomington, INCrash
PARKING BRAKE
WITHOUT WARNING VEHICLE STARTED ROLLING BACKWARDS ON A SLIGHT DECLINING RAMP. CONSUMER WAS UNABLE TO STOP THE VEHICLE FROM ROLLING INTO A TREE. CONSUMER STATED THAT THE EMERGENCY BRAKE FAILED.
NHTSA complaint #10051874 — an unverified report by a vehicle owner.
Lancaster, CACrash
PARKING BRAKE:CONVENTIONAL
LTR FM NILA ANN HAMILTON (CA) OWNER OF A 1994 JEEP WRANGLER SEEKING TO BE REIMBURSED. VEHICLE ROLLED DOWN DRIVEWAY HIT A WALL/FENCE, THE EMERGENCY BRAKE SELF RELEASED AND CAUSED AN ACCIDENT. *MR RECALL# 02V041000 *SCC THE CONSUMER RECEIVED A RECALL NOTICE MONTHS LATER REGARDING THE EMERGENCY BRAKE. *JB
NHTSA complaint #10046565 — an unverified report by a vehicle owner.